Table of Contents
Advertisement
Quick Links
HHB4SE,HHB6SE & HHB8SE
The HHB4SE, HHB6SE and HHB8SE have been exempted under the clean air act 1993 as suitable
for use in smoke control areas when burning seasoned wood logs. The stove contains a factory
fitted secondary air stop which ensures that the secondary air cannot be closed further than:
5mm open for the 4SE, 9mm open for the 6SE and 4mm open for the 8SE. Please carefully read
the instructions on wood burning contained in this manual, these MUST be adhered to at all
times. Please see page 15 of the manual for further reference to the clean air act 1993
Please hand these instructions to the stove user when the installation is complete. Leave the stove ready for
operation and instruct the user in the correct use of the appliance and operation of controls.
Important: – This product must be installed by a suitably qualified installer.
PLEASE READ ALL THESE INSTRUCTIONS CAREFULLY!
For safety reasons it is essential that your stove is correctly installed and operated. Hothouse cannot
accept responsibility for any fault or consequential problems arising through incorrect installation or
operation.
SMOKE EXEMPT
BREEZE RANGE
Installation and Operating
Instructions
Please fix label with serial number and stove
typehere before putting manual into stove
Hothouse Inspired Products Ltd
Express Trading Estate
technical@hothouseproducts.co.uk
Imperial Point
Stonehill road
Farnworth
Bolton BL4 9TN
Advertisement
Table of Contents
Related Manuals for HotHouse HHB4SE
Summary of Contents for HotHouse HHB4SE
- Page 1 Please fix label with serial number and stove typehere before putting manual into stove The HHB4SE, HHB6SE and HHB8SE have been exempted under the clean air act 1993 as suitable for use in smoke control areas when burning seasoned wood logs. The stove contains a factory fitted secondary air stop which ensures that the secondary air cannot be closed further than: 5mm open for the 4SE, 9mm open for the 6SE and 4mm open for the 8SE.
-
Page 2: Table Of Contents
Shutting down Maintenance Seasonal Use 7. Safety Notes for your Guidance 8. Stove Dimensions 9. Frequently Asked Questions 10. HHB4SE Spare Parts List & Codes 11. HHB6SE Spare Parts List & Codes 12. HHB8SE Spare Parts List & Codes HHB468SE 12-09-13... -
Page 3: List Of Components
Hothouse Stove Assembly Tool Ash Pan Flue Collar Flue Collarfixing screws & Washers Legs Stove Operating Glove Touch up paint Warranty Card Fig 2 – HHB4SE Stove Assembly and controls Fig 3 – HHB6SE and HHB8SE Stove assembly and controls HHB468SE 12-09-13... -
Page 4: Component Identification And Assembly
2. Component Identification and Assembly Your Hothouse Stove comes packed in a cardboard box. Carefully remove any straps and remove all cardboard and any plastic packaging, open the door and remove all the contents. See Listof Components section and check contents carefully. -
Page 5: Installation Information
Handling Adequate facilities must be available for unloading and site handling. Hothouse Cassette Stoves are very heavily built so always ask for assistance when lifting and siting the stoves. Fire Cement Some types of fire cement are caustic and should not be allowed to come into contact with the skin. -
Page 6: Flue Draught
If the problem persists seek the advice of a chimney sweep. Material Clearances Safety Distances from Combustible Surfaces: Model Side Rear HHB4SE 500mm 700mm HHB6SE 400mm 400mm HHB8SE... -
Page 7: Hearths
Hearths: Hothouse stoves require a 125mm thick non-combustible constructional hearth beneath them to protect the building, this can include any solid non-combustible floor. A non-combustible superimposed hearth forming an apron of at least 225mm at the front of the stove and 150mm on either side must also be provided. The superimposed hearth must not be less than 12mm thick and must have a clearly defined edge (change of level) to discourage placing of any combustible materials on or partially over it. -
Page 8: Air Controls
MultifuelGrate Your Hothouse Stove is fitted with a rotary style grate, which is operated from the front of the stove via a riddle rod. Use the “Hook” end of tool to operate the riddling system. This rotary grate is located in the centre of a cast iron flat bed with suitable air slots that assist the burning of most fuels. -
Page 9: Notes On Wood Burning
Solid Fuel Burn only manufactured smokeless fuels listed as suitable for use in a closed appliance. Do not burn bituminous coal, “petro-coke” or other petroleum based fuels as this will invalidate the warranty. Notes on Wood burning Notes on Wood burning With a full load of wood, the stove will need to be refuelled approximately every 1.5 hours. -
Page 10: Shutting Down
Fuel Overloading Four good size logs is a sufficient quantity of fuel to achieve the rated output from this appliance. Never exceed this amount of fuel and never stack the fuel too high in the stove so as it touches the baffle as this may cause smoke to be produced. Shutting Down The stove will normally shut down by itself as the fuel is consumed. -
Page 11: Stove Dimensions
If the wall is becoming hot, move the furniture away. Ensure that the Fire Brigade can gain access to your roof space in order to check this area for signs of fire spread 8.0 Stove Dimensions Fig. 3 – HHB4SE, HHB6SE, HHB8SE Stove Stove HHB4SE 5”... -
Page 12: Frequently Asked Questions
A call out charge will apply if our engineer attends any stove problem that is not related to product failure. 6 Where can I get spare parts? Your local Hothouse Stove retailer will be pleased to supply spare parts and to provide any other information you require. -
Page 13: Legs
10. HHB4SE Spare Parts List and Codes Component HHB04SE Component HHB04SE Door Glass Y1HDF04D01E Ashpan Y1HDF04D28E Glass Brackets and Screws Y1HDF04D02E Glove Y1HD29E Y1HHF04D03E Y1HD31E Door Handle assembly Ashpan Tool Y1HDF04D04E Y1HBF04D32E Coalcatcher Door Back Plate/fireboard Y1HDF04D05E Primary Air Control including handle... - Page 14 11. HHB6SE Spare Parts List and Codes Component HHB06SE Component HHB06SE Door Glass Y1HDF06D01E Collar Y1HD23E Glass Brackets and Screws Y1HDF06D02E Ashpan Y1HDF06D28E Door Handle assembly Y1HHF06D03E Glove Y1HD29E Coalcatcher Y1HDF06D04E Ashpan Tool Y1HD31E Back Plate/fireboard Y1HDF06D05E Door Y1HBF06D32E Side Plate Left/fireboard Y1HDF06D06E Primary Air Control including handle Y1HBF06D33E...
-
Page 15: Hhb8Se Spare Parts List & Codes
12. HHB8SE Spare Parts List and Codes Component HHB08SE Component HHB08SE Door Glass Y1HDF08D01E Collar Y1HD24E Glass Brackets and Screws Y1HDF08D02E Ashpan Y1HDF08D28E Door Handle assembly Y1HHF08D03E Glove Y1HD29E Coalcatcher Y1HDF08D04E Ashpan Tool Y1HD31E Back Plate/fireboard Y1HDF08D05E Door Y1HBF08D32E Side Plate Left/fireboard Y1HDF08D06E Primary Air Control including handle Y1HBF08D33E... - Page 16 Ltd Approval does not cover the use of other fuels either alone or mixed with the recommended fuels listed above, nor does it cover instructions for the use of other fuels. Hothouse Inspired Products Ltd Imperial Point Express Trading Estate...
Need help?
Do you have a question about the HHB4SE and is the answer not in the manual?
Questions and answers