Page 3
This manual will guide you and help you to operate and maintain your All new Classic 350 motorcycle the right way. Please do avail all the services at your nearest Royal Enfield Authorised Service Centre, ensuring your ride gets the best care always.
Page 4
Wash only with plain water. Scratches or marks cannot be removed or touched up. NOTE Part No. RAM00347/A / Qty. 7000 / Sept 2021 / 500158 This motorcycle meets the BS VI Emission Norms. Royal Enfield All New Classic 350...
Warning Indications and Safety Systems ....Emission Warranty ........... 94 Pre-Operational Checks ......... 50 EVAP ................ 102 Running in Period ........... Service / Maintenance Record ........104 Starting ..............53 Gear Shifting, Riding and Stopping ......Royal Enfield All New Classic 350...
Indicates a potentially hazardous situation. Disregarding this message may result in injury to rider or other persons. This message, if disregarded, may result in damage to the motorcycle. Indicates important and useful messages for better understanding. Royal Enfield All New Classic 350...
Mobile : Licence No. Valid till : Model Color : Engine No. VIN. No. Tyre make Rear : Front : Tyre Nos. Rear : Front : Battery No. Battery make Sold by Date of Sale Royal Enfield All New Classic 350...
Use of other manufacturer’s are no open flames or sparks near the motor- parts may affect the performance of your motor- cycle, when refueling or servicing the fuel cycle and render the motorcycle void of warranty. system. Royal Enfield All New Classic 350...
Page 9
Removing increases the influence of any other condition or altering original parts may adversely affect affecting stability and increases the possibility of performance and could result in accident. loss of control. Royal Enfield All New Classic 350...
Page 10
Bright / light colours Rough or uneven road surfaces. are best for greater visibility in traffic, especially at night. Avoid loose, flowing garments and scarves. Slippery road surfaces. Royal Enfield All New Classic 350...
Page 11
Replace worn out parts. Worn out parts can adversely affect stability and Exhaust gas contains poisonous carbon monoxide handling. and chemicals, known to cause cancer, birth defects or other reproductive defects. Royal Enfield All New Classic 350...
Page 12
Failure cause loss of control of the motorcycle in the front, to do so may aggravate an initial problem, cause leading to an accident. costly repairs and jeopardize your personal safety. Royal Enfield All New Classic 350...
While turning either right or left, watch for Watch for loose debris, such as leaves, slippery, pedestrians, animals, as well as other vehicles. substances or gravel that can hamper the stability of your motorcycle. Royal Enfield All New Classic 350...
Page 14
Protect your motorcycle against theft. After Never jump a traffic light. When a parking your motorcycle, ensure that the steering change is imminent from GO to head is locked and then remove the ignition key. Royal Enfield All New Classic 350...
Page 15
However, vehicles and other objects seen in this type of mirror will look smaller and farther away than when seen in a flat mirror. Use care when judging the size or distance of vehicles / objects seen in these mirrors. Royal Enfield All New Classic 350...
Please adhere to the following guidelines when mounted loosely may affect the riding of the carrying a pillion, luggage or when fitting any motorcycle and affect the handling and stability of accessories. the motorcycle. Royal Enfield All New Classic 350...
Page 17
Royal Enfield offers a range of genuine motorcycle causing an accident, which could result in serious accessories that have been fully approved and injury or loss of life. extensively tested alongside the motorcycle. Royal Enfield All New Classic 350...
Page 18
If your motorcycle is equipped with saddlebags, a windshield or a passenger backrest, be prepared to reduce operating speed to maintain stability. Royal Enfield All New Classic 350...
20.21 PS @ 6100 rpm Spark plug gap ..... 0.7 to 0.8 mm Max Torque ......27 Nm @ 4000 rpm Spark plug ......YR7MES / Bosch Idle RPM ......1050 + 100 rpm Starting ....... E-Start Royal Enfield All New Classic 350...
Page 20
Final drive ......Chain Primary drive ..... Gear Secondary Sprocket Ratio 2.800:1 Primary ratio ...... 2.313 Drive Chain links ....104 links Gear box ......Constant Mesh Gear Ratio ......1 2.615 1.706 1.300 1.040 0.875 Royal Enfield All New Classic 350...
Page 21
90 mm travel (Tube Type) (Tubeless Type) Brakes 120/80 - 18 - 62 P 120/80 - 18 - 62 P Front Disc ....300 mm disc with Rear (Tube Type) (Tubeless Type) twin piston floating caliper Royal Enfield All New Classic 350...
Page 22
Fuel Dead Stock ....1.5 + 0.5 l Rear ......36 psi * The above values are approximate and the actual fuel Steering lock ...... Integrated with filling capacity will vary from the values mentioned. ignition lock Royal Enfield All New Classic 350...
Page 23
Neutral lamp tell tale ..12 V - LED warranty, but also affects performance of the Turn signal tell tale ... 12 V - LED motorcycle. Turn signal ......12 V, 10 W x 2 nos Royal Enfield All New Classic 350...
Page 24
Height measurement. Do not use the vehicle beyond the allowed Gross Saddle Height ..... 805 mm weight. The suspensions and tyres are designed to perform only to the maximum gross vehicle weight. Royal Enfield All New Classic 350...
* DO NOT mix DOT 4 & other brake fluids together. Dry fill : 2.2 l (Approx.) Use of wrong grade / mixed grade oil will reduce the life of the moving parts and seriously affect performance. Recommendation subject to change without notice. Royal Enfield All New Classic 350...
Model / Variant / Commercial Name Type of Transmission Type of Fuel system Month of Manufacturing (A-Jan., H- Aug., K- Sep., N-Dec.) Production Year (2020:L, 2021:M, 2022:N) Manufacturing Plant (1-Oragadam, 2-Vallam Vadagal) Production Serial No. Royal Enfield All New Classic 350...
Engine Capacity Type of Cooling Type of Transmission Type of Fuel system Production Month (A-Jan., H- Aug., K- Sep., N-Dec.) Year of Manufacturing (2020:L, 2021:M, 2022:N) Manufacturing Plant (1-Oragadam, 2-Vallam Vadagal) Production Serial Nos. Royal Enfield All New Classic 350...
6. Handle Bar 7. Instrument Cluster 8. Ignition Switch 9. Day Flash Switch 10. High Beam / Low Beam Switch 11. Info Button 12. Clutch Lever 13. Turn Signal Switch 14. Charger Port 15. Horn Button Royal Enfield All New Classic 350...
Page 29
Starter Motor Brake Pedal Horn Front Wheel* Right Trafficator Front Brake Lever Front Spark Plug * The part displayed above are for reference purpose only. This will vary from the parts chosen using motorcycle configurator. Royal Enfield All New Classic 350...
Page 30
Gear Change Pedal Side Stand Center Stand Left Trafficator Rear Seat* Left Side Panel Fuel Tank* * The part displayed above are for reference purpose only. This will vary from the parts chosen using motorcycle configurator. Royal Enfield All New Classic 350...
Turn key clockwise to open. Turn the handle bar to Press cap to lock with key in extreme left position. position. Push the key inside in “OFF” position, press and further turn Royal Enfield All New Classic 350...
Page 32
1. Fuel Tank Mouth Gasoline vapour is highly explosive. Please ensure 2. Splash Arrestor there are no open flames or sparks nearby while refueling and fill fuel only in a well ventilated area. 3. Maximum Fuel level Royal Enfield All New Classic 350...
Page 33
Wipe immediately incase fuel spills over as otherwise it will leave a permanent stain on the painted surfaces. In case of prolonged stoppage of vehicle, please turn off ignition key to avoid discharge of battery. Royal Enfield All New Classic 350...
Page 34
5. Display Features 5 A. Odometer 5 B. Trip 1 and Trip 2 5 C. Trip F 5 D. Fuel Bar Graph 5 E. ECO Mode 5 F. Service Reminder 5 G. Clock 5A 5B 5C Royal Enfield All New Classic 350...
Page 35
Display can be toggled using info button plan for a scheduled service at an authorized during this condition but will auto appear after service centre. 25 s Linked with stand switch to avoid re-set when in side stand condition. Royal Enfield All New Classic 350...
Page 36
Trip F reset may occur when riding in mid to rough roads conditions due to frequent fuel oscillations, this feature to be used for reference purpose only and on smooth road surfaces. Royal Enfield All New Classic 350...
Page 37
Enter into minutes mode (minutes to blink) info 0.2<t<1 Minutes to increment info t>3 Enter into unit mode (AM/PM) to blink info 0.2<t<1 Toggle between AM or PM info t>3 Save data and exit clock setting mode Royal Enfield All New Classic 350...
Page 38
OPERATION OF CONTROLS If Trip F not enabled A. LCD SEQUENCE (Info switch press <1 s):- If Trip F enabled CLOCK CLOCK For trip re-set press info button for T>3 s. Royal Enfield All New Classic 350...
Page 39
RE Mobile app. Tripper is being provided to have turn by turn Navigation on motorcycle to help riders to have a hassle free riding without handling the smartphones. This device works Royal Enfield All New Classic 350...
Page 40
Tripper unit display may look dull during sun overhead Mobile Phone low battery indication conditions this is normal and due to impact of direct sunlight on the unit customers to refer during other riding conditions Royal Enfield All New Classic 350...
Page 41
100 m, if there is no turn the display will be blank in this region. Distance to destination or ETA : Shows the total distance to destination or estimated time of arrival (based on used selection from RE Mobile app). Royal Enfield All New Classic 350...
Page 42
/ no input in paired mode tripper will Clock show clock a) If no connection is established b) If connection is established but no navigation input is observed c) Once destination is reached Royal Enfield All New Classic 350...
Page 43
Tripper as it may result in permanent damage to For first time pairing user needs to enter the the same. secured pin shown on tripper through RE Mobile Royal Enfield All New Classic 350...
Page 44
Disable battery optimisation settings / low battery cut-off setting of smartphone for favigation to Calibrate mobile phones frequently for more GPS work in low battery mode. accuracy & location accuracy is dependent on. Royal Enfield All New Classic 350...
Page 45
USB charging port which may lead to short circuit. Recommended not to use in rainy conditions to avoid damages to smart phones and charger, RE shall not be liable for any damage to smart phones. Royal Enfield All New Classic 350...
Page 46
USB charger will function only when engine is in different make mobile phones depending on running condition. smart phone battery capacity, SoC and smart Use standard approved and high quality USB phone charging circuits. cables for proper functioning. Royal Enfield All New Classic 350...
Royal Enfield Service Centre. Failure to continuously reduce the hydraulic pressure and do so can result in a serious injuries and loss of life. thereby prevent the brakes from locking the wheels Royal Enfield All New Classic 350...
Page 48
Please anticipate the stopping distance required for the speed of travel and apply brakes well in advance so as to bring the motorcycle to a safe stop. Royal Enfield All New Classic 350...
Page 49
- front & rear, if contamination is observed, circumstances, ABS may result in a longer stop- it is recommended to clear it suitably or you may ping distance. visit to nearest dealership for necessary action. Royal Enfield All New Classic 350...
Page 50
In the event of the ABS indicator remaining continuously inefficient braking. “ON”, please take the motorcycle to a nearest authorised Royal Enfield Service Centre to inspect the brake system. Royal Enfield All New Classic 350...
Page 51
Ensure the motorcycle is made upright and is on its center stand. Ensure gears are in correct neutral and the neutral lamp is glowing in the instrument console. Royal Enfield All New Classic 350...
5. Cable for fraying or crimping and free operation. Failure to do so may affect safe operation, damage your 6. Engine oil level. motorcycle and could result in an accident causing 7. Wheels for proper tightness. serious injury. Royal Enfield All New Classic 350...
2. Warm up the engine for a few minutes at idling speed to allow engine oil to lubricate all the moving parts in the engine before riding the motorcycle. Royal Enfield All New Classic 350...
Page 54
During the running-in period, do not exceed following speed limits. Motorcycle speed Gear First 500 km 501 - 2000 km 20 kmph 25 kmph 30 kmph 35 kmph 45 kmph 50 kmph 60 kmph 65 kmph 70 kmph 80 kmph Royal Enfield All New Classic 350...
Turn ignition key to “ON” posi- continuously. tion and engine kill switch on right hand side handle bar to “RUN” position Once the Kill switch ON, then only N (neutral) tell tale will glow in instrument cluster Royal Enfield All New Classic 350...
Page 56
Check the fuel level indicator in the cluster for engine starts for adequate fuel in the fuel tank. In case the last bar is a maximum of blinking continuously, it indicates low fuel level in 5 s. the tank. Please re-fuel immediately. Royal Enfield All New Classic 350...
Page 58
“OFF” as soon as gear is engaged. gently, while simultaneously shifting the gear. Do not attempt to shift gears without moving the motorcycle back and forth as it will damage the gears mechanism. Royal Enfield All New Classic 350...
Page 59
Do not release the button before engine starts. Do not press the starter button more than 5 s After three successive cranking, wait for 15 to 20 s the battery to recover. Royal Enfield All New Classic 350...
It is recommended to use half clutch condition jerky start or stalling when commuting in the city traffic condition along the engine besides causing damage to transmission (Engine rpm around idling to 2000 rpm) at 1st gear parts. Royal Enfield All New Classic 350...
Page 61
1 -- N -- 2 -- 3 -- 4 -- 5 appropriate lower gear to prevent the engine from stalling or straining to pull. Royal Enfield All New Classic 350...
Page 62
Gear Change kmph (mph) rider / other road users / passed by besides damage to the motorcycle. 5th - 4th 31.1 4th - 3rd 21.7 3rd - 2nd 15.5 2nd - 1st Royal Enfield All New Classic 350...
Page 63
“OFF” engine kill switch. When the engine speed decreases or while climbing a gradient or running at a reduced speed, shift to the appropriate lower gear to prevent the engine from stalling or straining to pull. Royal Enfield All New Classic 350...
Parking in a soft ground may cause stand to sink and the stand and pull motorcycle backwards, gently. motorcycle to fall, causing injury to you or to others and damage to the motorcycle parts. Royal Enfield All New Classic 350...
Ring Spanner 24x14-24 (Eye Wrench) x 14 (Open End) Combination Open End Spanner 17 x 13 D/E Spanner 10 x 12 Screw Driver 06 x 120 / 135 C-Spanner Extension Tube 28x7 & 24 x 14 Royal Enfield All New Classic 350...
Sterilized Gauze Swab 5 cm x 5 cm Sterilized Elastic Plaster 7 cm x 6 cm Elastic Gauze Bandage 8 cm x 1 m First aid kit pouch Check the expiry date of the first aid kit items before usage. Royal Enfield All New Classic 350...
Apply a few drops of oil on the pivots. Lubricate after water washing motorcycle or if used during rainy conditions. Apply a few drops of oil on the pivots after cleaning the area of dirt. Royal Enfield All New Classic 350...
Page 68
Engine oil level should be max level. Do not inspect the oil level window immediately working up allow it to settle properly. Do not overfill the engine oil above “Max”. Royal Enfield All New Classic 350...
Page 69
Maintain drive chain slackness within specified loosen the spindle nut with a 24 mm ring spanner and loosen the LH & RN Chain Adjuster by using limits every 5000 km or early as required. 6 mm Allen key. Royal Enfield All New Classic 350...
Page 70
Check and set the electrode gap between 0.70 to 0.80 mm. Refit the spark plug on the cylinder head and refit the spark plug cap on the spark plug. Royal Enfield All New Classic 350...
Page 71
Do not mix Swastik Dot 4 Front : Check that the brake fluid reservoir is horizontal and that the fluid level is above middle of the oil window. Oil window middle to be considered as “Min” mark. Royal Enfield All New Classic 350...
Page 72
ABS of spill please clean the area immediately with a hydraulic unit valves. soft cloth to avoid damage. Royal Enfield All New Classic 350...
Page 73
Check proper seating of the tyre beading on the rim Enfield, failure to adhere the same may result in tyre damage and may cause injury to the rider. whenever the tyre is reassembled. Royal Enfield All New Classic 350...
Page 74
Rear : The pads need to you may experience noise, be replaced if a brake pad this is normal for this is worm to the indicator. friction material. Royal Enfield All New Classic 350...
Page 75
For checking the battery voltage check with multi- meter in Voltage mode or contact Royal Enfield The poor contact or loose fitments of battery terminals Authorised Service Centre or battery service may cause electrical / electronic parts failure. center. Royal Enfield All New Classic 350...
Page 76
The adjusting screw is used to increase or decrease the height of the headlight beam in vertical direction only. This may be required to increase the visibility and to help prevent the other riders / vehicles passing nearby. Royal Enfield All New Classic 350...
Page 77
MINOR MAINTENANCE TIPS Fuse & Fuse carrier located in RH side cover. ABS FUSES Royal Enfield All New Classic 350...
Page 78
Failure to do so may result in repeated fuse failure. Usage of fuses other than specified rating or usage of any other conductive materials or low grade fuses will damage the complete electrical system Royal Enfield All New Classic 350...
Make the same adjustments on both sides, uneven are clear of all adjustment may lead to discomfort to the rider. dirt and debris before adjusting, if they have dirt or debris please clean it suitably before adjusting Royal Enfield All New Classic 350...
Page 80
Laden / Two up / Rider + Pillions / payload (Inc of rider weight, Rider + Pillion + Accessories pillion weight and accessories) *Ensure the preload is set equally on the LH and RH rear suspension. Royal Enfield All New Classic 350...
Any loose fasteners. Bulbs for headlight, trafficator light and fuse. Condition of the tyres. Accelerator and clutch cables. Correct oil level in engine. Spark plug, spark plug cap, fuel hose. Royal Enfield All New Classic 350...
Wash the motorcycle only when the engine is in calipers, air intakes & exhaust outlets. cold condition. Do not apply any corrosive solvent on painted Do not remove side panel while washing to avoid surfaces or rubber parts. water entry. Royal Enfield All New Classic 350...
Page 83
Please Royal Enfield All New Classic 350...
Page 84
Polish the painted and plated surfaces using recommended automobile polishing wax. Start the engine and allow to run at an idling speed for a few minutes to warm up engine. Royal Enfield All New Classic 350...
Wipe off excess lubricant after 5 min of application. Battery +ve connector can be disconnected to Remove charging circuit fuse from the fuse box. avoid battery drain issue in longterm. Royal Enfield All New Classic 350...
Please ensure that the effluents are not discharged into the environment. Please promote dry washing which helps the nation to conserve water too. --------------------------------------------------------------------------------------------------------------------------------------------- This not does not constitute legal advice; please contact your local authorities or your nearest Royal Enfield Service Center for further guidance. Royal Enfield All New Classic 350...
PERIODICAL MAINTENANCE The maintenance schedule detailed here will help you maintain your ALL NEW CLASSIC 350 motorcycle meticulously and to get a long trouble free service. The schedule provided herein is based upon average riding conditions and indicates the km, at which regular inspections, adjustments, replacements and lubrications are to be carried out.
Page 88
PERIODICAL MAINTENANCE Sl. No. DESCRIPTION PERIODICAL MAINTENANCE Royal Enfield All New Classic 350...
Page 89
PERIODICAL MAINTENANCE Sl. No. DESCRIPTION PERIODICAL MAINTENANCE Royal Enfield All New Classic 350...
Page 90
PERIODICAL MAINTENANCE Sl. No. DESCRIPTION PERIODICAL MAINTENANCE Royal Enfield All New Classic 350...
Page 91
Authorised Dealer / Service Centre for expert advice and to carry out the periodical maintenance. For maintenance after 50,000 km, please repeat the same frequency levels specified above, in consultation with a Royal Enfield Authorised Dealer / Service Centre. Royal Enfield All New Classic 350...
4. During the warranty period, RE’s obligations shall be limited to repairing/ replacing part(s) of the motorcycle for free, only if the part(s), on examination is deemed to have a manufacturing defect. Defective part(s) which have been replaced will become the sole property of RE. Royal Enfield All New Classic 350...
Page 93
(c) Failures occurred due to use of non recommended grade lubricants, fuel or improper level. (d) Damages due to use of non-genuine parts, lack of proper maintenance, incorrect riding habits. Royal Enfield All New Classic 350...
Page 94
(k) Electrical component like bulbs, fuses etc. and electronic components failure including ECU due to repairs by arc welding. (l) Motorcycle found with tampering / drilling / welding mark on any part of the frame. Royal Enfield All New Classic 350...
Page 95
Ride Sure with Royal Enfield's Annual Maintenance Contract, Extended Warranty and Roadside Assistance. To know more, visit our website or your nearest Royal Enfield store. Call us at 1800210007 to get in touch with us. Royal Enfield All New Classic 350...
Royal Enfield and / or our Authorised Service Centre and results of such examination will be final and binding. If on examination the warranty conditions of the part/s is/are not established, Royal Enfield Royal Enfield All New Classic 350...
Page 97
Royal Enfield reserves the right to carry out necessary consequential repairs to the motorcycle or replace any part, in addition to the repair or replacement of the components covered under emission warranty, to establish compliance to in-use emission standards. Such repairs / replacements will be chargeable to the customer. Royal Enfield All New Classic 350...
Page 98
Emission warranty will be applicable irrespective of the change of ownership of the motorcycle provided all the conditions as laid down in this document are met from the date of original sale of the motorcycle. Royal Enfield All New Classic 350...
Page 99
Production of a valid Pollution Under Control Certificate is necessary to claim Emission Warranty. Royal Enfield All New Classic 350...
Page 100
The motorcycle is not serviced by RE Authorised Dealer / Service Centre as per the service schedule described in the maintenance chart. The motorcycle has been subjected to abnormal use, abuse, neglect and improper maintenance or has met with an accident. Royal Enfield All New Classic 350...
Page 101
The motorcycle has been run on adulterated / leaded fuel or lubricant other than those specified by Royal Enfield in the Owner’s manual or any other document given to the customer at the time of sale of the motorcycle. Royal Enfield All New Classic 350...
Page 102
Always get your motorcycle checked to meet the emission regulations through an authorised emission checking centre. Always carry a valid "Pollution Under Control" certificate with you, as and if applicable by law. Royal Enfield All New Classic 350...
Page 103
Ensure the fuel used is not adulterated. Use correct spark plug as recommended in the owner’s manual. Use lubricants as per recommendations given on grade / brand in the owner’s manual. Royal Enfield All New Classic 350...
2. Replacing, removing OR modifying any portion of the EVAPORATIVE EMISSION CONTROL SYSTEM (consisting of fuel tank, fuel tank cap, canister, purge valve, throttle body, vapor hoses, fuel hoses and hose connectors) with parts not certified by Royal Enfield. Royal Enfield All New Classic 350...
Page 105
It is recommended that the routine maintenance of the motorcycle be carried out at specified intervals and any maintenance to the evaporative emission control systems should be performed only by an Authorised Royal Enfield Service Centre and using only genuine Royal Enfield spare parts. Royal Enfield All New Classic 350...
Cost of parts, lubricants, filters and other consumables are chargeable to the customer on their respective service activities. Refer the Periodic maintenance chart for the respective service activities. * Labour is free for this services alone. Royal Enfield All New Classic 350...
Page 108
Part No. RAM00347/A Edition : September 2021...
Need help?
Do you have a question about the Classic 350 and is the answer not in the manual?
Questions and answers