The use of a substitute replacement component which does Leakage 0.5mA current Device not have the same safety characteristics as the PIONEER tester under recommended replacement one, shown in the parts list in test this Service Manual, may create shock, fire, or other hazards.
Page 3
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. DJM-800...
MID ............. –26 dB to +6 dB (1 kHz) LOW ............–26 dB to +6 dB (70 Hz ) Microphone equalizer response HI ............... –12 dB to +6 dB (10 kHz) LOW ............–12 dB to +6 dB (100 Hz ) DJM-800...
Screws adjacent to mark on product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.) 2.1 PACKING SECTION DJM-800 DJM-800...
Page 7
Correction Sheet See Contrast table (2) Packing Case See Contrast table (2) Packing Sheet RHX1006 (2) CONTRAST TABLE DJM-800/WYXJ5, DJM-800/TLXJ and DJM-800/KUCXJ are constructed the same except for the fHollowing : DJM-800 DJM-800 DJM-800 Mark No. Symbol and Description /KUCXJ...
2.2 EXTERIOR SECTION Refer to "2.3 CONTROL PANEL SECTION". DJM-800...
Page 9
See Contrast table (2) Bracket TRIM DNF1728 Earth LABEL See Contrast table (2) Bracket SSW DNF1729 (2) CONTRAST TABLE DJM-800/WYXJ5, /TLXJ and DJM-800/KUCXJ are constructed the same except for the fHollowing : DJM-800 DJM-800 DJM-800 Mark No. Symbol and Description /KUCXJ /WYXJ5 /TLXJ >...
/// COLOR EFFECT (Others) /// CH 4 CH 4 same as CH 3 EFFECT CH SELECT CH1~ 4 Effect SW CH1 ~ 4 In EFFECT CH1 ~ 4 Processor CF_A/B EFFECT Processor MIX RATIO Effect Out Master EFFECT CUE To DSP BLOCK DIAGRAM DJM-800...
Page 13
÷ The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. ÷ : The power supply is shown with the marked box. DJM-800...
EFFECT CUE CableCheck /// BEAT EFFECT (Other) /// /// COLOR EFFECT (Others) /// EFFECT CH SELECT CH1~ 4 Effect SW CH1 ~ 4 In EFFECT CH1 ~ 4 Processor CF_A/B EFFECT Processor MIX RATIO Effect Out Master EFFECT CUE DJM-800...
Page 15
◊ I detect B P M only for CH which EFFECT CH SELECT appears, and was Counter. from CPU) /// H.P. MIX /// H.P.MONOSPLIT/STEREO SW CHx CUE CUE Balance H.P.Level Mono Split H.P. Out Lch Stereo EFFECT CUE CH1 ~ 4 Out Mono Split Master Balance H.P.Level Stereo H.P. Out Rch Master CUE DJM-800...
Page 19
(CH1) (CH1) (CH1Y) (D1) (CH1D) AUDIO SIGNAL ROUTE (LI) : LINE INPUT L CH SIGNAL (CDI) : CD INPUT L CH SIGNAL (CH1) : CH1 L CH SIGNAL (D1) : CH1 DIGITAL SIGNAL (CH1Y) : CH1 Y CH SIGNAL DJM-800...
Page 21
(CH2) (CH2) (CH2Y) (D2) (CH2D) AUDIO SIGNAL ROUTE (PI) : PHONO INPUT L CH SIGNAL (CDI) : CD INPUT L CH SIGNAL (CH2) : CH2 L CH SIGNAL (D2) : CH2 DIGITAL SIGNAL (CH2Y) : CH2 Y CH SIGNAL DJM-800...
Page 23
(CH3) (CH3) (CH3Y) (D3) (CH3D) AUDIO SIGNAL ROUTE (PI) : PHONO INPUT L CH SIGNAL (LI) : LINE INPUT L CH SIGNAL (CH3) : CH3 L CH SIGNAL (D3) : CH3 DIGITAL SIGNAL (CH3Y) : CH3 Y CH SIGNAL DJM-800...
Page 25
(CH4) (CH4) (CH4Y) (D4) (CH4D) AUDIO SIGNAL ROUTE (PI) : PHONO INPUT L CH SIGNAL (LI) : LINE INPUT L CH SIGNAL (CH4) : CH4 L CH SIGNAL (D4) : CH4 DIGITAL SIGNAL (CH4Y) : CH4 Y CH SIGNAL DJM-800...
Page 27
MUTE (REC) (REC) (MA) (REC) (MA) AUDIO SIGNAL ROUTE (RECD) : REC DIGITAL CH SIGNAL (REC) : REC L CH SIGNAL (MA) : MASTER L CH SIGNAL DJM-800...
: CH 3 Y CH SIGNAL (CH4Y) : CH 4 Y CH SIGNAL (D1) : CH1 DIGITAL SIGNAL (D2) : CH2 DIGITAL SIGNAL (D3) : CH3 DIGITAL SIGNAL (D4) : CH4 DIGITAL SIGNAL (MA) : MASTER L CH SIGNAL DJM-800...
Page 31
(MIC1) (MIC2) MIC A/D (MICD) AUDIO SIGNAL ROUTE (MIC1) : MIC1 L CH SIGNAL (MIC2) : MIC2 L CH SIGNAL (MICD) : MIC DIGITAL CH SIGNAL CN1704 DJM-800...
3.16 DIGI A ASSY DIGI A ASSY (DWX2555) CN1201 AUDIO SIGNAL ROUTE (D1) : CH1 DIGITAL SIGNAL (D2) : CH2 DIGITAL SIGNAL (D3) : CH3 DIGITAL SIGNAL : CH4 DIGITAL SIGNAL (D5) DJM-800...
3.17 DSP ASSY (1/3) DSP ASSY (DWX2534)(1/2) CN1702 CN1701 Large size SCH diagram 1/3,2/3 AUDIO SIGNAL ROUTE (SDD) : SEND DIGITAL SIGNAL (RND) : RETURN DIGITAL SIGNAL (BOD) : BOOTH DIGITAL SIGNAL : MASTER DIGITAL SIGNAL (MA1D) DJM-800...
DSP ASSY (DWX2534)(2/2) Large size SCH diagram 2/3,3/3 1/3,2/3 AUDIO SIGNAL ROUTE (CH1Y) : SCH 1 Y CH SIGNAL (CH2Y) : SCH 2 Y CH SIGNAL CN2503 CN1205 DJM-800...
(CH4Y) 1/3,3/3 AUDIO SIGNAL ROUTE (CH1Y) : SCH 1 Y CH SIGNAL (CH2Y) : SCH 2 Y CH SIGNAL (MA1D) : MASTER DIGITAL CH SIGNAL : MASTER DIGITAL CH SIGNAL (MA2D) (RECD) : REC DIGITAL CH SIGNAL CN201 (BOD) DJM-800...
Page 59
(SD) (RND) AUDIO SIGNAL ROUTE (SD) : SEND L CH SIGNAL (SDD) : SEND DIGITAL CH SIGNAL (RN) : RETURN L CH SIGNAL (RND) : RETURN DIGITAL CH SIGNAL DJM-800...
3.23 DIGI C ASSY DIGI C ASSY (DWX2547)(1/2) Large size SCH diagram AUDIO SIGNAL ROUTE (D1) : CH 1 DIGITAL SIGNAL (D2) : CH 2 DIGITAL SIGNAL (D3) : CH 3 DIGITAL SIGNAL : CH 4 DIGITAL SIGNAL (D4) (D1) DJM-800...
Page 62
DIGI C ASSY (DWX2547)(2/2) Large size SCH diagram (D1) (D2) (D1) AUDIO SIGNAL ROUTE (D1) : CH 1 DIGITAL SIGNAL (D2) : CH 2 DIGITAL SIGNAL (D3) : CH 3 DIGITAL SIGNAL : CH 4 DIGITAL SIGNAL (D4) DJM-800...
• In case of repairing, use the described parts only to prevent an accident. • Please write the red mark on the board when the primary section of POWER SUPPLY (SYPS) Unit is repaired. • Please take care to keep the space, not touching other parts when replacing the parts. DJM-800...
Page 78
NOTE: The following waveforms were measured at the point of the corresponding balloon number in the schematic diagram OUTPUT ASSY (2) CN901-pin12 (6M) V: 1V/div. H: 50nsec/div. CN901-pin10 (96K) (LRCK) V: 1V/div. H: 2µsec/div. DJM-800...
4.2 PANEL 1 ASSY CN2101 CN2102 SIDE A PANEL1 ASSY CN1710 CN1711 V+5D NO USE IC1710 IC1710 NO USE CN1710 CN1711 NO USE IC1709 IC1709 NO USE MIX2 D1720 D1735 CN1704 S1708 D1719 103B LEVEL1 LEVEL2 103B CN1704 CN1503 DJM-800...
4.3 TRIM 1 to TRIM 4 and AC SW ASSYS SIDE A SIDE A TRIM3 ASSY ACSW ASSY (DNP2208-C) LIVE TRIM2 ASSY WHITE BROWN NEUTRAL LIVE NEUTRAL (DNP2208-C) (DNP2208-C) TRIM4 ASSY TRIM1 ASSY (DNP2208-C) (DNP2208-C) 1/4–4/4 1/4–4/4 DJM-800...
Page 89
SIDE B SIDE B TRIM3 ASSY ACSW ASSY DWX2545- /J ACSW PRIMARY (DNP2208-C) LIVE TRIM2 ASSY NEUTRAL SOLDER (DNP2208-C) (DNP2208-C) TRIM4 ASSY TRIM1 ASSY C791 (DNP2208-C) (DNP2208-C) 1/4–4/4 1/4–4/4 DJM-800...
D2133 D2134 CUE EFC 103B S2109 LEVEL/DEPTH TIME EFFECT EFFECT CH SEL EFFECT SEL ON/OFF DIGI A ASSY DWX2555- /J DIGIA DIG IN 3 DIG IN 4 DIG IN 2 DIG IN 1 JA1402 JA1401 (DNP2210-C) CN1401 CN1401 CN1201 DJM-800...
6. ADJUSTMENT Mark No. Description Part No. > CN91 AMP U-P CONNECTOR 2P 2-178496-4 > J0 CONNECTOR ASSY DKP376 • There is no information to be shown in this chapter. DJM-800...
2 Mode 2 : ALL LED & FL display "OFF" MODE. "ALL CLR" It displays "ALL CLR" on the FL display in the first 2 seconds. 3 Mode 3 :ALL LED & FL display "ON" MODE. "ALL SET" It displays "ALL SET" on the FL display in the first 2 seconds. DJM-800...
Page 121
COLOR CH4 LED "DIGITAL" is selected : Lights Green : OFF MIC LED : ON MIC LED & CH1 Level Meter -24dB LED : TALK OVER -24dB : MONO SPLIT Headphone CH2 Level Meter LED MONO/STEREO : STEREO -15dB DJM-800...
Page 122
CF.B -1dB MASTER MONO : Lights off MONO STEREO Master Level Meter L CH LED 10dB Select SW STEREO : Lights ADD : Lights off MIC SIGNAL Select sw Master Level Meter L CH LED OVER CUT : Lights DJM-800...
Page 123
When the cable is connected up to L side RETURN IN terminal, it displays as "R". • Default "0" • Upper limit "100" TIME Encoder • Lower limit "-100" Example Example of selecting 96k Example of selecting Upper Limit DJM-800...
Page 124
I finish turning it. It displays "VOLTEST1" on the FL display in the first 2 seconds. Then it displays "VOL 1" on the bottom of ths FL Display. (in order to let you display TRIM value) VOL 1 DJM-800...
Page 125
I finish turning it. It displays "VOLTEST2" on the FL display in the first 2 seconds. Then it displays "VOL 2" on the bottom of ths FL Display. (in order to let you display TRIM value) DJM-800...
Page 126
I finish turning it. It displays "VOLTEST3" on the FL display in the first 2 seconds. Then it displays "VOL 3" on the bottom of ths FL Display.(in order to let you display TRIM value) DJM-800...
Page 127
I finish turning it. It displays "VOLTEST4" on the FL display in the first 2 seconds. Then it displays "VOL 4" on the bottom of ths FL Display. (in order to let you display TRIM value) DJM-800...
Starts the key scan IC1 is H. Also release the reset the IC904, IC1501, IC918, IC409, IC509, IC609, IC709, IC1307, IC1308, IC1202, IC1203, IC1208, IC1209, IC1214, IC1215, IC1217, Main processing IC1218 and IC12 with this pin. WAIT (10m sec) DJM-800...
Rotary SW knob (A) (DAA1198) ×3 (DAC2371) ×5 (DAA1175) ×3 White White White Black Black Black Rotary SW knob (B) Rotary SW knob S (A) Rotary SW knob (C) (DAA1176) ×12 (DAA1177) ×2 (DAA1180) ×1 White White Black Black Gray White DJM-800...
Page 130
CH Fader Section Remove the four slider knob (L2)s. Remove the four screws. Remove the CHF panel. CHF panel Slider knob (L2) Disconnect the four connectors. Remove the eight screws. Exchange CHFD2 Assy CHFD4 Assy CHFD1 Assy CHFD3 Assy DJM-800...
Remove the six screws. Remove the control panel section. Rotary SW knob (HM) Control panel section PANEL2 Assy PANEL1 Assy MIC2 Assy MIC1 Assy Front view CHFD3 Assy CHFD1 Assy CHFD4 Assy CHFD2 Assy HP JACK Assy CRSFD Assy DJM-800...
Page 132
Remove the bracket TRIM. ×4 Nut M7 Shield Case AC and Shield Case Remove the three screws. Remove the shield case AC. Remove the two screws. Remove the three screws. Remove the shield case. Shield case AC Shield case DJM-800...
Page 133
Disconnect cables, as required. Remove the shield case DSP. Shield case DSP DIGIA Assy SLSW Assy TRIM1 Assy TRIM3 Assy TRIM2 Assy TRIM4 Assy ACSW Assy DIGIB Assy DIGIC Assy OUTPUT Assy INPUT Assy HPAMP Assy POWER SUPPLY DSP Assy Unit DJM-800...
Page 135
HWRn For bus control FPGA For bus control FPGA For bus control PLLVCC PLLVCC Power supply for internal PLL oscillator VCC RESn RESn Reset input PLLVSS PLLVSS GND for internal PLL oscillator TEST Pin XTAL XTAL Crystal connection pin DJM-800...
Page 136
For rewriting RXD & SIO1gloup USB, FPGA, EEPROM, DIT Vacant TXD1 SIO1_TXD For rewriting TXD & SIO1gloup USB, FPGA, EEPROM, DIT TXD0 FL_TXD For FL display Mode pin 0 NOR: Mode 4 At rewriting: Mode 3 Mode pin 1 NOR: Mode 4 At rewriting: Mode 3 DJM-800...
Page 142
Address bus 3 with microcomputer µCA2 IO_L01N_5/RDWR_B Address bus 2 with microcomputer − − VCCO_5 Power supply µCA1 IO/VREF_5 Address bus 1 with microcomputer − µCA0 IO_L28P_5/D7 Address bus 0 with microcomputer µCCS IO_L28N_5/D6 Chip select with microcomputer − VCCAUX Power supply DJM-800...
Page 143
I/O port 3 (CH2 fader stop) GPIO12 IO_L40N_3/VREF_3 I/O port 2 (CH2 fader start) − VCCO_3 Power supply GPIO11 IO_L40P_2/VREF_2 I/O port 1 (CH1 fader stop) GPIO10 IO_L40N_2 I/O port 0 (CH1 fader start) − − IO_L24P_2 − IO_L24N_2 DJM-800...
Page 144
P138 Vcc VCCO_0 Power supply − P139 GND P140 DSPA3 IO_L01P_0/VRN_0 Address bus 3 with DSP P141 DSPA2 IO_L01N_0/VRP_0 Address bus 2 with DSP − P142 HSWAP_EN HSWAP_EN HSWAP_EN − P143 PROG_B PROG_B PROG_B (XPGM) − P144 NC Not used DJM-800...
Page 145
AINL- Ground input Must be connected to analog ground. Analog power input AINR- Differential right channel analog input AINR+ Quiescent voltage output Filter connection for the internal quiescent reference voltage. REF_GND Reference ground input FILT+ Positive voltage reference output DJM-800...
Page 146
: Latch Control Input 11) CLK : Shift Register Clock 12) SI : Serial Data Input 13) Solder composition is Sn-3Ag-0.5Cu. Grid Assignment Segment Designation EFFECT SELECT (2G-8G, 10G-14G) CH SELECT CH SELECT PARAMETER MIDI AUTO PARAMETER (9GA-9GD) (15G) DJM-800...
7. Microphone function indicator LINE/DIGITAL (channel 3 to 4): Lights when microphone is ON; flashes when TALK OVER is Use to select LINE input connectors (line level analog input) or DIGITAL input connectors. PHONO: Use to select PHONO input connectors (analog turntableinput). DJM-800...
Page 150
CUE ÷ At the right setting, the curve operates to produce an even, button. neutral rise throughout the channel fader’s movement. ÷ At the middle setting, an intermediate curve is produced, midway between the two curves noted above. DJM-800...
Page 151
[LEVEL/DEPTH (PARAMETER 2)] Adjusts quantitative parameters for selected effect . 40. Effect button/indicator (ON/OFF) Sets selected effect ON/OFF. Whenever power is first turned ON, effects default to OFF and the button is lighted. When effects are enabled (ON), the button flashes. DJM-800...
Page 152
2 000 8/1 16/1 32/1 64/1 Lower ROLL Upper ROLL 4 000 1/16 1/8 8/1 16/1 Lower REV ROLL Upper REVERSE 4 000 1/16 1/8 8/1 16/1 Lower ROLL SND/RTN Upper SEND/ Lower RETURN Shaded items are not displayed. DJM-800...
RCA type phono level (MM cartridge) input connectors. a Pioneer DJ CD player. Do not use for inputting line level signals. When the connectors are connected, the DJM-800’s fader can be 5. LINE input connectors used to perform start/stop on the DJ CD player.
Note: Although the ref. numbers for the CH2/CH4 FADER Assys are different, they are identical, and their functions in the circuitry are the same. You can connect to either of them. Connector Ass'y (W) Connector Ass'y (Y) White Yellow Gray Gray White White Rotary VR Rotary VR Solder Solder DJM-800...
• Insert the connectors securely, taking care not unit, but fire or electrical shock. Pioneer can accept to mistake the order in which the connectors no liability for injuries or damages resulting from in-...
Need help?
Do you have a question about the DJM-800 and is the answer not in the manual?
Questions and answers