Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for Rockworth AO630/308-2
Summary of Contents for Rockworth AO630/308-2
- Page 1 AO630/308-2 2HP • 50L AIR COMPRESSOR...
-
Page 2: Warranty
Warranty This product has been manufactured to a high quality standard. It is guaranteed against faulty materials and workmanship for 12 months from the date of purchase. Please retain your receipt as proof of purchase. If the product is found to be defective within the relevant time period, we will either replace all defective parts or, at our discretion, replace the unit free of charge with the same item or items of a greater value and/or specification. -
Page 3: General Safety Instructions
GENERAL SAFETY INSTRUCTIONS Before attempting to operate this compressor the following basic safety precautions should always be taken to reduce the risk of fire, electric shock and personal injury. It is important to read the instruction manual to understand the application, limitations and potential hazards associated with any tool. - Page 4 Secure the Work Piece Wherever possible secure the work piece using clamps or a vice. It is safer than using your hand and leaves both hands free to control the air tool. Do Not Over-reach Do not over-reach, keep proper footing and maintain your balance at all times. Maintain Tools with Care Keep cutting tools sharp and clean for better and safer performance.
- Page 5 Extension Cords and Reels In general, it is not recommended to use an extension lead. A longer air line is recommended as voltage drop on extension leads may lead to motor damage and will void warranty. If a exten- sion cord must be used, for lengths up to 5 metres, an approved 15amp rated cord must be used.
-
Page 6: General View And Main Components
GENERAL VIEW AND MAIN COMPONENTS Main compressor Pressure switch Outlet Valve Regulating Valve Pressure gauge Non-Return Valve Drain cock Wheel Discharge pipe Air tank Safety valve 2HP/50L Fan cover Note: Fittings may differ from those shown above. - Page 7 Assembly This air compressor requires some minor assemble before it can be used. Locate the accessory pack. It should contain : Wheels and axle set Rubber stopper Air Filter Oil Breather plug A bottle of oil Fit the wheels to the unit using the axle kit •...
-
Page 8: Oil Warning
Oil Warning : This unit is shipped without oil in the compressor pump. Oil must be added to the unit prior to operating. Using the oil provided carefully fill the crank case until the oil reaches the red mark on •... -
Page 9: Operation
Operation The pressure in the tank is controlled by the action of the pressure switch located under the pressure switch cover When the set maximum pressure is reached the pressure switch activates and the motor is turned off. The pressure will then decreases as the air is used until the set minimum is reached after which the pressure switch turns the motor to on again. -
Page 10: Maintenance
MAINTENANCE Warning: Before maintenance operation, stop the air compressor, disconnect the unit from the mains supply and discharge all air in the air tank. Daily 1. Check oil level before each use. 2. Drain the condensation from the air receiver. 3. -
Page 11: Troubles And Remedies
TROUBLES AND REMEDIES Trouble Possible causes Remedies Fault in line, or voltage insufficient Check the line Power wire too thin or too long Replace the wire Motor unable to Fault in pressure switch Repair or replace run or running Fault in motor Repair or replace slow Sticking of main compressor... - Page 12 SYMBOLS Air intake Before use, read the handbook carefully Absorbed current Warning, hot surfaces Max. pressure Obligatory eye protection Revolutions / min. (rpm) Danger - automatic control (closed loop) Voltage and frequency Dangerous voltage Weight Pumping unit Package overall dimensions Power Oil amount Tank capacity...
- Page 13 230V ~ Ac 50 Hz 230V ~ Ac 50 Hz...
-
Page 14: Warranty Information
Warranty Information RAAC2/24 and RAAC2.5/36 Rockworth products have a limited warranty against defects in material and workman- ship from the date of purchase. Rockworth products are designed for Domestic/Light Industrial use and the warranty does not apply to defects resulting from accidental damage, improper use, or exceeding the design limits of the product.
Need help?
Do you have a question about the AO630/308-2 and is the answer not in the manual?
Questions and answers