1. Manuals
  2. Brands
  3. Husqvarna Manuals
  4. Lawn Mower
  5. 2246LS
  6. Operator's manual

Husqvarna 2246 LS Operator's Manual

Ride mower
Hide thumbs Also See for 2246 LS:
Table of Contents

Advertisement

Quick Links

Operator's
2008-01
Manual
O0802010
Ride Mower
2246 LS 96043004300
Operator's Manual

Advertisement

Table of Contents
loading

Related Manuals for Husqvarna 2246 LS

Summary of Contents for Husqvarna 2246 LS

  • Page 1 Operator's 2008-01 Manual O0802010 Ride Mower 2246 LS 96043004300 Operator's Manual...

  • Page 2: Safety Rules

    SAFETY RULES Safe Operation Practices for Ride-On Mowers DANGER: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROW ING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. • Do not operate machine without the entire grass catcher, discharge guard, or other safety devices in place and WARNING: In order to prevent ac- ci den tal starting when setting up,...
  • Page 3 SAFETY RULES Safe Operation Practices for Ride-On Mowers III. CHILDREN GENERAL SERVICE • Never operate machine in a closed area. Tragic accidents can occur if the operator is not alert to • Keep all nuts and bolts tight to be sure the equipment the presence of children.

  • Page 4: Table Of Contents

    PRODUCT SPECIFICATIONS CUSTOMER RESPONSIBILITIES Gasoline Capacity 2.5 Gallons • Read and observe the safety rules. and type: Unleaded Regular • Follow a regular schedule in maintaining, caring for Oil Type (API-SG-SL): SAE 30 (above 32°F) and using your tractor. SAE 5W-30 (below 32°F) •...

  • Page 5: Assembly

    UNASSEMBLED PARTS Slope Sheet (1) Oil Drain Tube (2) Keys ASSEMBLY Your new tractor has been assembled at the factory with the exception of those parts left unassembled for shipping purposes. When right or left hand is mentioned in this man ual, it means when you are in the operating po si tion (seated be hind the steer ing wheel).
  • Page 6 ASSEMBLY ✓ TO ROLL TRACTOR OFF SKID (See Op- CHECKLIST er a tion section for location and function of BEFORE YOU OPERATE YOUR NEW TRAC TOR, WE con trols) WISH TO ASSURE THAT YOU RECEIVE THE BEST PER- • Raise attachment lift lever to its highest po si tion. FORMANCE AND SATISFACTION FROM THIS QUALITY •...

  • Page 7: Operation

    OPERATION These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. FAST SLOW REVERSE HIGH NEUTRAL CHOKE IGNITION SWITCH ENGINE START MOWER HEIGHT MOWER LIFT REVERSE ENGINE ON PARKING BRAKE ENGINE OFF OPERATION SYSTEM (ROS) CLUTCH/BRAKE...
  • Page 8 OPERATION KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and ad just ments. Save this manual for future reference. FIG.
  • Page 9 OPERATION The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye dam age. Always wear safety glass es or eye shields while operating your tractor or per form ing any ad just ments or repairs. We rec om mend standard safety glasses or a wide vision safety mask worn over spectacles.
  • Page 10 OPERATION The cutting height range is ap prox i mate ly 1" to 4". The TO MOVE FORWARD AND BACKWARD heights are measured from the ground to the blade tip with (See Fig. 7) the engine not running. These heights are approximate The direction and speed of movement is controlled by the and may vary depending upon soil conditions, height of forward and reverse drive pedals.
  • Page 11 OPERATION TO OPERATE ON HILLS TO OPERATE MOWER (See Fig. 10) Your tractor is equipped with an operator presence sensing CAUTION: Do not drive up or down switch. Any attempt by the operator to leave the seat with hills with slopes greater than 15° and the engine running and the attachment clutch engaged will do not drive across any slope.
  • Page 12 OPERATION SERVICE REMINDER/HOUR METER TO START ENGINE (See Fig. 3) Service reminder shows the total number of hours the engine When starting the engine for the first time or if the engine has run and flashes to indicate that the engine or mower has run out of fuel, it will take extra cranking time to move needs servicing.
  • Page 13 OPERATION MOWING TIPS PURGE TRANSMISSION • Mower should be properly leveled for best mowing performance. See “TO LEVEL MOWER HOUSING” in CAUTION: Never engage or disengage the Service and Adjustments section of this manual. freewheel lever while the engine is •...

  • Page 14: Maintenance Schedule

    MAINTENANCE BEFORE EVERY EVERY EVERY EVERY EVERY BEFORE MAINTENANCE EACH SEASON STORAGE SCHEDULE HOURS HOURS HOURS HOURS Check Brake Operation Check Tire Pressure Check Operator Presence & ROS Systems Check for Loose Fasteners Check/Replace Mower Blades Lubrication Chart Check Battery Level Clean Battery and Terminals Check Transaxle Cooling Check Mower Levelness...

  • Page 15: Maintenance

    MAINTENANCE TRACTOR BLADE CARE Always observe safety rules when per form ing any main- For best results mower blades must be sharp. Re place te nance. worn, bent or damaged blades. BRAKE OPERATION CAUTION: Use only a replacement If tractor requires more than five (5) feet to stop at highest blade approved by the manufacturer of speed in high est gear on a level, dry concrete or paved your tractor.
  • Page 16 MAINTENANCE DECK WASHOUT PORT (See Fig. 14) BATTERY Your tractor has a battery charging system which is suf fi cient Your tractor’s deck is equipped with a washout port on for normal use. However, periodic charging of the battery its surface as part of its deck wash system. It should be with an automotive charger will extend its life.
  • Page 17 MAINTENANCE CLEAN AIR SCREEN SAE VISCOSITY GRADES Air screen must be kept free of dirt and chaff to prevent SAE 30 engine dam age from overheating. Clean with a wire brush 5W-30 or compressed air to re move dirt and stubborn dried gum fibers.

  • Page 18: Service And Adjustments

    SERVICE AND ADJUSTMENTS WARNING: TO AVOID SERIOUS INJURY, BEFORE PERFORMING ANY SER VICE OR AD JUST - MENTS: • Depress brake pedal fully and set parking brake. • Place attachment clutch in “DISENGAGED” position. • Turn ignition key to “STOP” and remove key. •...
  • Page 19 SERVICE AND ADJUSTMENTS • ATTACH FRONT LINK (E) - Work from left side of trac- tor. Insert rod end of link assembly through front hole in tractor front suspension bracket (F). • Insert end of link (E) into hole in front mower bracket and secure with washer and retainer spring (J).
  • Page 20 SERVICE AND ADJUSTMENTS TO LEVEL MOWER • If adjustment is necessary, see step in Visual Adjust- ment instructions above. Make sure tires are properly inflated to the PSI shown on • Recheck measurements, adjust if necessary until both tires. If tires are over or under inflated, it may affect the sides are equal.
  • Page 21 SERVICE AND ADJUSTMENTS TO REPLACE MOWER DRIVE BELT • Pull belt slack toward rear of trac tor. Carefully remove belt up wards from trans mis sion input pulley and over (See Fig. 26) cooling fan blades (F). MOWER DRIVE BELT REMOVAL •...
  • Page 22 SERVICE AND ADJUSTMENTS TO START ENGINE WITH A WEAK BATTERY TO CHECK BRAKE (See Fig. 29) If tractor requires more than five (5) feet to stop at highest speed in high est gear on a level, dry concrete or paved WARNING: Lead-acid batteries gen- surface, then brake must be serviced.
  • Page 23 SERVICE AND ADJUSTMENTS INTERLOCKS AND RELAYS REPLACING BATTERY (See Fig. 30) Loose or damaged wiring may cause your tractor to run poorly, stop running, or prevent it from starting. WARNING: Do not short battery ter- • Check wiring. See electrical wiring diagram in the mi nals by allowing a wrench or any Repair Parts section.

  • Page 24: Storage

    STORAGE Immediately prepare your tractor for storage at the end ENGINE of the season or if the tractor will not be used for 30 days or more. FUEL SYSTEM IMPORTANT: IT IS IMPORTANT TO PREVENT GUM DEPOSITS WARNING: Never store the trac tor with FROM FORMING IN ES SEN TIAL FUEL SYSTEM PARTS SUCH gas o line in the tank inside a building AS CARBURETOR, FUEL FIL TER, FUEL HOSE, OR TANK...

  • Page 25: Trou Ble Shoot Ing

    TROUBLESHOOTING POINTS PROBLEM CAUSE CORRECTION Will not start Out of fuel. Fill fuel tank. Engine not “CHOKED” properly. See “TO START ENGINE” in Operation section. Engine flooded. Wait several minutes before attempting to start. Bad spark plug. Replace spark plug. Weak or dead battery.
  • Page 26 TROUBLESHOOTING POINTS PROBLEM CAUSE CORRECTION Engine dies when Reverse operation system Turn ignition key to tractor is shifted (ROS) is not "ON" while ROS "ON" position. into reverse mower or other attachment See Operation section. is engaged. Engine continues to run Faulty operator-safety presence control system.

  • Page 27: Repair Parts

    TRACTOR - - MODEL NUMBER 2246LS (96043004300), PRODUCT NO. 960 43 00-43 SCHEMATIC SCH13 BATTERY SOLENOID STARTER FUSE AMMETER BLACK (OPTIONAL) ELECTRIC CLUTCH WHITE PTO SWITCH BLACK WHITE (DISENGAGED) WHITE BLACK GRAY CLUTCH/BRAKE (PEDAL UP) BLUE REVERSE SWITCH (NOT IN REVERSE) BLACK BLACK BLACK...
  • Page 28 TRACTOR - - MODEL NUMBER 2246LS (96043004300), PRODUCT NO. 960 43 00-43 ELECTRICAL T21S With 12V Outlet Option With Service Minder Option...
  • Page 29 TRACTOR - - MODEL NUMBER 2246LS (96043004300), PRODUCT NO. 960 43 00-43 ELECTRICAL PART DESCRIPTION 532 16 34-65 Battery 874 76 04-12 Bolt Hex Head 1/4-20 x 3/4 532 19 32-28 Box Battery 532 17 61-38 Switch Interlock Push-In 532 18 37-59 Harness Socket Light W/4152J 532 00 41-52 Bulb Light...
  • Page 30 TRACTOR - - MODEL NUMBER 2246LS (96043004300), PRODUCT NO. 960 43 00-43 CHASSIS chassis-tex_GT Husq_11_r1...
  • Page 31 TRACTOR - - MODEL NUMBER 2246LS (96043004300), PRODUCT NO. 960 43 00-43 CHASSIS PART PART DESCRIPTION DESCRIPTION 532 40 86-06 Trim, Husq. 532 40 30-76 Vent Side Hood LH 532 40 50-12 Logo 532 41 66-13 Vent Top Hood 532 40 87-01 Dash 532 40 17-09 Skirt Hood Side RH...
  • Page 32 TRACTOR - - MODEL NUMBER 2246LS (96043004300), PRODUCT NO. 960 43 00-43 DRIVE drive-tex_K46_pedal_8...
  • Page 33 TRACTOR - - MODEL NUMBER 2246LS (96043004300), PRODUCT NO. 960 43 00-43 DRIVE PART PART DESCRIPTION DESCRIPTION 5324053-84 Transaxle, TUFFTORQ K46 872 11 06-16 Bolt RDHD SQNK 3/8-16UNC x 2 (Internal parts not available) 532 13 70-57 Spacer Split 532 12 35-83 532 40 31-18 Handle Parking Brake 819 13 13-16...
  • Page 34 TRACTOR - - MODEL NUMBER 2246LS (96043004300), PRODUCT NO. 960 43 00-43 ENGINE SPARK ARRESTER KIT engine-tex_bs-2cyl_7...
  • Page 35 TRACTOR - - MODEL NUMBER 2246LS (96043004300), PRODUCT NO. 960 43 00-43 ENGINE PART DESCRIPTION - - - - - - Engine Briggs & Stratton Model No. 40H777 532 14 97-23 Muffler 532 19 43-20 Keeper Belt Engine 532 40 00-08 Clutch 532 40 50-97 Pulley Engine...
  • Page 36 TRACTOR - - MODEL NUMBER 2246LS (96043004300), PRODUCT NO. 960 43 00-43 STEERING ASSEMBLY HUSQ SR PREM 2 steering-tex_special_9_r1...
  • Page 37 TRACTOR - - MODEL NUMBER 2246LS (96043004300), PRODUCT NO. 960 43 00-43 STEERING ASSEMBLY PART DESCRIPTION 532 41 64-80 Wheel, Steering 532 18 47-06 Axle Asm., Front 532 40 30-87 Spindle Asm., LH 532 40 30-88 Spindle Asm., RH 532 12 49-31 Bearing, Race Thrust Harden 532 12 17-48 Washer 25/32 x 1-5/8 x 16 Ga.
  • Page 38 TRACTOR - - MODEL NUMBER 2246LS (96043004300), PRODUCT NO. 960 43 00-43 SEAT ASSEMBLY seat-tex_7-vgt PART PART DESCRIPTION DESCRIPTION 873 80 05-00 Nut, Lock 5/16-18 unc 532 40 66-21 Seat 532 19 76-61 Handle Slide Seat 532 18 01-66 Bracket Pivot Fender 532 19 82-00 Spring Latch Seat 532 14 06-75...
  • Page 39 TRACTOR - - MODEL NUMBER 2246LS (96043004300), PRODUCT NO. 960 43 00-43 DECALS PART PART DESCRIPTION DESCRIPTION 532 14 50-05 Decal, Battery Dnge/Poi 532 41 16-58 Decal, Operators 532 16 03-96 Decal, Mower V-Belt Schematic 532 41 57-80 Decal, Hood 532 41 82-77 Decal, Deck Air Induct 532 41 82-12...
  • Page 40 TRACTOR - - MODEL NUMBER 2246LS (96043004300), PRODUCT NO. 960 43 00-43 MOWER DECK 46_tex_lt_pred_15...
  • Page 41 TRACTOR - - MODEL NUMBER 2246LS (96043004300), PRODUCT NO. 960 43 00-43 MOWER DECK KEY PART NO. NO. DESCRIPTION 532 41 08-63 Mower Housing 532 40 55-06 Cover Mandrel RH 532 40 55-07 Cover Mandrel LH 532 19 51-86 Arm Suspension 532 19 30-03 Bolt/Washer asm 7/16-20 unf 532 40 53-80...
  • Page 42 TRACTOR - - MODEL NUMBER 2246LS (96043004300), PRODUCT NO. 960 43 00-43 MOWER LIFT lift-tex_7 PART PART DESCRIPTION DESCRIPTION 532 19 51-81 Link Lift Susp Mower Rear 532 19 52-23 Shaft Asm., Lift 817 00 06-12 Screw 3/8-16 x 3/4 532 19 52-31 Lever Asm., Lift Rh 532 19 52-70...
  • Page 44 Rental Warranty: 90 days on all applicable professional equipment reference warranty time period charts mailed to Husqvarna Forest & Garden Company. This card should be mailed within ten (10) days from the date of purchase located in the back of the Retailer Warranty Policy & Procedure Manual.
  • Page 45 532 41 83-23 Rev. 1 11.30.07 AP Printed in the U.S.A.

This manual is also suitable for:

96043004300

Table of Contents