Page 1
Talk time Standby Note GSM: Up to GSM: Up to Depends on 10.5 hours 17 days network WCDMA: Up WCDMA: Up parameters to 4.5 hours to 20 days and phone settings ISSUE 1 Confidential Copyright @ 2008 NOKIA. All rights reserved...
12.11.2008 Approved The purpose of this document is to help NOKIA service levels 1 and 2 workshop technicians to carry out service to NOKIA products. This Service Manual is to be used only by authorized NOKIA service suppliers, and the content of it is confidential. Please note that NOKIA provides also other guidance documents (e.g.
Nokia operates a policy of continuous development. Nokia reserves the right to make changes and improvements to any of the products described in this document without prior notice. Under no circumstances shall Nokia be responsible for any loss of data or income or any special, incidental, consequential or indirect damages howsoever caused.
3. Use only approved components as specified in the parts list. 4. Ensure all components, modules screws and insulators are correctly re–fitted after servicing and alignment. 5. Ensure all cables and wires are repositioned correctly ISSUE 1 Confidential Copyright @ 2008 NOKIA. All rights reserved...
E63 RM-437, RM-449, RM-450 Service Manual Level 1&2 4. ESD PROTECTION Nokia requires that service points have sufficient ESD protection (against static electricity) when servicing the phone. Any product of which the covers are removed must be handled with ESD protection.
• modifications or attachments could damage the phone and may violate regulations governing radio devices. All of the above suggestions apply equally to the product, battery, charger or any accessory. ISSUE 1 Confidential Copyright @ 2008 NOKIA. All rights reserved...
Batteries’ performance is particularly limited in temperatures well below freezing. Do not dispose batteries in a fire! Dispose of batteries according to local regulations (e.g. recycling). Do not dispose as household waste. ISSUE 1 Confidential Copyright @ 2008 NOKIA. All rights reserved...
E63 RM-437, RM-449, RM-450 Service Manual Level 1&2 7. PRODUCT CONTROLS AND INTERFACES ISSUE 1 Confidential Copyright @ 2008 NOKIA. All rights reserved...
E63 RM-437, RM-449, RM-450 Service Manual Level 1&2 8. EXPLODED VIEW See corresponding ITEM/CIRCUIT REF in the Spare Parts Service Bulletins on NOL. ISSUE 1 Confidential Copyright @ 2008 NOKIA. All rights reserved...
For more information, refer to the Service Bulletin (SB-011) on Nokia Online. Supplier or manufacturer contacts for tool reorder can be found in the “Recommended service equipment” document in Nokia Online. ISSUE 1 Confidential Copyright @ 2008 NOKIA. All rights reserved...
Flash concept – (Point of Sales) To use the FLS-5 Flash Dongle, you have to follow the user guide inside the sales package. Please check always for the latest version of flash software, which is available on Nokia Online. ISSUE 1 Confidential Copyright @ 2008 NOKIA.
5) Use SS-93 tool to slide along the side of the 6) A-COVER ASSY can be taken away. phone to detach the A-COVER ASSY. Do the same on the opposite side. ISSUE 1 Confidential Copyright @ 2008 NOKIA. All rights reserved...
Page 14
11) Lift up the ATO-FRAME ASSY inclusive LCD with 12) Flap the ATO-FRAME ASSY to get better access SS-93 tool. to the connector. Disconnect the ATO-FRAME ASSY connection with SS-93 tool. ISSUE 1 Confidential Copyright @ 2008 NOKIA. All rights reserved...
Page 15
15) LCD can be taken away. 16) Pull out the EARPIECE RUBBER HOUSING inclusive EARPIECE STOUT as shown. 17) Remove EARPIECE STOUT with tweezers. 18) Disconnect the AV FLEX with SS-93 tool. ISSUE 1 Confidential Copyright @ 2008 NOKIA. All rights reserved...
Page 16
20) LIGHT SWAP PWB can be taken away. tool. 21) Use SS-102 tool to remove the CAMERA MOD. 22) Remove AV FLEX. 23) ANTENNA MODULE can be taken away. 24) DC-JACK can be taken away. ISSUE 1 Confidential Copyright @ 2008 NOKIA. All rights reserved...
Page 17
E63 RM-437, RM-449, RM-450 Service Manual Level 1&2 25) Lift up the IHF SPEAKER DONAU with SS-93 tool 26) Pull out SD DOOR… in order to remove it. 27) …and USB DOOR carefully. ISSUE 1 Confidential Copyright @ 2008 NOKIA. All rights reserved...
2) Tighten the screws to the torque of 17 Ncm in the order shown. order shown. 12.1 IHF speaker replacement 1) When assembling the IHF Speaker Donau, use a new IHF adhesive. ISSUE 1 Confidential Copyright @ 2008 NOKIA. All rights reserved...