Philips FW-C700 Service Manual

Mini system

Hide thumbs Also See for FW-C700:

User manual (52 pages)

Product information (2 pages)

User manual (29 pages)

100

101

102

103

104

105

106

107

108

109

110

111

112

113

114

115

116

117

118

119

120

121

122

123

124

125

126

127

128

129

130

131

132

133

134

135

136

137

138

139

140

141

142

143

144

145

146

147

148

149

150

151

152

153

154

155

156

157

158

159

160

161

162

163

164

165

166

167

168

169

170

171

172

173

174

175

176

177

178

179

180

page of 180

/ 180
Contents
Table of Contents
Bookmarks

Table of Contents

Quick Links

Need help?

Do you have a question about the FW-C700 and is the answer not in the manual?

Questions and answers

Summary of Contents for Philips FW-C700

Page 1 LASER PRODUCT © Copyright 2001 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips.
Page 2 LOCATION OF PRINTED CIRCUIT BOARDS MAINS SOCKET BOARD HEADPHONE BOARD POWER BOARD VERSION VARIATIONS: Type /Versions: FW-C700 Features & Board in used: Aux in /CDR in Line Out Surround Out Subwoofer Out Digital Out Matrix Surround CD Text Dolby B...
Page 3 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl SPECIFICATIONS GENERAL: CASSETTE RECORDER: Mains voltage : 110-127V/220-240V Switchable Number of track : 2 x 2 stereo : 4.76 cm/sec ± 2% Mains frequency : 50/60Hz Tape speed Power consumption : 15W at Standby Wow and flutter : <...
Page 4: Measurement Setup
www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl MEASUREMENT SETUP Tuner FM Bandpass LF Voltmeter 250Hz-15kHz e.g. PM2534 e.g. 7122 707 48001 RF Generator e.g. PM5326 S/N and distortion meter e.g. Sound Technology ST1700B Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz). Tuner AM (MW,LW) Bandpass LF Voltmeter...
Page 5 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl SERVICE AIDS Service Tools: ESD Equipment: Universal Torx driver holder ........4822 395 91019 Anti-static table mat - large 1200x650x1.25mm ... 4822 466 10953 Torx bit T10 150mm ..........4822 395 50456 Anti-static table mat - small 600x650x1.25mm ..4822 466 10958 Torx driver set T6 - T20 .........
Page 6: Laser Product
www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl WAARSCHUWING WARNING Alle IC’s en vele andere halfgeleiders zijn All ICs and many other semi-conductors are gevoelig voor electrostatische ontladingen susceptible to electrostatic discharges (ESD). (ESD). Careless handling during repair can reduce life Onzorgvuldig behandelen tijdens reparatie kan drastically.
Page 7 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl DISMANTLING INSTRUCTIONS Dismantling of the CDC Module and Front Panel Dismantling of the Cassette Cover 4) Remove the Cover Tray CDC (pos 106) as indicated. 2. Twist screw driver 3. Lift up and out Remove Cover Tray CDC 1.
Page 8 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl Dismantling of the Front Display Board and Front Control Board Dismantling of Rear Portion 1) Remove 1 screw C as indicated to loosen the Headphone 1) Remove 3 screws J and uncatch M1 as indicated to Board (pos 1101-B). loosen the AF Board (pos 1102-A).
Page 9 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl Repair Hints 3) During repair it is possible to disconnect the Tuner board Service pos C Picture 3 and CDC Module completely unless the fault is sus- pected to be in that area. This will not affect the performance of the rest of the set.
Page 10 Triggered when the focus could not be found within a certain time when starting up the CD or when the focus is lost for a certain time during play. LEDs FW-C500 , FW-C550 FW-C700 , FW-C720 FW-P750 Radial Error E1001...
Page 11 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl SET BLOCK DIAGRAM 75 ohm COAX1 (FROM CDC) Vpp 0.5V NOTE : MAIN SIGNAL PATH MEASUREMENTS ARE IN AUX MODE : LEVELS AT MAX VOL XX mV AUX 500mV YY dBA S/N AT 500mW CDR 1V ZZ dB HEADROOM (1% THD) WRT TO LEVEL AT MAX VOL +12V_A +9V1...
Page 12 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl SET WIRING DIAGRAM FRONT * For POWER 2001 Module (30-70W Version) Only. FRONT FRONT CONTROL/KEYS VU Meter # For VCD Only. CDC KEYS ( 1107 Note : Some values may varies, see respective parts list for correct value. ( 1107 ) MOTOR ( 1107 )
Page 13 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl REMARKS : FRONT CONTROL BOARD TABLE OF CONTENTS Front Control Board - Component & Chip layout .... 5-2 Front Control Board - Circuit diagram ......5-3 IR-Eye Part - Layout & Circuit diagram ......5-3 Key-CDC Part - Layout & Circuit diagram ....... 5-4 VU Meter Part - Layout &...
Page 14 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl FRONT CONTROL BOARD - COMPONENT LAYOUT This assembly drawing shows a summary of all possible versions. For components used in a specific version see schematic diagram and respective parts list. 3139 113 3446 pt2 dd wk0116 FRONT CONTROL BOARD - CHIP LAYOUT This assembly drawing shows a summary of all possible versions.
Page 15 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl FRONT CONTROL BOARD - CIRCUIT DIAGRAM IR-EYE BOARD - COMPONENT LAYOUT IR-EYE BOARD - CHIP LAYOUT 1600 F1 1653 C3 1660 D5 1667 C4 1674 D5 2605 B4 2622 F6 3606 A2 3613 C3 3620 C7 3632 D3 3639 D6 3648 G3 3655 H6...
Page 16 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl KEY-CDC BOARD - COMPONENT LAYOUT KEY-CDC BOARD - CIRCUIT DIAGRAM 1800 A3 1802 B2 1804 B1 2800 B1 3801 A1 3803 A1 3805 A2 3807 A2 6803 A1 1801 B2 1803 B2 1805 B1 3800 A1 3802 A2 3804 A1 3806 A2 6802 A1...
Page 17 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl KARAOKE BOARD - COMPONENT LAYOUT KARAOKE BOARD - CHIP LAYOUT ELECTRICAL PARTS LIST - FRONT CONTROL BOARD MISCELLANEOUS 1602 4822 265 11535 Flex Connector 8P 3607 4822 051 30103 10k 5% 0,062W 1603 4822 265 11208 Flex Connector 10P 3610 4822 051 30151 150R 5% 0,062W...
Page 18 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl ELECTRICAL PARTS LIST - FRONT CONTROL BOARD RESISTORS 3860 4822 051 30101 100R 5% 0,062W 3861 4822 051 30103 10k 5% 0,062W 3862 4822 050 11002 1k 1% 0,4W 4500 4822 051 30008 0R Jumper 0603 4600 4822 051 30008 0R Jumper 0603 4601...
Page 19 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl FTD DISPLAY PIN CONNECTIONS FRONT DISPLAY BOARD (1G) (1G) (1G) (1G) TABLE OF CONTENTS FTD pin connection ............6-1 Front Display Board - Chip layout ........6-2 Front Display Board - Component layout ......6-3 Front Display Board - Circuit diagram ......6-4 Headphone Part - Layout &...
Page 20 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl FRONT DISPLAY BOARD - CHIP LAYOUT This assembly drawing shows a summary of all possible versions. For components used in a specific version see schematic diagram and respective parts list. 3139 113 3447 pt2 dd wk0119 World of free manuals...
Page 21 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl FRONT DISPLAY BOARD - COMPONENT LAYOUT This assembly drawing shows a summary of all possible versions. For components used in a specific version see schematic diagram and respective parts list. 3139 113 3447 pt2 dd wk0119 World of free manuals...
Page 22 Option_R Ohms (3530) 1420 Note : Some values may varies, see respective parts list for correct value. FW-C500/37 180R @ : For DPL only FW-C550/37 470R FW-C700/37 820R : For RDS only FE-ST-VK-N FW-C700/34 # : Provision 1407 3560 100R...
Page 23 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl HEADPHONE BOARD - COMPONENT HEADPHONE BOARD - CHIP LAYOUT ELECTRICAL PARTS LIST - FRONT DISPLAY BOARD LAYOUT 2506 4822 122 31765 100pF 2% 63V 2569 4822 124 11947 10uF 20% 16V 2507 4822 122 31765 100pF 2% 63V 2570 4822 124 12233 47uF 20% 25V...
Page 24 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl ELECTRICAL PARTS LIST - FRONT DISPLAY BOARD ELECTRICAL PARTS LIST - FRONT DISPLAY BOARD RESISTORS 3429 4822 116 83883 470R 5% 0,5W 3501 4822 117 12864 82k 5% 0,6W 3565 4822 051 30221 220R 5% 0,062W 4435 4822 051 30008 0R Jumper 0603 3430...
Page 25 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 7A-1 7A-1 BLOCK DIAGRAM TUNER BOARD ECO 6 Systems Vcc1 buffer ampl. Stab Stab Discriminator FM-RF FM-IF 1 FM-IF 2 (MPX) Vcc2 1101 Loop (1102) LF filter 10,7 MHz 10,7 MHz 10,7 MHz 1120 left left right Stereo right Decoder...
Page 26 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 7A-2 7A-2 1101 A1 1102 B1 1103 F2 1120 E14 1130 A2 TUNER BOARD ECO6 1131 B2 / SYSTEMS NON CENELEC 1132 G13 2101 B3 VERSION PROGRAMMING COMPONENTS 2102 B1 1101 2103 C7 2105 AM-IF1 2104 B3 1130 2105 A2 5111...
Page 27 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 7A-3 7A-3 1101 A6 1120 A4 1132 A5 2128 C4 2138 C2 3142 D2 5110 B3 5114 A2 5123 D5 7112 C1 9104 B5 9107 D4 TUNER ADJUSTMENT TABLE ( ECO6 FM/MW- and FM/MW/LW - versions with AM-frame aerial ) 1102 B6 1130 B5 2106 C5...
Page 28 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 7A-4 7A-4 Electrical Partslist ECO6 SYSTEMS NON CENELEC MISCELLANEOUS RESISTORS ––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– 1101 2422 015 19376 SOCKET 2P CLICKFIT 3143 © 4822 051 20223 22kΩ 0,1W USA only RDS only 1102 4822 267 10283 SOCKET COAX, IEC 75Ω 3144 ©...
Page 29: Table Of Contents
www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl Tapedeck wiring (Double deck) TO ETF BOARD CONNECTOR 1770 (ND) 14P CONNECTOR 1740 (DB) 14P CRO2* CRO2* * Not for Ferro version ETF7 TAPE MODULE (Non-Dolby Version) MODE TAPE DECK MOTOR Mechanism B Mechanism A TO ETF BOARD TO ETF BOARD CONNECTOR 1730 (3P) CONNECTOR 1710 (ND) 5P...
Page 30 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl BLOCK DIAGRAM Line-In ATTEN 7710 7720 PB Out 9792 # Playback SOURCE SEL PRE-AMPLIFIER ATTEN Head HEF4952BT AN7318S For Dolby version only ALCEN 1A0 1A1 1A2 PB In PB Out 7630 Rec current REC Out 7740 DOLBY B NR Rec/Pb Rec In CXA1101M...
Page 31 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl Brief introduction General 13. Motor Speed (For FR versions only) Playback Mode During High speed dubbing, a feedback signal from the uP through pin 03 of the IC7610 (HEF4094BT) will trigger the Signal from the playback head Deck A or Deck B is selected and fed through by the Mode Selector IC7710 (HEF4952BT). transistors 7622 (BC847B) and 7616 (BC857B) to cause a change in the voltage level between High and Low, thus changing The signal is amplified by amplifier IC7720 (AN7323S) before feeding to the IC7740 (HEF4952BT) and out to the AF Board via connector 1701.
Page 32 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl CONNECTORS ASSIGNMENTS: CONNECTOR 1740 DECK A & B CONTROL INTERFACE (For Dolby B NR version only) CONNECTOR 1701 INTERCONNECTION TO AF BOARD REC-L Record input left REC REW Record tab protection status switch (reverse) [open=on: close=off] REC-R Record input right CrO2 B Chrome tape detection switch deck B...
Page 33 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl TAPE MECHANISM ELECTRONICS TAPE ADJUSTMENT & CHECK TABLE ADJUST TEST MEASURE RECORDER READ ON CASSETTE MODE with B Photo Sensor 1. B Rec Switch (REV) Rec-R ADJUST MOTOR SPEED 2. B CrO2 Switch CrO2* PLAY B 3620 3150Hz +/- 0.5% SBC420 frequency...
Page 34 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl COMPONENT LAYOUT CHIP LAYOUT Some location on this board is prepared for both 0603 & 0805 SMDs footprint, 3139 113 3409 pt2 dd wk0042 in such locations 0603 SMDs may be substituted. 3139 113 3409 pt2 dd wk0042 World of free manuals...
Page 35 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl ANALOG CIRCUIT 1701 F9 2705 A2 2712 B6 2719 C5 2726 D4 2735 B3 2745 F5 2765 B4 2785 F1 3705 A4 3712 B4 3719 C6 3726 D5 3733 A2 3744 F8 3753 F5 3760 A7 3767 A7 3774 E3 3781 D2 4794 C6...
Page 36 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl SERVO CONTROL CIRCUIT 1702 A7 1760 B8 2622 D2 2625 E4 3601 B2 3604 C2 3607 C6 3610 D6 3613 B2 3618 A4 3622 A4 3625 B3 3630 A6 3676 C5 3680 C5 3687 D2 4785 D2 6612 B6 7612 A6 7616 A4...
Page 37 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl TAPE MECHANISM - MOTOR EXPLODED VIEW TAPE MODULE EXPLODED VIEW 4822 361 11055 Motor Assembly 1 3139 118 77130 Autoreverse Mech. CWE44FR01 Screw M2,6 x 5 1 3139 118 77140 Non-Autoreverse Mech. CWE44FF02 Chrome/Ferro Screw M2 x 5 1 3139 118 77950 Non-Autoreverse Mech.
Page 38 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9-10 9-10 TAPE MECHANISM A - PLAY MECHANICAL PARTS - PLAY MECHANISM 9965 000 02313 Play Head (Non-Autoreverse deck) 9965 000 02321 Play Head (Autoreverse deck) 4822 402 10972 Pinch Arm Assembly R 9965 000 02314 Coil Assembly 9965 000 06443 Cam Gear 4822 528 11209...
Page 39 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9-11 9-11 TAPE MECHANISM B - RECORD/PLAYBACK (Non-Autoreverse version) MECHANICAL PARTS - REC/PB MECHANISM 9965 000 02313 Play Head 9965 000 02600 Head, Erase 4822 402 10972 Pinch Arm Assembly R 9965 000 02314 Coil Assembly 9965 000 06443 Cam Gear 4822 528 11209 Flywheel Assembly RV...
Page 40 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9-12 9-12 TAPE MECHANISM B - RECORD/PLAYBACK (Autoreverse version) MECHANICAL PARTS - REC/PB MECHANISM 4822 402 10972 Pinch Arm Assembly R 9965 000 02314 Coil Assembly 9965 000 06443 Cam Gear 4822 528 11209 Flywheel Assembly RV 9965 000 02322 Belt AF 44-2...
Page 41 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9-13 9-13 ELECTRICAL PARTS LIST - ETF7 NON-DOLBY BOARD ELECTRICAL PARTS LIST - ETF7 NON-DOLBY BOARD MISCELLANEOUS 2738 482212614585 100nF 10% 50V 3685 482211652234 100k 5% 0,5W 3745 482205120332 3k3 5% 0,1W Autoreverse 1701 482226710953 Flex Socket 7pin Vert. 2741 482212611585 22nF +80/-20% 25V 3686 482211710837...
Page 42 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9-14 9-14 ELECTRICAL PARTS LIST - ETF7 NON-DOLBY BOARD RESISTORS 4706 482205120008 0R Jumper 0805 6612 482213031878 1N4003G 4707 482205120008 0R Jumper 0805 6614 482213030621 1N4148 Autoreverse 4708 482205120008 0R Jumper 0805 6770 482213030621 1N4148 4709 482205120008 0R Jumper 0805 6771 482213030621 1N4148...
Page 43: Table Of Contents
www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-1 3CDC-LLC-DA11 (3 Disc Carousel Changer) Layout stage .3 TABLE OF CONTENTS Service Hints ..............10-2 Blockdiagram ..............10-5 Component Layout Main Board ........10-6 Circuit Diagram part1 ............10-7 Component Layout Main Board ........10-8 Circuit Diagram part2 ............10-9 Exploded View ..............10-10 Partslist ................10-12 World of free manuals...
Page 44: Service Hints
www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-2 Service hints CAUTION CHARGED CAPACITORS ON THE SERVO BOARD MAY DAMAGE THE CD DRIVE ELECTRONICS WHEN CONNECTING A NEW CD MECHANISM. THAT´S WHY, BESIDES THE SAFETY MEASURES LIKE • SWITCH OFF POWER SUPPLY • ESD PROTECTION ADDITIONAL ACTIONS MUST BE TAKEN BY THE REPAIR TECHNICIAN.
Page 45 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-3 Service hints Dismantling of Tray 1. Open the tray. 2. Release 2x catch as shown in fig. 2 and Detail A 3. Pull tray out. Detail A fig.2 Assembling of Tray 1. Turn Cam (pos. 48) clockwise to end position.
Page 46 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-4 Service Position World of free manuals...
Page 47 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-5 10-5 BLOCK DIAGRAM 3CDC-LLC-DA11 CD MECHANISM MAINBOARD DA11 DISC 7806 7802 TDA7073A TURNTABLE FOCB+ MOTOR FOCUS MOTOR FOCB- RADIAL RADB+ MOTOR RADB- 7805 1805 7807 TDA7073A SIGNAL PROCESSOR CD LEFT SLEDGEB+ SLEDGE CD10 MOTOR SAA7324 (SAA7325) SLEDGEB- Active low pass Analog Audio...
Page 48 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-6 10-6 Mapping Copperside Componentside 2800 E3 3741 C4 3889 C2 1800 F2 3CDC-LLC Copperside view 2801 D4 3742 C4 3890 H2 1801 C5 3CDC-LLC Componentside view 2802 E4 3743 C3 3891 H2 1805 A2 2803 D4 3744 B4 3892 C2 1810 C2...
Page 49 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-7 10-7 1800 F1 2804 D4 2811 A9 2818 B11 2826 G12 2838 D8 2851 B11 2888 C4 3702 D3 3721 D6 3792 F8 3800 D8 3807 B9 3819 D14 3828 G11 3839 H6 3846 F5 3863 G13 3895 G12 7803-B D5 MP713 C9...
Page 50 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-8 10-8 Mapping Copperside Componentside 2800 E3 3741 C4 3889 C2 1800 F2 3CDC-LLC Copperside view 2801 D4 3742 C4 3890 H2 1801 C5 3CDC-LLC Componentside view 2802 E4 3743 C3 3891 H2 1805 A2 2803 D4 3744 B4 3892 C2 1810 C2...
Page 51 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-9 10-9 1805 E15 2830 C9 2858 A9 2865 C4 2877 F11 3705 G4 3713 G8 3730 G2 3741 A7 3751 C7 3851 D7 3865 A10 3874 C13 3880 E6 3886 E7 3898 F7 4876 D13 6875 F7 7805-B A8 7876 G3 MP726 D8...
Page 52 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-10 10-10 EXPLODED VIEW (3CDC-LC M ODULE 45 5x MECHANICAL PARTS Loader → this page ––––––––––––––––––––––––––––––––––––––––––––––––––––– 3103 304 66500 DRAWER 3140 114 29070 PRESSURE RING-DA11 3140 111 21270 METAL RING-DA11 3103 304 66560 SUPPORT 4822 529 10386 RUBBER DAMPER CD DRIVE, REAR 4822 529 10387 RUBBER DAMPER CD DRIVE, FRONT...
Page 53 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-11 Drawer bottom view Drawer top view spare part non spare part 3CDC-LC Drawer assy 1999 09 13 World of free manuals...
Page 54 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-12 ELECTRICAL PARTSLIST 3CDC-LLC-DA11 MODULE –––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––– CAPACITORS MISCELLANEOUS ––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– 2861 4822 124 11947 10µF 3103 309 05310 CD DRIVE DA11T3CN 4822 361 10753 CAROUSEL MOTOR 2862 © 4822 126 13883 220pF 4822 361 10753 TRAY MOTOR 2863 ©...
Page 55 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-13 ELECTRICAL PARTSLIST 3CDC-LLC-DA11 MODULE –––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––– RESISTORS RESISTORS ––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– 3883 © 4822 117 10833 10kΩ 0,1W 3803 © 4822 117 10833 10kΩ 0,1W 3804 © 4822 051 30103 10kΩ 0,06W 3884 © 4822 051 30271 270Ω 0,06W 3805 ©...
Page 56 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-14 ELECTRICAL PARTSLIST 3CDC-LLC-DA11 MODULE –––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––– COILS ––––––––––––––––––––––––––––––––––––––––––––––––––––– 1810 4822 242 73557 CERAMIC RES. 8,46MHz DIODES ––––––––––––––––––––––––––––––––––––––––––––––––––––– 6871 © 4822 130 11397 BAS316 6872 © 4822 130 11397 BAS316 6873 © 4822 130 11397 BAS316 6874 © 4822 130 11397 BAS316 6875 ©...
Page 57 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 11-1 11-1 Circuit details: Amplifier: Attention: In the POWER 2001 module the power amplifier IC AN7591 is used as a bridge-amplifier. Any connection from output to ground will destroy the outpout stages! • Via the AMP_ON control line, connected to pins 6 (Stby), the power amplifiers are switched on/off by the µP. High level (approx.
Page 58 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 11-2 11-2 Circuit details continued: Generation of +C1 Full wave rectifying with 2 diodes of bridge rectifier 6202, using 50% secondary winding of mains transformer (pin 13-15/13-11). See picture 2 below. • Low power standby feature An additional small standby transformer, reduces power consumption in standby-mode. In case power is switched on, the control line ECO is low →...
Page 59: Mains Board
www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 11-3 11-3 Block Diagram MAINS BOARD P2001 BOARD 1200 5001 is used for monitoring the transformer temparature Mains socket 1204 6201 1207 Stand by Relais 7301,7302 6200 1210 1205 LEFT, RIGHT Power amplifier from Source Selector on Audio Frequency Board is used for filament of display...
Page 60 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 11-4 11-4 1200 B5 6210 C5 1201 B4 6211 B5 Mains Board Copperside view 1202 C1 6212 C5 1203 A5 6213 B5 1205 B3 6214 B5 1206 C1 6215 D5 1207 C3 6216 C5 1208 D1 6217 C5 1209 C5 6218 C5 B C E...
Page 61 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 11-5 11-5 1200 A6 1207 B6 1222 A2 2204 D7 2210 E7 2216 A7 3204 E7 3211 E6 6201 B8 6208 D4 6214 E3 6221 C8 9208 B2 9215 F6 1201 A9 1208 B4 1223 B2 2205 D8 2211 E3 2217 A8 3205 E4...
Page 62 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 11-6 11-6 0300 B3 1307 B5 1316 C1 2306 A4 2313 B4 2320 A5 2327 B3 2334 C3 2341 B1 3303 C4 3310 A5 3317 C3 3324 A3 3331 C1 3340 C5 3347 A3 3354 A4 3361 A1 3368 A4 3375 C1 3382 C2...
Page 63 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 11-7 11-7 3324 3331 3340 3347 3354 3361 3368 3375 3382 6300 6307 6314 6321 6328 7302 7309 7316 7323 7331 9308 0300 1307-a F14 1315 2305 2312 2319 2326 2333 2340 3303 3310 3317 1300 1307-b E14 1316 2306 2313...
Page 64 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 11-8 11-8 ELECTRICAL PARTSLIST POWER2001 MODULE ELECTRICAL PARTSLIST POWER2001 MODULE –––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––– –––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––– MISCELLANEOUS CAPACITORS RESISTORS DIODES ––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– ! 2422 086 10963 1200 FUSE RAD 5A 250V IEC 2328 4822 126 12882 100nF 3345 4822 116 83876 270Ω...
Page 65 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 12-1 12-1 BRIEF INTRODUCTION OF THE AF9 BOARD The AF9 Board consists of the following features : a. TDA7468D IC TDA7468D IC (7501) which includes functions such as source selection, loudness control, dynamic bass control, treble control, volume control and muting function. Sound features such as ALC, DBB, DSC and IS are controllable via I C Bus from the microprocessor.
Page 66 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 12-2 12-2 AF9 BOARD - COMPONENT LAYOUT This assembly drawing shows a summary of all possible versions. For components used in a specific version see schematic diagram and respective parts list. 3139 113 3435 pt4 dd wk0123 World of free manuals...
Page 67 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 12-3 12-3 AF9 BOARD - CHIP LAYOUT This assembly drawing shows a summary of all possible versions. For components used in a specific version see schematic diagram and respective parts list. 3139 113 3435 pt4 dd wk0123 World of free manuals...
Page 68 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 12-4 12-4 AF9 BOARD - CIRCUIT DIAGRAM (PART 1) 1501 E1 3511 A3 1502 E3 3512 B3 1503 F1 3513 A3 1504 H1 3514 B3 1505 E4 3521 A3 3521 2521 TU_Left 1506 A1 3522 A3 100n 1510 F1 3523 A3 1531 C1...
Page 69 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 12-5 12-5 AF9 BOARD - CIRCUIT DIAGRAM (PART 2) 1102 H3 3658 B6 1103 H3 3659 E4 1602 B13 3660 F4 1603 E7 3671 I7 2401 F13 3672 H7 2402 F12 3673 I7 VC_OUT_LEFT MUTE_SW_FR 2403 F12 3674 H7 2404 F11 3675 I6...
Page 70 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 12-6 12-6 AF9 BOARD - CIRCUIT DIAGRAM (PART 3) 1100 F6 1203 C1 1206 C1 1403 A9 1520 E6 1523 D6 1541 D4 2207 D3 2210 F2 2801 B4 2804 B3 2807 B1 2810 A4 2951 E7 2954 E6 3412 A8 3803 B3...
Page 71 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 12-7 12-7 VIDEO OUT CINCH BOARD - VIDEO OUT CINCH BOARD - ELECTRICAL PARTS LIST - AF9 BOARD COMPONENT LAYOUT CHIP LAYOUT MISCELLANEOUS 1206 4822 267 11039 Flex Connector 11P 2565 4822 121 43856 4,7nF 5% 250V 1401 4822 265 11553 Flex Connector 19P...
Page 72 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 12-8 12-8 ELECTRICAL PARTS LIST - AF9 BOARD ELECTRICAL PARTS LIST - AF9 BOARD CAPACITORS 2808 4822 126 14305 100nF 10% 16V 3594 4822 051 30562 5k6 5% 0,063W 3688 4822 051 30391 390R 5% 0,062W 4403 4822 051 30008 0R Jumper 0603 2809...
Page 73 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 13-1 13-1 SET MECHANICAL EXPLODED VIEW Exploded_View_3139 119 33850 dd wk0136 World of free manuals...
Page 74 0106 3139 118 14340 Cover Tray CDC 0253 3139 114 73570 Panel Left D3 x 12 0107 4822 454 13408 Badge Philips 0254 3139 114 73580 Panel Right D3 x 12 0111 3139 118 14870 Button Power 0255 3139 114 73590...
Page 75: Table Of Contents
LASER PRODUCT © Copyright 2000 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips.
Page 76 LOCATION OF PRINTED CIRCUIT BOARDS MAINS SOCKET BOARD HEADPHONE BOARD POWER BOARD VERSION VARIATIONS: Type /Versions: FW-C700 Features & Board in used: Aux in /CDR in Line Out Surround Out Subwoofer Out Digital Out Matrix Surround CD Text Dolby B...
Page 77 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl SPECIFICATIONS AMPLIFIER: GENERAL: Output power (6Ω, 1kHz, 10% THD) Mains voltage : 110-127V/220-240V Switchable for /21/21M L & R : 2 x 60W RMS 120V for /37 220V for /33 Output power (6Ω, 60Hz-12.5kHz, 10% THD) 220-230V for /22/34 230-240V for /30 L &...
Page 78 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl MEASUREMENT SETUP Tuner FM Bandpass LF Voltmeter 250Hz-15kHz e.g. PM2534 e.g. 7122 707 48001 RF Generator e.g. PM5326 S/N and distortion meter e.g. Sound Technology ST1700B Use a bandpass filter to eliminate hum (50Hz, 100Hz) and disturbance from the pilottone (19kHz, 38kHz). Tuner AM (MW,LW) Bandpass LF Voltmeter...
Page 79 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl SERVICE AIDS Service Tools: ESD Equipment: Universal Torx driver holder ........4822 395 91019 Anti-static table mat - large 1200x650x1.25mm ... 4822 466 10953 Torx bit T10 150mm ..........4822 395 50456 Anti-static table mat - small 600x650x1.25mm ..4822 466 10958 Torx driver set T6 - T20 .........
Page 80 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl WAARSCHUWING WARNING Alle IC’s en vele andere halfgeleiders zijn All ICs and many other semi-conductors are gevoelig voor electrostatische ontladingen susceptible to electrostatic discharges (ESD). (ESD). Careless handling during repair can reduce life Onzorgvuldig behandelen tijdens reparatie kan drastically.
Page 81 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl English World of free manuals...
Page 82 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl English World of free manuals...
Page 83 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl English World of free manuals...
Page 84 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl English World of free manuals...
Page 85 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl English World of free manuals...
Page 86 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl English World of free manuals...
Page 87 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl English World of free manuals...
Page 88 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl English World of free manuals...
Page 89 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl English World of free manuals...
Page 90 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 2-10 English World of free manuals...
Page 91 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 2-11 English World of free manuals...
Page 92 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 2-12 English World of free manuals...
Page 93 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl DISMANTLING INSTRUCTIONS Dismantling of the CDC Module and Front Panel Dismantling of the Cassette Cover 4) Remove the Cover Tray CDC (pos 106) as indicated. 2. Twist screw driver 3. Lift up and out Remove Cover Tray CDC 1.
Page 94 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl Dismantling of the Front Display Board and Front Control Board Dismantling of Rear Portion 1) Remove 1 screw C as indicated to loosen the Headphone 1) Remove 3 screws J and uncatch M1 as indicated to Board (pos 1101-B). loosen the AF Board (pos 1102-A).
Page 95 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl Repair Hints 3) During repair it is possible to disconnect the Tuner board Service pos C Picture 3 and CDC Module completely unless the fault is sus- pected to be in that area. This will not affect the performance of the rest of the set.
Page 96 Triggered when the focus could not be found within a certain time when starting up the CD or when the focus is lost for a certain time during play. LEDs FW-C500 , FW-C550 FW-C700 , FW-C720 FW-P750 E1001 Radial Error FW-C780 Triggered when the radial servo is off-track for a certain time during play.
Page 97 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl SET BLOCK DIAGRAM 75 ohm COAX1 (FROM CDC) Vpp 0.5V NOTE : MAIN SIGNAL PATH MEASUREMENTS ARE IN AUX MODE : LEVELS AT MAX VOL XX mV AUX 500mV YY dBA S/N AT 500mW CDR 1V ZZ dB HEADROOM (1% THD) WRT TO LEVEL AT MAX VOL +12V_A +9V1...
Page 98 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl SET WIRING DIAGRAM FRONT FRONT FRONT CONTROL/KEYS * For POWER 2001 Module (30-70W Version) only VU Meter CDC KEYS ( 1107 ) ( 1107 ) MOTOR ( 1107 ) LS SL/SR 1600 (12p) 1603 (10p) 1315 1300 ( Only for FW-C720 ) 1403 1401 1405 1321...
Page 99: Table Of Contents
www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl REMARKS : FRONT CONTROL BOARD TABLE OF CONTENTS Front Control Board - Component & Chip layout .... 5-2 Front Control Board - Circuit diagram ......5-3 IR-Eye Part - Layout & Circuit diagram ......5-3 Key-CDC Part - Layout & Circuit diagram ....... 5-4 VU Meter Part - Layout &...
Page 100 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl FRONT CONTROL BOARD - COMPONENT LAYOUT This assembly drawing shows a summary of all possible versions. For components used in a specific version see schematic diagram and respective parts list. 3139 113 3446 pt1 dd wk0047 FRONT CONTROL BOARD - CHIP LAYOUT This assembly drawing shows a summary of all possible versions.
Page 101 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl FRONT CONTROL BOARD - CIRCUIT DIAGRAM IR-EYE BOARD - COMPONENT LAYOUT IR-EYE BOARD - CHIP LAYOUT 1600 F1 1652 C3 1658 D3 1664 C5 1670 C6 1690 A1 2606 B2 2622 F6 3607 A2 3613 C3 3619 C6 3630 C2 3636 D4 3644 G6...
Page 102 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl KEY-CDC BOARD - COMPONENT LAYOUT KEY-CDC BOARD - CIRCUIT DIAGRAM 1800 A3 1802 B2 1804 B1 2800 B1 3801 A1 3803 A1 3805 A2 3807 A3 6803 A1 1801 B2 1803 B2 1805 B1 3800 A1 3802 A2 3804 A1 3806 A2 6802 A1...
Page 103 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl KARAOKE BOARD - COMPONENT LAYOUT KARAOKE BOARD - CHIP LAYOUT VCD INTERFACE BOARD - COMPONENT LAYOUT This assembly drawing shows a summary of all possible versions. For components used in a specific version see schematic diagram and respective parts list. This assembly drawing shows a summary of all possible versions.
Page 104 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl ELECTRICAL PARTS LIST - FRONT CONTROL BOARD ELECTRICAL PARTS LIST - FRONT CONTROL BOARD MISCELLANEOUS RESISTORS 1602 4822 265 11535 Flex Connector 8P 3606 4822 051 30103 10k 5% 0,062W 3851 4822 051 30181 180R 5% 0,062W 1603 4822 265 11208 Flex Connector 10P...
Page 105: Table Of Contents
www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl FTD DISPLAY PIN CONNECTIONS FRONT DISPLAY BOARD (1G) (1G) (1G) (1G) TABLE OF CONTENTS FTD pin connection ............6-1 Front Display Board - Chip layout ........6-2 Front Display Board - Component layout ......6-3 Front Display Board - Circuit diagram ......6-4 Headphone Part - Layout &...
Page 106 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl FRONT DISPLAY BOARD - CHIP LAYOUT This assembly drawing shows a summary of all possible versions. For components used in a specific version see schematic diagram and respective parts list. 3139 113 3447 pt1 dd wk0047 World of free manuals...
Page 107 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl FRONT DISPLAY BOARD - COMPONENT LAYOUT This assembly drawing shows a summary of all possible versions. For components used in a specific version see schematic diagram and respective parts list. 3139 113 3447 pt1 dd wk0047 World of free manuals...
Page 108 @ : For DPL only : For RDS only # : Provision 1407 FE-ST-VK-N 3560 100R TpADC2 Model Option_R Ohms (3530) 3561 100R TpADC1 FW-C500/37 FW-C550/37 FW-C700/37 FW-C700/34 TPShCLK 7412 7408 7410 7409 +5V6 FW-C700/22 BC847B BC847B BC847B BC847B 2579...
Page 109 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl HEADPHONE BOARD - COMPONENT HEADPHONE BOARD - CHIP LAYOUT ELECTRICAL PARTS LIST - FRONT DISPLAY BOARD LAYOUT 2511 4822 122 33777 47pF 5% 63V 2566 4822 124 22651 1µF 20% 50V 2512 4822 126 14249 560pF 10% 50V 2567 4822 126 13879 220nF +80/-20% 16V...
Page 110 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl ELECTRICAL PARTS LIST - FRONT DISPLAY BOARD ELECTRICAL PARTS LIST - FRONT DISPLAY BOARD RESISTORS 3432 4822 051 30471 470R 5% 0,062W 3505 4822 051 30471 470R 5% 0,062W 3570 4822 051 20109 10R 5% 0,1W 4434 4822 051 30008 0R Jumper 0603 3433...
Page 111 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 7A-1 7A-1 BLOCK DIAGRAM TUNER BOARD ECO 6 Systems Vcc1 buffer ampl. Stab Stab Discriminator FM-RF FM-IF 1 FM-IF 2 (MPX) Vcc2 1101 Loop (1102) LF filter 10,7 MHz 10,7 MHz 10,7 MHz 1120 left left right Stereo right Decoder...
Page 112 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 7A-2 7A-2 1101 A1 1102 B1 1103 F2 1120 E14 1130 A2 TUNER BOARD ECO6 1131 B2 / SYSTEMS NON CENELEC 1132 G13 2101 B3 VERSION PROGRAMMING COMPONENTS 2102 B1 1101 2103 C7 2105 2104 B3 AM-IF1 1130 2105 A2 5111...
Page 113 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 7A-3 7A-3 1101 A6 1120 A4 1132 A5 2128 C4 2138 C2 3142 D2 5110 B3 5114 A2 5123 D5 7112 C1 9104 B5 9107 D4 TUNER ADJUSTMENT TABLE ( ECO6 FM/MW- and FM/MW/LW - versions with AM-frame aerial ) 1102 B6 1130 B5 2106 C5...
Page 114 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 7A-4 7A-4 Electrical Partslist ECO6 SYSTEMS NON CENELEC MISCELLANEOUS RESISTORS ––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– 1101 2422 015 19376 SOCKET 2P CLICKFIT 3143 © 4822 051 20223 22kΩ 0,1W USA only RDS only 1102 4822 267 10283 SOCKET COAX, IEC 75Ω 3144 ©...
Page 115 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 7B-1 7B-1 BLOCK DIAGRAM ECO6 Tuner Board SYSTEMS CENELEC version: TABLE OF CONTENTS Blockdiagram ..............7B-1 Schematic Diagram ............7B-2 Component Layout............7B-3 Adjustment table .............7B-3 Electrical Partslist ............7B-4 World of free manuals...
Page 116 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 7B-2 7B-2 1101 A2 6106 D4 1102 B1 6107 G13 1103 E2 6120 C13 1110 B2 7101 C8 VERSION PROGRAMMING COMPONENTS 1120 E14 7103 H8 TUNER BOARD ECO6 1130 A2 7104 D2 / SYSTEMS-CENELEC 1131 C2 7105 F4 VERSION AM-IF1 1132 F13...
Page 117 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 7B-3 7B-3 1101 B5 1110 B4 1131 C5 2107 B3 2133 C1 2162 A4 5102 C4 5110 A2 5114 A2 5121 B2 7104 C4 9101 A2 9104 B1 9107 B4 9110 A4 TUNER ADJUSTMENT TABLE ( ECO6 Cenelec FM/MW - and FM/MW/LW - versions with AM-frame aerial ) 1102 B5 1120 A4 1132 A4...
Page 118 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 7B-4 7B-4 Electrical Partslist ECO6 SYSTEMS CENELEC MISCELLANEOUS RESISTORS TRANSISTORS ––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– 1101 2422 015 19376 SOCKET CLICKFIT 2P 3132© 4822 051 20479 47Ω 0,1W 7103 © 5322 130 42756 BC857C USA only RDS only 1102 4822 267 10283 SOCKET COAX, IEC 75Ω...
Page 119: Table Of Contents
www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl Tapedeck wiring (Double deck) TO ETF BOARD CONNECTOR 1770 (ND) 14P CONNECTOR 1740 (DB) 14P CRO2* CRO2* * Not for Ferro version ETF7 TAPE MODULE (Non-Dolby Version) MODE TAPE DECK MOTOR Mechanism B Mechanism A TO ETF BOARD TO ETF BOARD CONNECTOR 1730 (3P) CONNECTOR 1710 (ND) 5P...
Page 120 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl BLOCK DIAGRAM Line-In ATTEN 7710 7720 PB Out 9792 # Playback SOURCE SEL PRE-AMPLIFIER ATTEN Head AN7318S HEF4952BT For Dolby version only ALCEN 1A0 1A1 1A2 PB In PB Out 7630 Rec current REC Out DOLBY B NR Rec/Pb 7740 Rec In...
Page 121 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl Brief introduction General Playback Mode 13. Motor Speed (For FR versions only) Signal from the playback head Deck A or Deck B is selected and fed through by the Mode Selector IC7710 (HEF4952BT). During High speed dubbing, a feedback signal from the uP through pin 03 of the IC7610 (HEF4094BT) will trigger the transistors 7622 (BC847B) and 7616 (BC857B) to cause a change in the voltage level between High and Low, thus changing The signal is amplified by amplifier IC7720 (AN7323S) before feeding to the IC7740 (HEF4952BT) and out to the AF Board the speed of the motor.
Page 122 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl CONNECTORS ASSIGNMENTS: CONNECTOR 1701 INTERCONNECTION TO AF BOARD CONNECTOR 1740 DECK A & B CONTROL INTERFACE (For Dolby B NR version only) REC REW Record tab protection status switch (reverse) [open=on: close=off] REC-L Record input left REC-R Record input right CrO2 B Chrome tape detection switch deck B...
Page 123 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl TAPE MECHANISM ELECTRONICS TAPE ADJUSTMENT & CHECK TABLE ADJUST TEST RECORDER MEASURE READ ON CASSETTE MODE with B Photo Sensor 1. B Rec Switch (REV) Rec-R ADJUST MOTOR SPEED 2. B CrO2 Switch CrO2* PLAY B 3620 3150Hz –...
Page 124 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl COMPONENT LAYOUT CHIP LAYOUT Some location on this board is prepared for both 0603 & 0805 SMDs footprint, 3139 113 3409 pt2 dd wk0042 in such locations 0603 SMDs may be substituted. 3139 113 3409 pt2 dd wk0042 World of free manuals...
Page 125 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl ANALOG CIRCUIT 1701 F9 2719 C5 2765 B4 3705 A4 3719 C6 3744 F8 3753 F5 3774 E3 7782 E1 2705 A2 2712 B6 2726 D4 2735 B3 2745 F5 2785 F1 3712 B4 3726 D5 3733 A2 3760 A7 3767 A7 3781 D2...
Page 126 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl SERVO CONTROL CIRCUIT 1702 A7 1760 B8 2622 D2 2625 E4 3601 B2 3604 C2 3607 C6 3610 D6 3613 B2 3618 A4 3622 A4 3625 B3 3630 A6 3676 C5 3680 C5 3687 D2 4785 D2 6612 B6 7612 A6 7616 A4...
Page 127 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl TAPE MECHANISM - MOTOR EXPLODED VIEW TAPE MODULE EXPLODED VIEW 4822 361 11055 Motor Assembly 1 3139 118 77130 Autoreverse Mech. CWE44FR01 Screw M2,6 x 5 1 3139 118 77140 Non-Autoreverse Mech. CWE44FF02 Chrome/Ferro Screw M2 x 5 1 3139 118 77950 Non-Autoreverse Mech.
Page 128 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9-10 9-10 TAPE MECHANISM A - PLAY MECHANICAL PARTS - PLAY MECHANISM 9965 000 02313 Play Head (Non-Autoreverse deck) 9965 000 02321 Play Head (Autoreverse deck) 4822 402 10972 Pinch Arm Assembly R 9965 000 02314 Coil Assembly 9965 000 06443 Cam Gear 4822 528 11209...
Page 129 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9-11 9-11 TAPE MECHANISM B - RECORD/PLAYBACK (Non-Autoreverse version) MECHANICAL PARTS - REC/PB MECHANISM 9965 000 02313 Play Head 9965 000 02600 Head, Erase 4822 402 10972 Pinch Arm Assembly R 9965 000 02314 Coil Assembly 9965 000 06443 Cam Gear 4822 528 11209 Flywheel Assembly RV...
Page 130 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9-12 9-12 TAPE MECHANISM B - RECORD/PLAYBACK (Autoreverse version) MECHANICAL PARTS - REC/PB MECHANISM 4822 402 10972 Pinch Arm Assembly R 9965 000 02314 Coil Assembly 9965 000 06443 Cam Gear 4822 528 11209 Flywheel Assembly RV 9965 000 02322 Belt AF 44-2...
Page 131 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9-13 9-13 ELECTRICAL PARTS LIST - ETF7 NON-DOLBY BOARD ELECTRICAL PARTS LIST - ETF7 NON-DOLBY BOARD MISCELLANEOUS 2738 482212614585 100nF 10% 50V 3685 482211652234 100k 5% 0,5W 3745 482205120332 3k3 5% 0,1W Autoreverse 1701 482226710953 Flex Socket 7pin Vert. 2741 482212611585 22nF +80/-20% 25V 3686 482211710837...
Page 132 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9-14 9-14 ELECTRICAL PARTS LIST - ETF7 NON-DOLBY BOARD RESISTORS 4706 482205120008 0R Jumper 0805 6612 482213031878 1N4003G 4707 482205120008 0R Jumper 0805 6614 482213030621 1N4148 Autoreverse 4708 482205120008 0R Jumper 0805 6770 482213030621 1N4148 4709 482205120008 0R Jumper 0805 6771 482213030621 1N4148...
Page 133 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9A-1 9A-1 Tapedeck wiring (Double deck) TO ETF BOARD CONNECTOR 1770 (ND) 14P CONNECTOR 1740 (DB) 14P CRO2 CRO2 ETF7 TAPE MODULE (Dolby Version) MODE TAPE DECK MOTOR Mechanism B Mechanism A TO ETF BOARD TO ETF BOARD CONNECTOR 1730 (3P) CONNECTOR 1710 (ND) 5P CONNECTOR 1720 (DB) 6P...
Page 134 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9A-2 9A-2 BLOCK DIAGRAM Line-In ATTEN 7710 7720 PB Out 9792 # Playback SOURCE SEL PRE-AMPLIFIER ATTEN Head AN7318S HEF4952BT For Dolby version only ALCEN 1A0 1A1 1A2 PB In PB Out 7630 Rec current REC Out DOLBY B NR Rec/Pb 7740...
Page 135 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9A-3 9A-3 Brief introduction General Playback Mode 13. Motor Speed (For FR versions only) Signal from the playback head Deck A or Deck B is selected and fed through by the Mode Selector IC7710 (HEF4952BT). During High speed dubbing, a feedback signal from the uP through pin 03 of the IC7610 (HEF4094BT) will trigger the transistors 7622 (BC847B) and 7616 (BC857B) to cause a change in the voltage level between High and Low, thus changing The signal is amplified by amplifier IC7720 (AN7323S) before feeding to the IC7740 (HEF4952BT) and out to the AF Board the speed of the motor.
Page 136 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9A-4 9A-4 CONNECTORS ASSIGNMENTS: CONNECTOR 1701 INTERCONNECTION TO AF BOARD CONNECTOR 1740 DECK A & B CONTROL INTERFACE (For Dolby B NR version only) REC REW Record tab protection status switch (reverse) [open=on: close=off] REC-L Record input left REC-R Record input right CrO2 B...
Page 137 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9A-5 9A-5 TAPE MECHANISM ELECTRONICS Mechanism A Head Wires Soldering B Photo Sensor 1. B Rec Switch (REV) Rec-R Play Pink or 2. B CrO2 Switch Head CrO2 Screen (Gnd) 3. B Rec Switch (FWD) Rec-F White 4.
Page 138 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9A-6 9A-6 General Recording TEST MEASURE ADJUST RECORDER TEST MEASURE ADJUST READ ON RECORDER CASSETTE with READ ON MODE with CASSETTE MODE ADJUST MOTOR SPEED PRE-ADJUST BIAS AND BIAS-SYMMETRY 5040Hz ± 0.5% HIGH SPEED SBC420 DUBBING 3622 * frequency 3773 995mV...
Page 139 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9A-7 9A-7 COMPONENT LAYOUT 3139 113 3408 pt2 dd wk0050 World of free manuals...
Page 140 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9A-8 9A-8 CHIP LAYOUT 3139 113 3408 pt2 dd wk0050 World of free manuals...
Page 141 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9A-9 9A-9 ANALOG CIRCUIT 1701 F9 3720 D5 6775 C3 1720 C1 3721 C6 6776 F3 1730 A1 3722 D5 6777 E2 2727 6778 E4 2701 B2 3723 A3 2702 B2 3724 D5 6782 C7 3735 3711 2713 680p REC_L...
Page 142 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9A-10 9A-10 SERVO CONTROL CIRCUIT 1703 C1 1706 F1 1740 C7 1760 C7 DECK B 2621 E2 2622 E2 2623 E1 2624 F1 2625 F3 2626 C1 +MOTOR 7612 Mode_A 3601 C2 BC807-25 3602 D2 Photo_A 3603 C2 DECK A Sol_A 3604 D2...
Page 143 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9A-11 9A-11 DOLBY CIRCUIT 2631 B6 3684 F4 3689 B7 2632 E6 2633 B3 3690 E7 2634 C3 3691 B7 3661 2653 3665 3663 2635 C5 3692 B7 150K 470K 470p 2636 D5 3693 D3 2637 B8 3694 D6 2645 2641...
Page 144 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9A-12 9A-12 TAPE MECHANISM A - PLAY MECHANICAL PARTS - PLAY MECHANISM 996500002313 Play Head (Non-Autoreverse deck) 996500002321 Play Head (Autoreverse deck) 482240210972 Pinch Arm Assembly R 996500002314 Coil Assembly 482252811209 Flywheel Assembly RV 996500002315 Belt AF (Autoreverse deck) 996500002718 Belt AF (Non-autoreverse deck) 482249211761...
Page 145 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9A-13 9A-13 TAPE MECHANISM - MOTOR EXPLODED VIEW TAPE MODULE EXPLODED VIEW 996500003006 Motor Assembly 1 313911877150 Autoreverse Mech. CWE44FR03 Screw M2,6 x 5 Screw D3 x 10 Screw M2 x 5 4 313911034080 Flex Cable 14 pin 7,5 cm Screw M2 x 16 Note: Only the parts mentioned in this list are normal service spare parts.
Page 146 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9A-14 9A-14 TAPE MECHANISM B - RECORD/PLAYBACK (Autoreverse version) MECHANICAL PARTS - REC/PB MECHANISM 482240210972 Pinch Arm Assembly R 996500002314 Coil Assembly 482252811209 Flywheel Assembly RV 996500003001 Belt BF 44-2 996500002317 Flex Socket 14 Pin 44-3 996500002320 Photo Interrupter 44-4 482205016801...
Page 147 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9A-15 9A-15 ELECTRICAL PARTS LIST - ETF7 DOLBY BOARD ELECTRICAL PARTS LIST - ETF7 DOLBY BOARD MISCELLANEOUS 1701 482226710953 Flex Connector 7P 2715 482212480195 470µF 20% 10V 3620 482210012227 4k7 30% 0,1W 3683 482211710834 47k 1% 0,1W 1706 482226710953 Flex Connector 7P...
Page 148 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 9A-16 9A-16 ELECTRICAL PARTS LIST - ETF7 DOLBY BOARD ELECTRICAL PARTS LIST - ETF7 DOLBY BOARD RESISTORS 3745 482205120392 3k9 5% 0,1W 4697 482205120008 0R Jumper 0805 5701 482215711477 Coil 2,2µH 5% 7784 482213060373 BC857B 3746 482205120392 3k9 5% 0,1W 4701 482205120008...
Page 149 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-1 3CDC-LC-MB-DA11 Module (3 Disc Carousel Changer) Layout stage .2 TABLE OF CONTENTS Servicing Hints ..............10-2 Blockdiagram ..............10-5 Component Layout Main Board ........10-6 Circuit Diagram part1 ............10-7 Component Layout Main Board ........10-8 Circuit Diagram part2 ............10-9 Exploded View ..............10-10 Partslist ................10-12 World of free manuals...
Page 150 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-2 WARNING CHARGED CAPACITORS ON THE SERVO BOARD MAY DAMAGE THE CD DRIVE ELECTRONICS WHEN CONNECTING A NEW CDM MECHANISM. THAT´S WHY, BESIDES THE SAFETY MEASURES LIKE • SWITCH OFF POWER SUPPLY • ESD PROTECTION ADDITIONAL ACTIONS MUST BE TAKEN BY THE REPAIR TECHNICIAN. The following steps have to be done when replacing the CD mechanism: 1.
Page 151 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-3 Service Position World of free manuals...
Page 152 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-4 Technical Remarks World of free manuals...
Page 153 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-5 10-5 Blockdiagram 1805 CD MECHANISM PHOTODIODE & HF AMPLIFIER - LOADER CONTROL PCB +10V DISC +5,6V 7877 7805 TURNTABLE COMMON MOTOR TCA0372 7806 CD LEFT FOCUS MOTOR FOC - Active low pass TRACK - Filter RADIAL MOTOR TDA1308 CD RIGHT...
Page 154 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-6 10-6 Mapping Copperside Componentside 7860 B5 1800 F2 2800 F3 3746 B3 3880 A2 3881 A3 7861 B5 1801 C5 2801 D4 3750 B4 3751 B4 3882 H4 7873 A1 1805 A2 2802 E4 3CDC-LC-MB Copperside view 3CDC-LC-MB Componentside view 2803 D4 3752 H3...
Page 155 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-7 10-7 1800 D1 2801 C5 2805 B5 2809 H4 2813 F3 2818 B11 2822 F9 2826 G12 2835 B13 2839 H3 2843 G3 2847 G3 2851 B11 2859 I4 2884 E7 2891 E4 3727 B12 3754 G3 3773 G3 3801 C4 3805 B4...
Page 156 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-8 10-8 Mapping Copperside Componentside 3746 B3 3880 A2 7860 B5 1800 F2 2800 F3 2801 D4 3750 B4 3881 A3 7861 B5 1801 C5 2802 E4 3751 B4 3882 H4 7873 A1 1805 A2 2803 D4 3752 H3 3883 H4 7874 C2...
Page 157 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-9 10-9 1805 1880 2831 2861 2870 2877 3372 3705 3713 3730 3743 3757 3764 3781 3855 3871 3881 3888 4827 6874 7805-B B8 7851 1850 1881 2832 2862 2871 2878 3374 3706 3714 3732 3744 3758 3765 3782 3858...
Page 158 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-10 10-10 EXPLODED VIEW (3CDC-LC-DA11 M ODULE Loader → this page MECHANICAL PARTS ––––––––––––––––––––––––––––––––––––––––––––––––––––– 20 3103 304 66500 DRAWER 21 3140 114 29070 PRESSURE RING-DA11 23 3140 111 21270 METAL RING-DA11 45 5x 30 3103 304 66560 SUPPORT 31 4822 529 10386 DAMPER - RUBBER (Rear) 32 4822 529 10387 DAMPER - RUBBER (Front) 33 3103 304 06970 WASHER...
Page 159 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-11 Drawer bottom view Drawer top view spare part non spare part 3CDC-LC Drawer assy 1999 09 13 World of free manuals...
Page 160 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-12 ELECTRICAL PARTSLIST 3CDC-LC-MB-DA11 MODULE –––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––– MISCELLANEOUS CAPACITORS ––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– 4822 361 10753 CARROUSEL MOTOR 2846© 4822 126 13883 220pF 4822 361 10753 CARROUSEL MOTOR 2847 © 4822 126 14585 100nF 1800 2422 025 12133 FLEX FOIL CONNECTOR 16PIN 2848 ©...
Page 161 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-13 ELECTRICAL PARTSLIST 3CDC-LC-MB-DA11 MODULE –––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––– RESISTORS RESISTORS ––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– 3740© 4822 051 20223 22kΩ 0,1W 3835 © 4822 117 12925 47kΩ 0,06W 3741 © 4822 051 20223 22kΩ 0,1W 3836 © 4822 051 30273 27kΩ 0,06W 3742 ©...
Page 162 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 10-14 ELECTRICAL PARTSLIST 3CDC-LC-MB-DA11 MODULE –––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––– RESISTORS RESISTORS ––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– 3897 © 4822 051 20101 100Ω 0,1W 4876 © 4822 051 20008 CHIP JUMPER 0805 3898 © 4822 117 11503 220Ω 0,1W 4879 © 4822 051 20008 CHIP JUMPER 0805 3899 ©...
Page 163 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 11-1 11-1 Circuit details: Amplifier: Attention: In the POWER 2001 module the power amplifier IC AN7591 is used as a bridge-amplifier. Any connection from output to ground will destroy the outpout stages! • Via the AMP_ON control line, connected to pins 6 (Stby), the power amplifiers are switched on/off by the µP. High level (approx.
Page 164 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 11-2 11-2 Circuit details continued: Generation of +C1 Full wave rectifying with 2 diodes of bridge rectifier 6202, using 50% secondary winding of mains transformer (pin 13-15/13-11). See picture 2 below. • Low power standby feature An additional small standby transformer, reduces power consumption in standby-mode. In case power is switched on, the control line ECO is low →...
Page 165 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 11-3 11-3 Block Diagram MAINS BOARD P2001 BOARD 1200 5001 is used for monitoring the transformer temparature Mains socket 1204 6201 1207 Stand by Relais 7301,7302 6200 1210 1205 LEFT, RIGHT Power amplifier from Source Selector on Audio Frequency Board is used for filament of display...
Page 166 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 11-4 11-4 1200 B5 6213 B5 1201 B4 6214 B5 Mains Board Copperside view 1202 C1 6215 D5 1203 A5 6216 C5 1205 B3 6217 C5 1206 C1 6218 C5 1207 C3 6220 B3 B C E 1208 D1 6221 B3 1209 C5...
Page 167 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 11-5 11-5 1200 A6 1207 B6 1222 A2 2204 D7 2210 E7 2216 A7 3205 E4 3212 D9 6202 C8 6209 E4 6215 F3 7200 D7 9211 C4 1201 A9 1208 B4 1223 B2 2205 D8 2211 E3 2217 A8 3206 E3 5001 C5...
Page 168 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 11-6 11-6 0300 B3 1307 B5 1316 C1 2306 A4 2313 B4 2320 A5 2327 B3 2334 C3 2341 B1 3303 C4 3310 A5 3317 C3 3324 A3 3331 C1 3340 C5 3347 A3 3354 A4 3361 A1 3368 A4 3375 C1 3382 C2...
Page 169 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 11-7 11-7 7316 7323 7331 9308 0300 1307-a F14 1315 2305 2312 2319 2326 2333 2340 3303 3310 3317 3324 3331 3340 3347 3354 3361 3368 3375 3382 6300 6307 6314 6321 6328 7302 7309 1300 1307-b E14 1316 2306 2313...
Page 170 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 11-8 11-8 ELECTRICAL PARTSLIST POWER2001 MODULE ELECTRICAL PARTSLIST POWER2001 MODULE –––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––– –––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––––– MISCELLANEOUS CAPACITORS RESISTORS DIODES ––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– ––––––––––––––––––––––––––––––––––––––––––––––––––––– 1200 2422 086 10963 FUSE RAD 5A 250V IEC 2326 4822 124 22652 2,2µF 3343 4822 116 52285 470kΩ...
Page 171 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 12-1 12-1 BRIEF INTRODUCTION OF THE AF9 BOARD The AF9 Board consists of the following features : a. TDA7468D IC TDA7468D IC (7501) which includes functions such as source selection, loudness control, dynamic bass control, treble control, volume control and muting function. Sound features such as ALC, DBB, DSC and IS are controllable via I C Bus from the microprocessor.
Page 172 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 12-2 12-2 AF9 BOARD - COMPONENT LAYOUT This assembly drawing shows a summary of all possible versions. For components used in a specific version see schematic diagram and respective parts list. 3139 113 3435 pt2 dd wk0048 World of free manuals...
Page 173 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 12-3 12-3 AF9 BOARD - CHIP LAYOUT This assembly drawing shows a summary of all possible versions. For components used in a specific version see schematic diagram and respective parts list. 3139 113 3435 pt2 dd wk0048 World of free manuals...
Page 174 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 12-4 12-4 AF9 BOARD - CIRCUIT DIAGRAM (PART 1) 1102 L10 1531 D1 2205 D6 2504 G3 2516 G8 2535 D4 2549 D11 2558 H13 2568 H10 2589 B10 2604 F16 2621 B16 2654 B21 2681 H7 2771 K20 3201 C7 3409 K13...
Page 175 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 12-5 12-5 AF9 BOARD - CIRCUIT DIAGRAM (PART 2) 1100 F6 1101 C2 1201 C1 3412 1202 E1 1203 C1 FE-BT-VK-N 4909 1204 E1 1521 FE-BT-VK-N 1205 C1 4910 4911 1403 1401 1405 1206 C1 D_Text 4.5V GND_D 5802 3802...
Page 176 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 12-6 12-6 VIDEO OUT CINCH BOARD - VIDEO OUT CINCH BOARD - ELECTRICAL PARTS LIST - AF9 BOARD COMPONENT LAYOUT CHIP LAYOUT MISCELLANEOUS 1201 4822 267 10738 Flex Connector 13P 2544 5322 126 11583 10nF 10% 50V 1401 4822 265 11553 Flex Connector 19P...
Page 177 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 12-7 ELECTRICAL PARTS LIST - AF9 BOARD CAPACITORS 2803 4822 124 40756 1µF 20% 100V 3593 4822 051 30562 5k6 5% 0,063W 2804 4822 126 14305 100nF 10% 16V 3594 4822 051 30562 5k6 5% 0,063W 2805 4822 126 14305 100nF 10% 16V 3601...
Page 178 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 12-8 ELECTRICAL PARTS LIST - AF9 BOARD RESISTORS 3684 4822 051 30154 150k 5% 0,062W 4147 4822 051 30008 0R Jumper 0603 3686 4822 117 12864 82k 5% 0,6W 4403 4822 051 30008 0R Jumper 0603 3687 4822 117 11817 1k2 1% 1/16W 4501...
Page 179 www.freeservicemanuals.info 12/2/2013 www.nostatatech.nl 13-1 13-1 SET MECHANICAL EXPLODED VIEW Exploded_View_3139 119 33850 dd wk0050 World of free manuals...
Page 180 3139 118 14340 Cover Tray CDC 0209 4822 492 42787 Spring Cassette D3 x 12 0107 4822 454 13408 Badge Philips 0246 4822 462 40683 Foot Rubber (SQ) M3 x 12 0111 3139 118 14350 Button Standby/Eco Power /22 0251...

This manual is also suitable for:

Fw-c700/21

Philips FW-C700 Service Manual

Quick Links

TABLE OF CONTENTS

Need help?

Questions and answers

Related Manuals for Philips FW-C700

Summary of Contents for Philips FW-C700

This manual is also suitable for:

Table of Contents