Related Manuals for Stratford EcoBoiler
Summary of Contents for Stratford EcoBoiler
- Page 1 Operating & Installation Manual Stratford Eco Boiler HE Stove PLEASE RETAIN THIS GUIDE FOR FUTURE REFERENCE BK127 Rev 03 Aug 2011 Part No. AFS1552...
- Page 2 Should you have any questions about our Stratford Stoves that are not covered buy our manual set, please contact the Stratford dealer in your area, or call our technical support department on 0844 8475107 Copyright 2011 Arada Ltd...
-
Page 3: Table Of Contents
Typical installation examples for boilers 16-17 and Ash removal Boiler tapping positions Optional Extra / Accessories Water connections SPARE PARTS LIST 35-37 Hot water system check list GUARANTEE Final installation check list ADDITIONAL NOTES Building Control Consent Checklist) FACTORY CHECK LIST Stratford EcoBoiler Stove... -
Page 4: Important Fuel Notice
MUST NOT BE BURNED IN THIS APPLIANCE BITUMINOUS HOUSE COAL SHOULD NEVER BE USED IN YOUR STOVE TO USE OTHER FUELS WILL INVALIDATE THE APPLIANCE GUARANTEE IF IN DOUBT CONTACT THE SOLID FUEL ASSOCIATION TELEPHONE NUMBER 0845 601 4460 www.solidfuel.co.uk Stratford EcoBoiler Stoves... -
Page 5: Introduction
INTRODUCTION THE PRINCILE OF THE STOVE SAFETY Your Stratford stove is built to the highest standard A fireguard conforming to BS 8423:2010 should be of craftsmanship using the best materials and most used in the presence of children, the old or infirm. -
Page 6: Check List
1, ( 5" ) 5. Hot plate 1, ( 4" ) 1, ( 5" ) 1, ( 5" ) 6. Ash pan 7. Operating tool 8. Fire bed surrounds 9. Fire door handle 10. Instruction manual 12. Heat resistant glove Stratford EcoBoiler Stove... -
Page 7: Technical Data / Data Plate
Arada stoves are fitted with a data plate located on the bottom right hand side of the stove, just below the riddling shaft as shown in fig. a The data contained is as indicated in the table above. Fig. a Stratford EcoBoiler Stove... -
Page 8: Installation
Please note: Care should be taken to make sure that the The fitting of an extractor fan to either of these hinges are not damaged during installation. of these rooms is not permitted. Stratford EcoBoiler Stove... -
Page 9: Multi-Fuel Grate & Grate Bars
INSTALLATION MULTIFUEL GRATE The grate in the Stratford EcoBoiler multi fuel unit comprises of a series of reciprocating cast iron bars seated on a pivoted comb. All bars in the grate are identical, but every other bar is turned though 180 degrees, with the ends of the bars marked ‘H’... -
Page 10: Feds Inspection & Fitting
INSTALLATION FEDS Inspection & Fitting The Stratford EcoBoiler is not fitted with a traditional throat plate as found in most integrated boiler stoves, instead a highly efficient Flue Exhaust Diverter System is incorporated. This allows far more heat to be absorbed by the boiler jacket, and reduces the overall amount of heat wasted by slowing the flue gasses passage up the chimney. -
Page 11: Flue Outlet And Hotplate
THE FLUE PIPE MUST BE FITTED INSIDE THE OUTLET SPIGOT ( EB7 Outlet Collar) FAILURE TO with Building regulations and BS EN15287: parts 1 DO SO COULD RESULT IN THE SPILLAGE OF to 4. CONDENSATION ETC. RUNNING DOWN THE FLUE. Stratford EcoBoiler Stove... - Page 12 HETAS (Official Body to Solid Fuel Domestic BR_PDF_ADJ_2010.pdf Heating Appliances): Telephone 0845 634 5626 Details on the relevant Building Regulations and BS Web address: www.hetas.co.uk British Standards are given in the ‘General Precautions’ section of this manual. Stratford EcoBoiler Stove...
- Page 13 INSTALLATION NOTE: Under no circumstances should this appliance be connected to a shared flue system, that serves any other heating appliance. Minimum 150mm (6”) Diameter Flue Maximum 100mm (4”) Typical Rear Flue Outlet (As Per BS 8303-1) Stratford EcoBoiler Stove...
- Page 14 Installed to the chimney manufacturers instructions in compliance with Building Regulations and BS EN 15287 Pts 1 to 4 Typical Top Flue Outlet (AS Per BS 8303-1) PLAN VIEW OF REGISTER PLATE AND CLEARANCES FOR NON INSULATED FLUES Steel register plate 1.5mm thick minimum Stratford EcoBoiler Stove...
-
Page 15: Integral Boilers
Warning: If a pipe-stat is not fitted to control the radiator circulation pump then cold water corrosion can occur FAILURE TO COMPLY WITH THESE REQUIREMENTS WILL INVALIDATE THE GUARANTEE. Air inlet control thermostat Easy Boost Start air inlet Stratford EcoBoiler Stove... -
Page 16: Typical Installation Examples For Boilers
Central Heating and Domestic Hot water System Using Four Boiler Tapings Central Heating Without Domestic Hot water System Using Four Boiler Tapings Note: Diagrammatic representation only. Design and calculations for individual systems should always be carried out by a qualified heating engineer Stratford EcoBoiler Stove... - Page 17 Central Heating and Domestic Hot water System Using Three Boiler Tapings Central Heating Without Domestic Hot water System Using Three Boiler Tapings Note: Diagrammatic representation only. Design and calculations for individual systems should always be carried out by a qualified heating engineer Stratford EcoBoiler Stove...
-
Page 18: Boiler Tapping Positions
INSTALLATION Boiler Tapping Positions Dimensions (mm) EB 7 EB 9 EB 12 EB18 Stratford EcoBoiler Stove... -
Page 19: Water Connections
Direct Systems all times. The Stratford EcoBoiler stoves are NOT The expansion tank should have a capacity of at suitable for connecting to Direct domestic hot least 7% of the systems total water capacity. The water systems. -
Page 20: Hot Water System Check List
Is the pump thermostatically controlled YES/NO by a pipe stat? Balance the radiators. Re-vent and ensure there are no air locks What is the height and distance of the hot water tank above the stove? Stratford EcoBoiler Stove... -
Page 21: Final Installation Check List
I/We the undersigned confirm that the above details are correct. In my opinion, these works comply with the relevant requirements in part J of Schedule 1 of the Building regulations. Print name and title…………………………………………………………………..Profession………………………………….. Capacity……………………………………………………………………………...Telephone No. …………………………….. Address………………………………………………………………………………………………..Postcode………………….. Signed………………………………………………………………………………..Date………………………………………... Registered member of. (e.g. GAS SAFE,CORGI, OFTEC, HETAS, NACE, NACS)…………………………………………. Stratford EcoBoiler Stove... -
Page 22: Service & Maintenance
Use only genuine Arada Ltd spray paint as after a prolonged shut-down period. some paints interact and spoil the stove finish For removal of the FEDS for sweeping through, and invalidate the guarantee. follow the procedure detailed on page 11 Stratford EcoBoiler Stove... -
Page 23: Adjustment Of Thermostat Damper
10mm spanner for the damper boss and an 8mm for the damper lock nut. Fig. 3 Copper capillary tube Turned fully clockwise 10mm & 8mm locking nuts Set gap to 29mm +/- 1mm 8mm Spacer block Stratford EcoBoiler Stove... -
Page 24: Adjustment Of Door Hinges
Re-fit & check, repeat procedure if necessary Fig. 7 NOTE: There is no adjustment to the door lock, however periodically check the tightness of the retaining screw on the end of the door handle shaft (See Fig. 8) Fig. 8 Stratford EcoBoiler Stove... -
Page 25: Fire Door Rope Replacement
(See Fig. 9) Just before the final end, cut the rope seal to length and glue into position Allow at least 30 minutes before refitting the door to the appliance Fig. 9 Stratford EcoBoiler Stove... -
Page 26: Fire Door Glass Replacement
The pictures detailed in Fig. 10 to 12 are designed for illustration purposes only, and may differ slightly in appearance from your stove. However the procedure detailed is the same for all the Stratford EB range of boiler stoves Stratford EcoBoiler Stove... -
Page 27: Cleaning Around Thermostat Damper
(See Fig. 14) Vacuum out any lose material Repeat this operation until all ash is removed Fig. 13 Fig. 14 Remove any ash build up here Ash Removal Slot Stratford EcoBoiler Stove... -
Page 28: Service Record
Company Work Carried Out Signature Should you have any questions about your Stratford EcoBoiler stove that are not covered in this manual please contact your Arada dealer. Please keep all repair receipts safely. Please ensure you have this manual available when an engineer visits so they can complete the service record chart. -
Page 29: Operating Instructions
AIR INLET CONTROLS Setting Knob Stratford EcoBoiler stoves have three air inlets The air wash system (so called because pre-heated high speed air washes across the inner face of the glass, helping to keep it clear) provides the over draught air for the stove. -
Page 30: Operating Tool
OPERATING INSTRUCTIONS MULTI PURPOSE OPERATING TOOL RIDDLING Your STRATFORD stove comes with a Use the operating tool to set the grate bars in the multi-purpose operating tool (Fig. 17) which is correct position for burning. The grate bars used for both setting and for riddling the multi fuel should be set to the + symbol on the indicator grate bars. -
Page 31: Fuel Types
Do not light the fire if it is suspected that any part of the water system (pipe work, boiler etc) could be frozen. WARNING: Do not leave the Easy Boost air slider open for long periods , or if the stove is un-attended. Stratford EcoBoiler Stove... -
Page 32: Solid Fuel & Longer Burning Periods
Seek expert advice from your HETAS registered Ensure the area is well ventilated during this engineer. Do not attempt to re-light the stove until time. the cause of the fume emission has been identified and corrected. See page 12 for details. Stratford EcoBoiler Stove... -
Page 33: Over Firing, Chimney Fires
To enable a good flow of air through the appliance to reduce condensation and subsequent damage, leave the air controls fully open. Stratford EcoBoiler Stove... -
Page 34: Optional Extra /Accessories
EB 9 EB 12 EB 18 Stand Stand7-9HE Stand7-9HE Stand12HE Stand18HE Floor Fixing Kit AFS1135 AFS1135 AFS1135 AFS1135 Touch-up Paint AFS101A AFS101A AFS101A AFS101A ( aerosol ) SIGN5 SIGN5 SIGN7 SIGN9 Lattice Tracery TRACEL TRACEL TRACEL TRACEL Stratford EcoBoiler Stove... -
Page 35: Spare Parts List
Grate Bar AFS001 AFS001 AFS001 AFS001 Hot Plate Not Used AFS009B AFS010 AFS010 Operating Tool AFS008 AFS008 AFS008 AFS008 Ashpan AFS058 AFS058 AFS1394 AFS1337 Flue Spigot Not Used AFS009A AFS009 AFS009 Glass Replacement AFS1453 AFS1453 AFS1484 AFS1518 Stratford EcoBoiler Stove... - Page 36 Fire Door Locking AFS1385 AFS1385 AFS1385 AFS1385 Assembly Ecoboiler Thermo- -stat assembly, AFS1564 AFS1564 AFS1564 AFS1564 Damper & Knob Knob AFS1379 AFS1379 AFS1379 AFS1379 Ecoboiler Damper AFS1565 AFS1565 AFS1565 AFS1565 Plate Fire Bed Surround AFS1380 AFS1380 AFS1380 AFS1380 Stratford EcoBoiler Stove...
-
Page 37: Spare Parts List
AFS1321 Cover Heat Resistant Glove AFS1285 AFS1285 AFS1285 AFS1285 Control Knob AFS1405 AFS1405 AFS1405 AFS1405 Easy Boost Slider AFS1369 AFS1369 AFS1369 AFS1369 Plus / Minus Bracket AFS1412 AFS1412 AFS1412 AFS1412 Thermostat Mounting AFS1570 AFS1570 AFS1570 AFS1570 Bracket Stratford EcoBoiler Stove... -
Page 38: Guarantee
Once again we would like to thank you for buying a Stratford EcoBoiler stove. When you buy a STRATFORD stove, you are not only buying a first class appliance you are buying a commitment from us to look after you and your appliance for as long as you want. -
Page 39: Additional Notes
ADDITIONAL NOTES Stratford EcoBoiler Stove... -
Page 40: Factory Check List
Factory Check list Stove Model …………………….……..………………………………. Serial No Quality I’ve checked it Finish Flue Outlet (Not EB7) and its O.K Hot Plate (Not EB7) Fuel Retainer Grate Bars Assembled By………………………. Rear Fire Bed Surrounds Checked by…………………………. FEDS Cover Air Wash Door Handle Ash Pan...
Need help?
Do you have a question about the EcoBoiler and is the answer not in the manual?
Questions and answers