Advertisement
PELLET SMOKER & GRILL
OWNER'S MANUAL
SAVE THIS MANUAL FOR FUTURE REFERENCE
ASSEMBLY AND OPERATING IN STRUC TIONS
Model SMK2028AS
WARNING / ADVERTENCIA
NOTICE TO
PLEASE READ THIS ENTIRE MANUAL BEFORE
INSTALLER:
INSTALLATION AND USE OF THIS PELLET FUEL-
BURNING APPLIANCE. FAILURE TO FOLLOW THESE
LEAVE THESE
INSTRUCTIONS COULD RESULT IN PROPERTY
INSTRUCTIONS
DAMAGE, BODILY INJURY OR EVEN DEATH. CONTACT
WITH THE GRILL
LOCAL BUILDING OR FIRE OFFICIALS ABOUT
OWNER FOR
RESTRICTIONS AND INSTALLATION INSPECTION
FUTURE
REQUIREMENTS IN YOUR AREA. SAVE THESE
REFERENCE .
INSTRUCTIONS.
Advertisement
Related Manuals for Even Embers SMK2028AS
Summary of Contents for Even Embers SMK2028AS
- Page 1 PELLET SMOKER & GRILL OWNER’S MANUAL SAVE THIS MANUAL FOR FUTURE REFERENCE ASSEMBLY AND OPERATING IN STRUC TIONS Model SMK2028AS WARNING / ADVERTENCIA NOTICE TO PLEASE READ THIS ENTIRE MANUAL BEFORE INSTALLER: INSTALLATION AND USE OF THIS PELLET FUEL- BURNING APPLIANCE. FAILURE TO FOLLOW THESE...
- Page 2 IMPORTANT SAFETY WARNINGS WE WANT YOU TO ASSEMBLE AND USE YOUR SMOKER AS SAFELY AS POSSIBLE. THE PURPOSE OF THIS SAFETY ALERT SYMBOL IS TO ATTRACT YOUR ATTENTION TO POSSIBLE HAZARDS AS YOU ASSEMBLE AND USE YOUR SMOKER/GRILL. WHEN YOU SEE THE SAFETY ALERT SYMBOL, PAY CLOSE ATTENTION TO THE INFORMATION WHICH FOLLOWS! READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY BEFORE ASSEMBLING AND OPERATING YOUR SMOKER/GRILL.
-
Page 3: Table Of Contents
TABLE OF CONTENTS: General Warnings ..........3-4 Operating the Grill . -
Page 4: General Warnings
GENERAL WARNINGS: WARNING When using electric appliances, basic safety precautions should always be followed including the following: • Operate only per manufacturers instructions. • Keep all combustible materials at least 36 inches (66 cm) away from the grill at all times. Do not use this grill under any overhang or near any combustible structures. - Page 5 • This product is not designed for tabletop use. Do not set this product on a tabletop. • Outdoor extension cords must be used with outdoor use products and are marked with suffix “W” and with the statement “Suitable for Use with Outdoor Appliances.” •...
-
Page 6: Operating The Grill
USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR PELLET SMOKER & GRILL. FAILURE TO ADHERE TO THE SAFETY WARNINGS AND GUIDELINES IN THIS MANUAL COULD RESULT IN SEVERE BODILY INJURY OR PROPERTY DAMAGE. SAVE THIS MANUAL FOR FUTURE REFERENCE. OPERATING THE GRILL: WARNING Read and follow all warnings and instructions contained in the preceding sections of this manual. - Page 7 Step 2 Make sure temperature control knob is “OFF” . Plug power cord into a GFCI (grounded) outdoor electrical outlet. Step 3 Open the pellet hopper lid. Make sure the auger is free from debris and other objects. Turn the temperature control knob Control Panel to “SMOKE”...
- Page 8 Follow these steps If the grill does not ignite or if the fi re in the fi re pot goes out while cooking: Step 1 Turn the temperature control knob to “OFF” and unplug. Open cooking chamber lid and remove all food, cooking grills, grease tray and heat distribution plate. CAUTION: Some parts may contain sharp edges.
- Page 9 ® • Your Even Embers Pellet Smoker & Grill should never be moved while it is hot. If you are transporting your grill in a vehicle after cooking on it, make sure the fi re is completely out and the grill is cold before placing it in any vehicle.
-
Page 10: Proper Care And Maintenance
PROPER CARE & MAINTENANCE: • Remove wood pellets from hopper if grill will not be used for a long period of time. Wood pellets can become soggy due to moisture/humidity and can cause the auger to bind up or not push pellets to burn chamber. -
Page 11: Transporting And Storage
TRANSPORTING AND STORAGE: WARNING • Never move a grill when it is hot or when objects are on the cooking surfaces. • Never store fl ammable liquids or spray canisters under or near the grill. • DO NOT extinguish grease fi res using water. BEFORE STORING YOUR GRILL: •... -
Page 12: Trouble Shooting
TROUBLE SHOOTING: PROBLEM CAUSE CORRECTION Electric 1. Reseat plug in a 3-wire grounded GFCI 1. Check that the 3-wire plug is fully seated outlet wired for 120 volts. into a 3-wire grounded GFCI outlet wired element for 120 volts. 2. Reset breakers or replace fuse. will not 2. - Page 13 WIRING DIAGRAM: POWER CORD MOLEX TYPE CONNECTOR 4-TYPICAL BLACK WHITE ORANGE WHITE WHITE PURPLE WHITE BLOWER FAN AUGER MOTOR FIRE POT HOT ROD NOTE: FUSE IS LOCATED ON BACK OF CONTROL. Maximum Fuse Size: 5mm x 20 mm, 5 amps...
-
Page 14: Assembly Instructions
ASSEMBLY INSTRUCTIONS: Make sure you have all items listed under PARTS LIST and PARTS CARD CONTENTS before you begin the installation process. M8 Wheel Nuts - 2 Pcs M6 Lock Washers M4 x 10 mm Bolts - 20 Pcs & M4 Nuts - 2 Pcs M6 x 12 mm Bolts - 38 Pcs Wheel Axles... - Page 15 BEFORE ASSEMBLING AND OPERATING YOUR EVEN EMBERS® PELLET SMOKER & GRILL. FOR MISSING PARTS, PLEASE CALL CUSTOMER SERVICE AT 855-735-9922. (Proof of purchase will be required.) The following tools are required to assemble your Even Embers ® Pellet Smoker & Grill: • Phillips Screwdriver • Wrench...
- Page 17 Smoke Stack Opening Grease Hole Place grill body on its end with the lid open as illustrated. Grill Body Assembly (16) M6 Bolts (16) M6 Lock Washers Note: Do not fully tighten...
- Page 18 (4) M6 Bolts (4) M6 Lock Washers Note: Fully tighten (2) Wheel Axle Bolts (2) M8 Nuts (2) Wheel Washers Note: Fully tighten...
- Page 19 (2) Washers (2) Wingnuts Note: The washers and wing nuts are pre- attached to the handle. (4) M6 Bolts (4) M6 Nuts (1) Felt Gasket...
- Page 20 (4) M6 Bolts (2) M4 Bolts (2) M4 Nuts (4) M6 Bolts...
- Page 21 (2) Wingbolts (4) M6 Bolts (4) M6 Nuts...
- Page 22 Chimney (2) M6 Bolts Note: Screw on smokestack cap clockwise. Grease Drainage Tray Step B - Install cooking grates. Step A - Install grease tray.
- Page 23 Even Embers Pellet Smoker and Grill - Assembled...
- Page 24 WARRANTY ® Boltz Group warrants to the original purchaser that the Even Embers Pellet Fuel Grill is free from defects due to workmanship or materials for: One-year: frame, housing, cart, cooking grates, electric heating elements, temperature controller and other related parts Boltz Group obligations under this warranty are limited to the following guidelines: •...
Need help?
Do you have a question about the SMK2028AS and is the answer not in the manual?
Questions and answers