Sloan AER-DEC-8000 Installation Instructions Manual

AER-DEC -80000 Integrated Sink System
®
One, Two, Three, and Four Station Corian
AD-81000
Deck Sink Lavatory System
Notes:
1. Caution: These instructions are for standard, continuous basin designs only, for individual basin or other customization refer to the
provided custom installation instructions for rough-in information.
2. Components shown are for reference only and may not depict actual customer components.
Important
Read this entire installation manual to ensure
proper installation. When fi nished with the
installation, fi le this manual with the owner or
maintenance department. Compliance and
conformity to local codes and ordinances is
the responsibility of the installers.
Separate parts from packaging and make
sure all parts are accounted for before
discarding any packaging material. If any
parts are missing, do not begin installation until
all parts are obtained.
Make sure that all water supply lines have
been fl ushed and completely turned off
before starting the installation. Debris in supply
lines can cause valves to malfunction.
Tools and Supplies Required for Installation
• Electric drill for drilling anchor holes.
• Standard sockets, basin wrench, and open end wrench set for
installing anchoring fasteners and faucets.
• Pipe wrench for installing drain lines.
• Phillips and straight blade screwdrivers.
• Tubing cutter
• Level
• Carpenter's square
Prior to Installation
ADEQUATE STRUCTURAL SUPPORT IN OR BEHIND THE WALL IS REQUIRED.
•
ALL ELECTRICAL WIRING IS TO BE INSTALLED IN ACCORDANCE WITH NATIONAL/LOCAL CODES AND REGULATIONS. ELECTRICAL OUT-
•
LETS SHOULD BE RECESSED AND INSTALLED PRIOR TO INSTALLATION.
ALL PLUMBING SHOULD BE INSTALLED IN ACCORDANCE WITH APPLICABLE CODES AND REGULATIONS.
•
• BEFORE CONNECTING FLEX HOSES TO SUPPLY STOPS, FLUSH ALL WATER LINES UNTIL WATER IS CLEAR.
HOT AND COLD WATER SUPPLY LINES/TEMPERED SUPPLY LINE AND DRAIN LINES. RECOMMENDED TO HAVE CONTROL STOPS ON WATER
•
SUPPLY LINES IN PLACE PRIOR TO INSTALLATION.
Sloan® Limited Warranty Summary
Sloan Valve Company ("Sloan"), warrants its products against defects in materials and workmanship, excluding damage caused by
matters beyond Sloan's reasonable control. Instructions for fi ling claims can be found in the Limited Warranty which can be obtained
at www.sloan.com or by requesting a free copy by telephone at 888.756.2614. Sloan will repair or replace your defective product, or
provide a refund, as your exclusive remedy. This is only a general summary of Sloan's Limited Warranty so it is important to note that the
specifi c terms, conditions, limitations and exclusions, including the duration of warranty coverage for your particular Sloan product, are
contained in the actual Sloan Limited Warranty. The Limited Warranty is subject to applicable laws in your country, state, province or
other jurisdiction—and disputes arising under the Limited Warranty are to be resolved by binding arbitration unless you provide Sloan with
an opt-out notice no later than 30 days after your purchase date. In case of a confl ict with this summary, the terms and conditions set
forth in the complete Limited Warranty will prevail.
10500 Seymour Ave Franklin Park, IL 60131 | Phone: +1.800.982.5839 | Fax: +1.800.447.8329 |
or Quartz Lavatory Systems
®
AD-82000
Deck Sink Lavatory System
Copyright © 2024 Sloan. All rights reserved.
AD-83000
Deck Sink Lavatory System
Turn off electrical power to the electrical outlets,
then unplug units prior to installation. Electrical
power MUST remain off until installation is
complete.
Installers hardware must be appropriate for
wall construction. Wall anchors and mounting
fasteners MUST have a minimum pull-out rating of
1,000 lbs.
For standard height mounting, DO NOT exceed
the recommended 34 inch distance from the top
of the lav deck to the fi nished fl oor. To meet ADA
requirements the lav deck cannot not exceed
the 34 inch maximum height dimension.
• Caulk gun
• 1/2" NPT hot/cold or tempered supply piping
• 1 1/2" NPT drain piping including p-trap
• Adhesive: Loctite® PL Premium® FAST GRAB Polyurethane
Construction Adhesive
• 110 volt GFCI protected electrical outlet for 100-120 VAC plug-
in transformer
• Screen fi lter(s) included with faucet(s)
• Backing supplied by others to meet local codes
CAUTION
Installation Instructions
Code No. XXXXXXXX Rev. 2 (03/24)
AD-84000
Deck Sink Lavatory System
www.Sloan.com
Page: 1 of 25