Table of Contents
Advertisement
SCHWINN STINGRAY ELECTRIC
WARNING
• Age range for use: 10 to 16 years of age.
• Maximum loading: 200 lbs.
• NEVER carry a passenger on a StingRay Electric.
Manufactured for Pacific Cycle, Inc.
(A Division of Dorel Industries)
Pacific Cycle, Inc.
4902 Hammersley Road
Madison, WI 53711
800-666-8813
www.schwinnstingray.com
Customer Service/Warranty
• 877-741-6154
• service@pacific-cycle.com
© 2005 Pacific Cycle, Inc.
Made in China
1
Advertisement
Table of Contents
Related Manuals for Schwinn SCHWINN STINGRAY ELECTRIC
Summary of Contents for Schwinn SCHWINN STINGRAY ELECTRIC
- Page 1 • Age range for use: 10 to 16 years of age. • Maximum loading: 200 lbs. • NEVER carry a passenger on a StingRay Electric. Manufactured for Pacific Cycle, Inc. (A Division of Dorel Industries) Pacific Cycle, Inc. 4902 Hammersley Road...
-
Page 2: Table Of Contents
TABLE OF CONTENTS Introduction ..............03-04 Service and Repairs ............05 Charge the Battery ............06-07 Safety Rules ..............08-10 Get to Know Your StingRay Electric ......11-12 Before Every Ride .............13 Care and Maintenance ..........14-21 Cleaning ............14 Tire Maintenance ..........15 Brake Lever and Fuse ........16 Batteries ............17 Replacing the Batteries ........18... -
Page 3: Introduction
WARNING FOR THE SAFETY OF YOUR CHILD, READ ALL WARNINGS AND ASSEMBLY/USE INSTRUCTIONS. KEEP THIS GUIDE FOR FUTURE REFERENCE. • SEVERE INJURY OR DEATH can result if you do not follow the instructions in this manual. • ADULT ASSEMBLY REQUIRED. The product contains small parts, which are for adult assembly ONLY. - Page 4 KEEP THIS MANUAL This manual should be considered a permanent part of the vehicle and should remain with the vehicle when resold or otherwise transferred to a new owner or operator. The manual contains important safety information and instructions which should be read carefully before operating the StingRay Electric. FOR ALL PARTS NOT COVERED IN THIS MANUAL, SEE STINGRAY BICYCLE OWNERS MANUAL.
-
Page 5: Service And Repairs
• Complete and return registration card to validate your warranty (see warranty information on page 22). • If you experience problems, missing parts, or need service repairs for your StingRay Electric, do Call Pacific Cycle Customer Service/ Warranty not return it to the place of purchase. -
Page 6: Charge The Battery
CHARGE THE BATTERY • The StingRay Electric uses two 12-volt DC batteries to supply power to a 250 watt motor. • Charge batteries for 12 hours before use. • Failure to charge battery according to directions will permanently damage battery and void the warranty. - Page 7 WARNING • ONLY ADULTS may charge battery. NEVER allow a child to charge battery. Serious injury could occur. • DO NOT charge battery if you see wear or damage to the battery, connections and wires, charger and its supply cord. •...
-
Page 8: Safety Rules
SAFETY RULES WARNING SEVERE INJURY OR DEATH can result if you do not follow the instructions in this manual. • Age range for use: 10 to 16 years of age. DO NOT allow children younger than 10 years of age to operate the StingRay Electric. - Page 9 • NEVER attempt wheelies, jumps or other stunts. • ALWAYS inspect the StingRay Electric each time it is used to make sure it is in safe operating condition. Refer to "Before Every Ride" and "Care and Maintenance" sections in this manual. •...
- Page 10 • ALWAYS use caution going down hills. ALWAYS use caution when braking while going down hills. Check terrain carefully before you start down any hill. ALWAYS shift weight backward. NEVER go down a hill at the fast speed. DO NOT go down a hill at an angle that would cause the vehicle to lean sharply to one side. Go straight down the hill when possible.
-
Page 11: Get To Know Your Stingray Electric
GET TO KNOW YOUR STINGRAY ELECTRIC Throttle Brake Levers Battery Box Fuse Holder Motor... - Page 12 3 lights 2 lights 1 light below low Throttle Battery Light The Throttle is on the right handlebar. Turn The battery light will glow only when the StingRay throttle forward to make the StingRay Electric Electric is powered up. When battery is fully charged, go forward.
-
Page 13: Before Every Ride
BEFORE EVERY RIDE • An adult should ALWAYS perform the following checklist before every ride, for the safety of your child and to keep the StingRay Electric in good working order. • If you find any damaged or worn parts, DO NOT use the StingRay Electric. Refer to "Service and Repairs"... -
Page 14: Care And Maintenance
CARE AND MAINTENANCE Your StingRay Electric will provide years of fun, if properly cared for and maintained. If you find damaged or worn parts, DO NOT use the StingRay Electric. Refer to "Service and Repairs" on page 5 to order new parts or find an authorized repair center. -
Page 15: Tire Maintenance
TIRE MAINTENANCE WARNING • ONLY an adult can inflate the tires. NEVER allow a child to inflate tires. • ONLY use bicycle pump to inflate tires. DO NOT inflate tires at a gas station, as the greater pressure of the pumps may cause a blowout. Serious injury or death could occur. -
Page 16: Brake Lever And Fuse
BRAKE LEVER WARNING • NEVER allow the StingRay Electric to be used if the brake lever is not functioning properly. • The brake lever may become loose over time. Tighten screw nut connecting brake cable to brake lever. • Squeeze brake lever and make sure the StingRay Electric cannot be pushed forward. Start motor and make sure brake is working properly. -
Page 17: Batteries
BATTERIES READ ALL WARNINGS ABOUT BATTERY SAFETY. ONLY ADULTS MAY RECHARGE OR HANDLE BATTERIES. • The StingRay Electric uses two 12-volt batteries to supply power to a 250-watt motor. • Recharge batteries after each use. When batteries are fully charged, three lights on the StingRay Electric Throttle will glow. -
Page 18: Replacing The Batteries
• Take the exhausted battery to a federally or state-approved lead acid battery recycle center, such as an auto parts store or an authorized repair center. Call Pacific Cycle Customer Service/Warranty at 877-741-6154 or e-mail at service@pacific-cycle.com to find a repair center near you. -
Page 19: Troubleshooting
TROUBLESHOOTING PROBLEM PROBABLE CAUSE WHAT TO DO The StingRay Electric • Batteries are low • Recharge the batteries does not run. • Batteries are dead • Replace the batteries. See page 18. • Fuse has blown • Turn power off, replace fuse. •... - Page 20 PROBLEM PROBABLE CAUSE WHAT TO DO Batteries will not recharge • Charging plug is not plugged in all • Firmly insert plug into outlet. the way into the charging outlet of the StingRay Electric. • Charger is not plugged into the •...
- Page 21 PROBLEM PROBABLE CAUSE WHAT TO DO StingRay Electric runs sluggishly. • Batteries need recharging. • Recharge batteries. See page 7. • Batteries are old. • Replace batteries. See page 18. • StingRay Electric is overloaded. • Maximum weight: 200 lbs. Reduce weight on StingRay Electric.
-
Page 22: Warranty
Schwinn StingRay Electric. This warranty covers normal use only. It does not cover the Schwinn StingRay Electric or batteries if the product has been abused. Damage due to misuse, neglect, accident, improper service or other causes not arising out of defects in materials or workmanship are also not included in the limited warranty.
Need help?
Do you have a question about the SCHWINN STINGRAY ELECTRIC and is the answer not in the manual?
Questions and answers