Mono Bx Eco Connect Plus Installation And Operation Manual

Mono Bx Eco Connect Plus Installation And Operation Manual

Advertisement

Quick Links

www.monoequip.com
Installation and Operation Manual
FG1BX-UK-MAN-0300 | Rev. A21 (Dec. 2021)
Oven Serial Number _________________________________
Oven Code
138
Condenser Serial Number ____________________________ (if fitted)
In the event of an enquiry, please quote these serial numbers.
Bx OVEN
Eco Connect Plus
149
150
153
158
159
170
4/5/7/10-Tray | Steam
173

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Bx Eco Connect Plus and is the answer not in the manual?

Questions and answers

Summary of Contents for Mono Bx Eco Connect Plus

  • Page 1 Oven Serial Number _________________________________ Oven Code www.monoequip.com Condenser Serial Number ____________________________ (if fitted) In the event of an enquiry, please quote these serial numbers. Bx OVEN Eco Connect Plus Installation and Operation Manual 4/5/7/10-Tray | Steam FG1BX-UK-MAN-0300 | Rev. A21 (Dec. 2021)
  • Page 2 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual FG1BX-UK-MAN-0300 | Rev. A21 (Dec. 2021) MONO...
  • Page 3 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens ATTENTION If the oven fails to heat up when first connected to a power supply or during use at any time, press the reset buttons located on the rear back panel.
  • Page 4 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Safety symbols The following safety symbols are used throughout this document and manual (available at www.monoequip.com). Before using your new equipment, read the instruction manual carefully and pay special attention to information...
  • Page 5 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Electrical safety and advice regarding supplementary electrical protection Commercial kitchens and food service areas are environments where electrical appliances may be located close to liquids or operate in and around damp conditions or where the restricted movement for installation and service is evident.
  • Page 6: Table Of Contents

    MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Contents Page 1. Introduction ......................8 2. Specifications ......................10 Mechanical specifications ........................10 Electrical specifications ........................10 Electrical specifications ........................11 3. Safety ........................12 4. Installation ....................... 13 Power ..............................
  • Page 7 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens 8. Cleaning ........................51 Daily cleaning instructions ........................51 Weekly cleaning instructions ........................ 51 9. Maintenance ......................56 General maintenance ........................... 56 Steam system maintenance ......................... 56 Light bulb replacement .........................
  • Page 8: Introduction

    “A combination of clean industrial design and the latest technology.”  The MONO BX oven range is designed to take the baking Industry’s standard trays. Ovens in the range are of stainless steel construction, and selected models have removable tray racks ...
  • Page 9 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Figure 1: BX oven features Power on/off switch Identification / Serial number plate. Touchscreen Damper flue – do not cover the flue Figure 2: Optional condenser FG1BX-UK-MAN-0300 | Rev. A21 (Dec. 2021)
  • Page 10: Specifications

    MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual 2. Specifications Mechanical specifications Table 1: Mechanical specifications 4/5-Tray 7-Tray 10-Tray FG159 FG153 FG158 FG173 FG138 FG150 FG149 FG170 18 in. 40 cm 60 cm 40 cm 18 in.
  • Page 11: Electrical Specifications

    Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Display  7-inch HD TFT resistive touchscreen, portrait format Environmental specifications Table 3: Environmental Noise level Less than 85 dB Water supply Not required Drainage Not required FG1BX-UK-MAN-0300 | Rev.
  • Page 12: Safety

    Do not attempt any repairs.  Contact the Mono Service Department for advice.  Fit only MONO spare parts to this oven.  All connections to the oven must comply with the statuary requirements of the country of installation. ...
  • Page 13: Installation

    Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens 4. Installation Power Warning!  A 30mA Residual Current Device (RCD) must protect the supply to this machine.  Always fit a wall isolator to isolate the oven completely. The isolator must be visible, labelled clearly, and easily accessible by an operator.
  • Page 14: Water

    Allow a 50 mm gap at the sides and rear of this oven.  Chimneys and evacuation ducts fitted above mono ovens should be insulated. Before use In the interests of hygiene, we strongly recommend that, before using the oven for the first time, you wipe the inside of the oven and all accessories thoroughly with a clean cloth soaked in warm soapy water.
  • Page 15: Ambient Working Temperatures

    It is the customers’ sole responsibility to arrange for adequate ventilation. Any component malfunctioning during the guarantee period found to have been subject to excessive humidity or ambient working temperature above 40 °C (115 °F) will not be covered by the component manufacturer guarantee or MONO’s product warranty. FG1BX-UK-MAN-0300 | Rev. A21 (Dec. 2021)
  • Page 16: Isolation

    MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual 5. Isolation Electrical supply To stop the oven in an emergency, switch off the electricity at the wall isolator. Water supply In an emergency, shut off the water supply to stacked ovens by closing the shut-off valves...
  • Page 17: Touchscreen Operations

    Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens 6. Touchscreen Operations Operations are performed by touching an area of the screen, bringing up the next information panel or activating a function.  Caution! Do not use excessive force to operate the touchscreen panel...
  • Page 18: Starting And Operating Using Ready-Made Recipes (Programs)

    MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Starting and operating using ready-made recipes (programs) Ensure the power and water supplies are safely connected to the oven (see Installation on page 13). If the display (A) is blank, press the green power button (B) at the bottom of the front panel.
  • Page 19 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Touch the Programs tile on the Choose an option screen. Select a product category. (a) Touch the scroll up and down buttons to change category pages. ...
  • Page 20 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual A baking screen now appears. (a) Wait while the oven heats up. A Heating message flashes on the screen. (b) Load the oven with products when Ready flashes on the screen.
  • Page 21 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens During a bake, two actions can be performed.  Touch the View button to view settings during a bake.  Touch the numbered square (e.g., 2) to view the settings for different baking phases.
  • Page 22: Manual Bake (No Program Mode)

    MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Manual bake (no program mode) 1. Touch the Manual Bake tile. 2. Set the temperature required. (a) Touch the Temperature circle. (b) Key in the temperature required.
  • Page 23 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens 4. Load the oven with products and touch Start.  The timer counts down from a set time to 00:00 or counts upwards if no time set.
  • Page 24: Setting The Time And Date

    MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Setting the time and date Touch the Settings tile. Enter the Oven Settings password, and then touch the OK () button. Note Default passwords for the various access levels are in the Passwords section of this manual. However, for security reasons, the passwords section may have been removed.
  • Page 25 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Touch the item that needs adjusting, and then use the up or down arrows as required.  The time, date, month, and year can be adjusted. ...
  • Page 26: Setting Up A New Program

    MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Setting up a new program Touch the Programs tile. Choose the category or number group required. Touch the Info (i) button of the next free recipe slot.
  • Page 27 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Enter the Operator password and touch OK. Note Default passwords for the various access levels are in the Passwords section of this manual. However, for security reasons, the passwords section may have been removed.
  • Page 28 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Edit a tray layout for the new product recipe. (a) Touch the Change tray layout box (b) Touch the W (width) box to highlight it. (c) Use the up or down arrow key to change quantity across the tray.
  • Page 29: Multi Bake Operation

    Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Multi bake operation Touch the Multi Bake tile. Set a timer Touch a time-setting box. Adjust the bake time required using up and down keys. Touch the OK () button.
  • Page 30 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Set the temperature for the bakes (a) Touch a heat-setting box. (b) Type in temperature required. (c) Touch OK to confirm the temperature. Start the bake. (a) Load the oven.
  • Page 31 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens The panel flashes when a bake finishes, and the oven emits a beep-beep alarm. Touch the Stop button next to the 00:00 time. 10. Touch the Stop button at any time to end a bake, and the same settings are useable again.
  • Page 32: 7-Day Timer

    MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual 7–Day Timer While the oven is in standby mode, it can heat up at preset times every day as required. Touch the 7 Day Timer tile. Touch the day an oven operation is required.
  • Page 33 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Set the Off-time. (a) Touch the Off tile of a time panel. (b) Set the time using the keys in the box that appears, and then touch Save (A).
  • Page 34: Putting The Oven Into Standby Mode

    MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Putting the oven into Standby mode The Standby button turns the oven off until the screen is touched again. Putting the oven into Sleep mode The Sleep button instructs the oven to maintain temperature to a preset value if enabled in the settings.
  • Page 35: User Settings (Oven Setup)

    Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens User settings (oven setup) Caution!  Do not make changes to settings unless you are fully aware of the results. Touch the Settings tile. Enter the Oven Settings password, and then touch OK.
  • Page 36 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Touch the Left Arrow and Right Arrow buttons to access the pages of oven settings. Page 1 Page 2 Page 3 5. To make an adjustment, touch the item and change the setting.
  • Page 37 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Table 4: Oven settings explained (general level) Temperature Units Centigrade (Celsius) or Fahrenheit. Sleep Mode Delay The oven enters sleep mode after the set minutes, providing it is up to temperature and has been through at least one bake cycle.
  • Page 38: Factory Settings (Oven Setup)

    MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Factory settings (oven setup) Caution!  Do not make changes to settings unless you are fully aware of the results. Touch the Settings tile. Enter the Oven Settings password, and then touch OK.
  • Page 39 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Enter the High Level Settings password, and then touch OK. Touch the Factory settings box (B). Touch the Left Arrow and Right Arrow buttons to access the pages of oven settings.
  • Page 40: Changing The Passwords

    MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual 7. To make an adjustment, touch the item and edit a new setting. 8. Touch the Save () when the oven settings are as required. Changing the passwords Touch the Settings tile.
  • Page 41 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Enter the High Level Settings password, and then touch OK. Touch the password level you want to change (e.g., user password). Change the password. (a) Touch the Old Password box, and enter the current password.
  • Page 42: Diagnostics

    MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Diagnostics The operation of the following items can be checked from the diagnostics screen: Door switch operation Fan forward Lights on/off    Fan overload Fan reverse Canopy ...
  • Page 43 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Using the diagnostics screen Touch the item to be tested (e.g., Light)  The red square changes to a green square (E). Touch the same item again to end the test.
  • Page 44 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Using the Inverter Diagnostic screen 1. Touch the Inverter Diagnostic box (F). 2. Touch the red square (labelled as “running”) to start the testing.  The red square changes to a green square (G).
  • Page 45: Using The Usb Port

    Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens 7. Using the USB Port Using the USB port to import recipes Importing a recipe archive to an oven without IoT firmware installed Insert a USB flash drive into the USB socket.
  • Page 46 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Touch the High Level Settings box on the main options screen. Enter the High Level Settings password, and then touch OK. Touch the Down Arrow button (C) to display the next page of high-level settings.
  • Page 47 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Touch the recipe archive required (F), and then touch the Upload () button. 10. Touch Yes when a pop-up window (G) warns about deleting all current recipes from the oven.
  • Page 48 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Importing a recipe archive to an oven with IoT firmware installed Insert a USB flash drive into the USB socket.  Do not force the flash drive into the socket. It only fits in one way.
  • Page 49 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Touch the High Level Settings box on the main options screen. Enter the High Level Settings password, and then touch OK. Touch the Import From USB box (C).
  • Page 50 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Touch the recipe archive required (E), and then touch the Save () button. 10. Touch Yes when a pop-up window (F) warns about applying the archive. ...
  • Page 51: Cleaning

    Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens 8. Cleaning Warning!  Isolate the oven from the mains supply and allow time to cool before cleaning. Warning! Do not remove the rear panelling inside the oven. That panel ...
  • Page 52 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Figure 6: Removing and installing a runner rack A. Top pin slots B. Bottom pin slots C. Instructions in Figure 7 viewed from this direction and shows the left-hand rack.
  • Page 53 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Figure 7: Installing a runner rack (left-hand side shown) A. Place slots nearest oven wall over top pins B. Swing rack into line up bottom slots with bottom pins C.
  • Page 54 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Figure 8: Check for the correct number of runners on the left and right sides A. 4-tray runners B. 5-tray runners FG1BX-UK-MAN-0300 | Rev. A21 (Dec. 2021)
  • Page 55 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Door glass cleaning The inner door glass is hinged to enable the cleaning of inner surfaces. Undo the two screws shown in Figure Swing the inner glass panel away from the door (Figure 10).
  • Page 56: Maintenance

    MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual 9. Maintenance General maintenance  Check for frayed or bare cables.  Do not use the machine if frayed or bare cables are visible. Follow cleaning instructions (see Cleaning on page 48).
  • Page 57 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens 10. Spares When ordering the spares, contact the Spares Department. Please quote the machine serial number as found on the silver information plate of the machine and on the front cover of this manual.
  • Page 58: Spares

    MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual 11. Condenser Unit (Option)  All versions should be part of a regular cleaning schedule. Caution! Water should be drained and parts cleaned with an antibacterial wash.
  • Page 59: Condenser Unit (Option)

    MONO Bx Eco Connect Plus Ovens Introduction (condenser unit) A condenser unit can be fitted to any MONO Bx oven (or stacked Bx ovens) as required. The thermostatic control can be adjusted to operate in most ambient temperatures. A simple water connection (washing machine type fitting) and a hose to drain are required to operate efficiently.
  • Page 60 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Dimensions (condenser unit) Figure 12: Dimensions of a condenser unit Water out Water in Rear of the oven FG1BX-UK-MAN-0300 | Rev. A21 (Dec. 2021) MONO...
  • Page 61 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Specifications (condenser unit) Power  230 Vac (50 Hz), single phase  21 Watts Wired to the oven electrical panel.  Water  Washing machine type connection to the normal water supply via steam water connection to the oven(s).
  • Page 62 While the oven is in operation (and for some time after use), it is inadvisable to touch the condenser or the surrounds because of conducted heat.  No unauthorised modifications to the condenser are permitted.  Only use MONO spare parts on this condenser. FG1BX-UK-MAN-0300 | Rev. A21 (Dec. 2021) MONO...
  • Page 63 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Installation (condenser unit) Ensure that all power is disconnected and the oven is cool. Before fitting the main condenser assembly, insert blanking plug (A) into the lower hole that will not be required for the type of oven being used.
  • Page 64 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Figure 13: Installation of a condenser unit FG1BX-UK-MAN-0300 | Rev. A21 (Dec. 2021) MONO...
  • Page 65 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Figure 14: Water pipe connections Condenser solenoid Oven #1 Oven #2 Bracket fixings for the water tap Mains water supply inlet Tee-pipe for double oven connection FG1BX-UK-MAN-0300 | Rev. A21 (Dec. 2021)
  • Page 66 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Operation (condenser unit) Review all safety sections in this manual. Ensure that the water is connected correctly and the oven power is on. 15). Adjust the thermostat control to the required position (Figure It is suggested that, as a starting point, the thermostat is set at 60.
  • Page 67 MONO Bx Eco Connect Plus Ovens Spares (condenser unit) This section is for Engineer use only Do not attempt any modifications to the condenser or oven. If in doubt, contact Mono Equipment for advice. Figure 16: Main parts of the condenser unit FG1BX-UK-MAN-0300 | Rev.
  • Page 68 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Item Part number Description Quantity 150-07-01300 Inlet water control unit 150-19-01700 Top sheet 150-19-02300 Cover plate 150-19-02600 Base tray 150-19-02700 Water tank 150-25-07100 Junction box A900-01-196 Jubilee clip...
  • Page 69 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Other versions of the condenser that may be fitted The following evaporation design versions could be fitted to your oven. They only require to be plugged into the socket found to the rear of the oven (Figure 17).
  • Page 70 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Figure 18: Condenser unit FG150/AC5 FG1BX-UK-MAN-0300 | Rev. A21 (Dec. 2021) MONO...
  • Page 71 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Figure 19: Condenser assembly FG155/X38 FG1BX-UK-MAN-0300 | Rev. A21 (Dec. 2021) MONO...
  • Page 72 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Figure 20: Condenser assembly FG158/AC1 FG1BX-UK-MAN-0300 | Rev. A21 (Dec. 2021) MONO...
  • Page 73 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Figure 21: Reduced height condenser FG158/AC3 FG1BX-UK-MAN-0300 | Rev. A21 (Dec. 2021) MONO...
  • Page 74 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual Figure 22: Reduced height condenser FG158/AC4 FG1BX-UK-MAN-0300 | Rev. A21 (Dec. 2021) MONO...
  • Page 75 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens Figure 23: Condenser FG159/AC1 FG1BX-UK-MAN-0300 | Rev. A21 (Dec. 2021) MONO...
  • Page 76 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual FG1BX-UK-MAN-0300 | Rev. A21 (Dec. 2021) MONO...
  • Page 77: Passwords

    Oven setting access – setting time/date, etc. 2413 High level settings access. Note If the passcodes have been changed and are not available, contact Mono Equipment for a master number that will open all screens. FG1BX-UK-MAN-0300 | Rev. A21 (Dec. 2021) MONO...
  • Page 78 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual (Intentional Empty Page) FG1BX-UK-MAN-0300 | Rev. A21 (Dec. 2021) MONO...
  • Page 79 Installation and Operation Manual 4/5/7/10-Tray | Steam MONO Bx Eco Connect Plus Ovens (Intentional Empty Page) FG1BX-UK-MAN-0300 | Rev. A21 (Dec. 2021) MONO...
  • Page 80 MONO Bx Eco Connect Plus Ovens 4/5/7/10-Tray | Steam Installation and Operation Manual If a fault arises, please do not hesitate to contact the Customer Service Department, quoting the machine serial number on the silver information plate of the machine and on the front cover of this manual...

This manual is also suitable for:

Bx eco connect

Table of Contents