WHIRLPOOL CONSUMER SERVICES Models AVM595 WH AVM595 BL Page 3 of 14 SAFETY PRECAUTIONS INTRODUCTION Before leaving the factory each oven is carefully checked. It must however, be installed and used correctly. Despite all the steps taken to make the oven safe, the safety is dependent on the correct installation and the fact the user understands how to use and maintain the oven.
Page 4
WHIRLPOOL CONSUMER SERVICES Models AVM595 WH AVM595 BL Page 4 of 14 Dimensions of Cabinet Height Width Depth Dimensions of Cavity Height Width Depth Cavity Volume Weight Packed Electrical Voltage 230-240 Frequency Power consumption 1500 Power Nominal Output Power Microwave frequency...
WHIRLPOOL CONSUMER SERVICES Models AVM595 WH AVM595 BL Page 5 of 14 INSTALLATION REQUIREMENTS GENERAL The oven should be placed on a flat and stable surface Place the oven away from high temperature and steam sources. Clearance of at least 50mm on each side must be provided to allow adequate ventilation.
WHIRLPOOL CONSUMER SERVICES Models AVM595 WH AVM595 BL Page 6 of 14 OPERATIONAL DESCRIPTION The following describes the basic operation of the appliance. Please refer to the schematic diagram when reading: Food is placed inside the oven and the door is closed. “Start” button is not pressed: Primary and secondary interlock switches are closed.
WHIRLPOOL CONSUMER SERVICES Models AVM595 WH AVM595 BL Page 7 of 14 MICROWAVE TEST The following is a simple test to check if the appliance is generating microwave energy. This test is not intended to be an accurate test. An accurate measurement of output power must be performed under strict control following the IEC standard.
WHIRLPOOL CONSUMER SERVICES Models AVM595 WH AVM595 BL Page 8 of 14 If leakage is found to be above 5 mW/cm , the oven must not be operated until the necessary repairs have been performed and the oven retested. TROUBLE SHOOTING GUIDE CAUTION AND IMPORTANT Before disassembling the oven, the oven power must be turned off.
WHIRLPOOL CONSUMER SERVICES Models AVM595 WH AVM595 BL Page 9 of 14 QUICK SERVICE REFERENCES PROBLEM POINTS TO CHECK Cavity lamp does not light, but other 1. Lamp failed. electrical components (e.g. turntable) are 2. Bad contact between lamp and working.
WHIRLPOOL CONSUMER SERVICES Models AVM595 WH AVM595 BL Page 11 of 14 INTERLOCK SWITCH SYSTEM Oven door Primary switch Secondary Monitor status switch switch Open Open Open Close Close Close Close Open The interlock and monitor switches positions are not service adjustable. If the screws on the hinges of the oven door are loosen, the door may not be in a correct position.