1. Manuals
  2. Brands
  3. Lenovo Manuals
  4. Laptop
  5. ThinkPad X60 Tablet
  6. Hardware maintenance manual

Lenovo ThinkPad X60 Hardware Maintenance Manual

Hide thumbs Also See for ThinkPad X60:
Table of Contents

Advertisement

Quick Links

Download this manual See also: Troubleshooting Manual, Hardware Maintenance Manual
ThinkPad
Hardware Maintenance Manual
This manual supports:
ThinkPad X60
(MT 1702, 1703, 1704, 1705, 1706, 1707, 1708, 1709, 2507, 2508,
2509, 2510, 2533, and 2534)
®
X60

Advertisement

Table of Contents
loading

Related Manuals for Lenovo ThinkPad X60

Summary of Contents for Lenovo ThinkPad X60

  • Page 1 ® ThinkPad Hardware Maintenance Manual This manual supports: ThinkPad X60 (MT 1702, 1703, 1704, 1705, 1706, 1707, 1708, 1709, 2507, 2508, 2509, 2510, 2533, and 2534)
  • Page 3 ® ThinkPad Hardware Maintenance Manual...
  • Page 4 RESTRICTED RIGHTS. Use, duplication or disclosure by the Government is subject to the GSA ADP Schedule contract with Lenovo Group Limited, if any, or the standard terms of this commercial license, or if the agency is unable to accept this Program under these terms, then we provide this Program under the provisions set forth in Commercial Computer Software–Restricted Rights at FAR 52.227-19, when applicable, or under Rights in...

  • Page 5: Table Of Contents

    Bottom view for X60 . . 105 Rear View for ThinkPad X6 UltraBase . . 106 ThinkPad X60 ... . 33 Bottom View for ThinkPad X6 UltraBase . . 106 Product overview .
  • Page 6 MT1702/1703/1704/1705/1706/1707/1708/1709/2507/2508/2509/2510/2533/2534...

  • Page 7: About This Manual

    About this manual This manual contains service and reference information for ThinkPad X60 (MT 1702, 1703, 1704, 1705, 1706, 1707, 1708, 1709, 2507, 2508, 2509, 2510, 2533, and 2534) product. Use this manual along with the advanced diagnostic tests to troubleshoot problems.
  • Page 8 MT1702/1703/1704/1705/1706/1707/1708/1709/2507/2508/2509/2510/2533/2534...

  • Page 9: Introduction

    Important service information Important BIOS and device driver fixes are customer-installable. The BIOS and device drivers are posted on the customer support site http://www.lenovo.com/ support Advise customers to contact the Customer Support Center at 800-426-7378 if they need assistance in obtaining or installing any diskette fixes.

  • Page 10: Important Notice For Replacing A System Board

    Important service information Important notice for replacing a system board Some components mounted on a system board are very sensitive. Improper handling of a system board can cause damage to those components, and may cause a system malfunction. Attention: When handling a system board: v Do not drop a system board or apply any excessive force to it.

  • Page 11: Fru Identification For Cto, Cmv, And Gav Products

    (this is the same record found in PEW). v eSupport can be accessed at the following Web site: http://www.lenovo.com/ support v To view the key commodities, click on PARTS INFORMATION, then PARTS LOOKUP.

  • Page 12: Important Information About Replacing Rohs Compliant Frus

    RoHS compliant. Lenovo plans to transition to RoHS compliance well before the implementation date and expects its suppliers to be ready to support Lenovo's requirements and schedule. Products sold in 2005, will contain some RoHS compliant FRUs. The following statement pertains to these products and any product Lenovo produces containing RoHS compliant FRUs.

  • Page 13: Diskette Compatibility Matrix

    Diskette compatibility matrix Diskette compatibility matrix The compatibility of each of the drives with the diskettes for it is as follows: Diskette Diskette Compatibility drive capacity 3.5-inch 1.0 MB Read and write 2.0 MB Read and write 4.0 MB Not compatible Safety notices: multilingual translations In this manual, safety notices appear in English with a page number reference to the appropriate multilingual, translated safety notice found in this section.
  • Page 14 Safety notices Safety notice 2 DANGER Some standby batteries contain a small amount of nickel and cadmium. Do not disassemble a standby battery, recharge it, throw it into fire or water, or short-circuit it. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing.
  • Page 15 Safety notices Safety notice 3 DANGER The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack.
  • Page 16 Safety notices Safety notice 4 DANGER The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations.
  • Page 17 Safety notices Safety notice 5 If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affected areas with water for at least 15 minutes. Seek medical care if any symptoms from the fluid are present after washing. Si le panneau d’affichage à...
  • Page 18 Safety notices Safety notice 7 DANGER Though the main batteries have low voltage, a shorted or grounded battery can produce enough current to burn personnel or combustible materials. Bien que le voltage des batteries principales soit peu élevé, le court-circuit ou la mise à...

  • Page 19: Safety Information

    Safety information Safety information The following section presents safety information with which you need to be familiar before you service a ThinkPad computer. General safety Follow these rules to ensure general safety: v Observe good housekeeping in the area of the machines during and after maintenance.
  • Page 20 Safety information Important Use only approved tools and test equipment. Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents. Many customers have, near their equipment, rubber floor mats that contain small conductive fibers to decrease electrostatic discharges.

  • Page 21: Safety Inspection Guide

    Safety information v Do not service the following parts with the power on when they are removed from their normal operating places in a machine: – Power supply units – Pumps – Blowers and fans – Motor generators and similar units. (This practice ensures correct grounding of the units.) v If an electrical accident occurs: –...

  • Page 22: Handling Devices That Are Sensitive To Electrostatic Discharge

    Safety information Handling devices that are sensitive to electrostatic discharge Any computer part containing transistors or integrated circuits (ICs) should be considered sensitive to electrostatic discharge (ESD.) ESD damage can occur when there is a difference in charge between objects. Protect against ESD damage by equalizing the charge so that the machine, the part, the work mat, and the person handling the part are all at the same charge.

  • Page 23: Laser Compliance Statement

    Laser compliance statement Laser compliance statement Some models of ThinkPad computer are equipped from the factory with an optical storage device such as a CD-ROM drive or a DVD-ROM drive. Such devices are also sold separately as options. If one of these drives is installed, it is certified in the U.S.
  • Page 24 Laser compliance statement A CD-ROM drive, a DVD-ROM drive, or any other storage device installed may contain an embedded Class 3A or Class 3B laser diode. Note the following: DANGER Emits visible and invisible laser radiation when open. Do not stare into the beam, do not view directly with optical instruments, and avoid direct exposure to the beam.

  • Page 25: General Descriptions

    Note for warranty: During the warranty period, the customer may be responsible for repair costs if the computer damage was caused by misuse, accident, modification, unsuitable physical or operating environment, or improper maintenance by the customer. © Copyright Lenovo 2006...
  • Page 26 Read this first Following is a list of some common items that are not covered under warranty and some symptoms that might indicate that the system was subjected to stress beyond normal use. Before checking problems with the computer, determine whether the damage is covered under the warranty by referring to the following list: The following are not covered under warranty: v LCD panel cracked from the application of excessive force or from being...

  • Page 27: Related Service Information

    Service Web site When the latest maintenance diskette and the system program service diskette become available, they will be posted on http://www.lenovo.com/think/spm Restoring the pre-installed system When the hard disk drive is replaced because of a failure, no Product Recovery program is on the new hard disk.

  • Page 28: Supervisor Password

    If it has, it can be used for access to the hard-disk drive. If no master HDP is available, Lenovo does not provide any services to reset either the user or the master HDP, or to recover data from the hard-disk drive. The hard-disk drive can be replaced for a scheduled fee.

  • Page 29: Power Management

    Attention: If User only mode is selected and the user HDP has been forgotten and cannot be made available to the servicer, Lenovo does not provide any services to reset the user HDPs or to recover data from the hard-disk drive. The hard-disk drive can be replaced for a scheduled fee.

  • Page 30: Standby Mode

    Related service information 3. If the time set on the “Turn off monitor” timer in the operating system expires, v The LCD backlight turns off. To end screen blank mode and resume normal operation, press any key. Standby mode When the computer enters standby mode, the following events occur in addition to what occurs in screen blank mode: v The LCD is powered off.
  • Page 31 Related service information v If you are using the ACPI operating system and have defined one of the following actions as the event that causes the system to go into hibernation mode, perform that action. – Closing the lid. – Pressing the power button. –...

  • Page 32: Checkout Guide

    Checkout guide Checkout guide Use the following procedures as a guide in identifying and correcting problems with the ThinkPad computer. Note: The diagnostic tests are intended to test only ThinkPad products. The use of non-ThinkPad products, prototype cards, or modified options can lead to false indications of errors and invalid system responses.
  • Page 33 Checkout guide Creating the PC-Doctor diagnostics diskette In X60, the PC-Doctor disk can be created by using the ThinkVantage Rescue and Recovery. To create the PC-Doctor disk from the , do as follows: 1. Enter the ThinkVantage Rescue and Recovery application by pressing the blue ThinkVantage button during POST.

  • Page 34: Detecting System Information With Pc-Doctor

    Checkout guide Diagnostics Interactive Tests v Run Normal Test v Keyboard v Run Quick Test v Video v CPU/Coprocessor v Internal Speaker v Systemboard v Mouse v Video Adapter v Diskette v Serial Ports v System Load v Parallel Ports v CD-ROM/DVD Test v Fixed Disks v Intel Wireless Radio...

  • Page 35: Power System Checkout

    Checkout guide v PNPISA Info v SMBIOS Info v VESA LCD Info v Hardware Events Log Utility v Run External Tests v Surface Scan Hard Disk v Benchmark System v DOS Shell v Tech Support Form v Battery Rundown v View Test Log v Print Log v Save Log v Full Erase Hard Drive...

  • Page 36: Checking Operational Charging

    Checkout guide Voltage (V dc) Ground +19.5 to +21.0 3. If the voltage is not correct, replace the ac adapter. 4. If the voltage is acceptable, do the following: v Replace the system board. v If the problem persists, go to “Product overview” on page 34. Note: Noise from the ac adapter does not always indicate a defect.

  • Page 37: Checking The Backup Battery

    Checkout guide Terminal Voltage (V dc) + 0 to + 14.4 Ground (−) 3. If the voltage is less than +14.4 V dc, the battery pack has been discharged. Note: Recharging will take at least 3 hours, even if the indicator does not turn If the voltage is still less than +14.4 V dc after recharging, replace the battery.
  • Page 38 Checkout guide MT1702/1703/1704/1705/1706/1707/1708/1709/2507/2508/2509/2510/2533/2534...

  • Page 39: Thinkpad X60

    1120 MDC . . 70 Power cords (system) . . 133 1130 Backup battery . 71 Notices . 135 1140 Speaker . . 72 Trademarks . . 136 1150 DC-in and RJ-11 connectors . . 73 © Copyright Lenovo 2006...

  • Page 40: Product Overview

    Product overview Product overview This section presents the following product-unique information: v “Specifications” v “Status indicators for X60” on page 36 v “FRU tests” on page 38 v “Fn key combinations” on page 40 Specifications Feature Description Processor ® ® v Intel Pentium M Processor, Standard Voltage, Dual Core,...
  • Page 41 2 parallel of 4 series of cells (2P4S) Li-Ion battery pack (5.2 AH) (Hybrid) Note: The prismatic battery is only for ThinkPad X60s computer. The standard and hybrid batteries require a spacer when used with ThinkPad X60s computer. Preinstalled operating v Windows XP system ThinkPad X60...

  • Page 42: Status Indicators For X60

    Product overview Status indicators for X60 The system status indicators show the status of the computer, as follows: 9 10 MT1702/1703/1704/1705/1706/1707/1708/1709/2507/2508/2509/2510/2533/2534...
  • Page 43 If a battery is installed in the computer, it is charged when this indicator is green. Standby status Green: The computer is in standby mode. Blinking green: The computer is entering standby mode or hibernation mode, or is resuming normal operation. ThinkPad X60...

  • Page 44: Fru Tests

    Product overview FRU tests The following table shows the test for each FRU. Applicable test System board 1. Diagnostics --> CPU/Coprocessor 2. Diagnostics --> Systemboard 3. If the docking station or the port replicator is attached to the ThinkPad computer, undock it. Place the computer on a horizontal surface, and run Diagnostics -->...
  • Page 45 3. If the test does not detect the error, run Diagnostics --> Memory Test - Full. Note: The maximum supported memory size is 3GB. 1. Turn on the computer and check the air turbulence at the louver near the power switch. 2. Run Diagnostics --> ThinkPad Devices --> Fan. ThinkPad X60...

  • Page 46: Fn Key Combinations

    Product overview Fn key combinations The following table shows the function of each combination of Fn with a function key. Key combination Description Fn+F1 Reserved. Fn+F2 Reserved. Fn+F3 Standby mode Turn off the LCD display, leaving the screen blank. Hard disk drive spindown while CPU still works.
  • Page 47 Note: To use Fn+F12 for hibernation in Windows XP and Windows 2000, the PM device driver must have been installed on the computer. Fn+Home LCD brightness up The LCD becomes brighter. Fn+End LCD brightness down The LCD becomes less bright. Fn+Spacebar FullScreen magnifier Enable the FullScreen Magnifier function. ThinkPad X60...

  • Page 48: Symptom-To-Fru Index

    Symptom-to-FRU index Symptom-to-FRU index The symptom-to-FRU index in this section lists symptoms and errors and their possible causes. The most likely cause is listed first, in boldface type. Note: Do the FRU replacement or other actions in the sequence shown in the column headed “FRU or action, in sequence.”...
  • Page 49 0251 Replace the backup battery and run BIOS System CMOS checksum bad— Default Setup Utility to reset the time and date. configuration used. 0252 Reset the password by running BIOS Setup Password checksum bad—The password is Utility. cleared. ThinkPad X60...
  • Page 50 Symptom-to-FRU index Symptom or error FRU or action, in sequence 0260 1. Replace the backup battery and run System timer error. BIOS Setup Utility to reset the time and date. 2. System board. 0270 1. Replace the backup battery and run Real-time clock error.
  • Page 51 (HDD) may not function correctly on this If in the primary bay the customer is using a system. Ensure that your HDD is supported non-IBM or non-Lenovo hard disk drive on this system and that the latest HDD (HDD), or an old generation IBM HDD firmware is installed.

  • Page 52: Error Messages

    Symptom-to-FRU index Symptom or error FRU or action, in sequence 2110 1. Reseat the hard disk drive. Read error on HDD0 (Main hard disk drive) 2. Main hard disk drive. 3. System board. 2112 1. Reseat the hard disk drive. Read error on HDD1 (Ultrabay hard disk 2.
  • Page 53 No valid operating system. 1. Check that the operating system has no failure and is installed correctly. 2. Reinstall the operation system. Excluded from boot order. v Enter the BIOS Setup Utility and add the device in boot order. ThinkPad X60...

  • Page 54: Beep Symptoms

    Symptom-to-FRU index Beep symptoms Symptom or error FRU or action, in sequence One beep and a blank, unreadable, or 1. Reseat the LCD connector. flashing LCD. 2. LCD assembly. 3. External CRT. 4. System board. One long and two short beeps, and a blank 1.

  • Page 55: Lcd-Related Symptoms

    1. See important note for “LCD-related v Characters missing pixels. symptoms.” v Screen abnormal. 2. Reseat all LCD connectors. v Wrong color displayed. 3. LCD assembly. 4. System board. Horizontal or vertical lines displayed on LCD assembly. LCD. ThinkPad X60...

  • Page 56: Intermittent Problems

    Symptom-to-FRU index Intermittent problems Intermittent system hang problems can be due to a variety of causes that have nothing to do with a hardware defect, such as cosmic radiation, electrostatic discharge, or software errors. FRU replacement should be considered only when a problem recurs.

  • Page 57: Fru Replacement Notices

    Retaining serial numbers This section includes the following descriptions: v “Restoring the serial number of the system unit” on page 52 v “Retaining the UUID” on page 52 v “Reading or writing the ECA information” on page 52 ThinkPad X60...

  • Page 58: Restoring The Serial Number Of The System Unit

    FRU replacement notices Restoring the serial number of the system unit When the computer was manufactured, the EEPROM on the system board was loaded with the serial numbers of the system and all major components. These numbers need to remain the same throughout the life of the computer. If you replace the system board, you must restore the serial number of the system unit to its original value.
  • Page 59 If the system board is being replaced, try to read the ECA information from the old system board and transfer the information to the new system. If the system board is inoperable, this will not be possible. ThinkPad X60...

  • Page 60: Removing And Replacing A Fru

    Removing and replacing a FRU Removing and replacing a FRU This section presents directions and drawings for use in removing and replacing a FRU. Be sure to observe the following general rules: 1. Do not try to service any computer unless you have been trained and certified. An untrained person runs the risk of damaging parts.

  • Page 61: 1010 Battery Pack

    Removing and replacing a FRU 1010 Battery pack DANGER Use only the battery specified in the parts list for your computer. Any other battery could ignite or explode. ThinkPad X60...

  • Page 62: 1020 Hard Disk Drive (2.5-Inch)

    Removing and replacing a FRU 1020 Hard disk drive (2.5-inch) Note: This procedure is only for models with a 2.5-inch hard disk drive. Attention v Do not drop or apply any shock to the hard disk drive. The hard disk drive is sensitive to physical shock.

  • Page 63: 1030 Dimm Cover

    For access, remove following FRU: v “1010 Battery pack” on page 55 Note: Loosen the screws 1 , but do not remove them. Step Screw (quantity) Color Torque M2 × 3 mm, wafer-head, nylon-coated (2) Black 0.157 Nm (1.6 kgfcm) ThinkPad X60...

  • Page 64: 1040 Dimm

    Removing and replacing a FRU 1040 DIMM For access, remove following FRUs, in order: v “1010 Battery pack” on page 55 v “1030 DIMM cover” on page 57 MT1702/1703/1704/1705/1706/1707/1708/1709/2507/2508/2509/2510/2533/2534...

  • Page 65: 1050 Keyboard

    For access, remove following FRU: v “1010 Battery pack” on page 55 Remove 4 screws with keyboard icon to remove keyboard. Step Icon Screw (quantity) Color Torque M2 × 6 mm, wafer-head, Black 0.196 Nm nylon-coated (4) (2 kgfcm) (continued) ThinkPad X60...
  • Page 66 Removing and replacing a FRU Gently push the keyboard forward, as shown in step 2 . Then lift up the keyboard slightly, as shown in step 3 . Detach the keyboard connector 4 to remove the keyboard 5 . MT1702/1703/1704/1705/1706/1707/1708/1709/2507/2508/2509/2510/2533/2534...
  • Page 67 Removing and replacing a FRU When installing: Follow the steps below. 1. Attach the connector. 2. Make sure that the keyboard edges are under the frame. Then press the keys to latch the keyboard firmly in place. ThinkPad X60...
  • Page 68 Removing and replacing a FRU 3. To make sure that the front side of the keyboard is housed firmly, gently press the keys with your thumbs and try to slide the keyboard toward you. 4. Secure the keyboard by tightening the screws from the bottom side of the computer.

  • Page 69: 1060 Upper Case

    “1010 Battery pack” on page 55 v “1050 Keyboard” on page 59 Step Screw (quantity) Color Torque M2 × 6 mm, wafer-head, nylon-coated (6) Black 0.196 Nm (2 kgfcm) Note: For models with a fingerprint reader, detach the fingerprint cable 2 . (continued) ThinkPad X60...
  • Page 70 Removing and replacing a FRU Note: Open the LCD at least 150 degrees. Press down and gently lift upper case up, as shown in steps 3 and 4 , to remove upper case. When installing: Follow the steps below to make sure that the upper case is installed firmly.

  • Page 71: 1070 Fingerprint Reader

    For access, remove following FRUs, in order: v “1010 Battery pack” on page 55 v “1050 Keyboard” on page 59 v “1060 Upper case” on page 63 Step Screw (quantity) Color Torque M2.5 × 3.5 mm, wafer-head, nylon-coated (2) Silver 0.196 Nm (2 kgfcm) ThinkPad X60...

  • Page 72: 1080 Hard Disk (1.8-Inch)

    Removing and replacing a FRU 1080 Hard disk (1.8-inch) Note: This procedure is only for models with a 1.8-inch hard disk drive. Attention v Do not drop or apply any shock to the hard disk drive. The hard disk drive is sensitive to physical shock. Incorrect handling can cause damage and permanent loss of data.

  • Page 73: 1090 Hard Disk Housing (1.8-Inch)

    “1050 Keyboard” on page 59 v “1060 Upper case” on page 63 v “1080 Hard disk (1.8-inch)” on page 66 Step Screw (quantity) Color Torque M2.5 × 3.5 mm, wafer-head, nylon-coated (2) Silver 0.196 Nm (2 kgfcm) ThinkPad X60...

  • Page 74: 1100 Wireless Wan Pci Express Mini Card

    Removing and replacing a FRU 1100 Wireless WAN PCI Express Mini card Note: This procedure is only for models with wireless WAN feature. Step 2 is only for models with Verizon wireless WAN. For access, remove following FRUs, in order: v “1010 Battery pack”...

  • Page 75: 1110 Wireless Lan Pci Express Mini Card

    For access, remove following FRUs, in order: v “1010 Battery pack” on page 55 v “1050 Keyboard” on page 59 v “1060 Upper case” on page 63 v “1100 Wireless WAN PCI Express Mini card” on page 68 ThinkPad X60...

  • Page 76: 1120 Mdc

    Removing and replacing a FRU 1120 MDC For access, remove following FRUs, in order: v “1010 Battery pack” on page 55 v “1050 Keyboard” on page 59 v “1060 Upper case” on page 63 Step Screw (quantity) Color Torque M2.5 × 3.5 mm, wafer-head, nylon-coated (2) Silver 0.196 Nm (2 kgfcm)

  • Page 77: 1130 Backup Battery

    Use only the battery specified in the parts list for your computer. Any other battery could ignite or explode. For access, remove following FRUs, in order: v “1010 Battery pack” on page 55 v “1050 Keyboard” on page 59 When installing: Make sure that the battery connector is attached firmly. ThinkPad X60...

  • Page 78: 1140 Speaker

    Removing and replacing a FRU 1140 Speaker For access, remove following FRUs, in order: v “1010 Battery pack” on page 55 v “1050 Keyboard” on page 59 v “1060 Upper case” on page 63 When installing: Make sure that the speaker connector is attached firmly. MT1702/1703/1704/1705/1706/1707/1708/1709/2507/2508/2509/2510/2533/2534...

  • Page 79: 1150 Dc-In And Rj-11 Connectors

    “1060 Upper case” on page 63 Step Screw (quantity) Color Torque M2.5 × 3.5 mm, wafer-head, nylon-coated (2) Silver 0.196 Nm (2 kgfcm) When installing: Make sure that the DC-in and RJ-11 cables are routed properly and the connectors are attached firmly. ThinkPad X60...

  • Page 80: 1160 Lcd Assembly

    Removing and replacing a FRU 1160 LCD assembly For access, remove following FRUs, in order: v “1010 Battery pack” on page 55 v “1050 Keyboard” on page 59 v “1060 Upper case” on page 63 v “1100 Wireless WAN PCI Express Mini card” on page 68 v “1110 Wireless LAN PCI Express Mini card”...
  • Page 81 Removing and replacing a FRU Step Screw (quantity) Color Torque M2 × 3.5 mm, wafer-head, nylon-coated (3) Silver 0.196 Nm (2 kgfcm) (continued) ThinkPad X60...
  • Page 82 Removing and replacing a FRU Step Screw (quantity) Color Torque M2.5 × 5 mm, wafer-head, nylon-coated (2) Black 0.294 Nm (3 kgfcm) M2.5 × 5 mm, wafer-head, nylon-coated (2) Black 0.294 Nm (3 kgfcm) (continued) MT1702/1703/1704/1705/1706/1707/1708/1709/2507/2508/2509/2510/2533/2534...
  • Page 83 Then route the wireless antenna cables as shown below. For wireless WAN: red is main; blue is aux. For wireless LAN: gray is main; black is aux. Remember to reattach the mylar and tapes. (continued) ThinkPad X60...
  • Page 84 Removing and replacing a FRU When installing: Make sure to position the LCD cable properly and reattach the mylar and tape. The LCD cable switch should fit in its slot 7 . MT1702/1703/1704/1705/1706/1707/1708/1709/2507/2508/2509/2510/2533/2534...

  • Page 85: 1170 Hard Disk Sub-Card

    “1150 DC-in and RJ-11 connectors” on page 73 v “1160 LCD assembly” on page 74 Note: The hard disk sub-card is different for 2.5-inch hard disk drives and 1.8-inch hard disk drives. For 1.8-inch hard disk drive For 2.5-inch hard disk drive ThinkPad X60...

  • Page 86: 1180 System Board

    Removing and replacing a FRU 1180 System board For access, remove following FRUs, in order: v “1010 Battery pack” on page 55 v “1020 Hard disk drive (2.5-inch)” on page 56 v “1030 DIMM cover” on page 57 v “1050 Keyboard” on page 59 v “1060 Upper case”...
  • Page 87 Following components soldered on the top and bottom sides of the system board are extremely sensitive. When you service the system board, avoid any kind of rough handling. Accelerometer chip for the HDD Active Protection System Security chip MCH (Memory Controller Hub) ICH (I/O Controller Hub) Bottom ThinkPad X60...
  • Page 88 Removing and replacing a FRU Step Screw (quantity) Color Torque M2 × 3.5 mm, wafer-head, nylon-coated (2) Silver 0.1372 Nm (1.4 kgfcm) When installing: Do not damage the wireless micro switch 1 on the system board. MT1702/1703/1704/1705/1706/1707/1708/1709/2507/2508/2509/2510/2533/2534...

  • Page 89: 1190 Fansink

    M2 × 3.5 mm, wafer-head, nylon-coated (1) Silver 0.196 Nm (2 kgfcm) M2 × 9 mm, flat-head, spring-loaded, (3) Silver 0.245 Nm (2.5 kgfcm) Note: Remove the fansink screws in the order shown: 3a , 3b , and 3c . ThinkPad X60...

  • Page 90: 2010 Lcd Bezel

    Removing and replacing a FRU 2010 LCD bezel For access, remove following FRUs, in order: v “1010 Battery pack” on page 55 v “1050 Keyboard” on page 59 v “1060 Upper case” on page 63 v “1100 Wireless WAN PCI Express Mini card” on page 68 v “1110 Wireless LAN PCI Express Mini card”...
  • Page 91 Be careful to route the antenna cables properly. For TMD LCD (continued) ThinkPad X60...
  • Page 92 Removing and replacing a FRU Step Screw (quantity) Color Torque M2 × 2.5 mm, wafer-head, nylon-coated (4) Black 0.1568 Nm (1.6 kgfcm) M2.5 × 5 mm, wafer-head, nylon-coated (3) Black 0.294 Nm (3 kgfcm) Note: The adhesive on the bezel can make bezel removal difficult. When installing: The replacement bezel should have adhesive pre-applied;...

  • Page 93: 2020 Inverter Card

    “1160 LCD assembly” on page 74 v “2010 LCD bezel” on page 84 Step Screw (quantity) Color Torque M2 × 2.5 mm, wafer-head, nylon-coated (1) Silver 0.1568 Nm (1.6 kgfcm) When installing: Make sure that both connectors are attached firmly. ThinkPad X60...

  • Page 94: 2030 Bluetooth Daughter Card

    Removing and replacing a FRU 2030 Bluetooth daughter card Note: The following procedures are for models with Bluetooth. For access, remove following FRUs, in order: v “1010 Battery pack” on page 55 v “1050 Keyboard” on page 59 v “1060 Upper case” on page 63 v “1100 Wireless WAN PCI Express Mini card”...

  • Page 95: 2040 Lcd

    “1150 DC-in and RJ-11 connectors” on page 73 v “1160 LCD assembly” on page 74 v “2010 LCD bezel” on page 84 v “2020 Inverter card” on page 87 v “2030 Bluetooth daughter card” on page 88 For SPWG LCD (continued) ThinkPad X60...
  • Page 96 Removing and replacing a FRU Step Screw (quantity) Color Torque M2 × 2.5 mm, wafer-head, nylon-coated (6) Black 0.1568 Nm (1.6 kgfcm) (continued) MT1702/1703/1704/1705/1706/1707/1708/1709/2507/2508/2509/2510/2533/2534...
  • Page 97 Removing and replacing a FRU For TMD LCD When removing: Make sure you do not touch or put pressure on these two sections of the LCD indicated below. ThinkPad X60...

  • Page 98: 2050 Wireless Lan Antenna Cables (Spwg)

    Removing and replacing a FRU 2050 Wireless LAN antenna cables (SPWG) Note: The following procedure is for SPWG LCD only. For access, remove following FRUs, in order: v “1010 Battery pack” on page 55 v “1050 Keyboard” on page 59 v “1060 Upper case”...
  • Page 99 Removing and replacing a FRU When installing: Route the cable properly along the side and into the hinge. ThinkPad X60...

  • Page 100: 2060 Hinges

    Removing and replacing a FRU 2060 Hinges For access, remove following FRUs, in order: v “1010 Battery pack” on page 55 v “1050 Keyboard” on page 59 v “1060 Upper case” on page 63 v “1100 Wireless WAN PCI Express Mini card” on page 68 v “1110 Wireless LAN PCI Express Mini card”...
  • Page 101 Removing and replacing a FRU For TMD LCD Step Screw (quantity) Color Torque M2 × 2.5 mm, wafer-head, nylon-coated (2) Black 0.1568 Nm (1.6 kgfcm) (continued) ThinkPad X60...
  • Page 102 Removing and replacing a FRU MT1702/1703/1704/1705/1706/1707/1708/1709/2507/2508/2509/2510/2533/2534...

  • Page 103: 2070 Wireless Lan Antenna Cables (Tmd)

    “2020 Inverter card” on page 87 v “2030 Bluetooth daughter card” on page 88 v “2040 LCD” on page 89 v “2050 Wireless LAN antenna cables (SPWG)” on page 92 v “2060 Hinges” on page 94 (continued) ThinkPad X60...
  • Page 104 Removing and replacing a FRU Note: For models without wireless WAN, the only antenna present on the right-side is the aux wireless LAN antenna. When installing: Route the cable properly inside the ribs as shown below. MT1702/1703/1704/1705/1706/1707/1708/1709/2507/2508/2509/2510/2533/2534...

  • Page 105: 2080 Wireless Wan Antenna Cable (Tmd)

    “2040 LCD” on page 89 v “2030 Bluetooth daughter card” on page 88 v “2050 Wireless LAN antenna cables (SPWG)” on page 92 v “2060 Hinges” on page 94 v “2070 Wireless LAN antenna cables (TMD)” on page 97 (continued) ThinkPad X60...
  • Page 106 Removing and replacing a FRU Note: For models with wireless WAN, the antennas present on the right-side are the aux wireless LAN antenna and the main wireless WAN antenna. When installing: Before installing the LCD, fit the WAN antenna cover first 1 , reattach the tape 2 , then route the cable properly inside the ribs 3 as shown below.

  • Page 107: 2090 Lcd Panel And Lcd Cable

    “2070 Wireless LAN antenna cables (TMD)” on page 97 v “2080 Wireless WAN antenna cable (TMD)” on page 99 For SPWG LCD When installing: Make sure that the cable is positioned correctly, the connector is attached firmly, and the tape is reattached. (continued) ThinkPad X60...
  • Page 108 Removing and replacing a FRU For TMD LCD When installing: Make sure that the cable is positioned correctly, the connector is attached firmly, and the tape is reattached. Note: For models with Bluetooth, the Bluetooth Daughter Card is attached to the LCD cable.

  • Page 109: Locations

    System status indicators Power switch Security keyhole AC power connector Modem connector Hard disk drive Microphone jack Stereo headphone jack USB connectors IEEE 1394 connector (for some models) Infrared port TrackPoint stick Fingerprint reader (for some models) ThinkVantage button ThinkLight ThinkPad X60...

  • Page 110: Rear View For X60

    Locations Rear view for X60 PC Card slot SD card slot Ethernet connector External monitor connector USB connector Battery pack MT1702/1703/1704/1705/1706/1707/1708/1709/2507/2508/2509/2510/2533/2534...

  • Page 111: Bottom View For X60

    Locations Bottom view for X60 Battery latch Docking connector Memory door Speaker Battery lock ThinkPad X60...

  • Page 112: Rear View For Thinkpad X6 Ultrabase

    Locations Rear View for ThinkPad X6 UltraBase AC power connector USB connectors External monitor connector Serial connector Parallel connectors Stereo headphone jack Microphone jack Ethernet connector Modem connector Security lock key Ultrabay latch Ultrabay Slim device Note: The Ultrabay Slim device accepts several storage devices, such as a DVD drive, a CD-RW / DVD combo drive, or a second hard disk drive.

  • Page 113: Parts List

    Parts list Parts list Overall ThinkPad X60...
  • Page 114 Parts list v Each FRU is available for all types or models, unless specific types or models are specified. v A CRU (customer-replacable unit) is identified by a single asterisk (*) or two asterisks (**) in the CRU ID column. An N in the CRU ID column means the part is not a CRU.

  • Page 115: Parts List

    88x, 47x, 34x, 8Kx v 1707-CTO, 5Kx v 1708-CTO, 54x, 5Kx, 5Mx, 74x, 7Dx, 86x, 8Cx, 95x v 1709-CTO, 47x, 54x, 5Jx, 5Lx, 5Nx, 74x, 7Dx, 7Hx, 85x, 86x, 89x, 8Cx, 96x, 97x v 2509-CTO v 2510-CTO (continued) ThinkPad X60...
  • Page 116 Parts list FRU no. RoHS Fingerprint card 41W1094 v 1702-CTO, 34x, 44x, C3x, 79x, 93x, 3Qx, 4Ex, 5Nx, 4Fx, 3Sx, 68x, 6Cx, 5Fx, 74x, 76x, 55x, 4Gx, 58x, 5Px, 4Kx, 5Ex, 5Cx, 5Kx, 5Jx, 95x, 96x, 98x, 99x, C4x, C5x, C6x, C7x, 5Mx, 86x, 38x, 4Bx, 5Gx, 63x, 6Bx, 45x, 64x, 65x, 4Hx, 97x, 3Rx, 75x, 77x, 78x, 5Qx, 5Rx, 87x, 39x, 5Dx, 57x, 25x, 73x, 5Sx, 5Tx...
  • Page 117 1707-CTO, 5Dx, 5Kx v 1708-CTO, 5Kx, 86x, 5Mx v 1709-CTO, 96x, 97x, 86x, 7Hx, 83x, 59x, 5Lx, 5Nx, 89x v 2509-CTO v 2510-CTO, 57x Sanyo 92P1171 Sony 92P1173 Extended battery Li-Ion (Sanyo) 40Y7904 — Battery spacer 92P1227 (continued) ThinkPad X60...
  • Page 118 Parts list FRU no. RoHS Hard disk drive cover 41V9740 Hard disk drive, 30GB, PATA, 4200rpm, 1.8-inch v 1702-CTO v 1703-CTO v 1704-CTO v 1705-CTO v 2507-CTO v 2508-CTO v 2533-CTO, B4x, A5x, A4x Toshiba 39T2747 Hard disk drive, 40GB, PATA, 4200rpm, 1.8-inch v 1702-CTO v 1703-CTO v 1704-CTO...
  • Page 119 1706-CTO, 63x, 64x, 8Ax, 85x, 86x, 95x, 6Dx, 89x, 87x, 8Ex, 8Dx, 49x, 4Ax, 8Bx, 93x, 94x, 8Fx, 88x, 84x, 8Kx v 1707-CTO v 1708-CTO, 86x, 95x, 8Cx v 1709-CTO, 96x, 86x, 83x, 8Cx, 89x, 84x, 85x v 2509-CTO v 2510-CTO Hitachi 39T2705 Toshiba 39T2713 Fujitsu 39T2641 (continued) ThinkPad X60...
  • Page 120 Parts list FRU no. RoHS Hard disk drive, 100GB, SATA, 5400rpm, 2.5-inch v 1702-CTO, 5Nx, 68x, 6Cx, 76x, 5Px, 77x, 5Qx v 1703-CTO v 1704-CTO, 69x v 1705-CTO v 2507-CTO v 2508-CTO v 2533-CTO v 1706-CTO, 69x, 6Bx, 8Gx, 8Hx v 1707-CTO v 1708-CTO v 1709-CTO, 97x...
  • Page 121 1707-CTO, 5Dx, 5Kx v 1708-CTO, 5Kx, 86x, 5Mx, 7Dx, 95x, 8Cx v 1709-CTO, 96x, 97x, 24x, 86x, 7Hx, 47x, 79x, 83x, 59x, 7Dx, 8Cx, 5Lx, 5Nx, 5Ax, 5Jx, 5Ex, 45x, 89x, 84x, 85x v 2509-CTO, 57x v 2510-CTO, 57x (continued) ThinkPad X60...
  • Page 122 Parts list FRU no. RoHS Hard disk drive sub card, 1.8-inch 92P6238 v 1702-CTO, 74x, 94x, 76x, 95x, 96x, 98x, 99x, C4x, C5x, C6x, C7x, 97x, 75x, 77x, 78x, 73x, 7Ax, 7Bx v 1703-CTO v 1704-CTO v 1705-CTO v 2507-CTO v 2508-CTO v 2533-CTO, B4x, B5x, A5x, A4x Hard disk drive sub card, 2.5-inch...
  • Page 123 1705-CTO, 4Cx, 5Hx for xxG v 2507-CTO v 2508-CTO v 2533-CTO v 1706-CTO, 8Gx for xxG v 1707-CTO, 5Dx, 5Kx for xxG v 1708-CTO, 7Dx, 95x, 8Cx for xxG v 1709-CTO for xxG v 2509-CTO v 2510-CTO (continued) ThinkPad X60...
  • Page 124 Parts list FRU no. RoHS Intel PRO Wireless 3945ABG PCI Express Mini Card 41W1031 v 1702-CTO, 3Jx, 3Qx, 49x, 4Ex, 37x, 4Fx, 58x, 5Jx, 84x, 85x, 36x, 3Fx, 5Mx, 86x, 38x, 5Gx, 3Rx, 3Kx, 75x, 77x, 78x, 5Qx, 5Rx, 87x, 39x, 23x, 25x, 73x, 3Hx, 3Cx, 3Nx, 5Kx, 83x, 5Dx, 53x, 57x, 5Sx for xxC, xxK v 1703-CTO, 37x, 3Jx, 3Qx for xxC, xxK...
  • Page 125 2508-CTO v 2533-CTO v 1706-CTO, 5Dx, 5Kx, 7Fx, 59x, 58x, 5Fx, 5Hx, 55x, 44x, 47x, 33x, 34x for xxT v 1707-CTO, 5Dx, 5Kx for xxT v 1708-CTO for xxT v 1709-CTO for xxT v 2509-CTO v 2510-CTO (continued) ThinkPad X60...
  • Page 126 Parts list FRU no. RoHS ThinkPad 11a/b/g Wireless LAN PCI Express Mini Card Japan 39T5613 v 1702-CTO for xxJ, xxE v 1703-CTO v 1704-CTO v 1705-CTO v 2507-CTO v 2508-CTO v 2533-CTO, B5x for xxJ, xxE v 1706-CTO, 63x, 64x, 69x, 6Bx, 4Bx, 4Cx, 49x, 4Ax, 26x for xxJ, xxE v 1707-CTO v 1708-CTO...
  • Page 127 41W1073 v 1702-CTO for xxK v 1703-CTO v 1704-CTO v 1705-CTO v 2507-CTO v 2508-CTO v 2533-CTO v 1706-CTO for xxK v 1707-CTO v 1708-CTO v 1709-CTO for xxK v 2509-CTO v 2510-CTO ThinkPad Modem (MDC-1.5) 39T0495 (continued) ThinkPad X60...
  • Page 128 Parts list FRU no. RoHS Lower case assembly with label, X60s (M/T 1702) 41V9727 Lower case assembly with label, X60s (M/T 1703) 41V9728 Lower case assembly with label, X60s (M/T 1704) 41V9729 Lower case assembly with label, X60s (M/T 1705) 41V9730 Lower case assembly with label, X60s (M/T 2507) 41V9731...
  • Page 129 Speaker kit 39T7306 Planar Yonah SC ULV U1300 1.06GHz 42T0017 v 1702-CTO, 83x, 84x, 85x, 86x, 87x, 93x, 95x, 96x, 97x, v 1703-CTO v 1704-CTO v 1705-CTO, 85x v 2507-CTO v 2508-CTO v 2533-CTO, B3x, B4x, B5x (continued) ThinkPad X60...
  • Page 130 Parts list FRU no. RoHS Planar Yonah DC LV L2400 1.67GHz 42T0019 v 1702-CTO, 34x, 79x, 3Jx, 3Lx, 3Qx, 37x, 3Hx, 3Dx, 3Ex, 3Cx, 74x, 94x, 76x, 3Gx, 3Mx, 3Nx, 3Ax, 98x, 36x, 3Fx, 38x, 35x, 3Rx, 3Kx, 75x, 77x, 78x, 39x, 53x, 73x, 7Ax, v 1703-CTO, 37x, 3Jx, 3Qx v 1704-CTO, 33x, 34x, 3Qx, 3Tx, 3Dx v 1705-CTO, 33x, 34x, 3Qx, 3Ux, 3Gx, 3Px, 53x...
  • Page 131 2508-CTO, 3Bx v 2533-CTO, A3x, A4x, A5x Fan assembly, Standard Voltage 41V9749 v 1706-all v 1707-all v 1708-all v 1709-all v 2509-all v 2510-all Backup battery (3V with wire) 92P1210 TrackPoint cap set 91P9642 ThinkPad X6 UltraBase 40Y8120 ThinkPad X60...

  • Page 132: Lcd Frus

    Parts list LCD FRUs 12.1-in. XGA TFT MT1702/1703/1704/1705/1706/1707/1708/1709/2507/2508/2509/2510/2533/2534...
  • Page 133 LCD inverter card (Foxconn) 39T5699 LCD inverter card (Sumida) 41W1024 Note: The WAN antenna cable set for Verizon (SPWG) 5 is included in FRU 91P6976 together with the WWAN cable for Verizon (aux) 13 listed in “Overall” on page 107. ThinkPad X60...

  • Page 134: Keyboard

    Parts list Keyboard Language P/N (NMB) RoHS CRU ID Arabic 39T7280 Belgian 39T7277 Canadian, multilanguage (445) 39T7266 Chinese, Traditional 39T7291 Czech 39T7285 Danish 39T7274 Dutch 39T7271 English, U.K. 39T7269 English, U.S. 39T7265 English, U.S. (International, with a Euro symbol) 39T7295 Finnish, Swedish 39T7272 French, Canadian (058)

  • Page 135: Recovery Cds

    7Ex, 7Fx, 85x, 86x, 87x, 8Ax, 8Bx, 8Dx, 8Fx, 8Gx, 8Hx, 8Jx, 93x, 94x, 95x, v 1707-5Dx, 5Kx, v 1708-5Kx, 5Mx, 7Dx, 86x, 8Cx, 95x, v 1709-24x, 47x, 59x, 5Jx, 79x, 7Dx, 7Hx, 83x, 85x, 86x, 8Cx, 96x, 97x v 2509-57x v 2510-57x ThinkPad X60...
  • Page 136 Parts list Language RoHS Chinese, Simplified 42J7138 Chinese, Traditional (Taiwan) 42J7139 Chinese, Traditional (Hong Kong S.A.R.) 42J7140 Czech 42J7129 Danish 42J7127 Dutch 42J7128 English, Arabic 42J7133 English, Russian 42J7323 English, Universal, Disabled 42J7121 English, U.S. 42J7117 Finnish 42J7130 French 42J7118 German 42J7119 Greek...

  • Page 137: For Windows Xp Home

    1706-27x, 48x, 4Ex, 5Ax, 5Bx, 5Gx, 5Lx, 78x, 7Bx, 7Cx, 7Gx, 84x, 88x, 89x, 8Ex, v 1709-45x, 5Ax, 5Ex, 5Lx, 5Nx, 84x, 89x Language RoHS Chinese, Simplified 42J7319 Chinese, Traditional 42J7320 Chinese, Traditional (Hong Kong S.A.R.) 42J7321 English, U.S. 42J7317 Japanese 42J7318 Korean 42J7322 ThinkPad X60...

  • Page 138: Miscellaneous Parts

    Parts list Miscellaneous parts RoHS Base cover miscellaneous parts kit 41V9741 System miscellaneous parts kit 41V9742 Screw kit 41V9754 Rubber kit (X60s) 41V9750 Rubber kit (X60) 41V9772 AC adapters RoHS 2-pin (65 W, 20 V) AC adapter (Delta) 92P1155 v Models-CTO, xxE, xxF, xxJ, xxP, xxS, xxU, xxY 2-pin (65 W, 20 V) AC adapter (Liteon) 92P1159 v Models-CTO, xxE, xxF, xxJ, xxP, xxS, xxU, xxY...

  • Page 139: Common Parts List

    PCI-Express/USB wrap card 27K9813 ThinkPad Hardware Maintenance Diskette Version 1.73 or later — Note: Download the file from the following Web site: http://www.lenovo.com/ think/spm Power cords (system) A ThinkPad power cord for a specific country or region is usually available only in...
  • Page 140 Parts list For 3-pin power cords: Region RoHS China 39M4996 Australia, New Zealand 39M4960 U.S., Canada, Thailand 39M4955 Europe 39M4964 Denmark 39M4968 South Africa, India 39M4972 U.K. 39M4976 Switzerland 39M4980 Italy 39M4984 Israel 39M4988 Korea 39M5000 MT1702/1703/1704/1705/1706/1707/1708/1709/2507/2508/2509/2510/2533/2534...

  • Page 141: Notices

    Web sites. The materials at those Web sites are not part of the materials for this Lenovo product, and use of those Web sites is at your own risk.

  • Page 142: Trademarks

    Actual results may vary. Users of this document should verify the applicable data for their specific environment. Trademarks The following terms are trademarks of Lenovo in the United States, other countries or both: Lenovo Rescue and Recovery...
  • Page 143 Trademarks ThinkPad X60...
  • Page 144 Part Number: 41W2542 (1P) P/N: 41W2542...

Table of Contents