All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by WS 0572 Customer Service...
Safety Instructions, Warnings, and Notes LC4.1HE AB EN 3 Mini Jack: Audio Head phone - Out RJ45: DATA2 (Xpress Box- In/Out) Bk - Head phone 32 - 600 ohm / 10 mW - +12V +12 V / 1 W - GND...
EN 4 LC4.1HE AB Mechanical Instructions 4. Mechanical Instructions Service Position Index of this chapter: 4.1 Service Position 4.2 Cable Dressing 4.1.1 Foam Bars 4.3 Assy/Panel Removal 4.4 Set Re-assembly Notes: • Only information that is related to the iTV module, is published in this manual.
Page 5
Mechanical Instructions LC4.1HE AB EN 5 Assy/Panel Removal 4.3.3 Side I/O Panel 4.3.1 Rear Cover Warning: Disconnect the mains power cord before you remove the rear cover. 1. Remove the screws that secure the rear cover. 2. Lift the rear cover from the cabinet cautiously. Make sure that wires and other internal components are not damaged during cover removal.
EN 6 LC4.1HE AB Service Modes, Error Codes, and Fault Finding 5. Service Modes, Error Codes, and Fault Finding See the relevant chassis manual (order code on front page). Personal Notes: E_06532_012.eps 131004...
Block Diagrams, Test Point Overviews, and Waveforms LC4.1HE AB 6. Block Diagrams, Test Point Overviews, and Waveforms Wiring Diagram 15” Wiring 15” TOP CONTROL 1684 I BOARD 8408 LVDS CONNECTOR LEFT RIGHT TO DISPLAY SPEAKER SPEAKER 8951 8910 1951 1910...
Page 8
Block Diagrams, Test Point Overviews, and Waveforms LC4.1HE AB Wiring Diagram 20” & 23” WIRING 20” AND 23” I BOARD 8400 8405 THE NUMBERS BETWEEN ( ) 8408 ARE FOR THE 20” DISPLAYS LVDS CONNECTOR LEFT RIGHT TO DISPLAY SPEAKER...
Block Diagrams, Test Point Overviews, and Waveforms LC4.1HE AB Block Diagram Audio & Control AUDIO SIDE AV TUNER + IF HERCULES AUDIO AMPLIFIER AUDIO AMPLIFIER (20”, 23”) 7712 7217 1302 TDA1517ATW TDA15021H UR1316S F306 2321 1330 SIF2 IF-TER TV IN...
Block Diagrams, Test Point Overviews, and Waveforms LC4.1HE AB Supply Voltage Overview SUPPLY LINE OVERVIEW AUDIO AMPLIFIER TV SUPPLY TUNER + IF SUPPLY PANEL SCALER (PSU) 1703 1200 INVERTER F903 F905 MODULE SIDE I/O HERCULES 1003 1004 F906 SCALER IO...
Circuit Diagrams and PWB Layouts LC4.1HE AB 7. Circuit Diagrams and PWB Layouts Side I/O Panel & LKB 15” SIDE I/O 15” 1002 LEDIN_SCL1 IRIN_DATA-IN TO i-BOARD MODE_12V STATUS_DATA-OUT MODE_12V DGND IR OUT RJ12 TV_12V 1004 HSYN 1001 5002 VSYN...
Page 16
Circuit Diagrams and PWB Layouts LC4.1HE AB Layout Side I/O Panel 15” (Top Side) Personal Notes: 3139 123 5986.2 F_15790_013.eps 061205 Layout Side I/O Panel 15” (Bottom Side) E_06532_012.eps 3139 123 5986.2 F_15790_014.eps 131004 061205...
Circuit Diagrams and PWB Layouts LC4.1HE AB Side I/O & Panel & LKB 20” & 23” SIDE I/O 20” & 23” 1002 LEDIN_SCL1 IRIN_DA TA-IN TO i-BOARD M ODE_12V 4003 1004 STATUS_DA TA-OUT 5002 M ODE_12V DGND JUM PER 10uH...
Page 18
Circuit Diagrams and PWB Layouts LC4.1HE AB Layout Side I/O Panel 20” & 23” (Top Side) F_15790_016.eps 3139 123 6159.1 061205 Layout Side I/O Panel 20” & 23” (Bottom Side) F_15790_017.eps 3139 123 6159.1 061205...
Circuit Diagrams and PWB Layouts LC4.1HE AB Layout LED and IR Panel (Top Side) Personal Notes: F_15800_013.eps 3139 123 6097.2 281105 Layout LED and IR Panel (Bottom Side) E_06532_012.eps F_15800_014.eps 3139 123 6097.2 131004 281105...
Alignments LC4.1HE AB EN 25 8. Alignments Index of this chapter: Table 8-1 Option Bytes (OP1 .. 7) overview 8.1 General Alignment Conditions 8.2 Hardware Alignments OP Bit Feature / Mode 8.3 Software Alignments Notes: • Only information that is related to the iTV module, is published in this manual.
Page 26
EN 26 LC4.1HE AB Alignments 8.3.2 ADC Gain and Grey Scale Alignment Caution: • Do not change the NVM settings without understanding the function of each setting, because The table below shows a number of important NVM settings (in incorrect NVM settings may seriously hamper the decimal values) used for each TV model.
Page 27
Alignments LC4.1HE AB EN 27 Byte/Addr. Bit Feature/Mode Description 15HF5443/10 20HF5473/10 23HF5473/10 Byte 6/ LTI status LTI last status 180(dec) INC_LIFE_TIME PC_MODE HD_MODE TACT_SWITCH SET_IN_SPECIAL_STBY HOTEL_OSDDISPLAY HOTEL_MONITOROUT Total Dec Values Byte 7/ HOTEL_ICONNMODE 181(dec) Dynamic Bass Enhancement Status SET_IN_PC_SLEEP_MODE Reserved...
Intermediate Frequency Infra Red Use the specific manual (order code on front page). Institutional TV LC04 Philips chassis name for LCD TV 2004 project Liquid Crystal Display Light Emitting Diode; A semiconductor diode that emits light when a current is...