Mclane 20" Owner's Handbook Manual

Front throw reel front

Advertisement

2
3
4-6
7-10
12-14
13-14
11
r
Safety Rules
Front Throw Reel Mower
Features
Assembly
Instructions
Operation
and Maintenance
Lawn Mower
Parts Illustration
Lawn Mower Parts List
Trouble Shooting
I!
z
7110 East Rosecrans
Ave.
_
Paramount, CA 90723
_
Telephone
(562) 633:815,8 (213),636-833._ j

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 20" and is the answer not in the manual?

Questions and answers

Oscar Gamez
April 4, 2025

how can l replace a tire on this mower

Summary of Contents for Mclane 20"

  • Page 1 Safety Rules Front Throw Reel Mower Features Assembly Instructions 7-10 Operation and Maintenance 12-14 Lawn Mower Parts Illustration 13-14 Lawn Mower Parts List Trouble Shooting 7110 East Rosecrans Ave. Paramount, CA 90723 Telephone (562) 633:815,8 (213),636-833._ j...
  • Page 2 Checkgrass catcherfrequently for wear or deterioration. TWO YEAR LIMITED WARRANTY For two years from purchase (80 days for commemlal use) McLane Manufacturing tno, will replace for the original purchaser, free of charge, any part or parts, found upon examiner+on by any factory authorize...
  • Page 3 Hotice to customers in the State of California. The Manual Drive Lever engine on this units is not equipped with a spark Throttle arresting muffler. USEOROPERATION OFTHIS ENGINEON AW_' F ORESTCOVERED, B RUSH COVERED_ OR GRASS COVEREDLAND WITHOUTA STATE APPROVED Engine Clutch Lever SPARK ARRESTORIN EFFECTIVEWORKING ORDER CONSTITUTESA...
  • Page 4 ASSEMBLY TOOLS REQUIRED: 7/'16" Wrench, Pliers, Screwdriver (11/16" Wrench needed to adjust Clutch Tension) NOTE; Reference to left or right side Assemble the clutch control rod by D Refer to the operation instruc- of the mower is from operator's inserting the short rod bent end in the tions before using mower..
  • Page 5 ASSEMBLY RGURE 4: Installthe Wheel Drive Control rod on top and insert RGURE 7: Put the bentend ofthe rodthroughthe hole of the dr_¢e dt_ch lever. cotter pin.Then, open itsbottom to secureiyfastenit, INSTALUNGTHROTTLE CONTROL: 1. One end of the throt_econtrolis factory installedto the carburetor,, The other end needs to be installed in the t_3per handle_ 2_ Takehold of the control feverat the other end of the cableand...
  • Page 6 ASSEMBLY THROTTLE CONTROL ASSEMBLY: FUEL AND OIL 3, See Fig 11: Une the completeknob and 1o See Fig,9:When theknob is throughthe controlbody unitwith the panel slot.Use NOTE:Engineis shippedWITHOUToil.Use handle panel, straighten the throttle bothhandsand pushthecontrolbodyunit a high quality detergent oil dashed 'for cable so the throttlecontrol body can be intothe panelslo! unfititlocksin place,...
  • Page 7 B, Remove side plate chain-Nor 21 C. Remove clutch drive chain-No/15 and add (2) chain links° They can be purchased from the factory or McLane Service Center,, Part Noo5016 Figure 13 D. Remove (8) retainer bolts-No_12 E,_Loosen (8) hanger bolts-No,, 13...
  • Page 8 OPERATION HOW TO USE THE CONTROLS AND CAUllON; To avoid possible damage to front wheels do not start WHAT THE CONTROLS DO mower before setting height adjustment Notchedheight bracketat 1. From the operators pos_onwhich is behind the lawn mower, right front of mower (Fig, 14) must be placed at desired cutting heightposition.
  • Page 9 MARNTENANCE GENERAL RECOMMENDATION LUBRICATION 3. Clean bylapping gently on a flat surface. 1. The spark plug and air filter should be tfvery dirty,replacecartridgeor clean as Check oil level regularly. Oil all exposed follows: replaced once a year, This will assure bearings,linage and front wheels.Oil chain better engine performance and longer a.
  • Page 10 SERVICE AND ADJUSTMENTS TO ADJUST CHOKE CONTROLS: CLUTCH BELT MAINTENANCE: NOTE: The deam:mcemust be checked Refer to engine manual for detailed 1. Inspect dutch beltfrequency forwear and adjustment made when the dutch is instnJc_ons. and damage.Wornand damaged engaged and _here is tension on the bee beltscancausethe dutch to operate (Lift dutch lever to the handle to engage REPLACE AIR CLEANER.
  • Page 11 TROUBLE SHOOTnNG CHART PROBLEM CAUSE Engine fails to start. Check fuel tank for gas,, Spark plug lead wire disconnected. Throttle control lever not in starting posttion_ Check spark plug_ Carburetor improperly adjusted. Engine flooded, Remove spark plug, dry the plug, crank engine with plug removed, and throttle in off position,, Replace spark plug and lead wire and resume starting procedures Old/stale gas.
  • Page 12 Front Throw Reea Mower o 20" IVlodeas o Repair Parts _6 23 &...
  • Page 13 McLane Models Front Throw ReeMMower Repair Parts 20" RER PART RER PART DESCRIPTION DESCRIPTION 1001-A Handle 1033 "5/16" - 18 x 1/2" Bolts 7015-A Shoulder Bolt for Handle t060-B Clutch Belt 1003 1061 Belt Guard Handle Grips (2 req,,) 1004...
  • Page 14 NicLane Front Throw ReeW Mower Repair Parts 20" Models (Continued) REFo PART REF. PART DESCRIPTION DESCRIPTION 1108 ! 120 Flat Washer Reel Bearings (2 req,) 1109 1121 "7/16" -, t4 x 3-1/4" Bolt Reel Bearing Retainer 1033 1122 Plastic Grass Catcher "5/16"...
  • Page 15 STORAGE MOWER: IMPORTANT: 1T IS IMPORTANT TO PREVENT GUM DEPOSITS o Clean all debris off mower and engine with a rag or brush.. FROM FORMING IN ESSENTIAL FUEL SYSTEM PARTS SUCH AS THE CARBURETOR, FUEL FILTER, * Do not use water. FUEL HOSE, OR TANK DURING STORAGE..
  • Page 16 NOTES--. MAINTENANCE RECORD...

This manual is also suitable for:

25"

Table of Contents

Save PDF