All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by PF0261 Service Singapore...
EN 4 SD-4 Safety Instructions, Warnings, and Notes 2. Safety Instructions, Warnings, and Notes Safety Instructions Warnings 2.1.1 General Safety 2.2.1 General Safety regulations require that during a repair: • All ICs and many other semiconductors are susceptible to electrostatic discharges (ESD, "). Careless handling •...
Directions for Use SD-4 EN 5 3. Directions for Use There is no DFU available 4. Mechanical Instructions The SD4.0 module can be configurate into 2 options as shown : Option 1 with monoboard below loader similar Option 2 with monoboard beside loader to allows for a lower total height of module CL 16532163_014.eps...
Page 7
Mechanical Instructions SD-4 EN 7 CL 16532163_015.eps 230102 Figure 4-2 CL 06532147_003.eps 4.1.1 Dismantling of DVD Mono Board 151100 Figure 4-4 See Figure 4-1 and 4-2 for dismantling of DVD module. It is possible to open the tray manually by moving the Slider in...
Page 8
EN 8 SD-4 Mechanical Instructions Service Hints 4.2.1 DVD Module This module can be repaired as follows: 1. The VAL6013/01 is a combination of loading mechanism and DVD-mechanism. Both the mechanism is not a repairable unit and in case of failure it has to be replaced with a new loader VAL6013/01.
Test Instructions Mono Board DVD-SD4.00 SD-4 EN 9 5. Test Instructions Mono Board DVD-SD4.00 General PM3380B ch1: dT=73.0ms V1= 65.0mV • Impedance of measuring-equipment should be > 1MΩ. • Most tests have to be done by software commands. Together with the software command you will find a Ref.# nbr.
Page 10
EN 10 SD-4 Test Instructions Mono Board DVD-SD4.00 Ref. # Command Name Remark PM3380B PapChksFl Checksum FLASH CompSdramWrR SDRAM Write Read CompSdramWrR checks the complete SDRAM for failures inside the IC.The BasicInterconSDRAM check is done by writing & reading some well chosen patterns to all address and data interconnections of the SDRAM.
Page 11
Test Instructions Mono Board DVD-SD4.00 SD-4 EN 11 Check the Mute output at testpoint T798: 0V ±0.3V PM3380B 5.4.5 Audio I2S Check To check the audio output, connect a audio DAC (on the A/V board) to the I2S output and start-up the audio test. Look at the audio outputs from the A/V board for both sine and pink noise.
Page 12
EN 12 SD-4 Test Instructions Mono Board DVD-SD4.00 PM3380B PM3394B CH1 2.00 V~ MTB 100ns ch1+ CH1 2.00 V= BWL MTB100ns ch1+ CL06532065_009.eps CL 16532163_024.eps 161100 230102 Figure 5-8 PCMSCLK Figure 5-11 SPDIF To switch the audio signal OFF, press the STOP button on the PM3394B front.
Page 13
Test Instructions Mono Board DVD-SD4.00 SD-4 EN 13 VIDEO PM3380B 5.5.1 Video Output Check Measure the DC voltages at all video-outputs at conn 1701 while the video signal is turned off: 1V ± 10% Generate a color-bar via next software commands: Ref.
Page 14
EN 14 SD-4 Test Instructions Mono Board DVD-SD4.00 Check the level of SCART0 and SCART1 with the following commands: PM3380B Command Scart0 Scart1 Level on Pin 8 Ref. # Name (PIO3.6) (PIO3.7) of scart VideoScartLo 1 0-2V VideoScartMi 0 4.5-7V VideoScartHi 0 9.5-12V...
Page 15
Test Instructions Mono Board DVD-SD4.00 SD-4 EN 15 5.5.3 Video Hsync Check. To measure the Video Hsync, the connector 1703 must be connected to the external video processing device such as high quality progressive scan codex and high quality Video DAC, else there will not be any waveform.
Page 16
EN 16 SD-4 Test Instructions Mono Board DVD-SD4.00 5.6.2 Spindle Motor: PM3380B Before switching on the discmotor, check the following testpoints: Name Testpoint Value STDBY_MOTOR F308 MOTO1 F206 1V5 ±0.3 Switch the Discmotor ON/OFF with the following commands: Ref. # Command Name...
Page 17
Test Instructions Mono Board DVD-SD4.00 SD-4 EN 17 5.6.3 Radial PM3380B Radial ON will only work when the PCB is connected to a CDM and DVD Disc is inserted. Switch the Radial control ON/OFF with the following commands: Ref. # Command Name...
Page 18
EN 18 SD-4 Test Instructions Mono Board DVD-SD4.00 Name Testpoint Value Waveform PM3380B VOL - F327 10Vpp ±0.5V Refer to Figure 5-32 VOL + F326 10Vpp ±0.5V Refer to Figure 5-32 Measure input sledge control (sledge in HOME position) Name...
Page 19
Test Instructions Mono Board DVD-SD4.00 SD-4 EN 19 Name Testpoint Value PM3394B F119 2.6V ±0.2% F127 2.6V ±0.2% F124 2.6V ±0.2% F122 2.6V ±0.2% F115 2.6V ±0.2% F117 2.6V ±0.2% At outputs of diodes A, B, C, D the following waveform can be...
EN 20 SD-4 Test Instructions Mono Board DVD-SD4.00 Diagnostic Software Description Logical Physical interface Interface Description components 5.7.1 Introduction Used for S2B Service PC, running a interface communication with S2B monitor program, the Basic Engine connected to the Purpose RS232 port of DVD...
Page 21
Test Instructions Mono Board DVD-SD4.00 SD-4 EN 21 menu will then appear. For the layout of the menus, see chapter “Layout of Menu and Submenu”. DVDv4 Diagnostic Software version 4.03 To switch between interfaces, the DVD player needs to be...
Page 22
EN 22 SD-4 Test Instructions Mono Board DVD-SD4.00 5.9.3 S2B Interface LCD Display [30b] LCD BkLight [30c] Keyboard [27] Set-up Physical Interface Components LEDs [29] Hardware needed: Remote Control [28] • Control PC P50 Check [60] • one free COM port on the Control PC •...
Page 23
Test Instructions Mono Board DVD-SD4.00 SD-4 EN 23 MAIN > BASIC ENGINE > S2B MENU Jump To Outside Grooves [42c S2B Echo [13] S2B Pass-Through [14] Screen Layout With Menus When menus are used, no specific screen layout can be given: MAIN >...
Page 24
EN 24 SD-4 Test Instructions Mono Board DVD-SD4.00 5.11.3 Components 1. 0001 Unknown command ER @ 2. 3100 OK @ Ref. # Reference Name Remark 3. 0901 Data line X is not connected to the DRAM ER @ CompSdramWrR SDRAM Write Read 4.
Page 25
Test Instructions Mono Board DVD-SD4.00 SD-4 EN 25 5.11.6 DisplayPWB (slave processor) 5.11.10 Karaoke Ref. # Reference Name Remark Ref. # Reference Name Remark DispVer Version number KaraokeModeOff Switch Karaoke mode off DispKeyb Keyboard KaraokeModeOn Switch Karaoke mode on DispRc...
Page 26
EN 26 SD-4 Test Instructions Mono Board DVD-SD4.00 5.12.2 Basic Engine Nuclei Error code Error text 4242 “Unexpected response from Basic Engine” Error code Error text 4243 “Communication time-out error” 3900 Test successful 4244 “Basic Engine returned error number 0xXX”...
Page 27
Test Instructions Mono Board DVD-SD4.00 SD-4 EN 27 Error Error code Error text code Error text 5820 Test successful 6001 “No readback on P50” 5840 Test successful 6002 “Disp not responding “ 5860 Test successful 6003 “P50 readback error” 5801 "Unexpected response from Basic Engine"...
Page 28
EN 28 SD-4 Test Instructions Mono Board DVD-SD4.00 Error Error code Error text code Error text 3203 "Error log could not be read from NVRAM" 4720 “Total Power On time (minutes) : XX” 4721 The total power-on time could not be read from NVRAM.
Features The SD4.0 modules consist of the Mercury 3 Loader Audio Video Others VAL6013/01 (from Philips Optical Storage), and a Mono Board. The module is capable of analogue video (with option for digital YUV video) and digital audio. Module interface CL 16532163_047.eps...
Page 46
EN 46 SD-4 Circuit Descriptions, List of Abbreviations and IC Data The Servo Processor/Decoder SAA7812 1Mbits of the memory is accessible. Conversely, when this pin The servo circuit in the SAA7812 (item 7200) takes care of the is HIGH, the upper 1Mbits is accessible.
Page 47
Circuit Descriptions, List of Abbreviations and IC Data SD-4 EN 47 External Memory the other three channels (pins 32, 33 and 34) are Y, C, and The STi55xx family is capable of accessing external memory CVBS. via three buses: A new video output buffer (see diagram M7, e.g. item 7707 for •...
Page 48
EN 48 SD-4 Circuit Descriptions, List of Abbreviations and IC Data New FTD 9.3.5 Top Side Connectors In the fourth DVD player generation (VFM2002), a new FTD is used, which requires a new serial bus (SIO instead of I2C bus).
Serial Clock I2C SCLK Audio serial bit clock Serial Data I2C SDRAM Synchronous DRAM S/PDIF Sony Philips Digital InterFace SRAM Static RAM STBY Standby SVCD Super Video CD Software Total Harmonic Distortion Transistor Transistor Logic (5V logic)
EN 50 SD-4 Circuit Descriptions, List of Abbreviations and IC Data IC Data In this paragraph, the internal blockdiagrams and pinning are given of ICs that are drawn as 'black box' in the electrical diagrams (with exception of 'memory' and 'logic' ICs).
Page 51
Circuit Descriptions, List of Abbreviations and IC Data SD-4 EN 51 TZA1033 Pinning (item 7100) DVDALAS2plus Advanced Analogue DVD TZA1033 Signal Processor and Laser Supply PINNING handbook, full pagewidth CD-A CD-B CD-C CD-D CD-REF VDDA4 CD-E VSSA4 CD-F VDDA1 VSSA1...
EN 52 SD-4 Circuit Descriptions, List of Abbreviations and IC Data 9.5.2 Diagram M2 SAA7812HL Block Diagram (item 7200) Channel decoder Block decoder/ CD/DVD Erco encoder DRAM interface drive Host Bit Detector Memory Proc & Demodulator interface interface Memory Proc...
Page 53
Circuit Descriptions, List of Abbreviations and IC Data SD-4 EN 53 SAA7812HL Pinning (item 7200) DASP DAC_RP DA2_GRD DAC_RN DAC_VPOS PDIAG DAC_VNEG DA1_GWR DAC_LP IOCS16 DAC_LN INTRQ TEST1 DMACK_GRQ TEST2 IORDY CRIN DIOR CROUT DIOW DMARQ_GACK HFIN_DN SAA7812 M3x HFIN_DP...
EN 54 SD-4 Circuit Descriptions, List of Abbreviations and IC Data 9.5.3 Diagram M6 STi5580 Block Diagram (item 7600) 2 UART & Internal peripherals 2 SmartCards Central CACHE SUBSYSTEM command port (C2+) Front-end & link interface Clock DMAs ICache generator...
Page 55
Circuit Descriptions, List of Abbreviations and IC Data SD-4 EN 55 STi5580 Pinning (item 7600) PIO2[5] CPU_DATA[13] PIO2[6] CPU_DATA[12] PIO2[7] CPU_DATA[11] VDD3_3 CPU_DATA[10] CPU_DATA[9] PIO3[0] CPU_DATA[8] PIO3[1] PIO3[2] VDD2_5 PIO3[3] CPU_DATA[7] PIO3[4] CPU_DATA[6] PIO3[5] CPU_DATA[5] PIO3[6] CPU_DATA[4] PIO3[7] CPU_DATA[3] VDD2_5...
Page 56
EN 56 SD-4 Spare Parts List 10. Spare Parts List SD4 EU 2301 4822 126 14305 100nF 10% 16V 0603 2736 4822 124 12095 100µF 20% 16V 2302 4822 126 14305 100nF 10% 16V 0603 2737 4822 126 14305 100nF 10% 16V 0603...
Page 57
Spare Parts List SD-4 EN 57 3302 4822 117 12917 1Ω 5% 0.062W CASE0603 3723 4822 051 30689 68Ω 5% 0.063W 0603 RC21 5606 2422 549 45153 IND FXD SM EMI 100mH z 3304 4822 051 30682 6k8 5% 0.062W...