DeWalt DCV586 Original Instructions Manual
Hide thumbs
Also See for DCV586:
- Original instructions manual (189 pages) ,
- Service training (24 pages)
Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for DeWalt DCV586
Summary of Contents for DeWalt DCV586
- Page 1 DCV586M...
- Page 2 English (original instructions) Copyright D WALT...
- Page 3 Fig. A XXXX XX XX Fig. B...
- Page 4 Fig. C Fig. D Fig. E Fig. F Fig. G Fig. H Ø Ø...
- Page 5 Fig. I Fig. J...
-
Page 6: Technical Data
English DUST EXTRACTOR DCV586M Congratulations! The undersigned is responsible for compilation of the technical file and makes this declaration on behalf of D WALT. You have chosen a D WALT dust extractor. Years of experience, thorough product development and innovation make D WALT one of the most reliable partners for professional power tool users. -
Page 7: Definitions: Safety Guidelines
English Batteries Chargers/Charge Times (Minutes)*** Weight (kg) DCB104 DCB107 DCB112 DCB113 DCB115 DCB116 DCB117 DCB118 DCB132 DCB119 Cat # DCB546 18/54 6.0/2.0 1.08 DCB547 18/54 9.0/3.0 1.46 135* 110* 135* DCB548 18/54 12.0/4.0 1.46 DCB549 18/54 15.0/5.0 2.12 DCB181 0.35 DCB182 0.61 60/40**... -
Page 8: Additional Safety Warnings
English • Stay alert, watch what you are doing and use and check whether the filter is installed correctly or is common sense when operating a dust extractor. Do defective. Defective filters must be replaced immediately. not use a dust extractor while you are tired or under l ) Have servicing performed by a qualified repair the influence of drugs, alcohol or medication. -
Page 9: Electrical Safety
English Electrical Safety • These chargers are not intended for any uses other than charging D WALT rechargeable batteries. Any other uses The electric motor has been designed for one voltage only. may result in risk of fire, electric shock or electrocution. Always check that the battery pack voltage corresponds to the Do not expose charger to rain or snow. -
Page 10: Important Safety Instructions For All Battery Packs
English cloth or soft non‑metallic brush. Do not use water or any Charge Indicators cleaning solutions. Never let any liquid get inside the tool; Charging never immerse any part of the tool into a liquid. Battery Packs Fully Charged Important Safety Instructions for All Hot/Cold Pack Delay* Battery Packs When ordering replacement battery packs, be sure to include... -
Page 11: Storage Recommendations
English Transport Mode: When the cap is attached to the FLEXVOLT the battery pack in aprons, pockets, tool boxes, product kit boxes, drawers, etc., with loose nails, screws, keys, etc. battery, the battery is in Transport mode. Keep the cap for shipping. CAUTION: When not in use, place tool on its side on a stable surface where it will not cause a tripping When in Transport mode, strings... -
Page 12: Package Contents
English Discard the battery pack with due care for Ø Ø the environment. Hose diameter switch postions. Charge D WALT battery packs only with designated WALT chargers. Charging battery packs other than the designated D WALT batteries with a D WALT Acoustic alarm charger may make them burst or lead to other dangerous situations. -
Page 13: Assembly And Adjustments
English The dust extractor can be used with a D WALT TSTAK transport of charge in the battery is below the usable limit, the fuel gauge system or as a stand alone unit on the floor. will not illuminate and the battery will need to be recharged. The DCV586M is suitable for picking up dry and non‑flammable nOTE: The fuel gauge is only an indication of the charge left on dusts, liquids, wood chips, mineral dusts containing quartz and... -
Page 14: Operation
English Replacing the Coin Cell Battery in the OPERATION Remote Control (Fig. J) Instructions for Use DANGER: DO NOT INGEST BATTERY; WARNING: Always observe the safety instructions and CHEMICAL BURN HAZARD.This product contains applicable regulations. a coin / button cell battery. If the coin / button cell WARNING: To reduce the risk of serious personal battery is swallowed, it can cause severe internal injury, turn dust extractor off and disconnect battery... - Page 15 English 6. When finished, turn the dust extractor off by pressing the 2. Your D WALT construction dust extractor is fitted with the WALT AirLock connection system. The AirLock allows for a three position switch to the Off (O) position. fast, secure connection between the dust extractor hose 2 ...
-
Page 16: Automatic Filter Cleaning System
WARNING: When stacking, always place the dust nOTE: Dispose of filter in appropriate container according to extractor on the bottom. statutory provisions. The DEWALT TSTAK stacking latches 10 l allow for other To Install Filters (Fig. E, F, I) TSTAK products to securely stack one on top of the other for convenience and portability. -
Page 17: Optional Accessories
English Storage (Fig. A) hazardous area and appropriate measures must be taken to avoid dust distribution. CAUTION: The three position switch must be in OFF (0) WARNING: To reduce the risk of serious personal position to prevent unintentional being switched on by injury, turn dust extractor off and disconnect battery Wireless Tool Control. -
Page 18: Protecting The Environment
English Paper filter bags: The DCV9401 filter bags are designed to capture many types of dust including drywall, concrete and wood. These bags should be disposed of once the airflow becomes restricted. DO NOT reuse bags. DCV9401 Disposable paper filter bag Fleece filter bag: The DCV9402 fleece bag is designed to capture many types of dust including drywall, concrete and wood. -
Page 19: Troubleshooting Steps
English TROUBLESHOOTING Problem Possible Cause Troubleshooting steps Motor does not run. Switch is not in On (I) position. Ensure three position switch is in On (I) position. Low battery voltage/poor battery connection. Ensure battery is fully charged and fully inserted. Tank is full of liquid and sense circuit is tripped. - Page 20 Belgique et WALT - Belgium BVBA Tel: NL 32 15 47 37 63 www.dewalt.be Luxembourg België en Luxemburg Egide Walschaertsstraat 16 Tel: FR 32 15 47 37 64 enduser.BE@SBDinc.com 2800 Mechelen Fax: 32 15 47 37 99 Danmark www.dewalt.dk WALT (Stanley Black&Decker AS)
Need help?
Do you have a question about the DCV586 and is the answer not in the manual?
Questions and answers