Table of Contents
Advertisement
Operating & Installation Manual
Stratford Tf & Ti
Multifuel Boiler Stoves
Stratford Tf 70 Boiler Stove
(With optional stand)
PLEASE RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE
Aarrow Fires Ltd
Rev 5
The Fireworks
June 2004
Bridport
Part No:AFS1121
Dorset, DT6 3BE
Great Britain
Tel. (44) 01308 427234
Fax. (44) 01308 427441
www.aarrowfires.com
Advertisement
Table of Contents
Related Manuals for Aarrow Stratford Tf
Summary of Contents for Aarrow Stratford Tf
- Page 1 Operating & Installation Manual Stratford Tf & Ti Multifuel Boiler Stoves Stratford Tf 70 Boiler Stove (With optional stand) PLEASE RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE Aarrow Fires Ltd Rev 5 The Fireworks June 2004 Bridport Part No:AFS1121 Dorset, DT6 3BE Great Britain Tel.
- Page 2 Technical support department on 01308 427234 © COPYRIGHT 2003 Aarrow Fires Ltd This booklet has copyright & may not be copied in whole or part used for any purpose other than that for which it is supplied without express written consent from Aarrow Fires Ltd.
-
Page 3: Table Of Contents
Fuel Types Lighting The Fire Solid Fuel Burning Overnight Burning Over Firing Cleaning Accessories Maintenance Stratford Tf & Ti Multifuel Boiler Stoves Page INSTALLATION General Precautions Combustible Materials Multifuel Grate & Grate Bars Throat Plate Inspection Flue Outlet and Hotplate... - Page 4 APPLIANCE GUARANTEE IF IN DOUBT CONTACT THE SOLID FUEL ASSOCIATION TELEPHONE NUMBER 0800 600 000 www.solidfuel.co.uk THE USE OF SPARE PARTS OTHER THAN THOSE SUPPLIED BY AARROW FIRES LTD WILL INVALIDATE THE APPLIANCE GUARANTEE. Stratford Tf & Ti Multifuel Boiler Stoves...
-
Page 5: Introduction
Aarrow Fires are also fitted with an "air wash" so called because it provides a curtain of high speed preheated air behind the glass to help keep it clean and to provide secondary air/over draught. -
Page 6: Check List
8. Fire bed supports 9. Fire door handle 10. Instructions Stratford Stratford Tf 30b Tf 50b 1(5”) 1(5”) 1(5”) 1(5”) Stratford Stratford Stratford Tf 70b Tf 90b Ti 40b 1(6”) 1(6”) 1(6”) 1(6”) Stratford Tf & Ti Multifuel Boiler Stoves... -
Page 7: Technical Data
Width (mm) Depth (mm) Height to centre of rear flue Depth from back to centre of flue Flue diameter Weight packed (Kg) *1kW = 3420 BTU’s Stratford Tf & Ti Multifuel Boiler Stoves Stratford Stratford Tf 50b Tf 30b 6,840 8,550... -
Page 8: Operating Instructions
Stratford Tf and Ti with the ash door fully shut, the settings range from 0 (fully anti-clockwise) a shut-off setting at which the damper will shut off... -
Page 9: Interlock System
INTERLOCK SYSTEM Stratford Tf and Ti Multifuel Boiler Stoves are fitted with an "interlock" system. A situation where the fire door is closed and the ash door is open may lead to serious overfiring which could damage the appliance. Correct use of the doors and interlock system will ensure that this does not happen. -
Page 10: Door Adjustments
The bars are symmetrical and of even lengths making incorrect fitting impossible. Note: This operation should only be carried out when the appliance is unlit and cold. Stratford Tf & Ti Multifuel Boiler Stoves Fig. 7... -
Page 11: Fuel Types
Taybrite, Sunbrite (Doubles/Singles), Anthracite (Large Nuts), and Welsh Dry Steam Coal (Large/Small Nuts). Stratford Tf & Ti Multifuel Boiler Stoves OPERATING INSTRUCTIONS Approval does not cover the use of other fuels either alone or mixed with the suitable fuels listed above, nor does it cover instructions for the use of other fuels.For latest details please refer to Hetas... -
Page 12: Solid Fuel Burning
•Check for flue or chimney blockage, and clean if required. Seek expert advice from your HETAS registered installer. Do not attempt to re-light the fire until the cause of the fume emission has been identified and corrected. Stratford Tf & Ti Multifuel Boiler Stoves... -
Page 13: Over Firing
Should a chimney fire occur immediately close the appliance down. Get everyone out of the house and call the fire Stratford Tf & Ti Multifuel Boiler Stoves OPERATING INSTRUCTIONS brigade. A chimney fire may cause structural damage of the chimney. -
Page 14: Maintenance
•Burn slowly for the first four hours, then build up heat gradually to cure the paint. Note: Use only genuine Aarrow touch-up spray as some paints interact. This could ruin the finish and invalidate the guarantee. Stratford Tf & Ti Multifuel Boiler... -
Page 15: Installation
Care should be taken to make sure that the hinges are not damaged during installation. Stratford Tf & Ti Multifuel Boiler Stoves HEARTH The fire should be installed to stand on a constructional hearth of non-combustible materials not less than 125mm (5'') thick conforming to Building Regulations. -
Page 16: Multifuel Grate & Grate Bars
Warning: If the fire is operated with the throat plate in the down position the air wash will not operate effectively. Stratford Tf & Ti Multifuel Boiler Stoves GRATE BAR REPLACEMENT After extended use it may be necessary to replace some of the grate bars. -
Page 17: Flue Outlet And Hotplate
THE FLUE PIPE MUST BE FITTED INSIDE THE OUTLET SPIGOT FAILURE TO DO SO COULD RESULT IN THE SPILLAGE OF CONDENSATION ECT. RUNNING DOWN THE FLUE. Fig. 13 Flue and Spigot Fitting Stratford Tf & Ti Multifuel Boiler Stoves INSTALLATION FLUES AND CHIMNEYS Please remember that chimney draught is dependent on four main factors: •... -
Page 18: For All Appliances
300mm rated output. For advice on flues and chimneys contact; NACE (National Association of Chimney Engineer): telephone 0800 0924019 www.nace.org.uk NACS (National Association of Chimney Sweeps): telephone 01785 811732 www.chimneyworks.co.uk Stratford Tf & Ti Multifuel Boiler for each kW of... -
Page 19: Integral Boilers
SO THE PROCEDURES WILL ONLY BE REQUIRED WHEN REPLACING OR RE SETTING THE THERMOSTAT. Stratford Tf & Ti Boiler Multifuel Stoves To fit/remove thermostat on Tf models For fitting/removal of thermostat on Ti models please see page 20. 1. Pull thermostat knob off of the shaft. -
Page 20: Additional Information For Inset Stoves
Reinstate brickwork to chimney breast and make good. Remember to make provision for access boiler connections observation/maintenance. Replace parts previously removed and check unit thoroughly. Stratford Tf & Ti Boiler Multifuel Stoves routine... -
Page 21: Typical Installation For Boiler Models
INSTALLATION Stratford Tf & Ti Multifuel Boiler Stoves... - Page 22 INSTALLATION IEW OF REGISTER PLATE AND CLEARANCES FOR NON INSULATED FLUES A is minimum clearance for non-insulated flue = 1.5 x D to a non-combustible surface/material 3 x D to combustible surface/material Stratford Tf & Ti Boiler Multifuel Stoves...
- Page 23 Central Heating and Domestic Hot Water System Using Four Boiler Tappings Central Heating System Without Domestic Hot Water Using Four Boiler Tappings Note: Diagrammatic representation only. Design and calculations for individual systems should always be carried out by a qualified heating engineer. Stratford Tf & Ti Boiler Multifuel Stoves...
- Page 24 Central Heating and Domestic Hot Water System Using Three Boiler Tappings Central Heating System Without Domestic Hot Water Using Three Tappings Note: Diagrammatic representation only. Design and calculations for individual systems should always be carried out by a qualified heating engineer. Stratford Tf & Ti Multifuel Boiler Stoves...
-
Page 25: Boiler Tapping Positions
BOILER TAPPING POSITIONS Stratford Tf30 Boiler Tapping Positions Stratford Tf50 Boiler Tapping Positions All dimensions in mm Stratford Tf & Ti Multifuel Boiler Stoves... - Page 26 BOILER TAPPING POSITIONS Stratford Tf70 Boiler Tappings Positions Stratford Tf90 Boiler Tappings Positions All dimensions in mm Stratford Tf & Ti Multifuel Boiler Stoves...
-
Page 27: Boiler Tapping Positions
BOILER TAPPING POSITIONS Stratford Ti 40 Inset Boiler Tapping Positions All dimensions in mm Stratford Tf & Ti Multifuel Boiler Stoves... -
Page 28: Water Connections
The ball valve should have a copper ball. The overflow pipe from the expansion tank should be 28mm diameter copper. Pipes in unheated spaces must be lagged. Stratford Tf & Ti Multifuel Boiler Stoves... -
Page 29: Hot Water Systems Check List
•Operate the heating system and set the pump head. •Balance the radiators. •Re-vent and ensure no air locks. Stratford Tf & Ti Multifuel Boiler Stoves INSTALLATION •Check the circulation round the primary system and the heat leak radiator, particularly when the pump is running, to ensure circulation is not reversed. -
Page 30: Final Installation Check List
Part J of Schedule 1 to the Building regulations. Print name and title...Profession... Capacity...Telephone... Address...Postcode... Signed...Date... Registered membership of..(e.g. CORGI, OFTEC, HETAS, NACE, NACS)... CHECKLIST Outlet Details: Complies with: visual sweeping coring ball smoke Stratford Tf & Ti Multifuel Boiler Stoves... -
Page 31: Parts List
1. Fuel Retainers 2. Throat Plate 3. Grate Bar Set 4. Hot Plate 5. Operating Tool 6. Ashpan 7. Flue Spigot Stratford Tf & Ti Boiler Multifuel Stoves Tf 30b Tf 50b Tf 70b Part No. Part No. Part No. - Page 32 AFS047 AFS047 AFS048 AFS048 AFS048 AFS200 AFS201 AFS0201 AFS095 AFS096 AFS096 Ti 40b Tf 90b Part No. Part No. AFS1077 AFS1077 AFS090 AFS088 AFS091 AFS089 AFS047 AFS047 AFS048 AFS048 AFS201 AFS200 AFS096 AFS095 Stratford Tf & Ti Multifuel Boiler Stoves...
-
Page 33: Parts List
21. Spare side trims for Ti40 22. Replacement slot in grate bar rear landing 23. Replacement Interlock Stratford Tf & Ti Multifuel Boiler Stoves Tf 30b Tf 50b Tf 70b Part No. Part No. Part No. AFS204 AFS204... -
Page 34: Guarantee
Aarrow Fires, otherwise only a one year guarantee will apply. The three years guarantee applies to the main body of the fire, i.e. the steel carcass and items fixed immovably thereto. -
Page 35: Service Record
Should you have any questions about your Stratford Stove that is not covered in this manual please contact your Aarrow retailer. Please keep all repair receipts safely. Please ensure you have this manual available when an engineer visits as they will complete the service record chart. Stratford Tf & Ti Multifuel Boiler Stoves... -
Page 36: Final Factory Check List
ASH PAN OPERATING TOOL THERMOSTAT OPERATING INSTRUCTIONS Please ensure the enclosed registration card is completed and returned to Aarrow Fires and the following information completed for your own information. Date of Purchase... Name and Address of Supplier... *Please ensure installer completes BOILER CHECK LIST on page 29 and INSTALLATION CHECK LIST details on page 30 of this manual.
Need help?
Do you have a question about the Stratford Tf and is the answer not in the manual?
Questions and answers