Fujitsu SCALEOVIEW S17-2 Operating Manual page 43

Periodic Inspections
Recommended
Frequency
Once a month,
after drive-offs,
or as notified
about a potential
leak
New
Installations—
After 50,000
gallons (200,000
liters), or after
one month
MDE-3893P Encore® and Eclipse® Series Owner's Manual · December 2011
Components Recommended Maintenance
Leaks, within 1. Whenever possible, Gilbarco recommends
the lower removing power to the unit before performing
hydraulics these inspections.
cabinet 2. Block the unit area to prevent customers from
operating the unit during inspection.
3. Remove the lower panels slowly and carefully to
avoid any fuel being sprayed in the cabinet
(especially if a drive-off has occurred). Wear eye
protection.
4. Inspect all hydraulic connections and seals,
including the following:
• Meters
• Valves
5. If wetness or dripping fuel is found, stop using the
unit, and make arrangements to repair the leak.
Note: Some staining of parts around seals is
normal and does not indicate a problem.
Look for dripping or wet surfaces.
6. Monitor repaired places closely.
WARNING
To prevent injury when inspecting self-contained
units (equipped with pumps and electric motors), do
not place your hands near the belts, pulleys, or
motors. Do not allow anyone to use either side of the
pump when inspecting. Block the pump/dispenser off
or lock the nozzle to the nozzle hook.
WARNING
If you find a leak, stop using the pump/dispenser, and contact
your local ASC/CSC. Fire, explosion, or electrical shock could
result, if you continue to use a damaged pump/dispenser.
WARNING
Do not attempt to make these repairs yourself. Doing so could
result in severe injury or death.
CAUTION
To prevent potential injury, wear eye protection when
performing these inspections.
Filter change Replace filters, and clean strainers regularly.
and strainer Note: Water alert filters may fail prematurely if water
cleaning passes through them.
Maintaining Units
Who Performs the
Inspection/Repair
• Owner—Inspect
• ASC/CSC only—Repair
and test
CAUTION
CAUTION
CAUTION
Only an ASC/CSC must
perform these tasks.
Page 39