Page 1 FOREWORD This wiring diagram manual has been prepared to provide information on the electrical system of the 2007 YARIS. Applicable models: NCP91, 93 Series Refer to the following manuals for additional service specifications and repair procedures for these models: Manual Name Pub.
Page 2 2007 YARIS ELECTRICAL WIRING DIAGRAM Page Section Code INTRODUCTION .......
Page 3 A INTRODUCTION This manual consists of the following 13 sections: Section Description INDEX Index of the contents of this manual. INTRODUCTION Brief explanation of each section. HOW TO USE THIS Instructions on how to use this manual. MANUAL TROUBLE– Describes the basic inspection procedures for electrical circuits. SHOOTING ABBREVIATIONS Defines the abbreviations used in this manual.
Page 4 HOW TO USE THIS MANUAL B This manual provides information on the electrical circuits installed on vehicles by dividing them into a circuit for each system. The actual wiring of each system circuit is shown from the point where the power source is received from the battery as far as each ground point.
Page 5: How To Use This Manual
B HOW TO USE THIS MANUAL * The system shown here is an EXAMPLE ONLY. It is different to the actual circuit shown in the SYSTEM CIRCUITS SECTION. Stop Light (BAT) (IG) 7.5A STOP GAUGE Stop Lamp SW 15 CH1 G –...
Page 6 [A] : System Title [H] : Indicates the wiring color. Wire colors are indicated by an alphabetical code. [B] : Indicates a Relay Block. No shading is used and only the Relay Block No. is shown to distinguish it B = Black W = White BR = Brown from the J/B...
Page 7 B HOW TO USE THIS MANUAL System Outline Current is applied at all times through the STOP fuse to TERMINAL 2 of the stop lamp SW. When the ignition SW is turned on, current flows from the GAUGE fuse to TERMINAL 8 of the light failure sensor, and also flows through the rear lights warning light to TERMINAL 4 of the light failure sensor.
Page 8 [O] : Explains the system outline. [P] : Indicates reference pages showing the parts locations in the system circuit on the vehicle. Example : Code ”H4” (Light Failure Sensor) is on page 36 of the manual. * The first character of the code indicates the alphabetical code allocated to the wire harness, and the second character indicates the serial number of the parts connected to the wire harness.
Page 9 B HOW TO USE THIS MANUAL The ground points circuit diagram shows the connections from all major parts to the respective ground points. When troubleshooting a faulty ground point, checking the system circuits which use a common ground may help you identify the problem ground quickly.
Page 10: Power Source
The ”Current Flow Chart” section, describes which parts each power source (fuses, fusible links, and circuit breakers) transmits current to. In the Power Source circuit diagram, the conditions when battery power is supplied to each system are explained. Since all System Circuit diagrams start from the power source, the power source system must be fully understood.
Page 11: Connector List
B HOW TO USE THIS MANUAL K CONNECTOR LIST Black Gray 1 2 3 4 1 2 3 4 5 Black Gray 1 2 3 6 7 8 9 10111213 K CONNECTOR LIST Black Gray 1 2 3 5 6 7 8 9 10 11 6 7 8 9 10 11 12 13 [A] : Indicates connector to be connected to a part.
Page 12 Airbag Squib Junction Connector 90980–11398 90980–12490 [A] : Part Code [B] : Part Name [C] : Part Number Toyota Part Number are indicated. Not all of the above part numbers of the connector are established for the supply. YARIS (EM01V0U)
Page 13: Troubleshooting
C TROUBLESHOOTING VOLTAGE CHECK To Ignition SW IG Terminal (a) Establish conditions in which voltage is present at the check point. Example: Fuse [A] – Ignition SW on [B] – Ignition SW and SW 1 on [C] – Ignition SW, SW 1 and Relay on (SW 2 off) (b) Using a voltmeter, connect the negative lead to a good ground point or negative battery terminal, and the positive lead to the SW 1...
Page 14 FINDING A SHORT CIRCUIT To Ignition SW IG Terminal (a) Remove the blown fuse and disconnect all loads of the fuse. (b) Connect a test light in place of the fuse. (c) Establish conditions in which the test light comes on. Test Light Fuse Case Example:...
Page 15 C TROUBLESHOOTING HOW TO REPLACE TERMINAL Reference: (with terminal retainer or secondary locking device) 1. PREPARE THE SPECIAL TOOL HINT : To remove the terminal from the connector, please construct and use the special tool or like object shown on the left.
Page 16 Tool For Waterproof Type Connector Example: Terminal (Case 1) Tool Retainer HINT : Terminal retainer color is different according to connector body. Example: Terminal Retainer : Connector Body Black or White : Gray Black or White : Dark Gray Tool Access Hole Gray or White : Black...
Page 17 C TROUBLESHOOTING Push the terminal retainer down to the temporary lock position. Retainer at Full Lock Position Retainer at Temporary Lock Position [Male] [Female] Locking Lug (c) Release the locking lug from terminal and pull the terminal out from rear. Tool 4.
Page 18 ABBREVIATIONS D ABBREVIATIONS The following abbreviations are used in this manual. Air Conditioning Automatic Transaxle Anti–Lock Brake System Controller Area Network Central Processing Unit Electronic Brake Force Distribution Electronic Control Unit Electric Motor Power Steering Hatchback Type Integrated Circuit Junction Block Light Emitting Diode Left–Hand Manual Transaxle...
Page 19 E GLOSSARY OF TERMS AND SYMBOLS GROUND BATTERY The point at which wiring attaches to Stores chemical energy and the Body, thereby providing a return converts it into electrical energy. path for an electrical circuit; without a Provides DC current for the auto’s ground, current cannot flow.
Page 20 SPEAKER RELAY An electromechanical device which Basically, an electrically operated 1. NORMALLY creates sound waves from current switch which may be normally CLOSED flow. closed (1) or open (2). Current flow through a small coil creates a magnetic field which either opens or closes an attached switch.
Page 21: Engine Compartment
F RELAY LOCATIONS [Engine Compartment] (H/B) Engine Control Module Fusible Link Block Skid Control ECU with Actuator Engine Room R/B Engine Room J/B Engine Room R/B No.2 (S/D) Engine Control Module Fusible Link Block Skid Control ECU with Actuator Engine Room R/B Engine Room J/B Engine Room R/B No.2...
Page 22: Instrument Panel
[Instrument Panel] (H/B) Transponder Key ECU Theft Warning ECU Power Steering ECU Front Fog Light Relay Fuse Block Running Light Relay ACC Cut Relay J/B No.6 Main Body Instrument Shift Lock Panel J/B Control ECU Transponder Key Airbag Sensor A/C Amplifier J/B No.5 Amplifier Assembly Center...
Page 23 F RELAY LOCATIONS [Body] (5–Door) Occupant Classification ECU Door Control Receiver (3–Door) Occupant Classification ECU Door Control Receiver YARIS (EM01V0U)
Page 24 (4–Door) Occupant Classification ECU Door Control Receiver YARIS (EM01V0U)
Page 25 F RELAY LOCATIONS : Engine Room R/B Engine Compartment Left (See Page 20) Engine Compartment Left (See Page 20) : Engine Room J/B * 1:H-LP LH/H-LP LO LH * 2:H-LP RH/H-LP LO RH * 3:30A HTR SUB1 (for High Current) * 4:30A RDI (for High Current) * 5:40A HTR (for High Current) * 6:50A ABS1/VSC1 (for High Current)
Page 26 (from Engine Room Main Wire) (from Engine Room Main Wire) (from Engine Room Main Wire) Unit A YARIS (EM01V0U)
Page 27 F RELAY LOCATIONS [Engine Room R/B and Engine Room J/B Inner Circuit] Unit A 1 1A EFI Relay 4 1A 20A EFI 3 1A 2 1A 5 1A HORN Relay 8 1A 10A HORN 7 1A 6 1A 1 1B IG2 Relay 4 1B 15A AM2...
Page 28 Unit B 30A ABS2/VSC2 30A HTR SUB1 30A RDI 40A HTR 50A ABS1/VSC1 50A EPS 1 1E 40A HTR SUB2 10A H-LP LH/H-LP LO LH 10A H-LP RH/H-LP LO RH 10A HAZ 10A ETCS 7.5A ALT-S 7.5A ECU-B 15A DOME 1 1D 30A ST YARIS (EM01V0U)
Page 29 F RELAY LOCATIONS : Engine Room R/B No.2 Engine Compartment Right (See Page 20) HTR SUB2 Relay H-LP/AMT Relay HTR SUB3 Relay YARIS (EM01V0U)
Page 30 Memo YARIS (EM01V0U)
Page 31 F RELAY LOCATIONS : Instrument Panel J/B Lower Finish Panel (See Page 21) 8 7 6 5 4 3 2 1 7 6 5 4 3 (from Instrument (from Instrument Panel Wire) Panel Wire) (from Instrument Panel Wire) (from Engine Room Main Wire) (from Instrument Panel Wire)
Page 32 Main Body ECU 1617 6 7 8 9 11 13 13121110 9 8 7 6 1 2 3 4 5 6 7 1 2 3 3 2 1 (from Instrument Panel Wire) (from Instrument Panel Wire) 9 10 101112131415161718 (from Instrument (from Instrument Panel Wire) Panel Wire)
Page 33 F RELAY LOCATIONS : Instrument Panel J/B Lower Finish Panel (See Page 21) * 1:10A TAIL (H/B, S/D *3) 7.5A PANEL 2 (*4) * 2:10A TAIL (*4) * 3:Cold Area Spec., w/ Engine Immobiliser System, w/ ABS, w/ Rear Window Defogger, w/ Door Lock Control, w/ Daytime Running Light, w/ Remote Control Mirror,...
Page 34 Memo YARIS (EM01V0U)
Page 35 F RELAY LOCATIONS [Instrument Panel J/B Inner Circuit] * 1:H/B, S/D *3 * 2:Except *1 * 3:Cold Area Spec., w/ Engine Immobiliser System, w/ ABS, w/ Rear Window Defogger, w/ Door Lock Control, w/ Daytime Running Light, w/ Remote Control Mirror, w/ Air Conditioning 10 4A 29 4A 15 4B...
Page 36 (Cont'd) 30 4E 10A STOP 14 4E 18 4B 7.5A OBD2 17 4E 5 4S 28 4E 2 4M 12 4E 8 4M 7 4M 6 4M 1 4K 15A FR FOG 15 4A 9 4M 1 4S 5 4M 2 4E 7 4F 1 4L...
Page 37 F RELAY LOCATIONS [Instrument Panel J/B Inner Circuit] (Cont'd) 15A RR WIP 25 4A 11 4Q 10 4Q 1 4Q 29 4B 10 4S 7.5A A/C 10 4M 8 4F 25 4E 1 4J C/OPN Relay 11 4B 8 4A 1 4D 5 4E 9 4B...
Page 38 (Cont'd) 9 4E 4 4K 16 4C 21 19 34 4B ACC TRLY PWS HAZ GND1 ALTB 16 4B 4 4J 14 4C 10 4C 24 4A PCTY 14 4H 6 4C 5 4H 21 4A DCTY 2 4K 26 4E 27 4E 5 4A 11 4E...
Page 39 F RELAY LOCATIONS : J/B No.5 Left Kick Panel (See Page 21) (from Front Door LH Wire) (from Instrument Panel Wire) YARIS (EM01V0U)
Page 40 [J/B No.5 Inner Circuit] 1 5A 1 5B 2 5A 2 5B 3 5A 3 5B 4 5A 4 5B 5 5A 5 5B 6 5A 6 5B YARIS (EM01V0U)
Page 41 F RELAY LOCATIONS : J/B No.6 Right Kick Panel (See Page 21) (from Front Door RH Wire) (from Instrument Panel Wire) YARIS (EM01V0U)
Page 42 [J/B No.6 Inner Circuit] 1 6A 1 6B 2 6A 2 6B 3 6A 3 6B 4 6A 4 6B 5 6A 5 6B 6 6A 6 6B YARIS (EM01V0U)
Page 43 F RELAY LOCATIONS Fusible Link Block Near the Battery (See Page 20) Battery 120A ALT 60A MAIN (for High Current) (for High Current) (from Engine Wire) Wire Color : B YARIS (EM01V0U)
Page 44 Battery Black (from Engine Room (from Engine Room Main Wire) Main Wire) YARIS (EM01V0U)
Page 45 F RELAY LOCATIONS [Fusible Link Block Inner Circuit] A27(B), A28(A), C30(C) Fusible Link Block Battery 120A ALT 60A MAIN YARIS (EM01V0U)
Page 46 Fuse Block Near the Instrument Panel J/B (See Page 21) ACC2 7.5A YARIS (EM01V0U)
Page 47 G ELECTRICAL WIRING ROUTING Position of Parts in Engine Compartment [H/B] A 1 Turn Signal Lamp (Front Side RH) B 1 Turn Signal Lamp (Front RH) A 2 Turn Signal Lamp (Front Side LH) B 2 Horn A 3 A/C Pressure Sensor B 3 Parking Lamp (RH) A 4 Rear Washer Motor B 4 Headlamp (RH)
Page 48 Position of Parts in Engine Compartment [H/B] C30 C23 C 1 Starter C17 Throttle Body Assembly C 2 Crankshaft Position Sensor C18 Camshaft Position Sensor C 3 VSV (Purge) C19 Engine Coolant Temp. Sensor C 4 Fuel Injector (No.1) C20 Engine Control Module C 5 Fuel Injector (No.2) C21 Speed Sensor C 6 Fuel Injector (No.3)
Page 49 G ELECTRICAL WIRING ROUTING Position of Parts in Engine Compartment [S/D] A 3 A/C Pressure Sensor B 2 Horn A 5 Windshield Washer Motor B 4 Headlamp (RH) A 6 Airbag Sensor (Front RH) B 5 Ambient Temp. Sensor A 7 Speed Sensor (Front RH) B 6 Headlamp (LH) A 8 Cooling Fan Motor B 9 Fog Lamp (Front RH)
Page 50 Position of Parts in Engine Compartment [S/D] C11 C20 C27 C28 C 1 Starter C17 Throttle Body Assembly C 2 Crankshaft Position Sensor C18 Camshaft Position Sensor C 3 VSV (Purge) C19 Engine Coolant Temp. Sensor C 4 Fuel Injector (No.1) C20 Engine Control Module C 5 Fuel Injector (No.2) C21 Speed Sensor...
Page 51 G ELECTRICAL WIRING ROUTING Position of Parts in Instrument Panel [H/B] A 13 Stop Lamp SW Q 1 Airbag Squib (Front Passenger’s Airbag Assembly) A 16 Clutch Start SW Q 2 Airbag Squib (Front Passenger’s Airbag Assembly) A 17 PTC Heater A 19 Power Steering ECU V 1 Spiral Cable A 20 Accelerator Position Sensor...
Page 52 Position of Parts in Instrument Panel [H/B] D27 D39 D38 D35 D34 D32 D26 D16 D14 D20 D22 D30 D21 D75 D 1 Combination Meter D26 Theft Warning ECU D 2 Combination Meter D27 Passenger Seat Belt Warning Lamp D 3 Spiral Cable D28 Oxygen Sensor (Bank 1 Sensor 2) D 4 Headlamp Dimmer SW Assembly D29 Light Control Rheostat...
Page 53 G ELECTRICAL WIRING ROUTING Position of Parts in Instrument Panel [S/D] A 13 Stop Lamp SW Q 1 Airbag Squib (Front Passenger’s Airbag Assembly) A 16 Clutch Start SW Q 2 Airbag Squib (Front Passenger’s Airbag Assembly) A 17 PTC Heater A 19 Power Steering ECU V 1 Cruise Control SW A 20 Accelerator Position Sensor...
Page 54 Position of Parts in Instrument Panel [S/D] D35 D34 D29 D46 D18 D28 D16 D14 D 1 Combination Meter D28 Oxygen Sensor (Bank 1 Sensor 2) D 3 Spiral Cable D29 Light Control Rheostat D 4 Headlamp Dimmer SW Assembly D31 Power Steering ECU D 5 Windshield Wiper SW Assembly D32 Antenna Amplifier...
Page 55 G ELECTRICAL WIRING ROUTING Position of Parts in Body [5–Door] F 1 Power Window SW (Front RH) L 1 License Plate Lamp F 2 Outer Rear View Mirror (RH) F 4 Power Window Regulator Motor (Front RH) M 1 Center Stop Lamp F 5 Door Lock Assembly (Front Passenger’s Side) M 2 Rear Window Defogger F 6 Speaker (Front Door RH)
Page 56 Position of Parts in Body [5–Door] J 1 Door Courtesy SW (Front RH) J 20 Pretensioner (RH) J 2 Door Courtesy SW (Front LH) J 21 Pretensioner (LH) J 3 Rear Combination Lamp (RH) J 22 Curtain Shield Airbag Squib (RH) J 4 Rear Combination Lamp (LH) J 23 Curtain Shield Airbag Squib (LH) J 5 Fuel Suction Pump and Gage Assembly...
Page 57 G ELECTRICAL WIRING ROUTING Position of Parts in Body [3–Door] F 1 Power Window SW (Front RH) N 1 Rear Wiper Motor Assembly F 2 Outer Rear View Mirror (RH) N 2 Back Door Courtesy SW F 4 Power Window Regulator Motor (Front RH) N 3 Back Door Lock Assembly F 5 Door Lock Assembly (Front Passenger’s Side) N 4 Back Door Position SW...
Page 58 Position of Parts in Body [3–Door] J 1 Door Courtesy SW (Front RH) J 20 Pretensioner (RH) J 2 Door Courtesy SW (Front LH) J 21 Pretensioner (LH) J 3 Rear Combination Lamp (RH) J 22 Curtain Shield Airbag Squib (RH) J 4 Rear Combination Lamp (LH) J 23 Curtain Shield Airbag Squib (LH) J 5 Fuel Suction Pump and Gage Assembly...
Page 59 G ELECTRICAL WIRING ROUTING Position of Parts in Body [4–Door] F 1 Power Window SW (Front RH) K 1 Map Lamp F 2 Outer Rear View Mirror (RH) K 2 Room Lamp (Center) F 4 Power Window Regulator Motor (Front RH) F 5 Door Lock Assembly (Front Passenger’s Side) O 1 Rear Window Defogger F 6 Speaker (Front Door RH)
Page 60 Position of Parts in Body [4–Door] J 1 Door Courtesy SW (Front RH) J 28 Junction Connector J 2 Door Courtesy SW (Front LH) J 29 Junction Connector J 5 Fuel Suction Pump and Gage Assembly J 30 Diode (Room Lamp) J 10 Front Seat Inner Belt (Driver’s Side) J 32 Door Courtesy SW (Rear RH) J 11 Front Seat Inner Belt Assembly (Front RH)
Page 61 G ELECTRICAL WIRING ROUTING : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points [H/B] Sensor Wire Engine Room Main Wire Engine Room No.2 Wire Engine Wire YARIS (EM01V0U)
Page 62 : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points [S/D] Sensor Wire Engine Room Main Wire Engine Room No.2 Wire Engine Wire YARIS (EM01V0U)
Page 63 G ELECTRICAL WIRING ROUTING : Location of Connector Joining Wire Harness and Wire Harness [H/B] Instrument Panel Instrument Panel Wire Wire Assembly Roof Wire Instrument Panel No.2 Wire Front Door RH Wire Floor Wire Front Door LH Engine Room Main Wire Wire : Location of Ground Points YARIS (EM01V0U)
Page 64 : Location of Connector Joining Wire Harness and Wire Harness [S/D] Instrument Panel Instrument Panel Wire Wire Assembly Roof Wire Instrument Panel No.2 Wire Front Door RH Wire Floor Wire Front Door LH Engine Room Main Wire Wire : Location of Ground Points YARIS (EM01V0U)
Page 65 G ELECTRICAL WIRING ROUTING : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points [5–Door] Front Door Seat Airbag Rear Door RH Wire RH Wire No.1 Wire Rear Window No.1 Wire Roof Wire Front Door LH Wire Back Door No.2 Wire...
Page 67 G ELECTRICAL WIRING ROUTING : Location of Connector Joining Wire Harness and Wire Harness : Location of Ground Points [4–Door] Front Door Seat Airbag Rear Door No.1 RH Wire RH Wire Wire Rear Window Roof Wire No.1 Wire Front Door LH Wire Floor Wire Skid Control...
Page 68 SYSTEM CIRCUITS H 2007 YARIS ELECTRICAL WIRING DIAGRAM SYSTEM CIRCUITS Page ABS ............. . .
Page 69 Power Source 30A ABS2/VSC2 40A HTR SUB2 50A EPS 30A HTR SUB1 50A ABS1/VSC1 30A RDI 40A HTR Generator 7. 5A ALT–S 15A DOME 30A ST 7. 5A ECU–B 10A ETCS 10A HAZ 10A H–LP LH/H–LP LO LH Battery 10A H–LP RH/H–LP LO RH YARIS (EM01V0U)
Page 70 EFI Relay 20A EFI 10A EFI2 10A HORN 15A AM2 Ignition SW YARIS (EM01V0U)
Page 71 Power Source 7. 5A ACC2 Fuse Block 15A CIG 7. 5A ACC 7. 5A IGN 7. 5A MET ACCR Engine Control Module YARIS (EM01V0U)
Page 72 T–LP Relay 10A TAIL ∗ 1 : H/B, S/D ∗3 ( ∗1 ) ( ∗1 ) ( ∗1 ) ( ∗1 ) ∗ 2 : Except ∗1 ∗ 3 : Cold Area Spec. , 7. 5A PANEL1 w/ Engine Immobiliser System, ( ∗1 ) ( ∗1 ) ( ∗1 )
Page 73 Power Source : Parts Location Code See Page Code See Page Code See Page 46 (H/B) 47 (H/B) 51 (H/B) 48 (S/D) 49 (S/D) 53 (S/D) 43, 46 (H/B) 42, 47 (H/B) 45, 51 (H/B) 43, 48 (S/D) 42, 49 (S/D) 45, 53 (S/D) 43, 46 (H/B) 51 (H/B)
Page 74 Memo YARIS (EM01V0U)
Page 75 Starting ( BAT ) Relay Junction Connector Park/Neutral Position SW C1 ( A ) , C15 ( B ) Starter Battery ( ∗1 ) Junction ( ∗2 ) Connector YARIS (EM01V0U)
Page 76 ∗ 1 : A/T ( BAT ) ∗ 2 : M/T Ignition SW STSW Diode ( Starter ) STAR Junction Connector YARIS (EM01V0U)
Page 77 Starting : Parts Location Code See Page Code See Page Code See Page 50 (H/B) 49 (S/D) 51 (H/B) 52 (S/D) 47 (H/B) 53 (S/D) 46 (H/B) 49 (S/D) 51 (H/B) 48 (S/D) 47 (H/B) 53 (S/D) 46 (H/B) 49 (S/D) 51 (H/B) 48 (S/D) 47 (H/B)
Page 78 Memo YARIS (EM01V0U)
Page 79 Charging ( BAT ) ( IG ) ( IG ) ∗ 1 : w/ Daytime Running Light ∗ 2 : w/o Daytime Running Light CHG– ( H/B ) ( S/D ) ( ∗1 ) C9 ( A ) , C10 ( B ) Generator IC Regulator YARIS (EM01V0U)
Page 80 : Parts Location Code See Page Code See Page Code See Page 47 (H/B) 42, 47 (H/B) 53 (S/D) 49 (S/D) 42, 49 (S/D) 51 (H/B) 47 (H/B) 51 (H/B) 53 (S/D) 49 (S/D) 53 (S/D) 53 (S/D) 47 (H/B) 51 (H/B) 50 (H/B) 49 (S/D)
Page 81 Ignition ( BAT ) Ignition SW 4 AD2 4 1B Relay YARIS (EM01V0U)
Page 82 Ignition Coil Ignition Coil Ignition Coil Ignition Coil ( No. 1 ) ( No. 2 ) ( No. 3 ) ( No. 4 ) IGT2 IGT3 IGT4 W–B W–B IGT1 IGF1 IGT2 IGT3 IGT4 Engine Control Module YARIS (EM01V0U)
Page 83 Ignition : Parts Location Code See Page Code See Page Code See Page 47 (H/B) 49 (S/D) 47 (H/B) 49 (S/D) 47 (H/B) 49 (S/D) 47 (H/B) 49 (S/D) 51 (H/B) 49 (S/D) 47 (H/B) 53 (S/D) 47 (H/B) 49 (S/D) : Junction Block and Wire Harness Connector Code See Page...
Page 84 Memo YARIS (EM01V0U)
Page 85: Engine Control
Engine Control ( BAT ) ( BAT ) Relay Relay Ignition SW 5 AD4 11 CA1 YARIS (EM01V0U)
Page 86 ( IG ) ( BAT ) 7. 5A STOP C/OPN Relay Stop Lamp SW A21 ( A ) , C20 ( B ) Engine Control Module ST1– IGSW # 40 # 30 # 20 # 10 MREL BATT YARIS (EM01V0U)
Page 87 Engine Control ( BAT ) ( BAT ) DOME ETCS A21 ( A ) , C20 ( B ) Engine Control Module STSW STAR ACCR ETHW VPMP VCPP PPMP EPPM MPMP EFI2 VLVB VGND VOUT SGND MTRB MGND Canister Pressure Sensor Vent Valve Leak Detection Pump YARIS (EM01V0U)
Page 88 ∗ 1 : H/B, S/D ∗3 ∗ 2 : Except ∗1 ( BAT ) ∗ 3 : Cold Area Spec. , w/ Engine Immobiliser System, w/ ABS, w/ Rear Window Defogger, w/ Door Lock Control, T–LP TAIL w/ Daytime Running Light, Relay w/ Remote Control Mirror, w/ Air Conditioning...
Page 89 Engine Control IGT1 IGT2 IGT3 IGT4 IGF1 FAN2 HA1A A1A– A1A+ HT1B EX1B A21 ( A ) , C20 ( B ) Engine Control Module HA1A A1A– A1A+ Air Fuel Ratio Sensor ( Bank 1 Sensor 1 ) HT1B OX1B ( Shielded ) YARIS (EM01V0U)
Page 90 ( BAT ) Accelerator Position Sensor Relay ID/UP/ MIR HTR VCP2 VPA2 EPA2 VCPA A21 ( A ) , C20 ( B ) Engine Control Module ELS3 VCP2 VPA2 EPA2 VCPA OX1B KNK1 EKNK NE– ( Shielded ) YARIS (EM01V0U)
Page 91 Engine Control Throttle Body Assembly VTA2 M– A21 ( A ) , C20 ( B ) Engine Control Module VCTA VTA1 VTA2 M– GE01 OC1+ OC1– ME01 Generator YARIS (EM01V0U)
Page 92 A21 ( A ) , C20 ( B ) Engine Control Module TACH CANL CANH Airbag Sensor Assembly Center CANL CANH Junction Connector Junction Connector Data Link Connector 3 YARIS (EM01V0U)
Page 93 Engine Control ( IG ) ( BAT ) ( IG ) 7. 5A 7. 5A ECU–B ECU–IG Junction Connector D1 ( A ) , D2 ( B ) , D76 ( C ) Combination Meter 5V IC CAN Controller CAN I/F ( H/B ) ( S/D ) YARIS (EM01V0U)
Page 94 System Outline 1. Electronic Fuel Injection It controls to have appropriate fuel injection according to the basic injection time. The basic injection time is calculated to fit the engine condition and is corrected with signals from various sensors. 2. Electronic Spark Advance Appropriate ignition is conducted according to the basic ignition timing which is calculated to fit the engine condition after correcting it with signals from various sensors.
Page 95 Engine Control : Parts Location Code See Page Code See Page Code See Page 50 (H/B) 47 (H/B) 53 (S/D) 52 (S/D) 49 (S/D) 51 (H/B) 50 (H/B) 47 (H/B) 53 (S/D) 52 (S/D) 49 (S/D) 51 (H/B) 46 (H/B) 47 (H/B) 53 (S/D) 48 (S/D)
Page 96 : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) 63 (S/D) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 62 (H/B) 63 (S/D)
Page 97 ECT and A/T Indicator ( BAT ) ( IG ) ( BAT ) 7. 5A STOP Relay Stop Lamp SW A21 ( A ) , C20 ( B ) Engine Control Module ST1– STAR IGSW MREL BATT YARIS (EM01V0U)
Page 98 Accelerator Position Sensor VCP2 VPA2 EPA2 VCPA ETHW NT– VCP2 VPA2 EPA2 VCPA A21 ( A ) , C20 ( B ) Engine Control Module NE– ME01 YARIS (EM01V0U)
Page 99 ECT and A/T Indicator A21 ( A ) , C20 ( B ) Engine Control Module TACH CANL CANH Junction Connector Junction Connector Data Link Connector 3 YARIS (EM01V0U)
Page 100 ( BAT ) ( IG ) ETCS GAUGE A21 ( A ) , C20 ( B ) Engine Control Module 53 B SLU+ SLU– SLT+ SLT– THO1 ETHO ODMS 76 B SLU+ ( H/B ) SLU– SLT+ SLT– SL ( S/D ) NSSD Transmission Control SW...
Page 101 ECT and A/T Indicator ( BAT ) ( IG ) ( IG ) 7. 5A 7. 5A ECU–B ECU–IG Junction Connector Combination Meter 5V IC LED Driver CAN Controller CAN I/F YARIS (EM01V0U)
Page 102 : Parts Location Code See Page Code See Page Code See Page 50 (H/B) 49 (S/D) 51 (H/B) 52 (S/D) 47 (H/B) 53 (S/D) 50 (H/B) 49 (S/D) 51 (H/B) 52 (S/D) 47 (H/B) 53 (S/D) 46 (H/B) 49 (S/D) 51 (H/B) 48 (S/D) 47 (H/B)
Page 103: Cruise Control
Cruise Control ( BAT ) ( IG ) ( BAT ) 7. 5A STOP Relay Stop Lamp SW A21 ( A ) , C20 ( B ) Engine Control Module ST1– IGSW MREL BATT YARIS (EM01V0U)
Page 104 Accelerator Position Sensor VCP2 VPA2 EPA2 VCPA VCP2 VPA2 EPA2 VCPA A21 ( A ) , C20 ( B ) Engine Control Module TACH ME01 Data Link Connector 3 YARIS (EM01V0U)
Page 105 Cruise Control ( BAT ) ETCS Throttle Body Assembly VTA2 M– A21 ( A ) , C20 ( B ) Engine Control Module VCTA VTA1 VTA2 M– GE01 CANL CANH 6 AD4 Junction Connector D3 ( A ) , V1 ( B ) Spiral Cable Junction...
Page 106 ( IG ) ( IG ) ECU–IG GAUGE 24 4B ( M/T ) ( M/T ) ( A/T ) Junction Connector ( A/T ) ( A/T ) ( M/T ) A21 ( A ) , C20 ( B ) Engine Control Module SLU+ SLU–...
Page 107 Cruise Control ( BAT ) ( IG ) ( IG ) 7. 5A 7. 5A ECU–B ECU–IG Junction Connector Combination Meter 5V IC LED Driver CAN Controller CAN I/F YARIS (EM01V0U)
Page 108 System Outline The cruise control system is a constant vehicle speed controller in which control of the switch on the instrument panel makes it possible to automatically adjust the opening of the engine throttle valve without depressing of the accel pedal. 1.
Page 109 Cruise Control 10. Overdrive Control Function The overdrive control may be cancelled if the vehicle travels on the slope during cruise control travelling. After the overdrive control has been cancelled it is decided that the slope is finished, the vehicle returns to the overdrive control mode again. : Parts Location Code See Page...
Page 110 Memo YARIS (EM01V0U)
Page 111: Engine Immobiliser System
Engine Immobiliser System ( BAT ) ( IG ) 7. 5A 7. 5A ECU–B Transponder Key Amplifier Transponder Key Coil Engine Control Module CODE TXCT AGND EFIO EFII EGND CODE TXCT AGND Transponder Key ECU ( S/D ) Junction Connector ( S/D ) Junction Connector...
Page 112 : Parts Location Code See Page Code See Page Code See Page 46 (H/B) 51 (H/B) 51 (H/B) 48 (S/D) 53 (S/D) 53 (S/D) 51 (H/B) 51 (H/B) 51 (H/B) 53 (S/D) 53 (S/D) 53 (S/D) 51 (H/B) 51 (H/B) 55 (5–Door) 53 (S/D) 53 (S/D)
Page 113 Data Link Connector 3 ( BAT ) 7. 5A OBD2 Occupant Transponder Classification Key ECU CANL CANH CANL CANH TACH D34 ( A ) , D35 ( B ) Junction Connector CANL CANH Data Link Connector 3 ( ∗1 ) D34 ( A ) Junction Connector...
Page 114 ∗ 1 : w/ Cruise Control ∗ 2 : w/o Cruise Control Main Body ECU CANL CANH Junction Connector CANH CANL Combination Meter YARIS (EM01V0U)
Page 115: Data Link Connector
Data Link Connector 3 Airbag Sensor Assembly Center CANH CANL Junction Connector TX– CANH CANL A/C Amplifier Skid Control ECU with Actuator YARIS (EM01V0U)
Page 116 : Parts Location Code See Page Code See Page Code See Page 46 (H/B) 51 (H/B) 51 (H/B) 48 (S/D) 53 (S/D) 53 (S/D) 46 (H/B) 51 (H/B) 51 (H/B) 48 (S/D) 53 (S/D) 53 (S/D) 51 (H/B) 51 (H/B) 50 (H/B) 53 (S/D) 53 (S/D)
Page 117 Multiplex Communication System – CAN Main Body ECU Power Steering ECU CANL CANH CANH CANL Junction Connector CANH CANL Combination Meter YARIS (EM01V0U)
Page 118 Airbag Sensor Assembly Center CANH CANL Junction Connector CANL CANH CANH CANL TX– CANH CANL Engine Control Module Data Link Connector 3 A/C Amplifier Skid Control ECU with Actuator YARIS (EM01V0U)
Page 119 Multiplex Communication System – CAN : Parts Location Code See Page Code See Page Code See Page 46 (H/B) 53 (S/D) 51 (H/B) 48 (S/D) 51 (H/B) 53 (S/D) 46 (H/B) 53 (S/D) 51 (H/B) 48 (S/D) 51 (H/B) 53 (S/D) 51 (H/B) 53 (S/D) 50 (H/B)
Page 120 Memo YARIS (EM01V0U)
Page 121 Headlight ( BAT ) ( BAT ) H–LP RH/ H–LP LH/ H–LP LO RH H–LP LO LH GR ( ∗3 ) GR ( ∗4 ) V ( ∗4 ) L ( ∗3 ) GR ( ∗3 ) Headlamp ( RH ) Headlamp ( LH ) L ( ∗3 )
Page 122 ( BAT ) ∗ 1 : w/ Daytime Running Light ∗ 2 : w/o Daytime Running Light ∗ 3 : w/ H–LP/AMT Relay 7. 5A ∗ 4 : w/o H–LP/AMT Relay ECU–B GR ( ∗3 ) GR ( ∗3 ) GR ( ∗4 ) V ( ∗4 ) L ( ∗3 )
Page 123 Headlight ( BAT ) ( IG ) ∗ 1 : w/ Daytime Running Light ∗ 3 : w/ H–LP/AMT Relay FR FOG ECU–IG Headlamp Dimmer SW Assembly Fog Light Front Fog Front Light Relay Running Light Relay CHG– ( ∗1 ∗3 ) P ( ∗1 ) P ( ∗1 ) BR ( ∗1 )
Page 124 : Parts Location Code See Page Code See Page Code See Page 46 (H/B) 51 (H/B) 53 (S/D) 48 (S/D) 53 (S/D) 51 (H/B) 46 (H/B) 51 (H/B) 53 (S/D) 48 (S/D) 53 (S/D) 51 (H/B) 47 (H/B) 51 (H/B) 53 (S/D) 49 (S/D) 53 (S/D)
Page 125 Turn Signal and Hazard Warning Light ( IG ) ( BAT ) GAUGE 32 4B FLASH Relay ( S/D ) ( S/D ) ( H/B ) ( H/B ) ( S/D ) ( S/D ) ( H/B ) ( H/B ) W–B YARIS (EM01V0U)
Page 126 Headlamp Dimmer SW Assembly FLASH Relay ( H/B ) ( S/D ) ( S/D ) ( H/B ) ( S/D ) ( H/B ) 3 6A YARIS (EM01V0U)
Page 127 Turn Signal and Hazard Warning Light : Parts Location Code See Page Code See Page Code See Page 46 (H/B) 48 (S/D) 53 (S/D) 46 (H/B) 51 (H/B) 53 (S/D) 46 (H/B) 53 (S/D) 55 (5–Door) 48 (S/D) 51 (H/B) 57 (3–Door) 46 (H/B) 51 (H/B)
Page 128 Memo YARIS (EM01V0U)
Page 129: Interior Light
Interior Light ( BAT ) DOME D33 ( A ) Main Body ECU BCTY ( H/B ) LGCY ( S/D ) ( S/D ) ( H/B ) W–B W–B YARIS (EM01V0U)
Page 130 ( ACC ) ( BAT ) 7. 5A D33 ( A ) Main Body ECU ALTB GND1 CANH CANL Junction Connector W–B YARIS (EM01V0U)
Page 131 Interior Light ( BAT ) 7. 5A ECU–B D33 ( A ) Main Body ECU BECU DCTY PCTY RRCY ( ∗3 ) Y ( ∗3 ) G ( ∗3 ) L ( ∗3 ) YARIS (EM01V0U)
Page 132 ∗ 1 : S/D w/ Tachometer ∗ 2 : S/D w/o Tachometer, H/B ∗ 3 : S/D ∗5 ( IG ) ∗ 4 : H/B, S/D Except ∗5 ∗ 5 : Cold Area Spec. , w/ Engine Immobiliser System, 7. 5A w/ ABS, w/ Rear Window Defogger, w/ Door Lock Control,...
Page 133: Interior Light
Interior Light : Parts Location Code See Page Code See Page Code See Page 51 (H/B) 59 (4–Door) 59 (4–Door) 53 (S/D) 55 (5–Door) 55 (5–Door) 51 (H/B) 57 (3–Door) 59 (4–Door) 53 (S/D) 59 (4–Door) 55 (5–Door) 51 (H/B) 55 (5–Door) 59 (4–Door) 53 (S/D)
Page 134 : Ground Points Code See Page Ground Points Location 62 (H/B) Left Kick Panel Left Kick Panel 63 (S/D) 62 (H/B) Instrument Panel Reinforcement Left Instrument Panel Reinforcement Left 63 (S/D) 66 (4–Door) Lower Back Panel Left 64 (5–Door) Back Door Panel Center Back Door Panel Center 65 (3–Door) YARIS (EM01V0U)
Page 135 Taillight and Illumination ( BAT ) ( ∗1 ) Fusible Link Block T–LP TAIL Relay ( ∗1 ) ( ∗1 ) TRLY Main Body ECU ( ∗2 ) Light Control Tail Head ( S/D ) ( S/D ) ( ∗2 ) ( S/D ) ( S/D ) W–B...
Page 136 ( ∗1 ) TAIL ( ∗1 ) 7. 5A PANEL2 ( ∗2 ) ( S/D ) ( ∗2 ) ( S/D ) ( S/D ) ( S/D ) ( S/D ) ( S/D ) ( S/D ) ( H/B ) ( H/B ) ( S/D ) ( S/D )
Page 137 Taillight and Illumination ( IG ) 7. 5A 7. 5A PANEL1 7 4P 1 4M SB ( H/B ) R ( H/B ) R ( H/B ) ( S/D ) Junction Connector ( H/B ) ( S/D ) 16 C ( S/D ) Illumination I/F Junction Connector...
Page 138 ( IG ) GAUGE SB ( H/B ) R ( H/B ) ILL+ ILL– Light Control Rheostat ILL+ ILL– ILL– ( S/D ) W–B YARIS (EM01V0U)
Page 139 Taillight and Illumination : Parts Location Code See Page Code See Page Code See Page 46 (H/B) 53 (S/D) 53 (S/D) 48 (S/D) 51 (H/B) 50 (H/B) 43, 46 (H/B) 53 (S/D) 52 (S/D) 43, 48 (S/D) 51 (H/B) 50 (H/B) 46 (H/B) 53 (S/D) 52 (S/D)
Page 140 : Ground Points Code See Page Ground Points Location 60 (H/B) Left Suspension Tower Left Suspension Tower 61 (S/D) 60 (H/B) Radiator Support Left Radiator Support Left 61 (S/D) 62 (H/B) Right Kick Panel Right Kick Panel 63 (S/D) 62 (H/B) Instrument Panel Reinforcement Left Instrument Panel Reinforcement Left 63 (S/D)
Page 141: Back–Up Light
Back–Up Light ( IG ) GAUGE J28 ( A ) , J29 ( B ) Junction Connector ( S/D ) ( S/D ) ( H/B ) ( H/B ) Back–Up Lamp SW ( S/D ) ( S/D ) ( H/B ) ( H/B ) YARIS (EM01V0U)
Page 143 Stop Light ∗ 1 : S/D LED Type ∗ 2 : S/D Bulb Type ( BAT ) STOP Stop Lamp SW ( S/D ) ( H/B ) 2 A ( ∗1 ) 1 B ( H/B ) J28 ( A ) , J29 ( B ) Junction Connector ( ∗1 ) ( H/B )
Page 144 : Parts Location Code See Page Code See Page Code See Page 50 (H/B) 55 (5–Door) 59 (4–Door) 52 (S/D) 57 (3–Door) 59 (4–Door) 55 (5–Door) 59 (4–Door) 59 (4–Door) 57 (3–Door) 55 (5–Door) 59 (4–Door) 55 (5–Door) 57 (3–Door) 54 (5–Door) 57 (3–Door) 59 (4–Door)
Page 145 Horn ( BAT ) HORN HORN Relay 7 1A 8 1A 28 4B 17 AA2 18 4E 1 BA1 D3 ( A ) , V1 ( B ) , ( C ) Spiral Cable ( S/D ) ( H/B ) Horn V1 ( B ) , ( C ) Horn...
Page 146 : Parts Location Code See Page Code See Page Code See Page 46 (H/B) 51 (H/B) 52 (S/D) 48 (S/D) 53 (S/D) 50 (H/B) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) Engine Room Main Wire and Engine Room J/B (Engine Compartment Left) Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
Page 147: Front Fog Light
Front Fog Light Headlamp Dimmer SW Assembly Fog Light Front Running Light Relay Junction Connector ( H ) ( ED ) Flash Tail Head High Headlamp Dimmer SW Assembly W–B W–B YARIS (EM01V0U)
Page 148 ( BAT ) ∗ 1 : w/ Daytime Running Light ∗ 2 : w/o Daytime Running Light FR FOG Front Fog Light Relay ( H/B ) ( S/D ) A24 ( A ) , B13 ( B ) Junction Connector Fog Lamp ( Front LH ) Fog Lamp ( Front RH ) YARIS (EM01V0U)
Page 149 Front Fog Light : Parts Location Code See Page Code See Page Code See Page 46 (H/B) 51 (H/B) 53 (S/D) 48 (S/D) 53 (S/D) 51 (H/B) 46 (H/B) 51 (H/B) 53 (S/D) 48 (S/D) 51 (H/B) 51 (H/B) 46 (H/B) 53 (S/D) 53 (S/D) 48 (S/D)
Page 150 Memo YARIS (EM01V0U)
Page 151 Front Fog Light Headlamp Dimmer SW Assembly Fog Light Front Running Light Relay Junction Connector ( H ) ( ED ) Flash Tail Head High Headlamp Dimmer SW Assembly W–B W–B YARIS (EM01V0U)
Page 152 ( BAT ) ∗ 1 : w/ Daytime Running Light ∗ 2 : w/o Daytime Running Light FR FOG Front Fog Light Relay ( H/B ) ( S/D ) A24 ( A ) , B13 ( B ) Junction Connector Fog Lamp ( Front LH ) Fog Lamp ( Front RH ) YARIS (EM01V0U)
Page 153 Front Fog Light : Parts Location Code See Page Code See Page Code See Page 46 (H/B) 51 (H/B) 53 (S/D) 48 (S/D) 53 (S/D) 51 (H/B) 46 (H/B) 51 (H/B) 53 (S/D) 48 (S/D) 51 (H/B) 51 (H/B) 46 (H/B) 53 (S/D) 53 (S/D) 48 (S/D)
Page 154 Memo YARIS (EM01V0U)
Page 155 ( IG ) 7. 5A LED Driver CAN Controller CAN I/F ( H/B ) ( S/D ) Park/Neutral Position SW CANH CANL A21 ( A ) , C20 ( B ) Engine Control Module YARIS (EM01V0U)
Page 156 ( IG ) ( BAT ) ( BAT ) ( BAT ) ABS2/ ABS1/ ECU–IG STOP VSC2 VSC1 Stop Lamp SW Speed Sensor Speed Sensor ( Front LH ) ( Front RH ) FL– FR– Skid Control ECU with Actuator CANL CANH RL–...
Page 157 System Outline 1. Speed Sensor Detects the wheel speed of each of four wheels. 2. Skid Control ECU Based on signals from the sensors, it judges the vehicle driving condition and sends the brake control signal to the brake actuator. 3.
Page 158 : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) 63 (S/D) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 62 (H/B) 63 (S/D)
Page 159 Memo YARIS (EM01V0U)
Page 160 NOTICE: When inspecting or repairing the SRS, perform service in accordance with the following precautionary instructions and the procedure, and precautions in the Repair Manual applicable for the model year. D Malfunction symptoms of the SRS are difficult to confirm, so the DTCs become the most important source of information when troubleshooting.
Page 161 ( IG ) 7. 5A 16 4E Airbag Sensor Airbag Sensor ( Front RH ) ( Front LH ) –SR –SL D16 ( A ) , J8 ( C ) , J9 ( B ) Airbag Sensor Assembly Center –SR –SL PD–...
Page 162 Airbag Sensor ( Rear LH ) Airbag Sensor ( Rear RH ) BCL+ BCL– BCR+ BCR– BCL+ BCL– BCR+ BCR– Side Airbag Sensor ( LH ) Side Airbag Sensor ( RH ) BBL+ BBL– BBR+ BBR– D16 ( A ) , J8 ( C ) , J9 ( B ) Airbag Sensor Assembly Center BBD+ BBD–...
Page 163 ( IG ) ( IG ) Main Body ECU Combination Meter 7. 5A GAUGE CANL CANH LED Driver CAN Controller ( S/D ) CAN I/F Junction Connector Y ( H/B ) Junction Connector CANL CANH D– D2– D16 ( A ) , J8 ( C ) , J9 ( B ) Airbag Sensor Assembly Center D–...
Page 164 J24 ( A ) , U1 ( B ) Occupant Classification ECU Hazard Warning Signal SW Passenger' s Seat Belt/Airbag Indicator ( ON/OFF ) P–AB PAON FSR+ FSR– ( S/D ) Passenger Seat Belt Warning Lamp Passenger' s Seat Belt/Airbag Indicator ( ON/OFF ) P–AB PAON...
Page 165 J24 ( A ) , U1 ( B ) Occupant Classification ECU BGND SVC1 SIG1 SGD1 SVC3 SIG3 SGD3 11 B RBE+ RBE– SVC1 SIG1 SGD1 SVC3 SIG3 SGD3 Front Seat Inner Belt Occupant Classification Occupant Classification Assembly ( Front RH ) Sensor ( Front LH ) Sensor ( Rear LH ) Data Link...
Page 166 J24 ( A ) , U1 ( B ) ( IG ) ( BAT ) Occupant Classification ECU 7. 5A 7. 5A ECU–B SVC2 SIG2 SGD2 SVC4 SIG4 SGD4 12 B SVC2 SIG2 SGD2 SVC4 SIG4 SGD4 Occupant Classification Occupant Classification Junction Sensor ( Front RH ) Sensor ( Rear RH )
Page 167 System Outline ∗ The system reaches an ignition judgment to deploy the following device based on the signals received from the front airbag sensor and deceleration sensor. – Driver Airbag – Front Passenger Airbag – Seat Belt Pretensioner ∗ The system reaches an ignition judgment to deploy the following device based on the signals received from the side airbag sensors.
Page 168 : Relay Blocks Code See Page Relay Blocks (Relay Block Location) Engine Room R/B (Engine Compartment Left) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) Floor Wire and Instrument Panel J/B (Lower Finish Panel) Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
Page 169: Seat Belt Warning
Seat Belt Warning ( IG ) ( IG ) ( IG ) D1 ( A ) , D2 ( B ) , D76 ( C ) Combination Meter 7. 5A 7. 5A GAUGE 16 4E LED Driver CAN Controller ( S/D ) CAN I/F ( H/B ) ( S/D )
Page 170 J24 ( A ) , U1 ( B ) Occupant Classification ECU FSR+ FSR– Hazard Warning Signal SW Passenger' s Seat Belt/Airbag Indicator ( ON/OFF ) PBEW P–AB PAON ( S/D ) Passenger Seat Belt Warning Lamp Passenger' s Seat Belt/Airbag Indicator ( ON/OFF ) PBEW P–AB...
Page 171 Seat Belt Warning J24 ( A ) , U1 ( B ) Occupant Classification ECU BGND SVC1 SIG1 SGD1 SVC3 SIG3 SGD3 RBE+ RBE– SVC1 SIG1 SGD1 SVC3 SIG3 SGD3 Front Seat Inner Belt Occupant Classification Occupant Classification Assembly ( Front RH ) Sensor ( Front LH ) Sensor ( Rear LH ) Data Link...
Page 172 J24 ( A ) , U1 ( B ) ( IG ) ( BAT ) Occupant Classification ECU 7. 5A 7. 5A ECU–B SVC2 SIG2 SGD2 SVC4 SIG4 SGD4 10 B SVC2 SIG2 SGD2 SVC4 SIG4 SGD4 Occupant Classification Occupant Classification Junction Sensor ( Front RH ) Sensor ( Rear RH )
Page 173 Seat Belt Warning : Parts Location Code See Page Code See Page Code See Page 51 (H/B) 51 (H/B) 59 (4–Door) 53 (S/D) 53 (S/D) 54 (5–Door) 51 (H/B) 53 (S/D) 56 (3–Door) 51 (H/B) 53 (S/D) 58 (4–Door) 53 (S/D) 50 (H/B) 54 (5–Door) 51 (H/B)
Page 174 Memo YARIS (EM01V0U)
Page 175 ( IG ) ( IG ) 7. 5A ECU–IG Junction Connector Combination Meter LED Driver CAN Controller Speed Sensor CAN I/F 11 AD3 YARIS (EM01V0U)
Page 176 ( BAT ) Data Link Connector 3 c1 ( D ) Power Steering Torque Sensor TRQV TRQ1 TRQ2 TRQG CANH CANL PGND A19 ( A ) , D31 ( B ) , b1 ( C ) , c1 ( D ) Power Steering ECU D36 ( A ) Junction...
Page 177 System Outline ∗ In order to reduce driver’s steering force, the assist current is calculated from the torque sensor signal and vehicle speed signal of the meter or CAN communication to output to the motor. ∗ When abnormality occurs in the system, the assist is prohibited by shutting off the power source relay and motor relay in ECU, and the warning light (P/S) in the meter is lit up.
Page 178 Memo YARIS (EM01V0U)
Page 179: Power Window
Power Window ( BAT ) ( BAT ) ( IG ) Fusible 7. 5A Link Block ECU–B ECU–IG Relay POWER DOOR DOOR Main Body ECU BECU DCTY YARIS (EM01V0U)
Page 180 ∗ 1 : w/ Rear Power Window ∗ 2 : w/o Rear Power Window G1 ( A ) , ( B ) Power Window Master SW ( ∗1 ) 16 A ( ∗2 ) Power Window Regulator Motor ( Front LH ) Power Window SW ( Front RH ) Power Window Regulator Motor ( Front RH ) YARIS (EM01V0U)
Page 181 Power Window ∗ 1 : w/ Rear Power Window ∗ 2 : w/o Rear Power Window G1 ( A ) , ( B ) Power Window Master SW ( ∗1 ) ( ∗2 ) Power Window Regulator Power Window Regulator Motor ( Rear LH ) Motor ( Rear RH ) YARIS (EM01V0U)
Page 182 System Outline 1. Manual Up–and–Down Function During IG ON, one step operation upward (Pull) or downward (Push) of the door switch makes the door glass move upward or downward. Manual operation of the power window master switch for each window can control operation of each window remotely from the driver’s seat.
Page 183 Power Window : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) Front Door RH Wire and Instrument Panel Wire (Right Kick Panel)
Page 184 Memo YARIS (EM01V0U)
Page 185 Door Lock Control D33 ( A ) ( BAT ) ( BAT ) ( IG ) ( ACC ) Main Body ECU 7. 5A 7. 5A ECU–B ECU–IG ALTB BECU 1 5A YARIS (EM01V0U)
Page 186 D33 ( A ) Main Body ECU DCTY GND1 LSWP ACT– ACT+ 17 4E LSSR Door Lock Assembly ( Front Passenger' s Side ) W–B ( S/D ) W–B ( S/D ) W–B ( H/B ) 1 6B YARIS (EM01V0U)
Page 187 Door Lock Control D33 ( A ) Main Body ECU LSWD ACTD Back Door Lock Assembly 7 MN1 6 MN1 J28 ( A ) , J29 ( B ) Junction Connector LSSR Unlock Unlock Door Lock Assembly ( Driver' s Side ) Detection Detection LSSR...
Page 188 D33 ( A ) Main Body ECU ∗ 1 : w/ Rear Power Window ∗ 2 : w/o Rear Power Window ∗ 3 : w/ Power Window ∗ 4 : S/D w/o Power Window O ( S/D ) BR ( S/D ) 9 A ( ∗1 ) 9 B ( ∗2 ) 1 A ( ∗1 )
Page 189 Door Lock Control D33 ( A ) Main Body ECU CANL CANH Junction Connector Junction Connector CANL CANH D16 ( A ) , J8 ( C ) Airbag Sensor Assembly Center DSP+ DSP– DBE+ DBE– LSP+ LSP– LBE+ LBE– Front Seat Inner Belt ( Driver' s Side ) YARIS (EM01V0U)
Page 190 System Outline 1. Manual Lock & Unlock Function All the doors (Including the back door) are locked or unlocked by operating the door lock control switch (For manual operation) to ’lock’ or ’unlock’ side. 2. Door Key–Linked Lock & Unlock Function All the doors (Including the back door) are locked or unlocked by operating the key plate to ’lock’...
Page 191 Door Lock Control : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) Front Door RH Wire and Instrument Panel Wire (Right Kick Panel)
Page 192 Memo YARIS (EM01V0U)
Page 193 Wireless Door Lock Control D33 ( A ) ( BAT ) ( BAT ) ( IG ) ( ACC ) Main Body ECU 7. 5A 7. 5A ECU–B ECU–IG BCTY ( H/B ) ALTB BECU LGCY ( S/D ) YARIS (EM01V0U)
Page 194 D33 ( A ) Main Body ECU DCTY PCTY RRCY LSWP ACT– ACT+ LSSR Door Lock Assembly ( Front Passenger' s Side ) ∗ 1 : S/D ∗3 ∗ 2 : H/B, S/D Except ∗3 ∗ 3 : Cold Area Spec. , w/ Engine Immobiliser System, w/ ABS, w/ Rear Window Defogger,...
Page 195 Wireless Door Lock Control D33 ( A ) Main Body ECU LSWD ACTD Back Door Lock Assembly 7 MN1 6 MN1 J28 ( A ) , J29 ( B ) Junction Connector LSSR Unlock Unlock Door Lock Assembly Detection Detection ( Driver' s Side ) LSSR LSSR...
Page 196 ∗ 4 : w/ Theft Deterrent System D33 ( A ) Main Body ECU GND1 FLASH Relay BRK+ BRK– Theft Warning ECU O ( S/D ) W–B ( S/D ) YARIS (EM01V0U)
Page 197 Wireless Door Lock Control D33 ( A ) ( BAT ) Main Body ECU DOME Door Control Receiver W–B ( H/B ) YARIS (EM01V0U)
Page 198 System Outline 1. Wireless Lock & Unlock Function Pushing the lock button locks all the doors and pushing the unlock button unlocks the all the doors. 2. 30–Second Auto Lock Function If none of the door are opened within 30 seconds after they are unlocked with the unlock button, all the doors are locked automatically again to prevent the doors from being left open.
Page 199 Wireless Door Lock Control : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) Floor Wire and Instrument Panel J/B (Lower Finish Panel) Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel) Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
Page 200 Memo YARIS (EM01V0U)
Page 201 Theft Deterrent D33 ( A ) ( BAT ) ( BAT ) ( IG ) ( ACC ) Main Body ECU 7. 5A 7. 5A ECU–B ECU–IG BCTY ( H/B ) ALTB BECU LGCY ( S/D ) YARIS (EM01V0U)
Page 202 D33 ( A ) Main Body ECU DCTY PCTY RRCY GND1 LSWP ACT– ACT+ FLASH Relay 17 4E LSSR Door Lock Assembly ( Front Passenger' s Side ) W–B ( S/D ) W–B ∗ 1 : S/D ∗3 ( H/B ) ∗...
Page 203 Theft Deterrent D33 ( A ) Main Body ECU LSWD ACTD J28 ( A ) , J29 ( B ) Junction Connector LSSR Unlock Unlock Detection Detection LSSR LSSR Door Lock Assembly ( Driver' s Side ) Door Lock Door Lock Assembly Assembly ( Rear RH )
Page 204 D33 ( A ) Main Body ECU HRLY ( BAT ) O ( S/D ) BR ( S/D ) 6 FD1 5 FD1 9 A ( ∗5 ) 9 B ( ∗6 ) 1 A ( ∗5 ) 7 B ( ∗6 ) Junction Connector W–B...
Page 205 Theft Deterrent D33 ( A ) Main Body ECU HORN ( BAT ) HORN HORN Relay Door Control Receiver YARIS (EM01V0U)
Page 206 ( BAT ) ( BAT ) ( IG ) 7. 5A DOME ECU–B ECU–IG W–B W–B ( S/D ) ( H/B ) ( S/D ) ( H/B ) DSWH SH– LSR ( H/B ) LUG ( S/D ) BRK– BRK+ Theft Warning ECU ( S/D ) Junction...
Page 207 Theft Deterrent : Parts Location Code See Page Code See Page Code See Page 48 (S/D) 54 (5–Door) 55 (5–Door) 46 (H/B) 56 (3–Door) 57 (3–Door) 46 (H/B) 58 (4–Door) 59 (4–Door) 48 (S/D) 58 (4–Door) 55 (5–Door) 51 (H/B) 54 (5–Door) 57 (3–Door) 53 (S/D)
Page 208 : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 63 (S/D) 62 (H/B) Engine Room Main Wire and Instrument Panel Wire (Instrument Panel Left)
Page 209: Front Wiper And Washer
Front Wiper and Washer ( IG ) D5 ( A ) , D6 ( B ) Windshield Wiper SW Assembly INT1 INT2 MIST Washer SW INT1 INT2 Wiper Relay W–B YARIS (EM01V0U)
Page 210 ( IG ) Windshield Wiper Motor W–B YARIS (EM01V0U)
Page 211 Front Wiper and Washer System Outline 1. Intermittent Function When the wiper control switch is turned to INT position, the wiper makes intermittent operation with an interval time of approximately 3.3 seconds. 2. Washer–Linked Function When the washer switch is turned ON for approximately 0.3 seconds or more, the wiper starts a LO operation at the same time as the washer fluid is ejected.
Page 212 Memo YARIS (EM01V0U)
Page 213: Rear Wiper And Washer
Rear Wiper and Washer ( IG ) ( IG ) D5 ( A ) , D6 ( B ) Windshield Wiper SW Assembly RR WIP Wash On+Washer Junction Connector 18 JD1 Rear Washer Motor Rear Wiper Motor Assembly YARIS (EM01V0U)
Page 214 : Parts Location Code See Page Code See Page Code See Page 46 (H/B) 51 (H/B) 54 (5–Door) 50 (H/B) 51 (H/B) 56 (3–Door) : Junction Block and Wire Harness Connector Code See Page Junction Block and Wire Harness (Connector Location) Floor Wire and Instrument Panel J/B (Lower Finish Panel) Engine Room Main Wire and Instrument Panel J/B (Lower Finish Panel) Instrument Panel Wire and Instrument Panel J/B (Lower Finish Panel)
Page 215 Shift Lock ( ACC ) ( BAT ) ( IG ) STOP GAUGE 18 4B 2 4P Shift Lock Control ECU SLS+ SLS– KLS+ W–B Junction Connector 3 6A YARIS (EM01V0U)
Page 216 System Outline The shift lever can be shifted from P range only when the brake pedal is depressed with the ignition key at ON position. : Parts Location Code See Page Code See Page Code See Page 50 (H/B) 51 (H/B) 45, 51 (H/B) 52 (S/D) 53 (S/D)
Page 217: Rear Window Defogger
Rear Window Defogger ( BAT ) ( IG ) ( IG ) 7. 5A Relay Junction Connector Rear Window Defogger SW RDEF Noise Filter Noise Filter Rear Window Defogger SW ( H/B ) ( S/D ) J44 ( D ) , M2 ( A ) , O1 ( B ) , ( C ) Rear Window Defogger ( H/B )
Page 219: Remote Control Mirror
Remote Control Mirror ( ACC ) 7. 5A D34 ( A ) , D35 ( B ) Junction Connector Outer Mirror SW Left Right Left Right Junction Connector YARIS (EM01V0U)
Page 221 Cigarette Lighter / Power Outlet ( ACC ) Cigarette Lighter or Power Outlet Junction Connector YARIS (EM01V0U)
Page 223: Audio System
Audio System ( IG ) ( IG ) 7. 5A ECU–IG 1 4M 5V IC 12 CA2 6 AA2 11 AD3 ( S/D ) YARIS (EM01V0U)
Page 224 ( ACC ) ( BAT ) 7. 5A DOME Antenna Amplifier D10 ( A ) , D11 ( B ) , D74 ( C ) Radio Receiver Assembly FR– FL– Speaker ( Front Door RH ) Speaker ( Front Door LH ) ( S/D ) YARIS (EM01V0U)
Page 225 Audio System Speaker ( Rear LH ) Speaker ( Rear RH ) Speaker ( Rear LH ) Speaker ( Rear RH ) Speaker ( Rear LH ) Speaker ( Rear RH ) 5 IJ1 5 HJ1 1 JD3 5 JD2 15 JD2 ( S/D ) ( S/D )
Page 226 : Parts Location Code See Page Code See Page Code See Page 48 (S/D) 53 (S/D) 56 (3–Door) 49 (S/D) 51 (H/B) 58 (4–Door) 53 (S/D) 53 (S/D) 54 (5–Door) 51 (H/B) 51 (H/B) 54 (5–Door) 53 (S/D) 53 (S/D) 57 (3–Door) 51 (H/B) 54 (5–Door)
Page 227: Combination Meter
Combination Meter ( IG ) D1 ( A ) , D2 ( B ) , D76 ( C ) Combination Meter 5V IC Clock TRIP Buzzer Drive Monitor 6 AA2 W–B Speed Sensor YARIS (EM01V0U)
Page 228 ( BAT ) ( IG ) 7. 5A 7. 5A ECU–B ( H/B ) D1 ( A ) , D2 ( B ) , D76 ( C ) Combination Meter ( S/D ) 16 C Display Illumination I/F 19 C 18 C 17 C TX+1...
Page 229 Combination Meter D1 ( A ) , D2 ( B ) , D76 ( C ) Combination Meter LED Driver CAN Controller ( H/B ) CAN I/F ( H/B ) 20 A ( H/B ) ( S/D ) ( S/D ) PBEW ( S/D ) YARIS (EM01V0U)
Page 230 ∗ 1 : w/ Daytime Running Light ∗ 2 : w/o Daytime Running Light ∗ 3 : S/D w/ Tachometer ∗ 4 : S/D w/o Tachometer, H/B ∗ 5 : S/D A/T D1 ( A ) , D2 ( B ) , D76 ( C ) Combination Meter LED Driver ( S/D )
Page 231 Combination Meter ( H/B ) D1 ( A ) , D2 ( B ) , D76 ( C ) Combination Meter ( S/D ) ( H/B ) ( S/D ) YARIS (EM01V0U)
Page 232 Main Body ECU Power Steering ECU CANH CANL CANL CANH A21 ( A ) , C20 ( B ) Airbag Sensor Engine Control Module Assembly Center ETHW CANH CANL CANH CANL NE– Junction Connector TX– CANH CANL A/C Amplifier Skid Control ECU with Actuator YARIS (EM01V0U)
Page 233 Combination Meter : Parts Location Code See Page Code See Page Code See Page 46 (H/B) 49 (S/D) 51 (H/B) 48 (S/D) 47 (H/B) 53 (S/D) 46 (H/B) 49 (S/D) 51 (H/B) 48 (S/D) 51 (H/B) 53 (S/D) 46 (H/B) 53 (S/D) 51 (H/B) 48 (S/D)
Page 235: Cooling Fan
Cooling Fan ( BAT ) ( IG ) ECU–IG FAN NO. 1 FAN NO. 2 Relay Relay W–B YARIS (EM01V0U)
Page 236 A/C Amplifier TX– SG–1 S5–3 – CANL CANH ETHW FAN2 NE– A21 ( A ) , C20 ( B ) Engine Control Module YARIS (EM01V0U)
Page 237 Cooling Fan : Parts Location Code See Page Code See Page Code See Page 46 (H/B) 48 (S/D) 47 (H/B) 48 (S/D) 46 (H/B) 49 (S/D) 46 (H/B) 48 (S/D) 51 (H/B) 48 (S/D) 47 (H/B) 53 (S/D) 46 (H/B) 49 (S/D) 50 (H/B) 48 (S/D)
Page 238 Memo YARIS (EM01V0U)
Page 239: Air Conditioning
Air Conditioning ( BAT ) ( IG ) ∗ 1 : w/ PTC Heater ∗ 2 : w/o PTC Heater ∗ 3 : w/ Defroster Mode Detection SW ∗ 4 : w/o Defroster Mode Detection SW GAUGE ∗ 5 : w/ A/C SW ∗...
Page 240 A/C SW ( IG ) 7. 5A 12 DE1 ( ∗3 ∗5 ) ( ∗3 ∗5 ) ( ∗6 ) Junction Connector Rear Window Defogger SW E8 ( A ) , E9 ( B ) A/C Amplifier MAX– HEAT SBLW SG–2 10 A ( ∗1 )
Page 241 Air Conditioning HRLY E8 ( A ) , E9 ( B ) A/C Amplifier TX– SG–1 S5–3 – A/C Pressure Sensor Junction Connector NE– CANH CANL A21 ( A ) , C20 ( B ) Engine Control Module YARIS (EM01V0U)
Page 242 ( BAT ) ( BAT ) ∗ 1 : w/ PTC Heater SUB2 SUB1 W ( ∗1 ) R ( ∗1 ) SUB2 SUB3 SUB1 Relay Relay Relay W–B ( ∗1 ) PTC3 PTC2 ( ∗1 ) E8 ( A ) , E9 ( B ) A/C Amplifier SOL+ PTC1...
Page 243: Air Conditioning
Air Conditioning : Parts Location Code See Page Code See Page Code See Page 46 (H/B) 47 (H/B) 50 (H/B) 48 (S/D) 49 (S/D) 52 (S/D) 50 (H/B) 47 (H/B) 50 (H/B) 52 (S/D) 49 (S/D) 52 (S/D) 46 (H/B) 51 (H/B) 50 (H/B) 48 (S/D)
Page 244 : Ground Points Code See Page Ground Points Location 60 (H/B) Left Suspension Tower Left Suspension Tower 61 (S/D) 60 (H/B) Engine Block Left Engine Block Left 61 (S/D) 62 (H/B) Left Kick Panel Left Kick Panel 63 (S/D) 62 (H/B) Right Kick Panel Right Kick Panel 63 (S/D)
Page 245 I GROUND POINT W–B ( GND2 ) Skid Control ECU with Actuator W–B W–B ( PGND ) A19 ( GND1 ) Power Steering W–B W–B W–B ( SE ) W–B Speed Sensor ( EC ) Engine Control Module W–B W–B EFI Relay ( E ) Water Level Warning SW...
Page 246 Junction Connector ( E02 ) Engine Control ( ECC ) Module ( ∗1 ) Spiral Cable W–B ( GND ) Ignition Coil ( No. 4 ) ( ∗1 ) ( SG ) W–B W–B ( ∗2 ) Data Link ( GND ) Connector 3 Ignition Coil ( No.
Page 247 I GROUND POINT FLASH Relay W–B Main Body ECU ( E ) ( GND1 ) Headlamp Dimmer SW Assembly W–B NOISE FILTER ( ED ) W–B W–B IG 1 Relay ( E ) Room Lamp ( Center ) W–B PWR Relay ( L ) Map Lamp W–B...
Page 248 W–B ( GND ) A/C Amplifier Junction Connector W–B ( E ) Rear Window Defogger SW W–B ( E ) ( S/D ) Hazard Warning Signal SW W–B W–B W–B ( E ) ( E ) Hazard Warning ( H/B ) ( H/B ) Cigarette Lighter Signal SW...
Page 249 I GROUND POINT W–B W–B ( E ) ( E ) ( H/B ) Fuel Suction Back Door Pump and Courtesy SW Gage Assembly W–B W–B ( LSWE ) N4 ( FE ) ( H/B ) ( H/B ) Back Door Position SW W–B ( E )
Page 251 I GROUND POINT : Connector Joining Wire Harness and Wire Harness Code See Page Joining Wire Harness and Wire Harness (Connector Location) 62 (H/B) 63 (S/D) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) Engine Room Main Wire and Engine Room Main Wire (Instrument Panel Left) 62 (H/B) 63 (S/D)
Page 253 J POWER SOURCE (Current Flow Chart) The chart below shows the route by which current flows from the battery to each electrical source (Fusible Link, Circuit Breaker, Fuse, etc.) and other Parts. Headlamp Dimmer 10A TAIL SW Assembly (*2) (*2) (*2) DEF Relay 30A DEF...
Page 254 Example 7.5A PANEL2 7.5A PANEL1 (*2) (*2) Starter 10A ID/UP/MIR HTR Parts Code or Location 7.5A DRL Location Electrical Source 7.5A ACC2 7.5A ACC ACC Cut Relay 15A CIG 7.5A A/C 10A ECU-IG 10A GAUGE 15A RR WIP 15A WSH 25A WIP 10A EFI2 7.5A IGN...
Page 255 J POWER SOURCE (Current Flow Chart) Engine Room R/B and Engine Room J/B (See Page 24) Fuse System Page 7.5A ALT–S Charging Combination Meter Cruise Control Door Lock Control Electronically Controlled Transmission and A/T Indicator Engine Control Engine Immobiliser System Headlight 7.5A ECU–B...
Page 256: Table Of Contents
Fuse System Page Instrument Panel J/B (See Page 30) Fuse System Page Air Conditioning 7.5A Rear Window Defogger Audio System Door Lock Control Interior Light 7.5A Remote Control Mirror Theft Deterrent Wireless Door Lock Control Cruise Control Electronically Controlled Transmission and A/T Indicator Engine Control 7.5A Engine Immobiliser System...
Page 257 J POWER SOURCE (Current Flow Chart) Fuse System Page Headlight ECU–IG Power Window Theft Deterrent Wireless Door Lock Control Air Conditioning Back–Up Light Charging Cruise Control Electronically Controlled Transmission and A/T Indicator GAUGE Rear Window Defogger Seat Belt Warning Shift Lock Taillight and Illumination Turn Signal and Hazard Warning Light ID/UP/MIR HTR...
Page 258 Fusible Link Block (See Page 42) Fuse System Page Charging Engine Control 120A Key Reminder and Light Reminder Power Window Taillight and Illumination Fuse Block (See Page 45) Fuse System Page 7.5A ACC2 Shift Lock ∗ These are the page numbers of the first page on which the related system is shown. YARIS (EM01V0U)
Page 259 K CONNECTOR LIST Gray Gray Black Gray Black 1 2 3 Yellow Gray Gray 1 2 3 Yellow Black Black Black Black 4 5 6 10 11 12 17 18 19 26 27 28 32 33 34 Gray Black Black 1 2 3 4 5 6 YARIS (EM01V0U)
Page 260 Black Black 1 2 3 4 5 6 7 8 9 10 11 12 Black Black 1 2 3 4 Gray Black Brown Black Brown Gray Black Black Gray Gray 1 2 3 4 5 6 7 8 9 10 11 12 Gray Gray Black...
Page 261 K CONNECTOR LIST Black Gray Black Gray Gray Black Black Gray Black 1 2 3 4 1 2 3 4 1 2 3 4 Gray Black Gray Black Black 1 2 3 4 1 2 3 4 5 6 Black Black 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40...
Page 262 1 2 3 4 5 6 10 11 12 13 13 14 Gray 5 6 7 8 9 10 11 12 13 1 2 3 4 6 7 8 9 Blue 5 6 7 8 9 10 3 4 5 6 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 Black...
Page 263 K CONNECTOR LIST Black Black 2 3 4 5 6 4 5 6 8 9 10 11 12 13 14 Dark Gray 1 2 3 1 2 3 9 10 14 15 1 2 3 4 5 4 5 6 16 17 18 22 23 24 25 26 27 28 29 30 31 35 36...
Page 264 5 6 7 21 22 5 6 7 21 22 5 6 7 21 22 5 6 7 21 22 1 2 3 6 7 8 9 10111213 YARIS (EM01V0U)
Page 265 K CONNECTOR LIST Black Gray Gray 1 2 3 4 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 2 3 4 8 9 10 11 12 13 14 7 8 9 10 Black Black...
Page 266 1 2 3 4 5 2 1 3 1 2 3 4 3 4 5 6 5 6 7 8 9 10 2 1 3 3 4 5 6 5 6 7 8 9 10 1 2 3 4 5 1 2 3 4 3 4 5 6 5 6 7 8 9 10...
Page 267 K CONNECTOR LIST Yellow Yellow 1 2 3 4 5 6 1 2 3 4 5 6 Yellow 1 2 3 4 5 Yellow Yellow Yellow Yellow Yellow 1 2 3 4 1 2 3 4 Black Black Black Black 1 2 3 4 5 1 2 3 4 5 7 8 9 101112...
Page 268 Gray Gray Gray Black Black Gray Gray Black (H/B) Black (S/D) Black Black Orange Black 1 2 3 4 Gray Black Black Black Black 1 2 3 4 5 1 2 3 1 2 3 1 2 3 1 2 3 7 8 9 101112 YARIS (EM01V0U)
Page 269 K CONNECTOR LIST (H/B) (S/D) Orange Black 1 2 3 4 5 6 7 8 9 10 Black Black YARIS (EM01V0U)
Page 270 Memo YARIS (EM01V0U)
Page 271 K CONNECTOR LIST 9 10 4 5 6 7 6 5 4 3 14 13 12 11 10 18 19 22 21 20 19 Yellow 1 2 3 4 5 5 4 3 2 1 6 7 8 9 10 10 9 8 7 6 Black 8 7 6 5 4...
Page 272 6 5 4 3 2 3 4 5 9 10 12 11 10 9 11 12 Gray Yellow 1 2 3 4 7 6 5 4 3 4 5 6 15 14 13 12 YARIS (EM01V0U)
Page 273 K CONNECTOR LIST 7 6 5 4 3 14 15 16 17 16 15 14 13 7 6 5 4 3 13 14 15 16 15 14 13 12 7 6 5 4 3 14 15 16 17 16 15 14 13 7 6 5 4 3 13 14...
Page 274 7 6 5 4 3 13 14 15 16 15 14 13 12 7 6 5 4 3 14 15 16 17 16 15 14 13 Yellow Yellow 1 2 3 4 5 6 7 8 9 10 11 1213141516171819 20 YARIS (EM01V0U)
Page 275 K CONNECTOR LIST YARIS (EM01V0U)
Page 276 Memo YARIS (EM01V0U)
Page 277 L PART NUMBER OF CONNECTORS Code Part Name Part Number Code Part Name Part Number Turn Signal Lamp (Front Side RH) Crankshaft Position Sensor 90980–12028 90980–11162 90980–11162 Turn Signal Lamp (Front Side LH) VSV (Purge) 90980–11156 A/C Pressure Sensor 90980–10845 Fuel Injector (No.1) Rear Washer Motor 90980–11051...
Page 278 Code Part Name Part Number Code Part Name Part Number Spiral Cable 90980–12160 Speaker (Front Door RH) 90980–10935 Unlock Warning SW Door Lock Control SW (Front Passenger’s 90980–11013 90980–12063 90980–12063 Side) A/T Shift Lever Illumination Power Window Master SW 90980–12122 Parking Brake SW 90980–10871 Outer Rear View Mirror (LH)
Page 279 L PART NUMBER OF CONNECTORS Code Part Name Part Number Code Part Name Part Number Rear Combination Lamp (RH) Airbag Squib (Front Passenger’s Airbag 90980–12575 82824–52050 82824–52050 Assembly) Rear Combination Lamp (LH) Occupant Classification ECU 90980–12357 License Plate Lamp (RH) 90980–11148 90980–11148 Occupant Classification Sensor (Front LH)
Page 280 Memo YARIS (EM01V0U)
Page 281 * The system shown here is an EXAMPLE ONLY. It is different to the HOW TO READ THIS SECTION actual circuit shown in the wiring diagram section. S ta rtin g E n g in e C o n tro l B- R B- R (BAT)
Page 282 [A] : System Title [F] : Junction Block (The number in the circle is the J/B No. and the connector code is shown beside it). [B] : Indicates the wiring color. Junction Blocks are shaded to clearly separate them Wire colors are indicated by an alphabetical code. from other parts.
Page 283: Table Of Contents
SYSTEM INDEX SYSTEMS LOCATION SYSTEMS LOCATION ............17–1 Illumination .
Page 284 ( Cont. next page ) 1 YARIS P o w e r S o u rc e EFI Relay 30A ABS2/VSC2 40A HTR SUB2 20A EFI 10A EFI2 50A EPS 30A HTR SUB1 10A HORN 50A ABS1/VSC1 30A RDI 15A AM2 40A HTR 7.
Page 285 1 YARIS ( Cont' d ) P o w e r S o u rc e T–LP Relay 10A TAIL (∗1) (∗1) (∗1) ∗ 1 : H/B, S/D ∗3 ∗ 2 : Except ∗1 ∗ 3 : Cold Area Spec. , 7.
Page 286 2 YARIS ∗ 1 : A/T S ta rtin g ∗ 2 : M/T (BAT) (BAT) Ignition SW STSW Diode (Starter) Relay STAR Junction Connector Junction Connector Park/Neutral Position SW C1(A), C15(B) Starter Battery (∗1) Junction Connector (∗2)
Page 287 3 YARIS C h a rg in g (BAT) (IG) (IG) ∗ 1 : w/ Daytime Running Light 7. 5A 7. 5A ∗ 2 : w/o Daytime Running Light ALT–S GAUGE (H/B) (S/D) SB(∗1) L(∗1) C9(A), C10(B) Generator Battery IC Regulator...
Page 288 4 YARIS Ig n itio n (BAT) Ignition SW Ignition Coil (No. 1) Ignition Coil (No. 2) Ignition Coil (No. 3) Ignition Coil (No. 4) Relay IGT2 IGT3 IGT4 W–B W–B Engine Control Module < 5–11>...
Page 289 Memo YARIS (EM01V0U)
Page 290 ( Cont. next page ) 5 YARIS E n g in e C o n tro l (BAT) (BAT) (IG) 7. 5A C/OPN Relay Relay Relay Ignition SW...
Page 291 5 YARIS ( Cont' d ) ( Cont. next page ) E n g in e C o n tro l (BAT) (BAT) STOP ETCS Stop Lamp SW A21(A), C20(B) Engine Control Module ST1– STSW STAR ACCR ETHW IGSW # 40 # 30 # 20 # 10...
Page 292 5 YARIS ( Cont' d ) ( Cont. next page ) E n g in e C o n tro l Throttle Body Assembly VTA2 M– A21(A), C20(B) Engine Control Module VCTA VTA1 VTA2 M– GE01 IGT1 IGT2 IGT3 IGT4 IGF1 FAN2 ETHA...
Page 293 5 YARIS ( Cont' d ) ( Cont. next page ) E n g in e C o n tro l C ru is e C o n tro l (BAT) ∗ 1 : w/ Cruise Control Accelerator Position Sensor Relay ID/UP/ MIR HTR...
Page 294 5 YARIS ( Cont' d ) ∗ 2 : S/D M/T w/ Cruise Control E le c tro n ic a lly C o n tro lle d T ra n s m is s io n a n d A /T In d ic a to r ∗...
Page 295 6 YARIS E n g in e Im m o b ilis e r S y s te m (BAT) (IG) 7. 5A 7. 5A ECU–B Transponder Key Amplifier Transponder Key Coil Engine Control Module< 5–8> CODE TXCT AGND D36(A), D37(B) Junction Connector EFIO EFII...
Page 296 7 YARIS D a ta L in k C o n n e c to r 3 (BAT) ∗ 1 : w/ Cruise Control ∗ 2 : w/o Cruise Control 7. 5A OBD2 D34(A), D35(B) Junction Connector CANH CANL Data Link Connector 3 (∗1) D34(A) Junction...
Page 297 8 YARIS M u ltip le x C o m m u n ic a tio n S y s te m ( C A N ) Main Body ECU Power Steering ECU Airbag Sensor Assembly Center CANL CANH CANH CANL CANH CANL...
Page 298 ( Cont. next page ) 9 YARIS H e a d lig h t (BAT) (BAT) (BAT) ∗ 1 : w/ Daytime Running Light ∗ 2 : w/o Daytime Running Light ∗ 3 : w/ H–LP/AMT Relay 7. 5A H–LP RH/ H–LP LH/ ∗...
Page 299 9 YARIS ( Cont' d ) H e a d lig h t ∗ 1 : w/ Daytime Running Light (BAT) (IG) ∗ 3 : w/ H–LP/AMT Relay 7. 5A ECU–B ECU–IG D37(B) Junction Connector Running Light Relay CHG– (∗1 ∗3) P(∗1) BR(∗1)
Page 300 10 YARIS T u rn S ig n a l a n d H a z a rd W a rn in g L ig h t (IG) (BAT) GAUGE Headlamp Dimmer SW Assembly FLASH Relay Main Body ECU < 21–3> (S/D) (H/B) D7(B), D77(A)
Page 301 Memo YARIS (EM01V0U)
Page 302 ( Cont. next page ) 11 YARIS In te rio r L ig h t (BAT) DOME D33(A) Main Body ECU BCTY(H/B) LGCY(S/D) GND1 DCTY BR(S/D) BR(H/B)
Page 303 11 YARIS ( Cont' d ) In te rio r L ig h t ∗ 1 : S/D w/ Tachometer ∗ 2 : S/D w/o Tachometer, H/B (ACC) (BAT) (BAT) (IG) ∗ 3 : S/D ∗5 ∗ 4 : H/B, S/D Except ∗5 ∗...
Page 304 ( Cont. next page ) 12 YARIS T a illig h t a n d Illu m in a tio n (BAT) Fusible Link Block (∗2) (IG) 7. 5A 7. 5A TAIL(∗1) PANEL1 7. 5A T–LP PANEL2(∗2) TAIL Relay (∗1) (∗1) 1 4M ∗...
Page 305 12 YARIS ( Cont' d ) T a illig h t a n d Illu m in a tio n (IG) GAUGE SB(H/B) D38(A), D39(B) Junction R(H/B) Connector R(S/D) ILL+ Junction Connector Light Control Rheostat ILL+ ILL– ILL– Junction Connector...
Page 306 13 YARIS B a c k – U p L ig h t (IG) ∗ 1 : A/T ∗ 2 : M/T GAUGE Back–Up Lamp SW J28(A), J29(B) Junction Connector (∗1) (S/D) (S/D) (H/B) (H/B) (S/D) (S/D) (H/B) (H/B)
Page 307 14 YARIS S to p L ig h t ∗ 1 : S/D LED Type ∗ 2 : S/D Bulb Type (BAT) STOP Stop Lamp SW Engine Control Module< 5–6> (S/D) (H/B) Shift Lock Skid Control ECU Control ECU with Actuator< 17–2> <...
Page 308 15 YARIS F ro n t F o g L ig h t (BAT) ∗ 1 : w/ Daytime Running Light ∗ 2 : w/o Daytime Running Light FR FOG 9 4M Headlamp Dimmer SW Assembly Fog Light Front Fog Light Relay Front (H/B) A24(A), B13(B)
Page 309 16 YARIS K e y R e m in d e r a n d L ig h t R e m in d e r (IG) (BAT) 7. 5A 7. 5A ECU–B D33(A) Main Body ECU BECU CANL CANH GND1 DCTY Illumination I/F...
Page 310 17 YARIS A B S (IG) (IG) (BAT) (BAT) 7. 5A ABS2/ ABS1/ ECU–IG VSC2 VSC1 Junction Connector Speed Sensor (Front LH) Speed Sensor (Front RH) LED Driver FL– FR– Skid Control ECU with Actuator CANL CANH RL– RR– GND1 GND2 CAN Controller CAN I/F...
Page 311 Memo YARIS (EM01V0U)
Page 312 ( Cont. next page ) 18 YARIS S R S (IG) 7. 5A Airbag Sensor (Rear LH) Airbag Sensor (Rear RH) Airbag Sensor Airbag Sensor (Front RH) (Front LH) BCL+ BCL– BCR+ BCR– –SR –SL BCL+ BCL– BCR+ BCR– Side Airbag Sensor (LH) Side Airbag Sensor (RH) BBL+ BBL–...
Page 313 18 YARIS ( Cont' d ) ( Cont. next page ) S R S S e a t B e lt W a rn in g J24(A), U1(B) (IG) (IG) Occupant Classification ECU Taillight and D1(A), D2(B), D76(C) Illumination Combination Meter System<...
Page 314 18 YARIS ( Cont' d ) S e a t B e lt W a rn in g J24(A), U1(B) Occupant Classification ECU (IG) (BAT) 7. 5A 7. 5A ECU–B BGND SVC1 SIG1 SGD1 SVC3 SIG3 SGD3 SVC2 SIG2 SGD2 SVC4 SIG4 SGD4...
Page 315 19 YARIS E P S (IG) (BAT) (IG) 7. 5A ECU–IG c1(D) Power Steering Torque Sensor LED Driver TRQV TRQ1 TRQ2 TRQG CANH CANL PGND CAN Controller A19(A), D31(B), b1(C), c1(D) Power Steering ECU CAN I/F...
Page 316 ( Cont. next page ) 20 YARIS ∗ 1 : w/ Rear Power Window P o w e r W in d o w ∗ 2 : w/o Rear Power Window G1(A), (B) (BAT) (BAT) (IG) Power Window Master SW Fusible 7.
Page 317 20 YARIS ( Cont' d ) P o w e r W in d o w G1(A), (B) Power Window Master SW ∗ 1 : w/ Rear Power Window ∗ 2 : w/o Rear Power Window (∗1) (∗2) Power Window Regulator Power Window Regulator Motor (Rear LH) Motor (Rear RH)
Page 318 ( Cont. next page ) 21 YARIS D o o r L o c k C o n tro l D33(A) (BAT) (BAT) (IG) (ACC) Main Body ECU 7. 5A 7. 5A ECU–B ECU–IG BCTY(H/B) ALTB BECU DCTY PCTY RRCY LGCY(S/D) GND1 TRLY...
Page 319 21 YARIS ( Cont' d ) ( Cont. next page ) ∗ 1 : w/ Rear Power Window ∗ 2 : w/o Rear Power Window D o o r L o c k C o n tro l ∗ 3 : w/ Power Window ∗...
Page 320 21 YARIS ( Cont' d ) W ire le s s D o o r L o c k C o n tro l T h e ft D e te rre n t ∗ 5 : w/ Theft Deterrent System D33(A) Main Body ECU (BAT)
Page 321 22 YARIS F ro n t W ip e r a n d W a s h e r (IG) (IG) Junction Connector D5(A), D6(B) Windshield Wiper SW Assembly Windshield Washer Motor INT1 INT2 MIST Washer SW INT1 INT2 Windshield Wiper Motor Wiper Relay...
Page 322 23 YARIS R e a r W ip e r a n d W a s h e r S h ift L o c k (IG) (IG) (IG) (ACC) D5(A), D6(B) Windshield Wiper SW Assembly Fuse Block RR WIP GAUGE Wash On+Washer...
Page 323 24 YARIS R e m o te C o n tro l M irro r C ig a re tte L ig h te r/P o w e r O u tle t (ACC) (ACC) 7. 5A D34(A), D35(B) Junction Connector Outer Mirror SW Cigarette Lighter or Power Outlet Left...
Page 324 25 YARIS R e a r W in d o w D e fo g g e r H o rn (BAT) (IG) (IG) (BAT) 7. 5A HORN HORN Relay Relay Main Body ECU < 21–8> Junction Connector Noise Filter Rear Window Defogger SW RDEF (H/B)
Page 325 26 YARIS A u d io S y s te m ∗ 1 : H/B 5–Door ∗ 2 : H/B 3–Door (ACC) (BAT) Speaker (Rear LH) Speaker (Rear RH) 7. 5A DOME Speaker (Rear LH) Speaker (Rear RH) Speaker (Rear LH) Speaker (Rear RH) 5 HJ1 Antenna Amplifier...
Page 326 ( Cont. next page ) 27 YARIS ∗ 1 : S/D w/ Tachometer C o m b in a tio n M e te r ∗ 2 : S/D w/o Tachometer, H/B (IG) (BAT) (IG) 7. 5A 7. 5A ECU–IG ECU–B (H/B) D1(A), D2(B), D76(C)
Page 327 27 YARIS ( Cont' d ) C o m b in a tio n M e te r ∗ 1 : S/D w/ Tachometer ∗ 3 : S/D A/T (H/B) D1(A), D2(B), D76(C) Combination Meter (S/D) LED Driver (S/D) (S/D) (H/B) (S/D) Interior Light...
Page 328 28 YARIS C o o lin g F a n (BAT) (IG) ECU–IG FAN NO. 1 FAN NO. 2 Relay Relay Engine Control Module< 5–12> W–B...
Page 329 Memo YARIS (EM01V0U)
Page 330 ( Cont. next page ) 29 YARIS A ir C o n d itio n in g (BAT) (IG) (IG) A/C SW 7. 5A ∗ 1 : w/ PTC Heater GAUGE ∗ 2 : w/o PTC Heater ∗ 3 : w/ Defroster Mode Detection SW ∗...
Page 331 29 YARIS ( Cont' d ) A ir C o n d itio n in g ∗ 1 : w/ PTC Heater (BAT) (BAT) SUB2 SUB1 (∗1) (∗1) SUB2 SUB3 SUB1 Relay Relay Relay W–B E8(A), E9(B) A/C Amplifier (∗1) TX–...

Toyota 2007 YARIS Wiring Diagrams

Quick Links

Need help?

Questions and answers

Related Manuals for Toyota 2007 YARIS

Summary of Contents for Toyota 2007 YARIS

Table of Contents