Table of Contents
Related Manuals for Comfort Line Products CL 250-C
Summary of Contents for Comfort Line Products CL 250-C
- Page 1 Meijer.com Owner’s Manual Models CL 100-C • CL 250-C • CL 250-CSIMW 6’ SPA-N-A-BOX 5’ SPA-N-A-BOX Manufactured by: Comfort Line Products, Inc. 2717 N. Tamiami Trail N. Fort Myers, FL 33903 (888) 997-6366 (239) 997-6366 www.comfortlineproducts.com...
-
Page 2: Warnings / Avertissements
Meijer.com User’s Guide WARNINGS / AVERTISSEMENTS WARNING: CHILDREN SHOULD AVERTISSEMENT: NE LAISSEZ NOT USE SPAS OR HOT TUBS PAS LES ENFANTS UTILISER UN WITHOUT ADULT SUPERVISION. SPA OU UNE CUVE THERMALE SANS LA SUPERVISION D’UN ADULTE. WARNING: DO NOT USE AVERTISSEMENT: POUR ÉVITER SPAS OR HOT TUBS UNLESS QUE LES CHEVEUX OU UNE... - Page 3 Meijer.com Comfort Line Products, Inc. WARNINGS / AVERTISSEMENTS WARNING: PREGNANT AVERTISSEMENT: LES FEMMES OR POSSIBLY PREGNANT ENCEINTES, QUE LEUR WOMEN SHOULD CONSULT A GROSSESSE SOIT CONFIRMÉE PHYSICIAN BEFORE USING A SPA OU NON, DEVRAIENT OR HOT TUB. CONSULTER UN MÉDECIN AVANT D’UTILISER UN SPA OU...
-
Page 4: Important Safety Instructions
Meijer.com User’s Guide U.L. AND E.T.L. SAFETY INSTRUCTIONS The following instructions are required to be printed by Underwriters Laboratory (U.L.) as well as ETL Testing Laboratories, Inc. as a condition of their listing of this product. They contain important safety information, and we strongly encourage you to read and apply them. - Page 5 Meijer.com Comfort Line Products, Inc. pipe, or conduit within 5 feet (1.5m) of the unit as needed to comply with local requirements. 8. This appliance is provided with a ground-fault circuit interrupter (located near the end of the power supply and with the unit operating, push the test button.
-
Page 6: Additional Warnings
Meijer.com User’s Guide D. WARNING!! The use of alcohol, drugs or medication before or during spa or hot tub use can greatly increase the risk of fatal hypothermia. Hypothermia occurs when the internal temperature of the body reaches a level several degrees above the normal body temperature of 98.6°. - Page 7 Meijer.com Comfort Line Products, Inc. 3. Always operate spa with sufficient water. Water level must be above filter. Insufficient water will cause pump failure and void warranty. 4. Maintain proper water PH (7.4 - 7.6 is ideal). Failure to do so may cause damage to vinyl liner, pump seals, heater element, and damage will not be covered by warranty.
- Page 8 Meijer.com User’s Guide...
-
Page 9: Installation Instructions
Meijer.com Comfort Line Products, Inc. INSTALLATION INSTRUCTIONS SITE PREPARATION A. Structure: Your spa should always be installed on a structurally sound, relatively smooth and level surface. B. Electrical: The installation should be a grounded 120 volt outlet within 8 feet of the spa and allow for easy access to the cord mounted GFCI for periodic testing. -
Page 10: Outdoor Installation
Meijer.com User’s Guide OUTDOOR INSTALLATION Your spa may be installed on any level, smooth surface that is strong enough to support the filled unit. Observe the following considerations when deciding where to place your spa: 1. Make sure there are no sharp objects under the spa. 2. -
Page 11: Package Contents
Meijer.com Comfort Line Products, Inc. PACKAGE CONTENTS Refer to the following picture and product checklist to verify that all parts of the spa have been received and are undamaged. Report and missing or damaged parts immediately. 1. Air Loop 7. Top Spa Cover 2. - Page 12 Meijer.com User’s Guide SPA ASSEMBLY 1. Take all parts out of the box. Compare items with package contents diagram on previous page 2. Start with the panel that has 3 large Snap holes - hold with arrow pointing up Slide the Lock and arrow on the inside spa wall.
- Page 13 Meijer.com Comfort Line Products, Inc. 3. Place two (2) pieces of bottom foam inside of the spa. Use three (3) pieces of foam for 6’ model. 4. Remove label(s) from liner-to- powerpack union nut. 5. Place the liner inside the spa.
- Page 14 Meijer.com User’s Guide 7. Connect the inflation hose to the blower exhaust fitting on the top ��� ���� ��� of the power pack. Insert the key lock pin into the inflation hose fitting on the top of the power pack. The key lock pin must be inserted into the adapter of the inflation hose fitting when inflating.
- Page 15 Meijer.com Comfort Line Products, Inc. 10. Line up the water connections on the back of the power pack with the fittings on the side of the spa. 11. Attach the bottom, large fitting on the back of the power pack to the corresponding fitting on the spa, being careful not to cross-thread the fitting.
-
Page 16: Filling The Spa
Meijer.com User’s Guide FILLING THE SPA 1. Ensure that the power pack is not plugged in. 2. Remove the protective caps from the suction and discharge fittings inside the spa. Place the caps in a safe location. 3. Using a garden hose, fill the spa with approximately 1/2 inch of water. - Page 17 Meijer.com Comfort Line Products, Inc. 4. Bleed the air from the filter tank by turning the small black knob on the top of the filter tank counterclockwise. Allow the filter tank to bleed for approximately one minute, or until water drips from the fitting. Turn the fitting clock-wise to close the bleed...
- Page 18 Meijer.com User’s Guide 7. Place the top cover over the spa and line up the eight cover locks. Always supervise children around bodies of water. The spa cover is not a safety cover. The spa cover is not a substitute for adult supervision. 8.
-
Page 19: Operation
Meijer.com Comfort Line Products, Inc. OPERATION • Test the GFCI before each use. (Refer to the instructions provided in the Maintenance section of this manual.) • Plug into a properly grounded receptacle. • Do not use extension cords. Temperature Control 1. -
Page 20: Turbo Operation
Meijer.com User’s Guide Turbo Operation To turn the turbo wave pump on or off, push the on/off button. Look to see if the spa blows bubbles uniformly all the way around the spa. The turbo wave pump will automatically shut off after 15 minutes of operation. -
Page 21: Maintenance
Meijer.com Comfort Line Products, Inc. MAINTENANCE Vinyl Care - Interior 1. Empty the spa and refill with clean water every 3 months or when it becomes cloudy and proper water chemistry does not clear it up. 2. While empty, use a mild soap solution to wipe away any soil or stains on the inner liner. - Page 22 Meijer.com User’s Guide Recommended Chemical Balances PH: 7.4 - 7.6 Total alkalinity: 80 - 120 ppm Calcium hardness: 150 - 250 ppm Bromine residual: 2 - 3 ppm Total dissolved solids below 1,500 ppm Purchase a test kit from your dealer and test you water chemistry after each use of the spa, but no less than once per week.
- Page 23 Meijer.com Comfort Line Products, Inc. to ensure mixing. If you do not premix your chemicals, you may damage your vinyl surfaces and void your warranty. 4. Do not use gas chlorination, chlorine tablets, ionizers, scents, salts or soaps without consulting with your dealer.
-
Page 24: Cleaning The Filter
Meijer.com User’s Guide Cleaning the Filter 1. Unplug the power pack from the electrical outlet. 2. Using the three caps provided, cap the suction and discharge fittings on the inside of the spa. 3. Open the air bleed fitting on the top of the filter tank. - Page 25 Meijer.com Comfort Line Products, Inc. GFCI (120 volt units only) The GFCI, or Ground Fault Circuit Interrupt, fitting on the power pack electrical cord should be tested monthly. There are no user serviceable parts inside the GFCI. Do not open the GFCI as this will void your warranty.
-
Page 26: Service And Troubleshooting
Meijer.com User’s Guide SERVICE & TROUBLE SHOOTING Your spa was designed to minimize service requirements. If trouble should arise, carefully go through the steps in the following steps on trouble shooting. If you still experience a problem, call the dealer or the manufacturer. - Page 27 Meijer.com Comfort Line Products, Inc. Heater Problems Symptom Solution No heat 1. This may be caused by a dirty filter: Clean the filter per the instructions provided in the Maintenance section of this manual. If the filter is more than two months old, replace it. After cleaning or replacing the filter, cover the spa, turn...
- Page 28 Meijer.com User’s Guide Heater Problems No heat and 1. In some situations, the numerical temperature temperature display may read ‘OH’ (overheat) and the spa will display of ‘OH’ not heat until reset. To fix this problem, please use the following procedure: A.
-
Page 29: Specifications
Meijer.com Comfort Line Products, Inc. SPECIFICATIONS MODEL CL 250-C / 250-CSIMW SPA-N-A-BOX 6’ Capacity : Seating: 1-5 adults Water: 280 gallons Outside Dimensions : 73 ½ inches (flat side to flat side) Inside Dimensions : 64 ½ inches Height : 27 inches with cover... - Page 30 Meijer.com User’s Guide SPECIFICATIONS MODEL CL 100-C SPA-N-A-BOX 5’ Capacity : Seating: 1-3 adults Water: 170 gallons Outside Dimensions : 58 ½ inches (flat side to flat side) Inside Dimensions : 50 ½ inches Height : 24 inches with cover Number of Jets : 1 return jet Over 100 air jets Power Pack : 1 HP turbo blower...
- Page 31 Meijer.com Comfort Line Products, Inc. Comfort Line Products, Inc. Limited Warranty ~ TERMS & CONDITIONS This warranty extends to the original purchaser only.The warranty period commences on the original purchase date through 12 months.This warranty is not transferable to subsequent purchasers.This warranty is subject to the obligations, limitations, and exclusions listed below.
- Page 32 Meijer.com User’s Guide OWNER’S RECORD Date Purchased _________________________________________ Purchased From ________________________________________ Sales / Rep. / Contact ____________________________________ Address _______________________________________________ Telephone _____________________________________________ Serial # _______________________________________________ Model # ______________________________________________...
Need help?
Do you have a question about the CL 250-C and is the answer not in the manual?
Questions and answers