Removable face high-power logic-cont. cassette/rds receiver with cd changer control (69 pages)
Summary of Contents for Panasonic CQ-C8352N
Page 1
ORDER NO. ACED060608C3 AUTOMOTIVE AFTERMARKET CQ-C8352N / CQ-C7302N WMA MP3 CD Player/Receiver with Full Dot Matrix Display SPECIFICATIONS Specifications* General Power Supply DC 12V (11V - 16V), Test Voltage 14.4V Negative Ground Tone Controls (Bass/ Bass: ±12dB at 60Hz / Treble: ±...
CD Player Sampling Frequency 8 Times Oversampling Pick-up Type Astigma 3-Beam Light Source Semiconductor Laser Wave Length 790 nm Frequency Response 20Hz-20kHz (±1dB) Signal to Noise Ratio 96dB Total Harmonic Distortion 0.01% (1kHz) Wow and Flutter Below Measurable Limits Channel Separation 75dB FM Stereo Radio Frequency Range...
- Pb free solder has a higher melting point than standard solder; Typically the melting point is 50 - 70°F (30 - 40°C) higher. Please use a soldering iron with temperature control and adjust it to 700 ± 20°F (370 ± 10°C). In case of using high temperature soldering iron, please be careful not to heat too long.
9.2. How to Install the Main P.C.B. of the Electric Display 10. TERMINALS DESCRIPTION 10.1. Main Block IC601 : C2CBKG000018...
Page 8
Port Description FM AM CD 1 PANEL PANEL OPEN 5.2 5.2 OPEN detection 2 PANEL PANEL CLOSE 0 5.2 CLOSE detection 3 NC No Connection 4 BATT BATT detection 4.8 5 5 ACC ACC detection 4.8 5 6 SDA Electronic VOL I/O 4.9 4.9 4.9 data 7 SCK...
Page 9
Port Description FM AM CD 31 NC No Connection 32 Avdd Power supply of D/ 5.1 5.1 5.1 A converter 33 AVREF Reference voltage 5.1 5.1 5.1 for D/A converter 34 AVGND Reference GND for D/A converter 35 AVSS Grand for A/D and D/A converter 36 SD FM/AM signal...
Page 10
Port Description FM AM CD 58 AMP CONT External AMP O 4.9 5 4.9 control 59 BZ-OUT Buzzer output PPG 0 60 ANT CONT Motor antenna O 4.9 5 control 61 DIM1 Dimmer control output 1 62 DIM2 Dimmer control output 2 63 CDC REM Remote control...
Page 11
control output Port Description FM AM CD 88 ILL SENS External dimmer control input 89 SUBM CNT 3.3V control for microcomputer 90 NC No Connection 91 NC No Connection 92 NC No Connection 93 S W UP SUB.WAKE.UP.REQ O 4.9 5 4.9 94 DISPM Power supply O/I 0...
Page 12
Port Part Name & I/O (V) Description 20 A12 FLASH A11 21 VCC Positive power supply terminal 22 A13 FLASH A12 23 A14 FLASH A13 24 A15 FLASH A14 25 SUB SI/UP MAIN-u-com communication data input and external flash rewritting 26 SUB SO/UP MAIN-u-com communication data...
Page 13
Port Part Name & I/O (V) Description 46 NC FLASH writing program starter 47 MD0 Mode setting terminal 48 MD1 Mode setting terminal 49 MD2 Mode setting terminal 50 S W U REQ SUB-u-com wake up INT 3.0 request 51 ROTARY.1 Rotary encoder signal 1(VOL UP) 52 ROTARY.2...
Page 14
Port Part Name & I/O (V) Description 80 X0 MAIN system clock input (12.5MHz) 81 X1 MAIN system clock output (12.5MHz) 82 VCC Positive power supply 83 D0 FLASH D0/LCD D0 84 D1 FLASH D1/LCD D1 85 D2 FLASH D2/LCD D2 86 D3 FLASH D3/LCD D3 87 D4...
Page 15
Port Descriptions 15 CVSS3 16 /CVDD2 I/O system (3.3V) power supply 17 / No Connection HCS(NC) 18 HR/ No Connection W(NC) 19 READY 20 /PS FLASH ROM selection signal 21 /DS(NC) No Connection 22 /IS(NC) No Connection 23 R/W Lead/light signal to FLASH ROM 24 /MSTRB Memory access signal 25 /IOSTRB...
Page 16
Port Descriptions 46 HCNTL1 No Connection / (NC) 47 SI Serial data input 48 CLK M C AUDIO bit clock output 49 SCK Clock input 50 CVSS6 51 / No Connection HINT(NC) 52 CVDD3 CORE CPU system (1.6V) power supply 53 LRCK M AUDIO L/R identifying signal output...
Port Descriptions 112 DVDD5 I/O system (3.3V) power supply 113 D6 Data bus of FLASH ROM 114 D7 115 D8 116 D9 117 D10 118 D11 Data bus of FLASH ROM 119 D12 120 STAT Status signal input 121 D13 Data path of FLASH ROM 122 D14 123 D15...
Page 26
IC404 : YESAM178 12. REPLACEMENT PARTS LIST [CQ-C8352N] Notes : 1. Be sure to make your orders of replacement parts according to this list. 2. Important safety notice: Components, identified by mark have special characteristics important for safety. When replacing any of these components, use only manufacturer's specified parts.
Page 48
14. REPLACEMENT PARTS LIST [CQ-C7302N] Notes : 1. Be sure to make your orders of replacement parts according to this list. 2. Important safety notice: Components, identified by mark have special characteristics important for safety. When replacing any of these components, use only manufacturer's specified parts.
Page 49
3. Location keys in the remarks column indicates the general location of the parts shown in the exploded drawing, as in a road map. 4. The marking (RTL) indicates that Retention Time is limited for this item. After the discontinuation of assembly in production, the item will continue to be available for a specific period of time.
16. CD PLAYER PARTS LIST Notes : 1. Be sure to make your orders of replacement parts according to this list. 2. Important safety notice: Components, identified by mark have special characteristics important for safety. When replacing any of these components, use only manufacturer's specified parts.
Page 67
3. Location keys in the remarks column indicates the general location of the parts shown in the exploded drawing, as in a road map. 4. The marking (RTL) indicates that Retention Time is limited for this item. After the discontinuation of assembly in production, the item will continue to be available for a specific period of time.
Page 68
Ref. No. Part No. Part Name & Description Remarks [3032-14-14] CD Servo Block IC's and TRANSISTORs IC101 YESAM272 IC201 YESAM279 IC401 YESAM275 IC402 YESAM280 IC403 YESAM171 IC404 YESAM178 IC405 YESAM270 Q101 YESAN086 Transistor Q201 YESAN086 Transistor CAPACITORs C101 YESCC187 Ceramic, 0.1 F 25WV C102 YESCC384...
Page 69
Ref. No. Part No. Part Name & Description Remarks C125 YESCC187 Ceramic, 0.1 F 25WV C151 YESCC388 Electrolytic, 100 F 16WV C154 YESCC390 Electrolytic, 220 F 10WV C204 YESCC209 Ceramic, 0.0033 F 50WV C205 YESCC184 Ceramic, 0.0047 F 50WV C206 YESCC187 Ceramic, 0.1 F 25WV...
Page 70
Ref. No. Part No. Part Name & Description Remarks C422 YESCC187 Ceramic, 0.1 F 25WV C451 YESCC389 Electrolytic, 470 F 6.3WV C452 YESCC389 Electrolytic, 470 F 6.3WV C454 YESCC388 Electrolytic, 100 F 16WV RESISTORs J101-105 ERJ8GX0R00V Chip, 0 1/4W L102 YESRG241 Chip, 0 L201...
Page 74
Ref. No. Part No. Part Name & Description Remarks YERFX005004 Select Lock Arm Spring YERFX005013 Suspension Spring YESFX046140 Select Arm R YERFX03004 Link Plate YESFX005137 Link Plate Spring YERFS01001 Cushion F YERFS01002 Cushion R YERFX005014 Feed Spring Plate YERFX046005 Trigger Arm YERFX046008 Select Plate L YERFX046009...
Page 98
19.5. CD Servo Block To Main P.C.B 18P Connector CN101 3032-14-14 TP401 SYS 3.3V L201 L401 L402 Di gital GND R201 6.8k R215 TP202 5.6k R216 5.6k J104 0 R204 1k TP203 BA 5814FM CH1 Spindl e Motor CH2 Fe ed Motor CH3 Loa ding Motor (Not use) CH4 Focus Coil CH5 Tracking Coil...