Summary of Contents for MULTIQUIP Stow Cutter 3 CC813H20
Page 1
HONDA GASOLINE ENGINES CC813H20, CS813H20, CS820H20 MODEL # SERIAL # Revision #8 (09/22/06) STOW CONSTRUCTION EQUIPMENT PARTS DEPARTMENT: A DIVISION OF MULTIQUIP INC. 800-427-1244 POST OFFICE BOX 6254 FAX: 800-672-7877 SERVICE DEPARTMENT/TECHNICAL ASSISTANCE: CARSON, CA 90749 310-537-3700 • 888-252-STOW [888-252-7869] 800-478-1244 FAX: 310-537-1986 •...
Page 3
HERE'S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING PARTS DEPARTMENT 800-427-1244 FAX: 800-672-7877 310-537-3700 FAX: 310-637-3284 SERVICE DEPARTMENT 800-478-1244 FAX: 310-537-4259 310-537-3700 TECHNICAL ASSISTANCE 800-478-1244 FAX: 310-631-5032 WARRANTY DEPARTMENT 800-421-1244, EXT. 279 FAX: 310-537-1173 310-537-3700, EXT.
Direct TOLL-FREE access STOW CONSTRUCTION EQUIPMENT STOW CONSTRUCTION EQUIPMENT STOW CONSTRUCTION EQUIPMENT STOW CONSTRUCTION EQUIPMENT STOW CONSTRUCTION EQUIPMENT A DIVISION OF MULTIQUIP INC. to our Parts Department: POST OFFICE BOX 6254 CARSON, CA 90749 310-537-3700 • 888-252-STOW [888-252-7869] Toll-free nationwide — 800-427-1244 FAX: 310-537-1986 •...
Page 6
STOW CUTTER 3 SAW — SPECIFICATIONS r e t r e t f l e e l l y t i . n i . n i i t t . n i . n i . n i . n i .
STOW CUTTER 3 SAW — SAFETY MESSAGE ALERT SYMBOLS FOR YOUR SAFETY AND THE SAFETY OF OTHERS! HAZARD SYMBOLS Safety precautions should be followed at all times when operating this equipment. Failure to read and understand the Safety Messages and Operating Instructions could result in Lethal Exhaust Gases injury to yourself and others.
Page 9
STOW CUTTER 3 SAW — SAFETY MESSAGE ALERT SYMBOLS Accidental Starting Respiratory Hazard ALWAYS place the ON/OFF switch in the OFF position, remove key and/or disconnect the ALWAYS wear approved respiratory spark plug lead before servicing the engine protection. or equipment. Ground the lead to prevent sparks that could ignite a fire.
Fire or explosion could result NEVER use accessories or attachments, which are not from fuel vapors , or if fuel is spilled on recommended by or Multiquip for this equipment. Damage a hot! engine. to the equipment and/or injury to user may result.
Page 11
STOW CUTTER 3 SAW — RULES FOR SAFE OPERATION Diamond Blade Safety General Safety Use appropriate steel centered diamond blades ALWAYS read, understand, and follow procedures in manufactured for use on slab saws. Operator's Manual before attempting to operate equipment. Examine blade flanges for damage, excessive wear and ALWAYS be sure the operator is familiar with proper safety cleanliness before mounting blade.
Page 12
STOW CUTTER 3 SAW — RULES FOR SAFE OPERATION Maintenance Safety Emergencies NEVER lubricate components or attempt service on a ALWAYS know the location of running machine. the nearest fire extinguisher . ALWAYS allow the machine a proper amount of time to cool before servicing.
STOW CUTTER 3 SAW — DECALS Machine Safety Decals The Cutter 3 saws are equipped with a number of safety decals (Figure 2). These decals are provided for operator safety and maintenance information. The illustration below shows these decals as they appear on the slab saws. Should any of these decals become unreadable, replacements can be obtained from you dealer.
STOW CUTTER 3 SAW — MAJOR COMPONENTS Figure 3. Cutter 3 Major Components Figure 3 displays the location of the various operational control Water ON/OFF Valve – ON position opens valve and permits water to flow from source through saw water hose. features of the Cutter 3 Saw.
Page 15
STOW CUTTER 3 SAW — 13HP HONDA ENGINE COMPONENTS Figure 4. Engine Controls and Components (Honda GX390K1QWT2) INITIAL SERVICING The engine (Figure 4) must be checked for proper lubrication and filled with fuel prior to operation. Refer to the manufacturers Engine manual for instructions &...
Page 16
STOW CUTTER 3 SAW — 20HP HONDA ENGINE COMPONENTS Figure 5. Engine Controls and Components (Honda GX620TXF2) INITIAL SERVICING The engine (Figure 5) must be checked for proper lubrication and filled with fuel prior to operation. Refer to the manufacturer's engine manual for instructions &...
STOW CUTTER 3 SAW — GENERAL INFORMATION Familiarization Water System The Cutter 3 saws are designed for wet or dry cutting of concrete All saws provide a water direction system to provide cooling or asphalt utilizing diamond blades. They have been engineered water to the diamond blade.
STOW CUTTER 3 SAW — INSPECTION 3. Insert and remove the dipstick without screwing it into the filler Before Starting neck. Check the oil level shown on the dipstick. 1. Read safety instructions at the beginning of manual. 4. If the oil level is low (Figures 6 and 7), fill to the edge of the 2.
Page 19
STOW CUTTER 3 SAW — INSPECTION Battery (Self-Propelled models only) - The 12-volt DC battery Hydrostatic Transmission (Self-Propelled models only) - (Figure 10) is shipped dry, and will require a proper electrolyte An EATON® Model 7 hydrostatic transmission (Figure 8) level for operation.
STOW CUTTER 3 SAW — INSPECTION -BLADE Directional Arrow – Check to ensure that the blade is WARNING WARNING WARNING WARNING WARNING oriented properly on the blade shaft for sawing. Reference the directional arrow in the blade and place it so the direction Failure to thoroughly inspect the diamond blade (Figure 11) of rotation “downcuts”...
STOW CUTTER 3 SAW — INSPECTION - BLADE PLACEMENT Blade Nut – Remove the blade nut (4). For reassembly, The following steps should be NOTE DO NOT over tighten the blade nut against the outer flange. accomplished before placing the Tighten blade nut approximately 45-50 ft-lbs/62-69 N/m.
Page 22
STOW CUTTER 3 SAW — INSPECTION -GUARDS, COVERS & BELTS Guards and Covers Check V-Belts and Covers WARNING WARNING WARNING CAUTI CAUTI WARNING WARNING CAUTI CAUTION CAUTI NEVER operate the saw without blade NEVER attempt to check the V-belt with the guards and covers (Figures 13, 14 and 15) engine running because severe injury can in place.
Page 23
STOW CUTTER 3 SAW — INSPECTION - BELTS & WATER TANK 3. Check V-belt tension (Figure 17) by using a tensionmeter Water Tank (6.0 - 9.0 lbs.) against the inside belt at a mid point between The Cutter 3 saw is equipped with a removable 5-gallon on- the two pulleys, or by deflecting the center belt at a mid point board water tank fitted in the top of the console which can be 3/8”...
STOW CUTTER 3 SAW — MANUAL START-UP (13HP HONDA ENGINE) The CLOSED position of the choke CAUTI CAUTI CAUTI CAUTI CAUTION lever enriches the fuel mixture for NOTE starting a COLD engine. The OPEN DO NOT attempt to operate the saw until the Safety, General position provides the correct fuel Information and Inspection sections have been read and mixture for normal operation after...
Page 25
STOW CUTTER 3 SAW — MANUAL START-UP (13HP HONDA ENGINE) 7. Place the throttle lever (Figure 23) halfway between FAST 9. If the engine has started, slowly return the choke lever and SLOW for starting. All sawing is done at full throttle. The (Figure 22) to the CLOSED position.
Page 26
STOW CUTTER 3 SAW — ELECTRIC START-UP (20HP HONDA ENGINE) The CLOSED position of the choke CAUTI CAUTI CAUTI CAUTION CAUTI lever enriches the fuel mixture for NOTE starting a COLD engine. The OPEN DO NOT attempt to operate the saw until the Safety, General position provides the correct fuel Information and Inspection sections have been read and mixture for normal operation after...
Page 27
STOW CUTTER 3 SAW — SHUT-DOWN PROCEDURES Stopping the Engine (13 HP Honda Engine) Stopping the Engine (20 HP Honda Engine) forward/reverse speed lever in the NEUTRAL WARNING WARNING 1. Place the WARNING WARNING WARNING position (Self propelled models only). NEVER stop the engine while the blade is in the cut, except for 2.
Page 28
STOW CUTTER 3 SAW — OPERATION Adjusting the Blade Height CAUTI CAUTI CAUTION CAUTI CAUTI The Cutter 3 saw uses a manual raise/lower crank handle located on the console with clockwise rotation providing lowering NEVER stop the engine while cutting at high speeds, except for action, and counter-clockwise rotation providing raising and extreme emergencies.
Page 29
STOW CUTTER 3 SAW — OPERATION Traveling During Cutting (Push) 3. Move the travel lever towards the FORWARD position to increase forward travel speed during cutting (Figure 40). Push models of the Cutter 3 saw must be manually moved by the Placing the travel lever fully forward will move the saw at operator during cutting operations.
Page 30
STOW CUTTER 3 SAW — OPERATION Cutting WARNING WARNING WARNING WARNING WARNING The operator MUST wear the appropriate protective equipment and clothing while engaged in sawing. Failure to do so can result in SERIOUS INJURY. Figure 44. Water System ON/OFF Valve DANGER DANGER DANGER...
Page 31
STOW CUTTER 3 SAW — OPERATION Finishing A Cut Diamond Blades 1. Raise the blade out of the cut by cranking the Raise/Lower Diamond blade sawing consists of cutting WET (using water to cool the blade) or DRY (using the circulating air to cool the blade). handle COUNTER-CLOCKWISE (Figure 37).
STOW CUTTER 3 SAW — MAINTENANCE Maintenance Engine air filter: Clean air filter 2 to 3 times daily when DRY cutting. See WARNING WARNING WARNING WARNING WARNING Engine Owner’s Manual for detailed information. Engine tank & strainer: General maintenance practices are crucial to the Clean every year/or 300 hours.
Page 33
STOW CUTTER 3 SAW — MAINTENANCE General Transmission Care (Self-Propelled Models only) Spline Gear Wheels: All CUTTER 3 model saws utilize spline gear wheel design Check every 25 hours and clean as necessary. If the spline coupled with an EATON Model 7 Hydrostatic Transmission that wheels DO NOT engage the rear wheels with sufficient provides forward/reverse propulsion.
Page 34
Drive V-Belt(s) Replacement & Tension Adjustments 2. A change in Pulley diameters may require specifically sized Reference Pointers and Covers Assembly, Blade Shaft Assembly, V-Belts. Contact Multiquip Service Department to en- and Engine Mount Assembly for this operation. sure V-Belt compatibility.
Page 35
STOW CUTTER 3 SAW — MAINTENANCE Blade Shaft Bearing Replacement Reference Figure 50 & Figure 51 for steps 4-9 4. Remove Blade Hex Nuts (Figures 50 & 51, item 1) and The Cutter 3 saw is supported by “tapped base lock collar (w/set Outside/Inside Blade Flanges (Figures 50, item 2 &...
Page 36
STOW CUTTER 3 SAW — MAINTENANCE Battery Maintenance Check the battery regularly and make sure that each electrolyte level is to the bottom of the vent well Mishandling of the battery shortens the service life of the battery (Figure 43). If necessary add only distilled water in a and adds to maintenance cost.
STOW CUTTER 3 SAW — TROUBLESHOOTING (ENGINE) Practically all breakdowns can be prevented by proper handling and maintenance inspections, but in the event of a breakdown, please take a remedial action following the diagnosis based on the Engine Troubleshooting (Table 7) information shown below and on the proceeding page.
Page 40
STOW CUTTER 3 SAW — TROUBLESHOOTING (ENGINE) r i A e l c a e l a l p r i a e l c l f k t a o j d a t s u , t n - e r d l i n i l...
STOW CUTTER 3 SAW — TROUBLESHOOTING (BLADE) Practically all breakdowns can be prevented by proper handling and maintenance inspections, but in the event of a breakdown, please take a remedial action following the diagnosis based on the Blade Troubleshooting (Table 8) information shown below and on the proceeding page.
Page 42
STOW CUTTER 3 SAW — EXPLANATION OF CODE IN REMARKS COLUMN How to read the marks and remarks used in this parts book. Items Found In the “Remarks” Column Serial Numbers-Where indicated, this indicates a serial number range (inclusive) where a particular part is used. Model Number-Where indicated, this shows that the corresponding part is utilized only with this specific model number or model number variant.
STOW CUTTER 3 SAW — POINTERS AND COVERS ASSY. POINTERS AND COVERS ASSY. PAGE 64 — STOW CUTTER 3 SAW — OPERATION & PARTS MANUAL — REV. #8 (09/22/06)
Page 65
STOW CUTTER 3 SAW — POINTERS AND COVERS ASSY. POINTER AND COVERS ASSY. PART NO PART NAME QTY. REMARKS 28646-351 BLADE GUIDE WELDMENT 28649-001 SPANNER BUSHING CSI 28648-001 WHEEL, 3.00 X 1.25 .50 ID POLY CSI 28647-001 POINTER 1456 NUT, HEX FINISH 3/8-16 10133 NUT, NYLOC 3/8-16 15114...
Page 66
STOW CUTTER 3 SAW — WATER SYSTEM ASSY. WATER SYSTEM ASSY. PAGE 66 — STOW CUTTER 3 SAW — OPERATION & PARTS MANUAL — REV. #8 (09/22/06)
Page 67
STOW CUTTER 3 SAW — WATER SYSTEM ASSY. WATER SYSTEM FROM CONSOLE SP PART NO PART NAME QTY. REMARKS 12694-008 HOSE CLAMP, SPRING TYPE 7/8 O.D HOSE 23255-004 HOSE, WATER 1/2 X 37 23566-001 FITTING, PLASTIC 90 1/2MP X 1/2BARB 23259-001 VALVE, BALL 1/2 MPT BRASS NIBCO T585-70 23254-001...
Page 75
STOW CUTTER 3 SAW — TRANSMISSION ENGAGE LEVER ASSY. HYD. TRANSMISSION ENGAGE LEVER ASSY. PART NO PART NAME QTY. REMARKS 28825-351 LEVER ASSY. TRANS. ENGAGE 3360 GRIP, 1/4 X 1 BLACK 28822-351 MOUNT ASSY., LEVER RED 0655 SCREW, HHC 5/16-18 X 3/4 10136 WASHER, FLAT SAE 3/8 6014 B...
Page 113
HONDA GX620TXF2 ENGINE — AIR CLEANER ASSY. AIR CLEANER ASSY. PART NO PART NAME QTY. REMARKS 17200ZJ0U70 AIR CLEANER ASSY........1 ....INCLUDES ITEMS W/ 17207ZJ0U70 RUBBER, AIR CLEANER HOLDER 17208ZJ0U70 HOLDER, AIR CLEANER, UPPER 17209ZJ0U70 HOLDER, AIR CLEANER, LOWER 17210759013 ELEMENT.
Page 116
HONDA GX620TXF2 ENGINE — CONTROL ASSY. CONTROL ASSY. PAGE 116 — STOW CUTTER 3 SAW — OPERATION & PARTS MANUAL — REV. #8 (09/22/06)
Page 117
HONDA GX620TXF2 ENGINE — CONTROL ASSY. CONTROL ASSY. PART NO PART NAME QTY. REMARKS 16263ZE3790 JOINT, ROD 16500ZJ1000 CONTROL ASSY.......... 1 ....INCLUDES ITEMS W/ 16534ZJ1000 SPRING, STARTER 16550ZJ1000 ARM, GOVERNOR 16555ZJ1000 ROD, GOVERNOR 16561ZG1000 SPRING GOVERNOR 16561ZJ1000 SPRING, GOVERNOR 16562ZJ1000 SPRING ,THROTTLE RETURN 16570ZJ1000...
Page 121
HONDA GX620TXF2 ENGINE — CRANKCASE COVER ASSY. CRANKCASE COVER ASSY. PART NO PART NAME QTY. REMARKS 11300ZJ1600 COVER ASSY., CRANKCASE ..1 ..... INCLUDES ITEMS W/ 11381ZJ1000 GASKET, CASE COVER 13321ZJ1000 BEARING A, MAIN OPTIONAL ... 1 ..... SEE HONDA SERVICE MANUAL 13322ZJ1000 BEARING B, MAIN OPTIONAL ...
Page 125
HONDA GX620TXF2 ENGINE — CYLINDER BARREL ASSY. CYLINDER BARREL ASSY. PART NO PART NAME QTY. REMARKS 12000ZJ1810 CYLINDER ASSY......1 ..INCLUDES ITEMS W/ 12356ZJ1000 COVER, BREATHER 12358ZJ1000 GASKET, BREATHER COVER 12372ZE2300 VALVE, BREATHER 13321ZJ1000 BEARING A, MAIN, OPTIONAL ..1 ..SEE HANDA SERVICE MANUAL 13322ZJ1000 BEARING B, MAIN, OPTIONAL ..
Page 126
HONDA GX620TXF2 ENGINE — CYLINDER HEAD ASSY. CYLINDER HEAD ASSY. PAGE 126 — STOW CUTTER 3 SAW — OPERATION & PARTS MANUAL — REV. #8 (09/22/06)
Page 127
HONDA GX620TXF2 ENGINE — CYLINDER HEAD ASSY. CYLINDER HEAD ASSY. PART NO PART NAME QTY. REMARKS 12210ZJ1000 CYLINDER HEAD, R........1 ..INCLUDES ITEMS W/ 12220ZJ1000 CYLINDER HEAD, L........1 ..INCLUDES ITEMS W/ 12205ZE2305 GUIDE, EX. VALVE OS OPTIONAL 12216ZE2300 CLIP, VALVE GUIDE 12251ZJ1003...
Page 128
HONDA GX620TXF2 ENGINE — FAN COVER ASSY. FAN COVER ASSY. PAGE 128 — STOW CUTTER 3 SAW — OPERATION & PARTS MANUAL — REV. #8 (09/22/06)
Page 129
HONDA GX620TXF2 ENGINE — FAN COVER ASSY. FAN COVER ASSY. PART NO PART NAME QTY. REMARKS 19611ZJ1000ZB COVER, FAN R8, BRIGHT RED 19612ZJ1000 PLATE, R SIDE 19641ZJ1000 PLATE, L SIDE 19615ZJ0U60 HOOD, FAN COVER 19615ZJ0U70 HOOD, FAN COVER 19618ZJ0U70 PLUG, FAN COVER HOLE 19631ZJ1000 SHROUD, R.
Page 135
HONDA GX620TXF2 ENGINE — MUFFLER ASSY. MUFFLER ASSY. PART NO PART NAME QTY. REMARKS 06183ZJ1821 MUFFLER KIT, HIGH-B OPTIONAL ..... 1 ..INCLUDES ITEMS W/ 18310ZJ1003 MUFFLER, HIGH OPTIONAL 18321ZJ1003 PROTECTOR, MUFF., HIGH OPTIONAL 18330ZJ1600 PIPE, EX. HIGH-L OPTIONAL 18338ZJ1003 STAY, MUFFLER, HIGH OPTIONAL 18396ZJ1003 BAND ASSY.
Page 136
HONDA GX620TXF2 ENGINE — PISTON AND CONNECTING ROD ASSY. PISTON & CONNECTING ROD ASSY. PAGE 136 — STOW CUTTER 3 SAW — OPERATION & PARTS MANUAL — REV. #8 (09/22/06)
Page 137
HONDA GX620TXF2 ENGINE — PISTON AND CONNECTING ROD ASSY. PISTON & CONNECTING ROD ASSY. PART NO PART NAME QTY. REMARKS 13010ZE8601 RING SET, PISTON STANDARD 13011ZE8601 RING SET, PISTON OS 0.25 ......2 ..OPTIONAL 13012ZE8601 RING SET, PISTON OS .050 ......2 ..OPTIONAL 13013ZE8601 RING SET, PISTON OS .075 ......
Page 138
HONDA GX620TXF2 ENGINE — FUEL TANK ASSY. FUEL TANK ASSY. PAGE 138 — STOW CUTTER 3 SAW — OPERATION & PARTS MANUAL — REV. #8 (09/22/06)
Page 139
HONDA GX620TXF2 ENGINE — FUEL TANK ASSY. FUEL TANK ASSY. PART NO PART NAME QTY. REMARKS 15282 JOINT, FUEL TANK 17510ZE3010ZB FUEL TANK 17560ZJ0U70 SUPPORT, FUEL TANK 17620ZH7023 CAP, FUEL 17631ZH7023 GASKET, FUEL FILLER CAP 29219-001 COLLAR, FR. ENGINE HANGER 90018ZE1000 BOLT, FLANGE (6X23) 90022888010...
Page 143
HONDA GX620TXF2 ENGINE — CARBURETOR ASSY. CARBURETOR ASSY. PART NO PART NAME QTY. REMARKS 12357ZJ1000 TUBE, BREATHER 15772551000 CLIP, BREATHER TUBE 16010ZG8000 GASKET SET 16011382004 VALVE SET, FLOAT 16013ZV4005 FLOAT SET 16015ZJ1000 CHAMBER SET, FLOAT....... 1 ..INCLUDES ITEMS W/ # 16016ZJ1010 SCREW SET 16024124760...
Page 144
HONDA GX620TXF2 ENGINE — STARTER MOTOR ASSY. STARTER MOTOR ASSY. PAGE 144 — STOW CUTTER 3 SAW — OPERATION & PARTS MANUAL — REV. #8 (09/22/06)
Page 145
HONDA GX620TXF2 ENGINE — STARTER MOTOR ASSY. STARTER MOTOR ASSY. PART NO PART NAME QTY. REMARKS 31200ZJ1004 MOTOR ASSY., STARTER ........ 1 ... INCLUDES ITEMS W/ 31243ZJ1800 BRACKET, STARTER MAGNETIC SETTING ... 1 ... INCLUDES ITEMS W/ 32402ZJ1810 CABLE, MAGNET SWITCH ......1 32411KB9930 COVER A.
Need help?
Do you have a question about the Stow Cutter 3 CC813H20 and is the answer not in the manual?
Questions and answers