Table of Contents
Advertisement
ASSEMBLY & OPERATING INSTRUCTIONS
This safety alert symbol identifies important safety messages in this manual.
Failure to follow this important safety information may result in serious injury
or death.
LS125-810-0310
Rev. 2
MODEL NO.
1032822 & 1032830
Owner's Manual
VERTICAL/HORIZONTAL
22 TON LOG SPLITTER
Advertisement
Table of Contents
Related Manuals for Huskee 1032822
Summary of Contents for Huskee 1032822
- Page 1 VERTICAL/HORIZONTAL 22 TON LOG SPLITTER MODEL NO. 1032822 & 1032830 Owner’s Manual ASSEMBLY & OPERATING INSTRUCTIONS This safety alert symbol identifies important safety messages in this manual. Failure to follow this important safety information may result in serious injury or death.
-
Page 2: Table Of Contents
Table of Contents Page(s) Important Safety Information......................... Intended Use ......................... Personal Protective Equipment ....................Safety Decals ........................General Safety ........................Preparation of the Log ......................Work Area ........................... Operation of the Log Splitter ....................Repair and Maintenance Safety ..................... Hydraulic Safety ........................Fire Prevention ........................ -
Page 3: Important Safety Information
WARNING: Read and thoroughly understand all instructions and safety information before assem- bling or operating this log splitter. Failure to do so may cause serious injury or death. Do not allow anyone to operate this log splitter who has not read this manual. As with all power equipment, a log splitter can be dangerous if assembled or used improperly. - Page 4 PART NUMBER: 52055200 LOCATION: BOTH STRIPPER PLATES AND CYLINDER PART NUMBER: 52023200 LOCATION: HYDRAULIC TANK LOWER TANK, RIGHT CORNER PART NUMBER: 51018900 LOCATION: TOP OF HYDRAULIC CYLINDER Page 2...
-
Page 5: General Safety
GENERAL SAFETY Failure to follow these instructions may result in serious injury or death. ALWAYSEread the operator’s manual before operation. It is located in the plastic canister on the tongue. EVER NEVER allow children to operate this log splitter. NEVER allow adults lacking proper instructions and understanding to operate this log splitter. -
Page 6: Repair And Maintenance Safety
KNOW how to stop the log splitter and disengage the controls before operating it. NEVER place hands or feet between the log and splitting wedge during forward or reverse stroke. Serious injury or death could result. NEVER straddle or step over the log splitter during operation. NEVER reach or bend over the log splitter to pick up a log. -
Page 7: Hydraulic Safety
HYDRAULIC SAFETY The hydraulic system of your log splitter requires careful inspection along with the mechanical parts. Be sure to replace frayed, kinked, cracked or otherwise damaged hydraulic hoses or hydraulic components. NEVER check for leaks of hydraulic fluid with your hand. Fluid escaping from a small hole can be almost invisible. Escaping fluid under pressure can have sufficient force to penetrate skin causing serious personal injury or even death. -
Page 8: Towing Safety
IMPORTANT NOTE: This log splitter is equipped with an internal combustion engine and should not be used on or near any unimproved forest-covered, brush-covered or grass-covered land unless the engine’s exhaust system is equipped with a spark ar- rester meeting applicable local or state laws (if any). If a spark arrester is used, it should be maintained in efffective working order by the operator. -
Page 9: Assembly Instructions
ASSEMBLY INSTRUCTIONS 401613R0 Beam Assembly 401102R22 Tank/Engine Assembly 401102RC22 Tank/Engine Assembly (CA) 400312B0 Tire and Wheel assembly 40126300 Tongue Assembly 40115500 Hardware Kit NOTE: This log splitter was partially assembled at the factory. Refer to the drawing and parts list should it become necessary to disassemble the unit for repair or replacement of parts. - Page 10 STEP 3: Attach the tongue assembly (5) to the tank assembly (4) using two 1/2” NC x 4-1/2” hex cap bolts (1), two 1/2” lock washers (2) and two and two 1/2” hex nuts. Tighten. (3).Tighten. ITEM NO PART NO. DESCRIPTION QTY.
-
Page 11: Parts Breakdown Illustrations
STEP 5: Connect the end of the 1/2” ID x 44” hydraulic pressure hose (1) coming from the fitting on the pump to the fitting on the valve . See illustrations below. STEP 6: Slide one hose clamp on the end of the 3/4” x 44” hydraulic return hose (3) that comes from the fitting on the filter. -
Page 12: Beam Assembly Breakdown
BEAM ASSEMBLY BREAKDOWN ITEM NO. PART NO. DESCRIPTION QTY. 1/2” X 3-1/4” GR 5 Hex Cap Bolt 1/2” Regular Lock Washer 1/2” Hex Nut 401414R0 Beam 40141700 Wedge 390118BC 4” Cylinder 07073100 Cylinder Pin 390406SC Valve 39034700 1/2” Pipe to Steel To Steel Tube 39034300 1/2”... -
Page 13: Operating Instructions
OPERATING INSTRUCTIONS WARNING: Read and thoroughly understand all instructions and safety information before operating this log splitter. Failure to do so may cause serious injury or death. Do not allow anyone to operate this log splitter who has not read this manual. As with all power equipment, a log splitter can be dangerous if assembled or used improperly. -
Page 14: Operation
NOTE: The engine maximum governed speed is preset at the factory at 3600 RPM no load speed. When splitting wood the throttle should be set at the maximum speed to develop the horsepower required for the pump. OPERATION WARNING: See safety information related to operation of the log splitter on page 3 and 4 of this manual. Make sure that you have the recommended personal protective equipment described on page 1. -
Page 15: Notes/Warranty Information
IMPORTANT NOTICE We, the manufacturer, reserve the right to change the product and/or specifications in this manual without notification. The manual is for information usage only and the pictures and drawings depicted herein are for reference only. NOTES Warranty Repair and Service Do not return this product to the store for warranty issues or repair. -
Page 16: Specifications
SPECIFICATIONS & & " " " " " " " " " " " Note: Huskee log splitters are manufactured by Special Products Co. Part No. 53011900...
Need help?
Do you have a question about the 1032822 and is the answer not in the manual?
Questions and answers
To need Manuel for 22Ton Huskee log splitter
The manual for the 22-ton Huskee log splitter with part number 1032822 is referenced in the provided context. It contains specifications, operating instructions, and accessory details.
This answer is automatically generated