Unplugging and plugging the connectors dur- ing power-on mode may damage the ICs inside the unit. 2. To protect the pickup unit from electrostatic dis- charge during serviving, take an appropriate treat- ment(shorting-solder) by referring to "the DISAS- SEMBLY" on page 56. DEH-P460MP/XM/UC...
Page 3
By following the instructions in this manual, be sure to apply the prescribed grease or glue to proper portions by the appropriate amount.For replacement parts or tools, the prescribed ones should be used. DEH-P460MP/XM/UC...
21-5 Card See Contrast table(2) Handle CNC5395 21-6 Caution Card See Contrast table(2) Holder See Contrast table(2) Case Assy See Contrast table(2) Holder See Contrast table(2) Remote Control Unit CXC3173 Bush CNV3930 Inner Box XHW7001 Polyethylene Bag See Contrast table(2) DEH-P460MP/XM/UC...
Page 9
(2) CONTRAST TABLE DEH-P460MP/XM/UC, DEH-P4600MP/XM/UC and DEH-P4650MP/XM/ES are constructed the same except for the following: Parts No. Mark No. Symbol and Description DEH-P460MP/XM/UC DEH-P4600MP/XM/UC DEH-P4650MP/XM/ES Accessory Assy CEA3376 CEA3376 CEA3439 CEA3848 CEA3848 CEA3849 Screw Assy Fixing Screw BPZ20P060FZK BPZ20P060FZK Not used...
Page 11
Chassis Unit CXB9528 Sheet See Contrast table(2) Remote Control Unit CXC3173 Lighting Conductor XNV7012 Cover CNS7068 Button(CLOCK) See Contrast table(2) CD Mechanism Module(S10CODE2)CXK5665 Screw ISS26P055FTC Cable CDE7189 Tuner Amp Unit See Contrast table(2) Screw ASZ26P060FTC Screw BPZ26P080FTC Screw BSZ26P160FTC DEH-P460MP/XM/UC...
Page 12
(2) CONTRAST TABLE DEH-P460MP/XM/UC, DEH-P4600MP/XM/UC and DEH-P4650MP/XM/ES are constructed the same except for the following: Parts No. Mark No. Symbol and Description DEH-P460MP/XM/UC DEH-P4600MP/XM/UC DEH-P4650MP/XM/ES Panel CNS6935 XNS7070 CNS6935 Tuner Amp Unit XWM7023 XWM7023 XWM7024 Pin Jack(CN352) CKB1051 CKB1051 CKB1057(CN351)
BDATA,BSCK Q752 CLAMP 12EJ VDCONT DSCSNS Q751 HOME VDCONT DISC CLAMP 12EJ HOME +3.3V REGULATOR SENSE SENSE SENSE SENSE 3VDD IC 703 DETACH SENS IC 203 S-812C33AUA-C2N V3R3D NJM2391DL1-33 +3.3V REGULATOR Q754 IC 501 V1R5 V3R3D S-L2980A15MC-C6A 1.5V REGULATOR DEH-P460MP/XM/UC...
PANEL UNIT 12k ohms 0.01uF 10k ohms 101/10 100uF/10V Detailed page The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. DEH-P460MP/XM/UC...
Page 19
CD : 10.1dBs IP-BUS : 10.3dBs REAR OUTPUT > REAR OUTPUT LLER CEK1208 600µH > FM : 31.6dBs AM : 21.1dBs CD : 36.1dBs IP-BUS : 36.3dBs DETACH SENSE : UC model only : ES model only WIRED REMOTE CONTROL DEH-P460MP/XM/UC...
Page 32
7 SIN 500mV/div 200mV/div 1V/div @ TE 500mV/div 9 TIN 500mV/div CD-ROM play operation(Regular track Jump) Spindle waveform during play operation Spindle waveform during play operation (Wider) Ref.: Ref.: Ref.: REFO REFO REFO Mode: Mode: Mode: Normal Normal Normal DEH-P460MP/XM/UC...
Page 33
500mV/div 4 LOEJ 3 12SNS 9 TIN 5V/div 5V/div 500mV/div 4 LOEJ 5V/div 12 cm CD Eject operation 8 cm CD Eject operation CD-DA >> CD-ROM mode change(Band key) Ref.: Ref.: Ref.: REFO Mode: Mode: Mode: Normal Normal Normal DEH-P460MP/XM/UC...
Page 34
% RFAGC 1V/div 500ms/div 1V/div 500µs/div 8 CIN 9 TIN 500mV/div 1V/div 9 TIN @ TE 500mV/div 1V/div 0 FIN 1V/div CD-ROM >> CD-DA mode change(Band key) Black dot(800µm) during play Ref.: Ref.: REFO REFO Mode: Mode: Normal Normal DEH-P460MP/XM/UC...
For further information for WIRED respective destinations, be sure REMOTE to check with the schematic dia- CONTROL gram. 2.Viewpoint of PCB diagrams Capacitor Connector IP-BUS SIDE A SIDE B P.C.Board Chip Part CN901 DETACH SENSE DEH-P460MP/XM/UC...
Page 37
SIDE A CORD ASSY ANTENNA CN1950 FRONT DEH-P460MP/XM/UC...
D 834 Diode DAP202U R 302 RS1/16S103J R 303 RS1/16S103J D 835 Diode DAN202U D 836 Diode DAP202U R 304 RS1/16S331J D 901 Diode HZS6L(B1) R 351 RS1/16S821J D 902 Diode MPG06G-6415G50 R 352 RS1/16S821J D 911 Diode HZS9L(B3) DEH-P460MP/XM/UC...
Page 45
C 136 CEJQ1R0M50 R 743 RS1/16S221J R 744 RS1/16S221J C 137 CEJQ1R0M50 R 745 RS1/16S221J C 138 CEJQ1R0M50 R 746 RS1/16S221J C 139 CEJQ470M16 C 140 CKSRYB104K16 R 747 RS1/16S221J C 141 CKSRYB102K50 R 748 RS1/16S221J R 751 RD1/4PU221J DEH-P460MP/XM/UC...
Page 46
R 1904 RS1/16S121J C 911 CEJQ221M10 R 1910 RS1/16S181J C 912 CKSRYB103K50 R 1911 RS1/16S181J C 913 CEJQ101M16 R 1912 RS1/16S181J C 921 CEJQ220M10 R 1913 RS1/16S181J C 922 CKSRYB103K50 R 1914 RS1/16S181J C 924 CEJQ4R7M35 R 1915 RS1/16S181J DEH-P460MP/XM/UC...
Page 47
R 233 RS1/16SS0R0J C 1970 CKSRYB104K16 R 240 RS1/16SS0R0J R 241 RS1/16SS333J R 242 RS1/16SS0R0J Unit Number:CWX2851 R 243 RS1/16SS333J Unit Name:CD CORE UNIT(S10WMA) R 245 RS1/16SS333J R 250 RS1/16SS0R0J MISCELLANEOUS R 256 RS1/16SS0R0J R 261 RS1/16S0R0J IC 201 UPD63761GJ DEH-P460MP/XM/UC...
Page 48
C 301 CKSSYB221K50 R 754 RS1/16SS102J C 302 CKSSYB221K50 C 303 CKSSYB472K25 R 755 RS1/16SS102J R 756 RS1/16SS104J C 304 CKSSYB103K16 R 765 RAB4CQ221J C 305 100µF/16V CCH1504 R 769 RAB4CQ221J C 306 CKSSYB104K10 R 773 RAB4CQ221J C 307 CKSSYB104K10 DEH-P460MP/XM/UC...
Page 49
C 713 CKSSYB104K10 C 714 CKSSYB104K10 C 716 CKSSYB103K16 C 720 CKSQYB225K10 C 722 CKSRYB105K10 C 903 CKSSYB471K50 C 906 CKSRYB224K16 C 907 CKSSYB103K16 C 910 CKSQYB225K10 Miscellaneous Parts List Pickup Unit(P10)(Service) CXX1641 Motor Unit(SPINDLE) CXB6007 CXB8933 Motor Unit(LOADING/CARRIAGE) DEH-P460MP/XM/UC...
1k ohms in series. • The load and eject operation is not guarantied with the mechanism upside down. If the mechanism is blocked due to mistaken eject operation, reset the product or turn off and on the ACC to restore it. DEH-P460MP/XM/UC...
Page 51
TYP(1X) TRK 22 MIN 22 SEC 22 TRK 11 MIN 11 SEC 11 As for the double speed (2x), audio output cannot be supported. → → TYP(2X) TRK 11 MIN 11 SEC 11 TRK 22 MIN 22 SEC 22 DEH-P460MP/XM/UC...
Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the average angle. • Hint Reloading the disc changes the clamp position and may decrease the "wobble". DEH-P460MP/XM/UC...
Remarks: Mechanical errors are not displayed (because a CD is turned off in these errors). Unreadable TOC does not constitute an error. An intended operation continues in this case. Upper digits of an error code are subdivided as shown below: 1x: Setup relevant errors, 3x: Search relevant errors, Ax: Other errors. DEH-P460MP/XM/UC...
The frequency of the clock signal is 786.432kHz that is one 4th of the fundamental frequency. The clock signal should be 786.432kHz ± 32Hz. If the clock signal is out of the range, the X'tal (X601) should be replaced with new one. DEH-P460MP/XM/UC...
Removing the Tuner Amp Unit (Fig.2) Remove the screw and then remove the Holder. Remove the three screws. Remove the screw. Straighten the tabs at three locations indicated. Remove the screw and then remove the Tuner Amp Unit. Tuner Amp Unit Fig.2 DEH-P460MP/XM/UC...
Page 57
Caution: Before installing the carriage mechanism in the frames, be sure to apply some alcohol to the dampers and set the mechanism to the clamp mode. Carriage Mechanism Damper Lower Frame Damper Damper DEH-P460MP/XM/UC...
Page 58
Caution: In assembling, move the planet gear to the load/eject position before setting the feed screw in the inner holder. Washer Pickup Lock Arm Change Arm Styling Holder Feed Screw Inner Holder Planet Gear DEH-P460MP/XM/UC...
Clamp SW input VDCONT CD : VD power control output xsck CD LSI clock output CD LSI data input CD LSI data output CD LSI command/data control output xrst CD LSI reset control output xstb CD LSI strobe output DEH-P460MP/XM/UC...
Page 61
PLL data output TUNPCE PLL chip enable output Beep tone output * PE5407A IC's marked by * are MOS type. Be careful in handling them because they are very liable to be damaged by electrostatic induction. Format Meaning CMOS BD4834G Vref DEH-P460MP/XM/UC...
Page 62
Display data input Not used KYDT Key data output MODA Crystal oscillator connection pin Crystal oscillator connection pin 25,26 KDT2,3 Key data input 27,28 KST5,4 Key strobe output 29-55 SEG39-13 LCD segment output Power supply 57-64 SEG12-5 LCD segment output *PD6340A DEH-P460MP/XM/UC...
Page 63
CD mute control output 56-58 For changer(Interruption at the edge) CD LSI chip selection output Not used xwait CD LSI write control signal output CLKOUT Internal system clock output(Open) LOCK Spindle lock input Not used xwrite CD LSI write control signal output DEH-P460MP/XM/UC...
Page 64
CD-DA analog/digital output change setup testin Chip check test program starting input HOME Home SW sense input TEMP Temperature information sense input VDSENS VD power supply short sense input Not used * PE5402A Format Meaning CMOS * S-812C33AUA-C2N Reference Voltage DEH-P460MP/XM/UC...
Page 65
Output of DRAM ras cas)(LDQM) Output of DRAM lower cas(LDQM) cas!(UDQM) Output of DRAM upper cas(UDQM) Output of DRAM we oe(cas) Output of DRAM oe(cas) D.GND Ground for digital circuits 73-88 RDB0-15 Input/output of DRAM data0-15 89-99 RA0-10 Output of DRAM address0-10 DEH-P460MP/XM/UC...
Page 66
Connected to the capacitor for output of REFOUT Reversal input of FE Output of FE ADIN Input of FE, TE A/D converter Reversal input of TE Output of TE Output of LD Input of PD D.GND Ground for digital circuits * UPD63761GJ DEH-P460MP/XM/UC...
Page 67
Input pin for preamplifier for thread OPOUT3 CH3 preamplifier output pin OPIN3(-) Input pin for inverting input for CH3 preamplifier OPIN3(+) Input pin for non-inverting input for CH3 preamplifier PREVCC PreVcc BA5835FM * S-L2980A15MC-C6A VOUT Reference voltage ON/OFF circuit ON/OFF DEH-P460MP/XM/UC...
Page 68
22 AUDIOGND audio ground Ground of audio block 23 L ch O L channel output FM stereo “L-ch” signal output or AM audio output 24 R ch O R channel output FM stereo “R-ch” signal output or AM audio output DEH-P460MP/XM/UC...
In case of the above signal, the communication with Grille microcomputer may fail. Source keys If the time interval is not 300msec, the oscillator operative may be defective. Source ON SYSPW←H Pin 21 Completes power-on operation. (After that, proceed to each source operation) DEH-P460MP/XM/UC...
7.4 CLEANING Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools: Portions to be cleaned Cleaning tools CD pickup lenses Cleaning liquid : GEM1004 Cleaning paper : GED-008 DEH-P460MP/XM/UC...
Page 76
1. Attach the holders to both sides of the front panel. Holder CND1250(UC) CXX1645(ES) Holder CND1249(UC) CXX1644(ES) 2. Replace the front panel to the unit. 3. Flip the holders into upright positions. 4. Fix the front panel to the unit using fixing screws. Fixing screw BPZ20P060FZK(UC) CXX1646(ES) DEH-P460MP/XM/UC...