Table of Contents
Advertisement
Quick Links
FOR YOUR SAFETY
1. Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
2. An LP Tank not connected for use shall
not be stored in the vicinity of this or any
other appliance.
FOR YOUR SAFETY
If You smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, immediately call your
gas supplier or your fire department.
4754960
ASSEMBLY MANUAL
FOR OUTDOOR HOUSEHOLD USE ONLY. DO
NOT USE INDOORS OR FOR COMMERCIAL
COOKING
INSTALLER/ASSEMBLER: Leave these
instructions with consumer.
CONSUMER: Keep this manual for future
reference.
Failure to follow all manufacturer's instructions
could result in serious personal injury and/or
property damage.
Combustion by-products produced when using
this product contain chemicals known to the
State of California to cause cancer, birth
defects, or other reproductive harm.
Read and follow all safety statements, Assembly
Instructions and Use and Care directions before
attempting to assemble and cook.
Some parts may contain sharp edges -
especially as noted in the manual! Wear
protective gloves if necessary.
If you have any questions or need assistance
during assembly, please call 1-800-241-7548.
Visit us on the web at: www.charbroil.com
®
•••
4754960 • 1
Advertisement
Table of Contents
Related Manuals for Char-Broil Patio Caddie 4754960
Summary of Contents for Char-Broil Patio Caddie 4754960
- Page 1 1-800-241-7548. 1. Shut off gas to the appliance. 2. Extinguish any open flame. Visit us on the web at: www.charbroil.com 3. Open lid. 4. If odor continues, immediately call your gas supplier or your fire department. 4754960 • 1...
-
Page 2: Safety Symbols
Never operate grill with LP tank out of correct position. Date Purchased _______________________________ Always close LP tank valve and remove coupling nut before Carton Label # GG ___ ___ ___ ___ ___ ___ moving LP tank from specified operating position. 2 • 4754960... - Page 3 Parts List - Model 4754960 Key Qty -- Description --------------------------------- Part# GG X 4754960 • 3...
-
Page 4: Before Beginning Assembly
The tank must also have the safety cap installed onto the tank valve when not in use, see Use & Care section. Grill Bottom 208 between Leg and Grill Bottom (Finger tighten fully onto screws) (Inside Grill Bottom) Note: Tighten by turning screws only. 4 • 4754960... - Page 5 Leg and Grill Bottom (Finger tighten fully onto screws) To Grill Bottom Base s Wheels face Control Leg away from control leg. Base Repeat assembly Control leg properly attached to base on blank legs. 4754960 • 5...
-
Page 6: Very Important
Control Leg Valve Cover Valve Burner Tube s VERY IMPORTANT: Burner tube must pass through hole in valve cover and engage valve attached to control leg. Burner Tube Valve Valve Control Leg Cover Valve Correct Engagement Cover 6 • 4754960... - Page 7 Be sure Valve Cover is INSIDE Control Leg. beneath grill bottom Rear view of control leg Ignitor Heat Plate Ignitor Wire Round Grill Electrode Bottom Flat End Ignitor Wire View of electrode from beneath grill bottom 4754960 • 7...
- Page 8 Hold coupling nut and regulator as shown for An additional one-half to three quarters turn is proper connection to LP tank valve required to complete connection. Tighten by hand only - do not use tools. Coupling do not use this valve and regulator! Regulator 8 • 4754960...
- Page 9 1. Turn control knob to OFF rushing sound Correct before proceeding. 5. "If growing" • If "growing" bubbles appear do not use or move the LP tank. Contact an LP gas supplier or your fire department. 4754960 • 9...
- Page 10 Grease Clip Feed wire through hole from INSIDE Grill Bottom. Rear View Grease Clip Grease Cup Briquets should be evenly distributed around lowest part of grill bottom. Cooking Grate Briquet (Maximum 16) Grate rests on T- nuts. 10 • 4754960...
- Page 11 Before Your First Cookout • Light burner, check to make sure it is lit, close the lid and warm up grill on HIGH for 15 minutes. Curing of paint and parts will produce an odor only on first lighting. 4754960 • 11...
- Page 12 Troubleshooting if no click is heard. • Store grill indoors ONLY if LP tank is disconnected, removed from grill and stored outdoors. Valve Check • Knob locks in place. To check valve, first 12 • 4754960...
- Page 13 Do not store LP tank in an area where children play. Dealer should fill LP tank more than 80% of LP tank volume. Volume of propane in tank will vary by temperature. A frosty regulator indicates gas overfill. Immediately close LP 4754960 • 13...
-
Page 14: Burner Tube
Bradley Company. Thermos® is a registered trademark of the Thermos Company and its affiliates. Artisan Collection by Char-Broil ™, C3 and Design™, Char-Broil and Design™, Flame Design™, FlavorTents™, Grill 2 Go™, Grillin’ Stick™, Keeper of the Flame™, Keepers of the Flame™, Natural Grip™, Outdoor Cooking Collection and Design™, Patio Bistro™, PrecisionFlame™, Pro-Check™, QuickSet Grills and Design™, SmokerTents™, The Big Easy™, The Minute Grill™, The Edge™, The Tuscan Collection™, and The Urban Grill™... -
Page 15: Troubleshooting
Sudden drop in gas flow or low flame. Flames blow out. "Sudden drop in gas flow" Flare-up. Persistent grease fire. Open lid carefully After grill cools, remove and clean all parts. Flashback... Unable to fill LP tank 4754960 • 15... - Page 16 Cooking times and temperatures may vary according to specific recipes, cooking conditions, or barbecue equipment used. Take this into consideration to insure best results. ITEM SIZE/QUANTITY TEMPERATURE TIME TIPS Food Safety How To Tell If Meat Is Grilled Thoroughly Clean: Separate: Cook: Chill: 16 • 4754960...
Need help?
Do you have a question about the Patio Caddie 4754960 and is the answer not in the manual?
Questions and answers