Related Manuals for Skyteam ST50-8
Summary of Contents for Skyteam ST50-8
- Page 1 SKY TEAM CORPORATION LTD. 1104 CARNIVAL COMMERCIAL BLDG. 18 JAVA ROAD NORTH POINT HONGKONG TEL:00852 25089428 FAX:00852 25089478 EMAIL:SKYTEAM_HK@HOTMAIL.COM HTTP://WWW.SKYTEAM.CN...
- Page 2 Skyteam motorcycles are ideal means of transportation and will bring more convenience and pleasure to your life. This owner's manual contains the right usage and simple inspecting and adjusting methods of Skyteam motorcycle. Please make sure to read it carefully before running your motorcycles. It will help in using and maintaining Skyteam motorcycles.
-
Page 3: Table Of Contents
CONTENTS Important Notes Starting off ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ Consumer information Driving on a slope ○... -
Page 4: Important Notes
ACCESSORY INSTALLATION AND SAFETY PRECAUTION TIPS RUNNING-IN INFORMATION FOR YOUR MOTORCYCLE There are a variety of accessories available to Skyteam owners. The installation of unsuitable The first 1,600km is the most important in the life of your motorcycle. Proper running-in operation accessories can lead to unsafe riding. - Page 5 (5) Certain accessories displace the rider from his normal riding position. This will restrict not only the CHECKS BEFORE RIDING freedom of movement of the rider, but also his control ability. Review in detail the instructions in the "CHECKS BEFORE RIDING" section of this manual. Do not (6)Extra electrical accessories may overload the existing electrical system.
- Page 6 The frame and/or engine serial numbers are used to register the motorcycle. These information are very important to Skyteam service centers when you order spare parts or ask for special service. The frame number or vehicle identification number(VIN) are stamped on the tube of the steering head. The engine number is stamped on the left side of the crankcase.
-
Page 7: Fixation Of Spare Parts
FIXATION OF SPARE PARTS Beam switch high/low Instrument panel Night light switch Lever, brake, front Shock absorber, rear Name plate Lever, clutch Tool kit Lever, kick starter Cap, fuel tank Horn switch Engine start switch Ignition switch Cap, fuel tank Spark plug Foot rest Pedal, rear brake... -
Page 8: Controls
CONTROLS This motorcycle is equipped with a pair of identical ignition keys. Keep the spare key in a safe place. IGNITION SWITCH Air cleaner Shock absorber, rear There are two positions for ignition switch: Lever, choke "OFF" position Fuel cock Battery &... -
Page 9: Left Handlebar
" ": No matter the engine runs or not, the head light, instrument light and tail light come on simultaneously. LEFT HANDLEBAR " ": The head light, instrument light and tail light come off simultaneously. DIMMER SWITCH Electrical Start Button "... -
Page 10: Kick Starter Level
During this time, the gasoline flows through the fuel plug to the carburetor. GEARSHIFT LEVER "RES": If the fuel level in the fuel tank is too low. Turn the lever to the "RES" position to use the reserved This type of motorcycle has four gear positions. The lever fuel. -
Page 11: Helmet Lock
SAEJ183E80. Please use 15W/40 SF/CD GB11121-95 engine oil. We recommend you to use Skyteam's oil for 4-stroke engine-type 15W/40. Do not use common oil, vegetable oil or castor oil. -
Page 12: Running-In
RUNNING-IN ALLOW THE ENGINE OIL TO CIRCULATE BEFORE RIDING. The forward explains how important the proper running-in is to achieve maximum life and performance To start the engine that was in hot or cold condition, it should be allowed to have sufficient idling time of your new motorcycle. -
Page 13: Riding Tips
RIDING TIPS WHAT TO CHECK CHECK FOR: (1)Smoothness WARNING (2)No restriction of movement STEERING (1)If it is your first time to ride a motorcycle of this type, we suggest that you practice on a non- (3)No play or looseness public road until you are thoroughly familiar with the controls and operation of the motorcycle. (1)Correct pedal and lever play (2)Riding with only one hand is extremely dangerous. -
Page 14: Starting Off
Do not let engine run excessively without riding, or it will overheat and may damage internal sufficiently warms up, then return the choke lever to its original position. ST50-8, ST50-8A, ST110-8, ST110-8A engine components. When the engine runs smoothly and the choke lever is in its disengaged STARTING OFF position, the engine is warmed up sufficiently. -
Page 15: Use The Brakes And Parking
WARNING WARNING The higher the speed is the longer the braking distance is required. Be sure to keep distance Before starting off you must put the side stand back to its upper position. Don't let it hang. between you and the vehicles or objects in front of you. DVRIVE ON A SLOPE Pulling in the clutch lever and letting the linkage gear in the transmission disconnected, reduce the When climbing up a slope, the motorcycle may begin to decelerate and appear lack of power. -
Page 16: Checks And Maintenance
(cold state) (adjust) (Check&Adjust) Under this condition, Skyteam service station could give you further instructions. Steering components, Transmission Chain tension suspension and wheel components are key items that require very special and careful servicing. We Carburetor Clean suggest that you have these items checked and serviced by your authorized dealer. -
Page 17: Tools
In the periodic maintenance you may need to change one or more parts. We suggest you to when measured by the multi-meter. If the voltage is lower than the use Skyteam spare parts. We suggest you to go to qualified Skyteam service station for stipulated data, pls change the battery with the accumulator. -
Page 18: Air Cleaner
CLEANING THE FILTER ASSEMBLY CHARGING METHORD Clean the filter assembly as the following: Pls charge 10-12 hours under 0.2ampere AC. Then the charging voltage is 12.5-12.6 volt, and the (1)Fill a washing pan of a proper size with non-flammable cleaning solvent(A), performance of the battery could act 90%-100% which allow the battery could be used for quite a long immerse the filter assembly in the solvent and wash it clean. -
Page 19: Carburetor
If the spark plug color differs from a standard one, you should consult your two adjustments that you should take care: engine idle speed and throttle cable play. Skyteam dealer before selecting an alternative plug with a different heat range. The selection of an improper spark plug can lead to severe engine damage. -
Page 20: Transmission Chain
TRANSMISSION CHAIN ADJUSTMENT (1)Place the motorcycle on the side stand. We suggest you to change your transmission chain in Skyteam's service station or dealer's station (2)Loosen the locking nut(1), and then loosen the adjusting nut. when it has been worn. -
Page 21: Brakes
Remember to Check that the fluid level is above the lower level mark with the check periodically the brake system and these checks should be conducted by qualified Skyteam dealer. motorcycle in an upright position. FRONT BRAKE Brake fluid must be added to the reservoir when ever the fluid level begins to reach the lower level mark . - Page 22 When adjusting the travel of brake pedal(1), adjust the free travel to 20-30mm by screwing in or out the Skyteam dealer. Skyteam dealer knows your motorcycle best and rear brake adjusting nut(2).
-
Page 23: Rear Brake Light Switch
(adjust the nut)until the rear types of tires may cause problem. We suggest you choose standard tires Skyteam provided. The pressure and condition of tires are very important to the function and safety of the brake light turns on when the brake pedal is stepped down. -
Page 24: Troubleshooting
(1)Take off spark plug and connect it again to the inlet of spark plug. without Skyteam service station’s agreement may influence the content of the items of service. (2)Turn ignition switch to “ON” position, make the spark plug close to the engine case and start the engine. -
Page 25: Specifications
○ ○ ○ ○ ○ ○ ○ ○ ○ ○ Max. laden weight 90kg Type Single-cylinder, Second gear 31/18 (ST50-8 ST50-8A ST110-8 ST110-8A) Head light 12V 35W/35W ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○... - Page 26 Due to improvements or other changes, there may be some discrepancies in this manual. Skyteam reserve the right to make changes at any time without notice.
Need help?
Do you have a question about the ST50-8 and is the answer not in the manual?
Questions and answers