Home theater systems: digital media port adapter (40 pages)
Summary of Contents for Sony Digital BETACAM CA-701
Page 1
CAMERA ADAPTOR CA-701 MAINTENANCE MANUAL 1st Edition Serial No. 10001 and Higher (Except Japan) Serial No. 30001 and Higher (Japan)
Page 2
! WARNING This manual is intended for qualified service personnel only. To reduce the risk of electric shock, fire or injury, do not perform any servicing other than that contained in the operating instructions unless you are qualified to do so. Refer all servicing to qualified service personnel.
Manual Structure Purpose of this manual This manual is the maintenance manual for Camera Adaptor CA-701. Contents The followings are summaries of the each section for understanding the manual. Section 1 Service Overview Describes information about connection and how to replace the main parts. Section 2 Electrical Alignment Describes electrical adjustment.
When external cables are connected to the connector on the outside panel during maintenance, the hardware listed below (or the equivalents) must be used. Panel indication Matching cable connector/cable Connector Sony part No. SDI OUT 1, 2 1-560-069-11 AUDIO IN CH-3, 4 XLR 3P, MALE...
1-4. Setting the Switches on Board 1-4. Setting the Switches on Board 1-4-1. AD-119 board S153 S103 B side Ref No. Name Description Factory setting S103 CH-3 LIM ON-OFF Selects whether to turn on or off the limiter in the CH-3 audio input stage. ON : CH-3 Audio INPUT LIMITER ON OFF : CH-3 Audio INPUT LIMITER OFF S153...
1-5. Notes on System Connection 1-6. Board Layout 1-5. Notes on System Connection It is necessary to check the following items in the DVW-700/700WS/700P/700WSP when connect them to the CA-701. Perform the measures shown in the figure when the use conditions are not matched. Check item Use condition Measures...
1-7. Replacement of Main Parts 1-7. Replacement of Main Parts 1-7-1. Removal of cabinet Inside panel Loosen three screws and remove the inside panel. (The screws are not pulled out.) Outside panel 1. Loosen three screws and remove the outside panel. (The screws are not pulled out.) 2.
1-7. Replacement of Main Parts 1-7-2. Replacement of 40-pin connector 1. Remove the two screws (–). 4. Solder the new 40-pin connector on the CN-1176 2. Remove the six screws and remove the 40-pin bracket. board. 5. Attach the 40-pin connector in the reverse order of removal steps.
1-7. Replacement of Main Parts 1-7-3. Removal/Installation of flexible card wires on AD-119 board The two flexible card wires are used between the AD-119 board and MB-651 board. Be careful not to bend these wires. This shortens the wire life. Disconnecting 1.
1-7. Replacement of Main Parts 1-7-5. CN-1233 Board Removal 1-7-4. AD-119 Board Replacement The three flexible card wires are used CN-1233 board. Removal Be careful not to bend these wires. This shortens the wire life. 1. Remove the three screws and open the inside panel. 1.
1-8. Notes on Service 1-9. Tool 1-8. Notes on Service 1-8-1. Power circuit breaker 1-8-2. Notes on replacement of V shoe Excessive current in the internal circuitry, whatever the It is necessary to attach the V shoe on the main chassis cause, will trip the internal circuit breaker, automatically with precisely position when will attach the CA-701 on the cutting off the power.
Therefore, specified parts should be used in the case of replacement. 2. Standardization of Parts Some repair parts supplied by Sony differ from those used for the unit. These are because of parts commonality and improvement. Parts list has the present standardized repair parts.
Model Adjustment point : 1 RV1 (D-3)/DIF-41 board : 27.0 ±0.1 MHz Digital betacam camcorder DVW-700/700WS/700P/700WSP Specification AC adapter or Battery Sony AC-550/550CE or equivalent Oscilloscope Tektronix 2465B or equivalent Setting after adjustment Audio analyzer Tektronix AA501A (OP.02) or equivalent •...
MAIN CHASSIS-1 Section 3 Spare Parts B4 × 4 3-1. Exploded Views BTP2.6 × 10 E-1.5 P2.6 × 5 P2.6 × 5 E-1.5 P2.6 × 5 BTP2.6 × 10 (RED) (BLK) Part No. SP Description Part No. SP Description A-8272-689-A o MOUNTED CIRCUIT BOARD, DA-98 3-601-850-01 o PLATE(2),SHIELD A-8272-697-A o MOUNTED CIRCUIT BOARD, DIF-41 3-601-851-01 o RUBBER(1),VENTILATION...
Page 22
MAIN CHASSIS-2 P2 × 3 P2.6 × 4 P2.6 × 4 Part No. SP Description Part No. SP Description A-8272-691-A o MOUNTED CIRCUIT BOARD, MB-651 3-680-952-01 o KNOB,RELEASE LEVER A-8278-025-C s MOUNT,V ASSY 3-694-181-01 s TYPE1,AROCK PRECISION +P2.6 1-565-072-11 s CONNECTOR, CIRCULAR 4P, FEMALE 3-695-267-01 o BRACKET,DC-OUT 1-776-445-11 s WIRE, FLEXIBLE CARD 20P 3-695-273-01 o LID (BOTTOM)
Page 23
INSIDE PANEL B2 × 3 B3 × 15 SET. STC.HEX 3 × 15 WP Part No. SP Description Part No. SP Description A-8272-687-A o MOUNTED CIRCUIT BOARD, AD-119 3-695-258-01 o HINGE(UPPER) X-3678-125-1 s KNOB(2 POSI) ASSY,SW 3-695-259-01 o HINGE(UNDER) X-3678-126-1 s KNOB(3 POSI) ASSY,SW 3-695-270-01 s RUBBER,LCD X-3678-504-3 o PANEL SUB ASSY,INSIDE 3-695-271-01 o SPACER,LCD...
Page 24
OUTSIDE PANEL B3 × 14 B3 × 14 N2.6 TYPE2 Part No. SP Description Part No. SP Description A-8272-700-A o MOUNTED CIRCUIT BOARD, CN-1233 [for SY] 1-774-795-11 s CONNECTOR, XLR 5P, MALE A-8272-708-A o MOUNTED CIRCUIT BOARD, CN-1233A [for J] 3-669-596-01 s WASHER (2.3), STOPPER X-3678-131-1 s KNOB(M)ASSY,SW 3-680-265-01 o PLATE ORNAMENTAL AUDIO(I/P,UC) [for SY]...
3-2. Electrical Parts List ------------ AD-119 BOARD (AD-119 BOARD) ------------ Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No. SP Description A-8272-687-A o MOUNTED CIRCUIT BOARD, AD-119 C252 1-104-553-11 s FILM, CHIP 0.015uF 5% 16V 3-695-277-01 o SPACER,RUBBER C253 1-164-156-11 s CERAMIC, CHIP 0.1uF 25V...
Page 26
(AD-119 BOARD) (AD-119 BOARD) Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No. SP Description Q252 8-729-140-63 s TRANSISTOR 2SA1611-M5M6 R174 1-218-723-11 s METAL, CHIP 20K 0.5% 1/16W Q253 8-729-209-07 s TRANSISTOR 2SC4213-B R175 1-218-723-11 s METAL, CHIP 20K 0.5% 1/16W Q254 8-729-209-07 s TRANSISTOR 2SC4213-B R176...
Page 27
------------------- (AD-119 BOARD) CN-1233/1233A BOARD ------------------- Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No. SP Description S103 1-571-277-31 s SWITCH, SLIDE A-8272-700-A o MOUNTED CIRCUIT BOARD, CN-1233 S104 1-570-842-11 s SWITCH, SLIDE [for SY] S153 1-571-277-31 s SWITCH, SLIDE A-8272-708-A o MOUNTED CIRCUIT BOARD, CN-1233A...
Page 28
(CN-1233/1233A BOARD) (CN-1233/1233A BOARD) Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No. SP Description C259 1-164-156-11 s CERAMIC, CHIP 0.1uF 25V L152 1-412-137-11 s INDUCTOR 10UH C260 1-128-394-11 s ELECT 220uF 20% 10V C261 1-128-394-11 s ELECT 220uF 20% 10V 8-729-020-93 s TRANSISTOR 2SC2982C-TE12L C262...
Page 29
------------- (CN-1233/1233A BOARD) CN-1339 BOARD ------------- Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No. SP Description R208 1-218-716-11 s METAL, CHIP 10K 0.5% 1/16W 1-562-255-00 o HOUSING, 5P R209 1-218-732-11 s METAL, CHIP 47K 0.5% 1/16W 1-562-260-11 o CONTACT, SOCKET R211-215 1-218-692-11 s METAL, CHIP 1K 0.5% 1/16W 1-659-734-11 o PRINTED CIRCUIT BOARD, CN-1339...
Page 30
----------- DA-98 BOARD (DA-98 BOARD) ----------- Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No. SP Description A-8272-689-A o MOUNTED CIRCUIT BOARD, DA-98 C208 1-135-216-11 s TANTALUM, CHIP 10uF 20% 10V 3-695-278-02 o PLATE(DA),ORNAMENTAL C209 1-164-156-11 s CERAMIC, CHIP 0.1uF 25V 3-724-753-01 o RING C210...
Page 31
(DA-98 BOARD) (DA-98 BOARD) Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No. SP Description IC153 8-759-700-84 s IC NJM2041M-D 1-218-700-11 s METAL, CHIP 2.2K 0.5% 1/16W IC157 8-759-603-27 s IC M5201FP R101 1-218-716-11 s METAL, CHIP 10K 0.5% 1/16W IC158 8-759-700-84 s IC NJM2041M-D R102...
Page 32
(DA-98 BOARD) (DA-98 BOARD) Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No. SP Description R193 1-218-716-11 s METAL, CHIP 10K 0.5% 1/16W RB208 1-239-444-11 s NETWORK RESISTOR (CHIP) 220K R194 1-216-849-11 s METAL, CHIP 220K 5% 1/16W R195 1-216-809-11 s METAL, CHIP 100 5% 1/16W 1-237-039-11 s RES, ADJ METAL 100K...
Page 33
------------ DIF-41 BOARD (DIF-41 BOARD) ------------ Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No. SP Description A-8272-697-A o MOUNTED CIRCUIT BOARD, DIF-41 8-759-080-06 s IC TC74VHC574FS(EL) 3-601-849-01 o PLATE(1),SHIELD 8-759-147-05 s IC UPD42101G-3 3-601-850-01 o PLATE(2),SHIELD 8-759-080-03 s IC TC74VHCT541FS(EL) 2pcs 3-601-851-01 o RUBBER(1),VENTILATION...
Page 34
------------ (DIF-41 BOARD) DP-234 BOARD ------------ Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No. SP Description 1-208-806-11 s METAL, CHIP 10K 0.5% 1/10W 1-659-725-11 o PRINTED CIRCUIT BOARD, DP-234 1-216-635-11 s METAL, CHIP 220 0.5% 1/10W 3-695-271-01 o SPACER,LCD 1-216-635-11 s METAL, CHIP 220 0.5% 1/10W 1-216-625-11 s METAL, CHIP 82 0.5% 1/10W...
Page 35
------------ ------------ MB-651 BOARD RE-123 BOARD ------------ ------------ Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No. SP Description A-8272-691-A o MOUNTED CIRCUIT BOARD, MB-651 A-8272-699-A o MOUNTED CIRCUIT BOARD, RE-123 6pcs 3-729-061-01 s SCREW (M2X4.5) (TYPE 1) 3-695-280-02 o PLATE(RE),ORNAMENTAL 3-724-753-01 o RING 1-102-074-00 s CERAMIC 0.001uF 10% 50V...
Page 36
(RE-123 BOARD) (RE-123 BOARD) Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No. SP Description C209 1-163-037-11 s CERAMIC, CHIP 0.022uF 10% 25V 1-409-579-11 s COIL, CHOKE 8.2uH C210 1-164-004-11 s CERAMIC, CHIP 0.1uF 10% 25V 1-409-721-11 s COIL, CHOKE 42uH C212 1-135-210-11 s TANTALUM, CHIP 4.7uF 20% 10V...
Page 37
(RE-123 BOARD) (RE-123 BOARD) Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No. SP Description 1-216-674-11 s METAL, CHIP 9.1K 0.5% 1/10W R226 1-216-684-11 s METAL, CHIP 24K 0.5% 1/10W 1-216-696-11 s METAL, CHIP 75K 0.5% 1/10W R227 1-218-760-11 s METAL, CHIP 220K 0.5% 1/10W 1-208-810-11 s METAL, CHIP 15K 0.1% 1/10W...
Page 38
----- FRAME ----- Ref. No. or Q'ty Part No. SP Description 2pcs 1-774-157-11 s CONVERTER, COAXIAL CONNECTOR 1-776-444-11 s CABLE, COAXIAL 150MM 1-776-444-21 s CABLE, COAXIAL 150MM 2pcs 1-776-445-11 s WIRE, FLEXIBLE CARD 20P (CN11/HN-225 board to CN501/MB-651 board) (CN12/HN-225 board to CN502/MB-651 board) 2pcs 1-776-446-11 s WIRE, FLEXIBLE CARD 20P (CN1/AD-119 board to CN401/MB-651 board)
SEMICONDUCTOR Section 4 Semiconductor Pin Assignments Semiconductors of which functions are equivalent are described here. For parts replacement, refer to the section of Spare Parts in this manual. The circuit diagram of each IC is obtained from the IC data book published by the manufacturer. DIODE PAGE TRANSISTOR...
Page 40
DIODE, TRANSISTOR DIODE TRANSISTOR (SCALE 4/1) ********** EC10DS2 TOP VIEW 1S2836 TOP VIEW 2SA1314C-TE12L ****** TOP VIEW TOP VIEW TOP VIEW 1SS184 2SA1462 EA60QC06-F DAN202U ECL06B025-F 2SA1611 (SCALE 4/1) ********** TOP VIEW MBRS130LT3 2SC1623 1SS226 2SC2713G 2SC3356 2SC4177-L6 2SC4213B ********** (SCALE 4/1) TOP VIEW CL-181Y-C ;YELLOW...
Page 44
CXD8281Q(SONY)FLAT PACKAGE C-MOS DIGITAL AUDIO TIME BASE COMPRESSION FOR SIF TRANSMITER CA-701...
Page 45
CXD8385Q(SONY) C-MOS ENCODER INPUT PERROR1 ANC0-ANC9 ANCILLARY DATA —TOP VIEW— PERROR2 ANIS ANC GATE CONTROL CF1/CF2 CF DATA XZLD POUT CFINFO CFINFO CONTROL MUD0 CK27 27 MH CLOCK MUD1 COMP COMPOSIT/COMPONENT MUD2 D1/J2,SLNP MODE CONTROL MUD3 EXTF REF F MUD4...
Page 46
HD6435348RA00F(HITACHI) C-MOS 8-BIT 1-CHP MICROCOMPUTER -TOP VIEW- EXTAL XTAL STBY /IRQ /IRQ /IRQ /IRQ = (+ 5V ) SIGNAL No. I/O SIGNAL INPUT ADTRG ; EXTERNAL TRIGGER P63/PM3/IRO /A19 P21/R/W AN0 - AN7 ; ANALOG DATA P22/DS BREQ ; BUS REQUEST P23/RD P70/TMCI EXTAL...
Page 47
LC75821W(SANYO) LCD DRIVER - TOP VIEW - PORT 7 PORT 8 PORT 9 /IRQ /IRQ /IRQ (+3.0 to 6.5V) 10-BIT OPEN WATCHDOG /IRQ A/D CONVERTER TIMER (+3.0 to V ( X8 CHANNEL ) 16-BIT FREE PWM TIMER RUNNING TIMER ( X3 CHANNEL ) ( X3 CHANNEL ) SERIAL COMMUNICATION...
Page 48
M62352GP(MITSUBISHI)FLAT PACKAGE M5201FP(MITSUBISHI)FLAT PACKAGE C-MOS 8-BITx12 CHANNEL D/A CONVERTER DUAL OPERATIONAL AMPLIFIERS WITH SWITCHED OUTPUT (WITH BUFFER OPERATIONAL AMPLIFIER) -TOP VIEW- — TOP VIEW — SW CONTROL A (+) A (–) A (+) B (+) OUTPUT B (+) B (–) A (–) B (–) SW CONTROL...
Page 49
PGM VERIFY : DON'T CARE HI-Z: HIGH IMPEDANCE + 12.5V + 6V HI-Z PGM INH OUTPUT ENABLE OE/Vp-p CHIP ENABLE & SBX1601A(SONY) OUTPUT BUFFERS PROGRAM LOGIC 8- OR 10-BIT PARALLEL-TO-SERIAL CONVERTER -BOTTOM VIEW- TTL/ECL Y-GATING DECODER INDEX D9X(MSB) 512k-BIT DECODER...
Page 50
TC4W53F(TOSHIBA)CHIP PACKAGE(5.0 X 3.1) TC74VHC04F(TOSHIBA)FLAT PACKAGE C-MOS 2-CHANNEL MULTIPLEXER / DEMULTIPLEXER C-MOS HEX INVERTERS —TOP VIEW— (SCALE 3/1) —TOP VIEW— OPEN DD(+3 to +18V) Y = A GND 4 0 ; LOW LEVEL CONT.INPUT 1 ; HIGH LEVEL CHANNEL 0 ; LOW LEVEL NOTE: 1 ;...
Page 51
TC74VHC574FS(EL)(TOSHIBA)FLAT PACKAGE(SMALL) TC74VHC164F(TOSHIBA)FLAT PACKAGE IL08 C-MOS 3-STATE D-TYPE EDGE-TRIGGERED FLIP-FLOP C-MOS 8-BIT SERIAL-IN/PARALLEL-OUT SHIFT REGISTER —TOP VIEW— EACH FLIP-FLOP INPUTS HI-Z ; LOW LEVEL ; HIGH LEVEL ; DON'T CARE HI-Z ; HIGH IMPEDANCE ; NO CHANGE Q1 D2 Q2 D3 Q3 D4 Q4 D5 Q5 D6...
Page 52
TC7SH04FU(TOSHIBA)CHIP PACKAGE TC7W14FU(TOSHIBA)CHIP PACKAGE C-MOS HEX INVERTERS C-MOS INVERTER -TOP VIEW- (SCALE 6/1) —TOP VIEW— Y = A Y = A GND 3 Y = A 0 ; LOW LEVEL TYPE 0 ; LOW LEVEL 1 ; HIGH LEVEL 1 ; HIGH LEVEL 7S04F +2 to +6V 7SU04F...
RE-123 RE-123 CB101 IC101,102 IC81 POWER DC OUT UNREG +12V IN DC OUT UNREG +12V IN DC OUT Q60-62 1-10 DC IN UNREG +12V IN UNREG +12V IN UNREG +12V 1-49 DA,1-50 UNREG +12V L:POWER SW ON 1-50 DIF,1-49/50 AD,1-20 1-11 CAM UNREG HN,11-3/4...
Page 58
OHB-400/500/500WS & PAL OHB-450/451/550/550WS & PAL...
FRAME WIRING FRAME WIRING CA-701 (J) CA-701 (SY) LCD1 AD-119 BOARD DP-234 BOARD OVER EMPHA OVER S101(1/2) POWER OFF HARNESS DIGITAL +5.0V DIGITAL +5.0V SELECT ON (PSW-AD5) LCD DATA LCD DATA ALL ON L:POWER ON L:POWER SW ON LCD CLOCK LCD CLOCK LCD CE LCD CE...
Page 83
MB-651, DP-234, HN-225 MB-651, DP-234, HN-225 DP-234 DP-234 - A SIDE - - B SIDE - 1-659-725-11 1-659-725-11 MB-651 - A SIDE - 1-659-731-11 HN-225 HN-225 - A SIDE - - B SIDE - 1-659-724-11 1-659-724-11 MB-651 - B SIDE - 1-659-731-11 MB-651 BOARD (1-659-731-11) CN101...
CN-1233/1339, SW-819 CN-1233/1339, SW-819 CN-1233 CN-1233 - B SIDE - - A SIDE - 1-659-732-11 1-659-732-11 CN-1233 BOARD (1-659-732-11) J301 * D3 L101 * C3 L102 * D3 CN101 L151 * B3 CN151 L152 * C3 * C1 D101 * C2 SW-819 SW-819 - B SIDE -...
Page 85
The material contained in this manual consists of information that is the property of Sony Corporation and is intended solely for use by the purchasers of the equipment described in this manual. Sony Corporation expressly prohibits the duplication of any portion of this manual or the use thereof for any...