Sole Diesel MINI-62 Operator's Manual page 39

Troubleshooting
ENGINE FAILURE SYSTEM
GENERAL
FUEL SYSTEM
STARTS AND THEN
COOLING SYSTEM
STOPS
ELECTRICAL SYSTEM
(CC)
INLET AND EXHAUST
SYSTEM
FUEL SYSTEM
BLACK SMOKE
INLET AND EXHAUST
SYSTEM
GENERAL
BLUE SMOKE
LUBRICATION SYSTEM Oil level too high.
LOW OIL PRESSURE LUBRICATION SYSTEM
Solé, S.A. C-243 b, km 2 · 08760 Martorell (Barcelona) ·Tel. +34 93 775 14 00 · www.solediesel.com · info@solediesel.com
Marine diesel engines. Operator's manual
PROBABLE CAUSES
The fuel regulator is not operational.
Faulty or clogged fuel pump
Clogged fuel filter
Air in fuel system
Incorrect injection pump setting
Closed fuel outlet tap
Low cooling liquid level.
Faulty stop solenoid (ETR).
Pressed emergency stop button.
Control panel start signal.
Dirty or clogged air filter.
Clogged fuel filter.
Dirty or faulty fuel injectors.
Incorrect injection pump setting.
Clogged air filter.
Incorrect valve clearance.
Faulty oil pump.
Strangled oil pressure-relief valve.
Oil pressure too low.
Oil level too low.
Faulty oil pressure valve.
Faulty pressure gauge, pressure sensor and/or
pressure switch.
Engine tilt above allowable values.
RECOMMENDED ACTIONS
Contact an Official Solé Diesel Service.
Check fuel pump inlet.
Replace fuel filter.
Bleed fuel system.
Contact an Official Solé Diesel Service.
Open the fuel outlet tap.
Check cooling liquid level and fill tank if necessary.
Check stop solenoid and replace it if necessary.
Reset the emergency stop button position.
Check the start signal from the controller (yellow wire).
Replace the air filter element.
Replace fuel filter.
Clean, test and/or replace fuel injector which is not operating
properly.
Contact an Official Solé Diesel Service.
Replace the air filter element.
Perform valve adjustment.
Check the lubrication oil level and reset it.
Contact our dealer
Clean the valve and check its operation.
Check oil level.
Reset oil level. Inspect the engine for leaks.
Contact an Official Solé Diesel Service.
Check and/or replace elements.
Check the engine installation inclination. Reinstall the engine if
necessary.
39