Metal Part cal return path to the chassis. Any current measured must not exceed 0.5mA. Reverse the instrument power cord plug in the out- ohmmeter let and repeat the test. See Fig. 1-1. Fig. 1-2 Insulation Resistance Test Samsung Electronics...
Page 6
(5) antenna wiring. Always inspect in all areas tinuously and new instructions are issued whenev- for pinched, out-of-place, or frayed wiring, Do not er appropriate. change spacing between a component and the printed-circuit board. Check the AC power cord for damage. Samsung Electronics...
Components identi- fied by shading, by( ) or by ( ) in the circuit dia- gram are important for safety or for the characteris- tics of the unit. Always replace them with the exact replacement components. Samsung Electronics...
(6) Do not remove a replacement ESD device from its protective package until immediately before your are ready to install it.(Most replacement ESD devices are packaged with leads electrically short- ed together by conductive foam, aluminum foil or comparable conductive materials). Samsung Electronics...
◆ Be sure to put on a wrist strap grounded to the sheet. ◆ Be sure to lay a conductive sheet made of copper etc. Which is grounded to the table. Samsung Electronics...
Product Specification 2-2 Chassis Product Specification General Model Name DVD-R130/XAA Info Function Standard COLOR SYSTEM NTSC SYSTEM BROADCAST SSTEM AUTO CLOCK DVD-RAM DVD-R DVD-RW VIDEO MPEG-2 AUDIO RECORER DVD-RAM/-R(4.7GB) FUNCTION Flexible Recording Time Slip VCR+Plus Quick Dubbing EPG(Gemstar) IR Blaster...
Product Specification 2-3 Option Product Specification Description Fig Description Parts No Remark Remote Model Standard of (AK59-00055A) Control DVD-R130/XAA Model Standard of Batteries for (AC43-12002H) DVD-R130/XAA Remote Control S.N.A Model Standard of User’s Manual (AK68-01002A) DVD-R130/XAA Model Standard of (AK68-01013A)
Page 15
This can be virtually used as hard-disk, with a random DVD-RAM (more than 100,000 times) read-write access Rewritable Similar to DVD-RAM except than its technology features DVD-RW (About 1,000 times) a separated read-write access more like phonograph than a hard disk. Samsung Electronics...
Recording type Dolby Digital Linear PCM MPEG-1 Layer 2 AUDIO Transmission rate 448Kbps/stream 6.144Mbps/stream 224Kbps 1 Analog CH. Channel 5.1CH/stream 8CH/stream 1 Stream of Dolby Digital 2 Digital CH. (16Bit/44.1KHz) Sampling frequency 48KHz 16, 20, 24Bit/48, 96KHz 16Bit/44.1KHz Samsung Electronics...
Page 17
Data loss and enables Time efficient compression. Loss area • MPEG-1 (Fixed compression : Max. 1/140) Amount of data - Frame unit compression. - Compresses all data using the same ratio. Video-CD - Fast movements are jagged, and unnatural Time Samsung Electronics...
Page 18
- Various Digital Recordings are possible as shown in the table to the right. Sampling Frequency Bit Rate 16bit 48KHz 20bit 24bit 16bit 96KHz 20bit 24bit • Dolby Digital compatible Audio Mode Channel Format Audio Coding Front Surround (Rear) Remark Mode Mono Stereo Mono Mono Surround Samsung Electronics...
Page 19
• Up to 9 angles of view may be stored, enabling the viewer to select a specific viewpoint at a given time. --> Especially, for the Music Video and Sports Title, this provides a more lively image of the scene. Note ; This function is disc-dependent, may not work on all DVDs. Samsung Electronics...
Page 20
- Region 6 : China. - Region 0 : Worldwide (All Code) ˆ Œ ´ Œ Ø ´ Œ ˇ ˆ ¨ ´ ¨ • Adoptation of the Macrovision System disables the copying on to other media. 2-10 Samsung Electronics...
Page 21
- Different Authoring Process are used accoring to the Software developers, and this may affect the DVD image quality. • Authoring Process bit stream Video/Audio MPEG-2 Master Encoding Disc Production bit stream Video/Audio Surround Audio AC-3/MPEG Audio Cutting Subtitle Master Encoding Master Multiplexing bit stream Subtitle Subtitle Master Encoding Authoring Process Samsung Electronics 2-11...
• Write the downloaded file onto a blank CD-R or CD-RW disc, using the following settings : 1) Download the software update file from the samsung internet site. (www.samsung.com) 2) Write the file to disc using the CD-RW of your computer.
Page 24
Fig. 3-4 Fig. 3-5 6) After removing the update disc, turn off the unit with power button. And there after turn on the unit with power button and then the will be closed. The drive firmware is now completed. Samsung Electronics...
Page 25
Write the downloaded file onto a blank CD-R or CD-RW disc, using the following settings : 1) Download the software update file from the samsung internet site. (www.samsung.com) 2) Write the file to disc using the CD-RW of your computer.
The message below will be displayed in the screen after update is completed and the tray will open automatically. * If the message to the left isn’t displayed after 10minutes and the unit is no longer functioning properly, contact a samsung authorized service center. Flash Update Flash memory is successfully updated.
1) Remove 5 Screws Œ, ´, ˇ. 2) Lift up the Top Cabinet in direction of arrow. 1 SCREW (3 x 10 B) 3 SCREWS (3 x 10 B) 1 SCREW (3 x 10 B) Fig. 4-1 Top Cabinet Removal Samsung Electronics...
Page 29
4-1-3 Ass’y Deck Removal 1) Remove 4 Screws Œ, ´ from the Ass’y Deck ˇ and lift it up. 2 SCREWS 2 SCREWS (3 x 8 Y) (3 x 10 Y) Ass’y Deck Fig. 4-3 Ass’y Deck Removal Samsung Electronics...
Page 30
Disassembly and Reaasembly 4-1-4 Main PCB Removal 1) Remove 2 Screws Œ, from the Main PCB ´ and lift it up. 2 SCREWS (3 x 8 Y) Fig. 4-4 Main PCB Removal Samsung Electronics...
Page 31
2) Remove 1 Screw ¨ from the Sub PCB ˆ and lift it up. 4 SCREWS 1 SCREW (3 x 6 Y) (3 x 6 Y) 1 SCREW (3 x 6 W) Fig. 4-5 Jack PCB and Sub PCB Removal Samsung Electronics...
Change short circuited or PFZZ1/2~ PVZL1/2 opened parts SHORT and OPEN Are normal? Is there voitage at Change PQIZ1 IC. PQIZ1[Pin 5]? (Over 10V) Operation of PQIZ1 is Replace PQIZ1 Normal? Check feed back PQIZ1[PIN 3] Is 5.8V Samsung Electronics...
Page 34
Set audio setting to can Decode Current Setting is PCM. Bitstream in customer Bit-Steam menu. ChecK Digital Audio data Replace Main PCB at pin 2 of CN4 (MAIN PCB) Replace AVJ5 Check 5V AVJ5 AUDIO DATA Check the Cable Samsung Electronics...
Page 35
# IF Recorder is under PSO (progressive scan output) MODE, it does not output the CVBS& S-Video signal. Video signal of Check the connection between About P-P1V appears at VIC1 and output jack. Output Jack? CVBS(Color-bar) Check the RCA Cable Samsung Electronics...
Page 36
# Nomal level : pin 10 is 1Vpk-pk pin 8 is 0.28V on color burst Video signal of Check the connection between About P-P1V appears at VIC1 and output jack. Output Jack? Y(Color-bar) C(Color-bar) Check the RCA cable Samsung Electronics...
Page 37
Has about p-p 1V level? Pin 5 in IC702 and L2 Pin-Jack. Pin 13 In IC702 Check Pin 1 in IC702 Has about p-p 1V signal? of input power(5V). VIC1 of Main PCB Clock VIC1 of Main PCB DATA Samsung Electronics...
Page 38
VIC1 of Main PCB and Pin 7 in IC702. has about p-p 1V level? Pin40 and pin 54~43 in VIC1 Check VIC1 of Main PCB of Main PCB has Clock and peripheral circuit. . Digital Video Signal normal form ? CVBS(Color -bar) Change Main PCB Samsung Electronics...
Page 39
Pin40 and pin 54~43 in VIC1 Check VIC1 of Main PCB of Main PCB has Clock and peripheral circuit. Digital Video Signal normal form ? VIC1 of Main PCB Clock Change Main PCB VIC1 of Main PCB DATA Samsung Electronics...
Page 40
Tuner input line signal is OK? Connect tuner line to TV directly (jack PCB) Supplied power Pin 3 : 5V pin 14 : 33V check its line (Pin 3 : 5V pin 14 : 33V) for (jack PCB) tuner is OK? Samsung Electronics...
Page 41
Video signal of Check the connection between About 1V pk-pk appears at VIC1 and output jack. Output Jack? # Nomal level : pin 6 is 1Vpk-pk pin 2/4 is + 0.35V Check the RCA cable Pb(Color-bar) Pr(Color-bar) Y(Color-bar) Samsung Electronics...
Page 42
Replace Main PCB and 5V pin5 of AU5 (MAIN PCB) Digital clock(12) Check Digital clock and data Replace Main PCB pin 10, 11, 12, 15 of AU5(MAIN PCB) Digital clock(15) Check the passive parts around jack pin. 5-10 Samsung Electronics...
Page 43
Check the audio signal pin7 Replace Main PCB pin8 of AIC1 (MAIN PCB) Check digital clock and data pin1, 2, 3, 16 of AIC1 Replace MAIN PCB (MAIN PCB) AUDIO DATA Check the passive parts arond Jack pin. Samsung Electronics 5-11...
Page 44
Tuner line connect TV directly. is OK? IIC line (SCL,SDA) from Check the IIC line front micom is OK? Does TY2 make 14.31 Check TY2 or around elements Mhz signal? (jack PCB) Change IC601 or check around elements 5-12 Samsung Electronics...
Page 45
Check he power power OK? (5v, 12v) Is the 40pin FFC cable(betweenmain & deck) Reinsert FFC cable correctly inserted correctly? Is the wavefrom Change the Main board of DIC3 pin26 normal? (MAIN PCB) DIC3-Pin26 Change the deck Samsung Electronics 5-13...
Page 46
(Pin 3 : 5V pin 14 : 33V) for (jack PCB) tuner is OK? Check IC203 or its around elements Video signal of TE14 is OK? (jack PCB) (jack PCB) Tuner Video Refer to video line in abnormal 5-14 Samsung Electronics...
Page 47
4.5MHz signal from 13 pin Check the SIF signal or tuner of tuner(TM1) is OK? Does XT4M01 Check XT4M01 or around elements make 3.58MHz signal? (jack PCB) Tuner Audio If TIC1 is normal, refer to audio line in abnomal Samsung Electronics 5-15...
Page 48
Troubleshooting Remocon Error KRMC1(pin1) signal Check the power(pin2) line is OK? (SMPS PCB) orchange KRMC1. IC601(pin5) signal Check the signal line or surrounding is OK? (Jack PCB) elements. Change IC601 or surrounding elements 5-16 Samsung Electronics...
W275 (3 x 6 Y) P022 W275 (3 x 6 Y) C015 P004 W001 (3 x 10 B) P025 W268 (3 x 6 W) S.N.A.: Service Not Available A001 C001 W009 (3 x 10 Y) C002 P007 C657 Samsung Electronics...
C-CER,CHIP;100nF,10%,16V,X7R,TP,1608 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,TP,1608 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,TP,1608 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,TP,1608 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,TP,1608 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,TP,1608 2203-000440 C-CER,CHIP;1nF,10%,50V,X7R,TP,1608,- 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,TP,1608 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,TP,1608 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,TP,1608 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,TP,1608 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,TP,1608 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,TP,1608 2203-000426 C-CER,CHIP;0.018nF,5%,50V,C0G,1608 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,TP,1608 Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 54
R-CHIP;22ohm,5%,1/10W,TP,1608 RP23 2011-001194 R-NET;51ohm,5%,1/16W,L,CHIP,8P,TP,3. 2007-000070 R-CHIP;0ohm,5%,1/10W,TP,1608 RP24 2011-001194 R-NET;51ohm,5%,1/16W,L,CHIP,8P,TP,3. 2007-000070 R-CHIP;0ohm,5%,1/10W,TP,1608 RP25 2011-001194 R-NET;51ohm,5%,1/16W,L,CHIP,8P,TP,3. 2007-000070 R-CHIP;0ohm,5%,1/10W,TP,1608 RP26 2011-001194 R-NET;51ohm,5%,1/16W,L,CHIP,8P,TP,3. 2007-000070 R-CHIP;0ohm,5%,1/10W,TP,1608 RP27 2011-001194 R-NET;51ohm,5%,1/16W,L,CHIP,8P,TP,3. 2007-000070 R-CHIP;0ohm,5%,1/10W,TP,1608 RP28 2011-001194 R-NET;51ohm,5%,1/16W,L,CHIP,8P,TP,3. Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 55
R-CHIP;100ohm,5%,1/10W,TP,1608 2007-000113 R-CHIP;33ohm,5%,1/10W,TP,1608 AC702 2203-000783 C-CER,CHIP;0.33NF,5%,50V,C0G,TP,1608 2007-000113 R-CHIP;33ohm,5%,1/10W,TP,1608 AC705 2203-000783 C-CER,CHIP;0.33NF,5%,50V,C0G,TP,1608 VRP1 2011-000002 R-NET;22ohm,5%,1/16W,L,CHIP,8P,TP,32 AC714 2203-000783 C-CER,CHIP;0.33NF,5%,50V,C0G,TP,1608 AC715 2203-000783 C-CER,CHIP;0.33NF,5%,50V,C0G,TP,1608 VRP2 2011-000002 R-NET;22ohm,5%,1/16W,L,CHIP,8P,TP,32 ACC2 2203-000315 C-CER,CHIP;0.12nF,5%,50V,C0G,1608 VRP3 2011-000816 R-NET;100OHM,5%,1/16W,L,CHIP,8P,TP Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 56
2007-000090 R-CHIP;10Kohm,5%,1/10W,TP,1608 C637 2401-003107 C-AL;47uF,20%,16V,GP,TP,5x7,5 AR471 2007-000070 R-CHIP;0ohm,5%,1/10W,TP,1608 C647 2203-000681 C-CER,CHIP;0.027nF,5%,50V,C0G,1608 AR472 2007-000090 R-CHIP;10Kohm,5%,1/10W,TP,1608 C651 2202-000216 C-CERAMIC,MLC-AXIAL;0.027NF,5%,50V,SL,TP AR473 2007-000075 R-CHIP;220ohm,5%,1/10W,TP,1608 C652 2203-000681 C-CER,CHIP;0.027nF,5%,50V,C0G,1608 AR474 2007-000075 R-CHIP;220ohm,5%,1/10W,TP,1608 C658 2203-001155 C-CER,CHIP;0.068nF,5%,50V,NP0,TP,1608 Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 57
2401-001126 C-AL;330uF,20%,25V,WT,TP,10x12.5,5 IC603 1103-001134 IC-EEPROM;24C040,512x8,SOP,8P,5.13x3.95m PPCI3 2401-003499 C-AL;330uF,20%,16V,LZ,TP,8x11.5mm,5 IC604 1204-002509 IC-SIGNAL PROCESSOR;CXA2207N,SSOP,32P,11 PPCO1 2401-000385 C-AL;10uF,20%,100V,GP,TP,6.3x11,5 IC701 1003-001561 IC-LED DRIVER;PT6961,SOP,32P,300MIL,-,40 PPCO2 2401-002300 C-AL;47uF,20%,50V,GP,TP,6.3x11,5 IC702 1001-001056 IC-VIDEO SWITCH;MM1113XF,-,SOP,8P,-,-,5V PPDD1 0404-001235 DIODE-SCHOTTKY;SHK65-45R,60V,3000mA,DO-2 Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 58
R-CHIP;4.7Kohm,5%,1/10W,TP,1608 2401-001020 C-AL;3.3UF,20%,50V,GP,TP,4X7,5 R633 2007-000106 R-CHIP;220Kohm,5%,1/10W,TP,1608 2401-004014 C-AL;4.7uF,20%,16V,-,TP,4x5,2.5 R638 2007-000082 R-CHIP;3.3Kohm,5%,1/10W,TP,1608 2401-000414 C-AL;10uF,20%,16V,GP,TP,4x7,5 R639 2007-000081 R-CHIP;2.7Kohm,5%,1/10W,TP,1608 TC74 2203-005148 C-CER,CHIP;100nF,10%,16V,X7R,TP,1608 R652 2007-000090 R-CHIP;10Kohm,5%,1/10W,TP,1608 2401-000414 C-AL;10uF,20%,16V,GP,TP,4x7,5 R653 2007-000078 R-CHIP;1Kohm,5%,1/10W,TP,1608 2401-000414 C-AL;10uF,20%,16V,GP,TP,4x7,5 Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 59
AK66-00072A SHAFT-PU;DP-RW2,SUS420J2,91.5,3,NATURAL H401 AK61-00485B FRAME-MAIN;DP-R3,ABS,ABS,-,BLK,-,W150,L1 VZ12 0403-001083 DIODE-ZENER;UDZ9.1B,8.85-9.23V,200MW,UMD 3708-001331 CONNECTOR-FPC/FFC/PIC;40P,0.5mm,SMD-A,AU 0403-001083 DIODE-ZENER;UDZ9.1B,8.85-9.23V,200MW,UMD 0403-001083 DIODE-ZENER;UDZ9.1B,8.85-9.23V,200MW,UMD 2203-006048 C-CER,CHIP;100NF,10%,10V,X7R,TP,1005 0403-001083 DIODE-ZENER;UDZ9.1B,8.85-9.23V,200MW,UMD PC10 2402-000179 C-AL,SMD;47uF,20%,16V,GP,TP,6.6x6.6x5.7 0403-001083 DIODE-ZENER;UDZ9.1B,8.85-9.23V,200MW,UMD PC12 2203-006048 C-CER,CHIP;100NF,10%,10V,X7R,TP,1005 PC14 2203-006048 C-CER,CHIP;100NF,10%,10V,X7R,TP,1005 Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 60
R-CHIP;15Kohm,5%,1/16W,TP,1005 RC47 2203-000627 C-CER,CHIP;0.022nF,5%,50V,C0G,1005 RR46 2007-000171 R-CHIP;0ohm,5%,1/16W,TP,1005 RC48 2203-000438 C-CER,CHIP;1nF,10%,50V,X7R,1005 S.N.A AH31-00025A MOTOR-LOADING;RF-300EA-1D390,DP-7,170mA, RC49 2203-000438 C-CER,CHIP;1nF,10%,50V,X7R,1005 S.N.A AK66-00006A PULLEY MOTOR;DP-9,POM ,-,BLK,-,-,-,- RC50 2203-000254 C-CER,CHIP;10nF,10%,16V,X7R,1005 S.N.A 0201-000169 ADHESIVE-CYA;ARCN-A501F,NTR 0.01 SNA Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 61
UC46 2203-006048 C-CER,CHIP;100NF,10%,10V,X7R,TP,1005 S.N.A AK67-00035A LENS-MR;SOH-DR3,GLS,WHT,5.0*4.0,2.5,-, UC47 2203-000254 C-CER,CHIP;10nF,10%,16V,X7R,1005 S.N.A AK67-00036A LENS-DVD GT;SOH-DR3,GLS,WHT,2.5*3.0,1.0, UC48 2203-006048 C-CER,CHIP;100NF,10%,10V,X7R,TP,1005 S.N.A AK67-00038A LENS-CBS;SOH-DR3,GLS,WHT,3.0*3.0,3.0,-, UC49 2203-006048 C-CER,CHIP;100NF,10%,10V,X7R,TP,1005 S.N.A AK67-00041A LENS-CD GT;SOH-DR2.5,GLS,WHT,2.0*1.5,1.0 UC50 2203-006048 C-CER,CHIP;100NF,10%,10V,X7R,TP,1005 Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 62
R-CHIP;10Kohm,5%,1/16W,TP,1005 VR14 2007-000034 R-CHIP;1OHM,5%,1/4W,TP,3216 UR44 2007-000171 R-CHIP;0ohm,5%,1/16W,TP,1005 VR16 2007-000034 R-CHIP;1OHM,5%,1/4W,TP,3216 UR47 2007-000148 R-CHIP;10Kohm,5%,1/16W,TP,1005 VR18 2007-000034 R-CHIP;1OHM,5%,1/4W,TP,3216 UR48 2007-000148 R-CHIP;10Kohm,5%,1/16W,TP,1005 VR20 2007-000148 R-CHIP;10Kohm,5%,1/16W,TP,1005 UR49 2007-000143 R-CHIP;4.7Kohm,5%,1/16W,TP,1005 VR25 2007-007107 R-CHIP;100Kohm,1%,1/16W,TP,1005 Samsung Electronics 7-10 This Document can not be used without Samsung’s authorization...
Page 63
FL614 3809-001780 FFC CABLE-FLAT;30V,80C,105mm,40P,0.5mm,U FL615 3809-001787 FFC CABLE-FLAT;30V,80C,115mm,13P,1mm,UL7 AK68-01002A MANUAL USERS;DVD-R130,XAA,ENG,-,MOJO80,W SA DVD-R130/XAA AK68-01002B MANUAL USERS;DVD-R130,XAC,ENG,FRA, SA DVD-R130/XAC S.N.A AK69-00371A PACKING CASE;DVD-R130/XAA,SW-2,A-1 TYPE, VS106 AK39-00086A LEAD CONNECTOR;SV-R3600,LEAD CONNECTOR,U 7-11 Samsung Electronics This Document can not be used without Samsung’s authorization...
Page 64
Electrical Parts List MEMO Samsung Electronics 7-12 This Document can not be used without Samsung’s authorization...
L/R from (JACK) Tuner Audio D/A AIC2(Main) Audio A/D COAXIAL IC601 (JACK) IEC-958 Front Micom OPTICAL DIGITAL AUDIO OUT Key Input Front PCB Remocon FIC1 (Main) IEEE1394PHY 1394 JACK Samsung Electronics This Document can not be used without Samsung’s authorization.
MIXER SDOUT Video PENTA DAC CalmADM #1 Analog Video Out 12KB I-Cache D-Cache IODMA PLL, Clock/Reset APB Bridge Generation Block 27MHz X-tal SPDIF(IN) SPDIF(OUT) UART Host I/F TIMER GPIO Samsung Electronics This Document can not be used without Samsung’s authorization.
Schematic Diagrams 11-1 S.M.P.S (Jack PCB) Power 11-2 Samsung Electronics This Document can not be used without Samsung’s authorization.
Page 85
Schematic Diagrams 11-2 TM Block (Jack PCB) Video Audio Power Samsung Electronics This Document can not be used without Samsung’s authorization. 11-3...
Page 86
Schematic Diagrams 11-3 AV Input (Jack PCB) Video Audio Power 11-4 Samsung Electronics This Document can not be used without Samsung’s authorization.
Page 87
Schematic Diagrams 11-4 Micom (Jack PCB) Power Samsung Electronics This Document can not be used without Samsung’s authorization. 11-5...
Schematic Diagrams 11-10 Latch And Audio (Main PCB) Audio Power Samsung Electronics This Document can not be used without Samsung’s authorization. 11-11...
Schematic Diagrams 11-11 Main Connector (Main PCB) Video Audio Power 11-12 Samsung Electronics This Document can not be used without Samsung’s authorization.
Schematic Diagrams 11-12 Video Decoder (Main PCB) Video Power Samsung Electronics This Document can not be used without Samsung’s authorization. 11-13...
Schematic Diagrams 11-13 Sub and Key (Sub and Key PCB) Audio Power 11-14 Samsung Electronics This Document can not be used without Samsung’s authorization.
1. Lights when a disc is loaded. 4. Lights when a DVD-R/-RW/-RAM disc is 2. Lights in the record mode. loaded. 3. Lights to indicate the timer record mode. 5. Alpha/Numeric display. 6. Lights in the progressive scan mode. English - 11 Samsung Electronics 12-1...
TV, you must connect audio/video cables. Unpacking Accessories Check for the supplied accessories below. Batteries for Remote Control (AAA Size) Quick Guide Video/Audio Cable RF Cable for TV Remote Control Instruction Manual (AC43-12002H) (AC39-00073A) (AC39-42001J) (AK59-00055A) (AK68-01002A) (AK68-01013A) 12 - English 12-2 Samsung Electronics...
Use this to bookmark or mark a position while playing a disc. 10. MENU Button Brings up the DVD recorder’s setup menu. 11. ENTER/DIRECTION Buttons (UP/DOWN and LEFT/RIGHT Buttons) This button functions as a toggle switch. English - 13 Samsung Electronics 12-3...
Step 5 : Connecting the Power Cord ...27 building as close to the point of cable entry as Step 6 : Preparing the Remote Control ..27 practical. 14 - English 12-4 Samsung Electronics...
Page 101
The VHF/UHF ANT (RF) OUT jack of this ■ product sends only signals received through NOTE the antenna. It does not output Audio/Video signals. You must connect Audio/Video cables to view Video from the unit. (i.e. DVD playback) English - 15 Samsung Electronics 12-5...
Page 102
The VHF/UHF ANT (RF) OUT jack of this ■ product sends only signals received through NOTE the antenna. It does not output Audio/Video signals. You must connect Audio/Video cables to view Video from the unit. (i.e. DVD playback) 16 - English 12-6 Samsung Electronics...
Page 103
The VHF/UHF ANT (RF) OUT jack of this ■ product sends only signals received through NOTE the antenna. It does not output Audio/Video signals. You must connect Audio/Video cables to view Video from the unit. (i.e. DVD playback) English - 17 Samsung Electronics 12-7...
Page 104
• You will enjoy normal quality images. • Connect audio cables(white and red) between the AUDIO OUT jacks on the DVD Recorder and AUDIO IN jacks on your TV(or AV amplifier). (See pages 21 ~ 23) 18 - English 12-8 Samsung Electronics...
Page 105
TV connections and the • Connect audio cables(white and red) between the TV input selection settings. AUDIO OUT jacks on the DVD Recorder and AUDIO IN jacks on TV(or AV amplifier). (See pages 21 ~ 23) English - 19 Samsung Electronics 12-9...
Page 106
If there are questions regarding TV set compatibility signals to present clear and clean images. with this model, please contact our customer service center at 1-800-SAMSUNG. • Connect audio cables(white and red) between the AUDIO OUT jacks on the DVD Recorder and AUDIO IN jacks on TV(or AV amplifier).
Step 3 : Connecting the Audio Cable There are several ways to connect your DVD Recorder. Select one of the audio connections on the following pages. Connecting to your TV This connection will use your TV’s speakers. English - 21 Samsung Electronics 12-11...
Page 108
Operating Instructions Connecting to a stereo amplifier with analog input jacks If your stereo amplifier only has AUDIO INPUT jacks(L and R), use the AUDIO OUT jacks. 22 - English 12-12 Samsung Electronics...
Page 109
Digital or DTS sound, you will need to set up the audio settings. (See pages 32~33) Manufactured under license from Dolby Laboratories. “Dolby” and the double-D symbol are trademarks of Dolby Laboratories. “DTS” and “DTS Digital Out” are trademarks of Digital Theater Systems, Inc. English - 23 Samsung Electronics 12-13...
Page 110
Connecting a VCR, Set-Top Box(STB) or DVD Player to the AV 1 IN jacks Connecting a VCR or external device to the AV 1 IN jacks of the DVD Recorder. You can record from connected equipment (VCR, STB or DVD Player). 24 - English 12-14 Samsung Electronics...
Page 111
You can also use the AV 2 IN jacks on the front panel of the DVD Recorder. You can record from connected equipment, such as a camcorder. When an input source is inserted into AV 2 while watching TV, the input will be switched to AV 2 automatically. English - 25 Samsung Electronics 12-15...
Page 112
If the input is not selected automatically, press the ■ INPUT SEL. button on the remote control to select NOTE the DV input. Check your camcorder's owner's manual to see ■ how to use the camcorder in this mode. 26 - English 12-16 Samsung Electronics...
Check if the batteries are drained. • Check if remote sensor is blocked by obstacles. • Check if there is any fluorescent lighting nearby. Dispose of batteries according to local environmental regulations. Do not put them in the household trash. Samsung Electronics 12-17...
3) PALT1, PALT2, PACT1, PACT2 : Noise removal at power input/output. 4) PLRU1 : Rush current limit resistance at the momemt of power cord insertion. · Without PLRT1, the bridge diode might be damaged as the rush current increases. Samsung Electronics 13-1...
Page 116
(Vcc of PQIZ1 decreases below OFF voltage , using only the resistance dut to lode increase after PQIZ1 driving.) (d) Feedback Control Circuit 5.8V TRANS(PQTZ1) PPDF1 PPLF1 PPC1 PPCF3 ICE3B2065P PFRF4 PFRF1 PFRF5 PBIZ1 PFRF2 PFCF1 PFRF3 PFID1 PFRF6 Fig. 13-3 13-2 Samsung Electronics...
(VIDEO DEC) Front Panel I/F IC601 MN101DF06 (Front MICOM) Fig. 13-5 · Main system control · ATAPI interface with DVD-Multi Drive · A/V Encoding/Decoding · Analog Progressive/interlaced video output · Transcoding/rating · IEEE 1394 link layer function 13-4 Samsung Electronics...
Page 119
Circuit Operating Descriptions 13-2-1 GENERAL DESCRIPTION Samsung S5L3200 MPEG AV Codec is designed to provide a cost-effective, low power size and high performance DVD recorder solution for DVD-VR, DVD-video, DVD-audio & many of CD applications. To reduce total system cost, The S5L3200 also provides the following features: a front-end controller, a back-end decoder, a control CPU...
Page 120
· Decodes Dolby AC-3, MPEG1, MPEG2, DTS, MLP, HDCD, AAC and WMA · Supports down mix · MAC2424 for audio signal processing – 24-bit high performance fixed-point DSP coprocessor, 24x24 MAC operation in 1 cycle. – 2 multiplier accumulator registers, 4 general accumulator registers, and 8 pointer registers. 13-6 Samsung Electronics...
2 Direct Seek with Velocity Control 3 Step Motor Control: Macro Seek 4 De-Track and Lens Shift Detection and Compensation 5 Center Error Control 6 DVD Layer Jump 7 Tilt Detect and Compensation DP2 performs High Speed ECC and CD DA Decoder. Samsung Electronics 13-7...
Page 122
ENDEC Pick up Miscellaneous Signal LD,LD Driver (DFT/LPP ATAPI chip /WOBBLE) (ZIC1) Focus Actuator Processor Tracking Actuator APC & OPC TILT Actuator WRITE STRATEGY Sled Spindle Tray Motor Motor Motor Motor Driver MICOM (MIC1) Deck Fig. 13-6 13-8 Samsung Electronics...
As Pin 2, 4 of the IC702 are controlled by the Front Micom, IC702 select RF OF CVBS(Pin1) Line1 of CVBS[Pin3] and AV2 of CVBS[Pin 5]. The analog Video Signal of IC201 output is selected by the IC601 via VIC1(Video Decoder : TW9906) of analog Video Input parts. Samsung Electronics 13-9...
Page 124
The TW9906 decoder includes methods for advanced vertical blanking interval (VBI) data retrieval. The VBI data processor (VDP) slices, parses, and performs error checking on teletext, closed caption (CC), Copy Guard Detect Processing and other VBI data. 13-10 Samsung Electronics...
The above signals, which are CVBS (Composite Video Burst Synchronized), Y(S_Video), C(S_Video), Y(Component)/G(Green), Cr(component)/R(Red), Cb(component)/B(Blue), are selectively outputted 480I(inter- laced Video Output), 480P(progressive Video Output) by the Pront button DIC1 adopts 10bit D/A converter. DIC1 perform video en-coding as well as copy protection. Samsung Electronics 13-11...
Page 126
Y, C, Y(R), Cb(B), Cr(R) outputted from video encoder are inputted to VIC1 [Pin14, 16, 13, 12, 11] respectively. And CVBS Output[Pin 15] is made by Y & C Mixing signal. The signal to which gain is adjusted by amplifier is outputted from jack via 75ohm Resistance (VDR1,2,4,5,6,). 13-12 Samsung Electronics...
1/8 Prescaler Band Driver OSC Amp 4MHz 15 X-tal Prog.Dirlder Band Driver Phese Code 3wice Bas VHF OCS Recelver Charge Pump L.P.F VHF Mixer -RF Amp VHF OSC Single Tune Double Tune & CLOCK DATA ENABLE LOCK Fig.13-10 13-14 Samsung Electronics...
Page 129
Tuner Section EQ.Amp N.S.C SIF Trap APC Tine Const SW VCD Tank To Tuner Section Lock Det RF AGC RF AGC Amp IF AGC AFT Tank To Tuner Section AFT OUT VIDEO OUT AUDIO OUT Fig. 13-11 Samsung Electronics 13-15...
Page 131
However, the specification is open and line scan suppor t could be achieved via Format 7. As for USB 2, it is still in its infancy in machine vision and we are not aware of any kind of machine vision support. Samsung Electronics 14-1...
Page 132
Price 1394 Solution Price with multiple frame grabbers Four Cameras 18,000 Four 1394 Cameras 18,000 Four Frame Grabbers 4,400 One 1394 Interface Card Four Cable One 1394 Hub Four power Supplies Five Cables Total $23,120 Total $18,370 14-2 Samsung Electronics...
Page 133
- Easy and inexpens ive cabl ing , - The system meet s the expect ations for spee d and accuracy, - The range of inspect able parts is much bigger than with the old syste m. Samsung Electronics 14-3...
Page 134
Reference Information MEMO 14-4 Samsung Electronics...