1. Manuals
  2. Brands
  3. Master Spa Manuals
  4. Hot Tub
  5. Spas
  6. Owner's manual

Master Spa Spas Owner's Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

MASTER SPAS
OWNER'S MANUAL
®

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Spas and is the answer not in the manual?

Questions and answers

Related Manuals for Master Spa Spas

Summary of Contents for Master Spa Spas

  • Page 1 MASTER SPAS OWNER’S MANUAL ®...
  • Page 2 MASTER SPAS OWNER’S MANUAL Welcome To Ultimate Relaxation! Thank you for choosing your new spa built by Master Spas. Please read the entire Owner’s Manual before installing and using your spa. The goal of this manual is to provide you with safety and operational information plus some tips that will help you enjoy your spa to its fullest.

  • Page 3: Table Of Contents

    Wiring Schematic..........................17 Site Preparation / General Guidelines ....................18 Installation Instructions ....................... 19-20 Water Chemistry Terms ........................21-22 Spa Water Maintenance - Legend Series and Down East Spas ECO PUR Information........................23 ™ Water Quality Maintenance Start-Up ....................24 Advantages of ECO PUR ........................

  • Page 4: All Spa Models, Personal Safety

    INTROdUcTION It’s time to relax! You now have your very own portable spa by Master Spas, Inc. By fully understanding the operation of each of the features of your new Master Spa, you will be assured of many years of hassle-free, hot water therapy and fun.

  • Page 5: Important Safety Instructions

    WARNING – For indoor use only. This unit is not intended for outdoor use. (For units intended for outdoor use only) WARNING – For outdoor use only. This unit is not intended for indoor use. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 6: Important Safety

    WARNING – This product is provided with a ground-fault circuit interrupter locat- ed on the front panel of selected swim spas and on the power cord of 120 volt convertible spas. The GFCI must be tested before each use. With the product operating, open the service door.
  • Page 7 Recognize the Need to Exit Spa • Physical Inability to Exit Spa • Fetal Damage in Pregnant Women • Unconsciousness Resulting in a Danger of Drowning DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...
  • Page 8 DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 9: Save These Instructions

    All field installed metal components such as rails, ladders, drains, or other similar hard- ware within 3m of the spa shall be bonded to the equipment grounding bus with cop- per conductors not smaller than 6AWG. Save TheSe INSTRUcTIONS DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...
  • Page 10 NE PAS LAISSER LES ENFANTS UTILISER UNE CUVE DE RELAxATION SANS SURVEILLANCE WaRNINg: DO NOT USE SPAS OR HOT TUBS UNLESS ALL SUCTION GUARDS ARE INSTALLED TO PREVENT BODY AND HAIR ENTRAPMENT. aveRTISSemeNT: POUR éVITER QUE LES CHEVEUx OU UNE PARTIE DU CORPS PUISSENT êTRE ASPIRES, NE PAS UTILISER UNE CUVE DE RELAxATION SI LES GRILLES DI PRISE D’ASPIRATION NE...
  • Page 11 THE USE OF ALCOHOL OR DRUGS CAN GREATLY INCREASE THE RISk OF FATAL HYPERTHERMIA IN HOT TUBS AND SPAS LA CONSOMMATION D’ALCOOL OU DE DROGUE AUGMENTE CONSIDéRABLEMENT LES RISQUES D’HYPERTHERMIE MORTELLE DANS UNE CUVE DE RELAxATION. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 12: Glossary Of Spa Terminology

    1. NecK JeTS 1. NecK JeTS Your new Master Spa features a variety of jet styles. All jets, regardless of style return the water to the spa. Air is mixed with the water by using the air controls (if equipped) creating 2.

  • Page 13: Air Control Valves

    When not in use the air controls should be kept in the closed position, as air bubbles tend to cool the water. NOTE: Only available on Legend Series Spas. Down East Spas automatically inject air.

  • Page 14: Equipment Access Panel

    GLOSSARY OF SPA TERMINOLOGY 9. peRSONaL RemOTe cONTROL The Legend Series spas have additional remotes which allow the user to control the jet therapy while remaining in his/her seat (if applicable). By pressing the control one time, you will activate the pump.

  • Page 15: Spa Light

    NOTE: Slice valves must be completely open during normal operations. NOTE: Legend Series spas are the only models that come with slice valves on all pumps. Slice Valve and Pump Union 19. maIN pUmp This produces water flow through the main jets in the spa. The first pump may be operated on two speeds.

  • Page 16: Glossary Of Spa Terminology

    Your ozonator will operate in conjunction with your filtration system and circulation pump (if applicable). It will deactivate when any other control function is manually activated and will reactivate after one hour of inactivity. The ozonator is standard on all spas. Ozonator 25.

  • Page 17: Electrical Installation Requirements

    6 AWG copper wire and must be connected securely to a grounded metal structure such as a cold water pipe. All Master Spas equipment packs are wired for 240 VAC only. The only electrical supply for your spa must include a 50 AMP switch or circuit breaker to open all non-grounded supply conductors to comply with section 422-20 of the National Electrical Code.

  • Page 18: Wiring Schematic

    GFCI may result in permanent damage to spa system box. Repair / replacement of spa system box is not covered under warranty when damage results from improper wiring. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 19: Site Preparation / General Guidelines

    When possible, it is wise planning for the future to leave access to all sides of the spa in the event your spas plumbing requires maintenance. Your spa warranty does not cover the cost of providing access for service.

  • Page 20: Installation Instructions

    Be sure the jets in your spa are open by turning the face of the jet. Note: The Master Blasters are only turned on/off through the use of the “jets 3” button or the diverter valve (if equipped). DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 21: Installation Instructions

    Due to the nature of water flow and hydro-therapy pumps, please be advised that air locking of pumps may occur. Master Spas has taken measures to reduce the possibility of this, but it still may occur, especially after refilling a spa. This is not a service covered under warranty.

  • Page 22: Water Chemistry Terms

    Total alkalinity is measured in parts per million from 0 to 400 plus, with 80 to 150 ppm being the best range for spas. With low alkalinity, the pH will flip, or change back and forth, and be hard to control. With high alkalinity it becomes extremely difficult to change the pH.

  • Page 23: Water Chemistry Terms

    Always leave spa cover open for 15 minutes after adding chemicals to prevent the off gas from damaging your spa cover, spa pillows and other critical parts. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 24: Eco Pur

    Spa Water Maintenance Legend Series Spas and Down East Spas * All Down East and Legend Series Spas use the ECO PUR filter(s). This section pertains specifically to maintaining water chemistry in spas that have the ECO PUR filters. SpecIaL NOTe ECO PUR™...

  • Page 25: Water Quality Maintenance Start-Up

    * It may be necessary to rinse your filters within the first few days after filling your spa to ensure that they are not restricting water flow due to the initial removal of heavy contaminents in source water. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 26: Advantages Of Eco Pur

    (Do not soak the ECO PUR™ cartridge in filter cleaner.) If water appears to be visually cloudy, dull, or has an odor, shock the spa water with 2 ounces of chlorine to remove excessive containments. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 27: Water Quality Maintenance Schedule-Eco Pur

    * when cleaning filters, be sure to never have the pumps (including the circulation pump) running without the filters in place. Failure to do so may result in debris in the pumps causing unwarranted damage. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 28: Spa Water Maintenance Start-Up

    This is usually one or two drops Do not pour large amounts of defoamer into water. Wait two days, and begin a three day a week maintenance program. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 29: Spa Water Maintenance Schedule

    If necessary, clean water line with a spa general purpose cleaner or enzyme product. Use a defoamer only if necessary. day four Skip (cont. next page) DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...
  • Page 30 That is why only chemicals made for spas should be used. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 31: Water Maintenance Trouble-Shooting Guide

    RecOmmeNded LeveLS Of chemIcaL Chlorine 1.0 - 3.0 ppm pH 7.2 - 7.8 Total Alkalinity 80 - 150 ppm Calcium Hardness 180 - 250 ppm DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 32: Why Chemicals Are Important In A Spa

    Remember: The maintenance routines set forth in this manual may need to be adjusted depending on how much the spa is being used. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 33: Maintenance Recommendations

    • Fill the spa with water. Be sure water level is above skimmer opening to the minimum safe water level label. • Refer to your spas corresponding start-up section with any questions. TO cLeaN yOUR fILTeR eLemeNTS (also reference page 73) The filter in your spa is one of the most important components of your spa.

  • Page 34: Maintenance Recommendations

    You do not want to completely turn jets off. Doing so may cause a build up of stagnant water in the water line if not used often. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 35: Winterizing Your Spa

    Replace access panels. Cover spa to prevent water from entering the spa. * Disclaimer: Master Spas does not recommend winterizing your spa. If you choose to do so, any damage that may result is not covered under the spa warranty.

  • Page 36: Master Spas Legend Series Specifications

    5643lbs LSx1050 94”x 120”x 39” 240V 50A 595 gallons 1055lbs/ 4 pump 6011lbs 94”x 120”x 39” 240V 50A 595 gallons 1115lbs/ 4 pump 1050 STS 6071lbs DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 37: Controls

    If you wish to leave the lights in the same “function” setting for the next use, turn the lights off and do not turn back on for at least 5 seconds. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 38: Setting The Time

    • If you would like to select continuous filtration, set the filter 1 start and end times to be the exact same time. Continued on page 38. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 39: Standby Mode

    (polling) and then to heat the set temperature if needed, depending upon mode. When the low speed turns on automatically, it cannot be deactivated from the panel; however, the high speed may be started. Continued on page 39. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...
  • Page 40 Press the “jets 3” button once to turn pump 3 on or off. If left running, the pump will turn off after 15 minutes. NOTE: Air is injected into Master Blaster jets automatically on all equipped spas. Jets 4 (if equipped) Press the round auxiliary button designated for jets 4 once to turn pump 4 on and off. If left running, the pump will turn off after 15 minutes.
  • Page 41 The TL indicator light will light when the set temperature is locked. To unlock the set temperature, press “Warm” or “Cool” then “Time”, “jets 1” and “Cool.” DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 42: Diagnostic Messages

    Check water level in spa. Refill if necessary. If the water level is okay, make sure the pumps have been primed. Press any button to reset. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 43: Periodic Reminder Messages

    Follow all owner’s manual power connection instructions. Installation must be performed by a licensed electrician and all grounding connections must be properly installed. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 44: Master Spas - Legend Series - Lsx 557 Controls

    Touch the “jets 2” button once to activate the pump. Press the “jets 2” button again to turn off the pump. If left running, the pump will automatically turn off after 15 minutes. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 45: Freeze Protection

    Aux freeze sensor protection acts similarly except with the temperature thresholds determined by the switch and without a 4-minute delay in turnoff. See your dealer for details. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 46: Diagnostic Messages

    “HL” message within 24 hours.) you may press any button to reset. Heater is shut down, but other spa functions continue to run normally. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...
  • Page 47 Follow all owner’s manual power connection instructions. Installation must be performed by a licensed electrician and all grounding connections must be properly installed. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 48: Down East Spas Specifications

    Portsmouth 94”x 94”x 36” 240V 50A 485 gallons 780lbs/ 4 pump 4660lbs East 120”x 94”x 39” 240V 50A 620 gallons 970lbs/ 4 pump Hampton SE 6135lbs DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 49: Down East (3-4 Pump Systems) Controls

    “Warm” or “Cool” pad will continue to either raise or lower the set temperature. After three seconds, the LCD will stop flashing and display the current spa temperature. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 50: Controls

    The equipment stays on until 4 minutes after the sensors detect that the spa temperature has risen to 45°F/7.2°C or higher. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 51: Diagnostic Messages

    Heating capacity of the spa will not reset message within 24 hours.) Heater is automatically; you may press any button to reset. shut down, but other spa functions continue to run normally. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...
  • Page 52 Follow all owner’s manual power connection instructions. Installation must be performed by a licensed electrician and all grounding connections must be properly installed. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 53: Down East (Somerset) Controls

    5 seconds. If you wish to leave the lights in the same “function” setting for the next use, turn the lights off and do not turn back on for at least 5 seconds. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 54: Controls

    Aux freeze sensor protection acts similarly except with the temperature thresholds determined by the switch and without a 4-minute delay in turnoff. See your dealer for details. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 55: Diagnostic Messages

    “HL” message within 24 hours.) Heater you may press any button to reset. is shut down, but other spa functions continue to run normally. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...
  • Page 56 Follow all owner’s manual power connection instructions. Installation must be performed by a licensed electrician and all grounding connections must be properly installed. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 57: Stereo Systems

    Your Max Stereo System is also equipped with a shell mounted auxiliary stereo remote control to easily control most functions of your stereo while inside your spa. NOTE: Shell mounted remote not available on STS models. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...
  • Page 58 NOTE: This unit should be subjected to periodic routine maintenance (for example, once every 3 months) to make sure that the unit is operating correctly. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...
  • Page 59 Note: The television communicates with the wireless remote via IR. Please note that the IR is a line of sight communication method and the range and functionality can be compromised by sunlight and other wireless communications interferences that are not controlled by Master Spas. DO NOT DIVE.
  • Page 60 NOTE: This unit should be subjected to periodic routine maintenance (for example, once every 3 months) to make sure that the unit is operating correctly. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...
  • Page 61 Master Spas. Note: Your new spa’s T.V. lift is tied down with zip ties to prevent damage during shipping.
  • Page 62 98˚ F. If you wish to spend more time in your spa, whether enjoying music, watching tv, or just lounging, be sure to keep the spa water at or below body temperature (98.6˚ F). DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 63: Stereo Systems

    98˚ F. If you wish to spend more time in your spa, whether enjoying music, watching tv, or just lounging, be sure to keep the spa water at or below body temperature (98.6˚ F). DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 64: Dolphin Remote

    DOLPHIN REMOTE Legend Series All STS spas come with a Dolphin Remote Control. This remote uses both radio frequency and infrared signal to control TV, DVD, and Stereo functions. It will also operate the therapy pumps and LED lights. The blower, fiber and opt. 2 buttons are not used.
  • Page 65 NOTE: If utilizing a satellite receiver it is necessary to point the Dolphin Remote directly at the receiver as the RF portion of the Dolphin remote is not programmable. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...
  • Page 66 To lock in the code press the “POWER” button. master Spas device codes kenwood Stereo / 0337 MB Quart DVD-CD-Stereo / 1318 Flat LCD TV / 1868 DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...
  • Page 67 Press the volume up button to start programming. Your TV will now program all available stations into memory. Note: Menu will disappear after 10 seconds. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...
  • Page 68 Select the DVD mode by pressing the mode button. There must be a DVD loaded for the A/V unit to recognize this mode. Press the play button to start the DVD. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 69: Dolphin Remote

    Guide Title Menu Menu menu Exit Exit Audio Display Info DVD Menu ——- Setup Delimiter (.) Enter Enter/Band Function Mode Mode Last CH Last Sub T DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 70: Fusion Docking Station

    The docking station is compatible with the following iPod™ products Nano™ 3G 4G 8G, iPod Touch™ 8G 16G, iPod Classic™ 80G 160G, and iPod™ 5G 30G 60G 80G. Master Spas, Inc. does not guarantee compatibility with all iPod™ products due to software changes and upgrades.

  • Page 71: Fusion Docking Station

    NOTe: This unit should be subjected to periodic routine maintenance (for example, once every 3 months) to make sure that the unit is operating correctly. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 72: Spa Trouble Shooting Guide

    Check that the water level is adequate (up to minimum safe water level side) Make sure the jets are open and the air controls are open. See page 12. Check for dirty filters. Clean if necessary. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 73: Spa Trouble Shooting Guide

    SPA TROUBLE SHOOTING GUIDE Spa NOT heaTINg * If the spas heater has failed, the majority of the time it will trip the GFCI breaker. If the spa is not heating and has not tripped the breaker, please follow these steps: Check the control panel for diagnostic messages.

  • Page 74: Regular Maintenance Procedures

    Some Legend Series and Down East Spas have diverter valves. Due to mineral deposits and grit/sand that may get into the internal parts of the diverter valve, it may become hard to turn or freeze up complete- ly.

  • Page 75: Regular Maintenance Procedures

    You do not want to completely turn jets off. Doing so may cause a build up of stagnant water in the water line if not used often. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 76: Filter Cleaning

    DIRECTLY ON SURFACE OF SPA. PLACE 2”-3” BLOCKS BETWEEN COVER AND SPA. THIS ALLOWS FOR ADEQUATE VENTILATION OF COVER AND SPA. NOTE: The cover warranty is provided through the cover manufacturer and not through Master Spas. You will need to mail the cover warranty back to the cover manufacturer.

  • Page 77: Spa Care And Maintenance Record

    & clean Spa clean filter cartridges change ecO pUR™ element every 180 days Soak filter cartridges in Solution Test gfcI clean and condition Spa cover miscellaneous Service DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...
  • Page 78 Call Us Today : (920) 727 - 1700 SPA CARE AND MAINTENANCE RECORD DATE DATE DATE DATE DATE DATE DATE DATE DATE DATE DATE DATE DATE DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...
  • Page 79 Call Us Today : (920) 727 - 1700 SPA CARE AND MAINTENANCE RECORD DATE DATE DATE DATE DATE DATE DATE DATE DATE DATE DATE DATE DATE DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...
  • Page 80 Call Us Today : (920) 727 - 1700 SPA CARE AND MAINTENANCE RECORD DATE DATE DATE DATE DATE DATE DATE DATE DATE DATE DATE DATE DATE DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

  • Page 81: Master Spas

    Mail completed form with a check for $15.00 to: Master Spas 6601 Lincoln Parkway Fort Wayne, Indiana 46804 Please allow 4 to 8 weeks for delivery. DO NOT DIVE. Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...
  • Page 82 Master Spa Parts Call Us Today : (920) 727 - 1700 Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...
  • Page 83 Master Spa Parts Call Us Today : (920) 727 - 1700 Master Spa Parts 6927 Lincoln Parkway • Fort Wayne IN 46804 (920)727-1700 POP09OWNMAN www.masterspaparts.com Rev. 11/09 Master Spa Parts - 1068 American Drive, Neenah, WI, 54956, USA...

Table of Contents