Nokia C5-06 RM-816 Service Manual Level 1&2 Table of contents COPYRIGHT....................................4 WARNINGS AND CAUTIONS ..............................5 .................................... 5 ARNINGS ....................................5 AUTI ONS ESD PROTECTION ..................................6 CARE AND MAINTENANCE ..............................7 BATTERY INFORMATION ............................... 8 EXPLODED VIEW..................................9 SERVICE DEVICES ...................................
Page 3
Nokia C5-06 RM-816 Service Manual Level 1&2 CHANGE HISTORY Status Version No. Date Comments Approved 07.10.2011 First approved version The purpose of this document is to help NOKIA service levels 1 and 2 workshop technicians to carry out service to NOKIA products. This Service Manual is to be used only by authorized NOKIA service suppliers, and the content of it is confidential.
Nokia C5-06 RM-816 Service Manual Level 1&2 2. WARNINGS AND CAUTIONS Please refer to the phone’s user guide for instructions relating to operation, care and maintenance including important safety information. Note also the following: Warnings 1. CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH ELECTRONIC ENGINE MANAGEMENT SYSTEMS AND ANTI–SKID BRAKING SYSTEMS.
Nokia C5-06 RM-816 Service Manual Level 1&2 3. ESD PROTECTION Nokia requires that service points have sufficient ESD protection (against static electricity) when servicing the phone. Any product of which the covers are removed must be handled with ESD protection. The SIM card can be replaced without ESD protection if the product is otherwise ready for use.
Nokia C5-06 RM-816 Service Manual Level 1&2 4. CARE AND MAINTENANCE This product is of superior design and craftsmanship and should be treated with care. The suggestions below will help you to fulfil any warranty obligations and to enjoy this product for many years.
Nokia C5-06 RM-816 Service Manual Level 1&2 5. BATTERY INFORMATION Note: A new battery’s full performance is achieved only after two or three complete charge and discharge cycles! The battery can be charged and discharged hundreds of times but it will eventually wear out.
Nokia C5-06 RM-816 Service Manual Level 1&2 7. SERVICE DEVICES CA-101D BL-4U Battery AC-10 Travel Charger Nokia Standard Toolkit (v2) For more information, refer to the Service Bulletin (SB-011) on Nokia Online. Supplier or manufacturer contacts for tool re-order can be SS-88 Camera Removal tool found in “Recommended service...
Nokia C5-06 RM-816 Service Manual Level 1&2 9. DISASSEMBLY INSTRUCTIONS 1. Nokia C5-06 disassembly. 2. For disassembling you need the Nokia Standard Toolkit version 2, the camera removal tool SS-88 and an AV plug. 3. Protect the TOUCH PANEL with protective film.
Page 13
Nokia C5-06 RM-816 Service Manual Level 1&2 7. If there is a MicroSD card inserted, remove it also. 8. Use the SS-93 to detach the shown clip of the BOTTOM CAP. 9. Repeat the procedure on the other side. 10. Remove the BOTTOM CAP. Do not use it again.
Page 14
Nokia C5-06 RM-816 Service Manual Level 1&2 13. Detach also the clips on the other side, as shown. 14. Lift the FRONT COVER ASSEMBLY from the bottom side as shown. 15. Hold the FRONT COVER ASSEMBLY as shown. Be 16. Disconnect the TOUCH PANEL connector with the careful not to damage the flexes.
Page 15
Nokia C5-06 RM-816 Service Manual Level 1&2 19. Use the SS-93 to carefully detach the DISPLAY 20. Lift the DISPLAY away from the FRONT COVER from all sides. ASSEMBLY. 21. Protect the DISPLAY with protective film. 22. Protect also the TOUCH PANEL from the inside with protective film.
Page 16
Nokia C5-06 RM-816 Service Manual Level 1&2 25. Use the SS-93 to open the first ENGINE BOARD 26. Repeat the procedure on the second clip. clip. Be careful not to damage any nearby components. 27. Lift the ENGINE BOARD from the detached side to 28.
Page 17
Nokia C5-06 RM-816 Service Manual Level 1&2 31. Carefully bend the shown side of the CHASSIS and 32. Lift up the ANTENNA MODULE ASSEMBLY from the push the ANTENNA MODULE ASSEMBLY up from the other side and remove it. back side.
Nokia C5-06 RM-816 Service Manual Level 1&2 10. ASSEMBLY 1. Nokia C5-06 assembly. 2. For assembling you need the Nokia Standard Toolkit version 2. 3. Remove the protective film from the EARPIECE 4. Place the EARPICE ADHESIVE to its place with the ADHESIVE.
Page 20
Nokia C5-06 RM-816 Service Manual Level 1&2 7. Place the AV JACK with the tweezers to its place 8. Place the ANTENNA MODULE with the tweezers. and push it down with the SS-93 to lock it in its place. 9. Press the ANTENNA MODULE down from the 10.
Page 21
Nokia C5-06 RM-816 Service Manual Level 1&2 13.Carefully press it down from the shown places 14. Remove the protective films from the DISPLAY and to lock it up. the FRONT COVER. Place the DISPLAY to the FRONT COVER and make sure that it is correctly aligned.