Table of Contents
Advertisement
Quick Links
SUPPLEMENT OF
SUPPLEMENT OF
SUPPLEMENT OF
SUPPLEMENT OF
SUPPLEMENT OF
SER
SER
VICE MANUAL
VICE MANUAL
SERVICE MANUAL
SER
SER
VICE MANUAL
VICE MANUAL
W W W W W ARNING TO SER
PRECAUTIONS TO BE OBSERVED BEFORE AND DURING
SERVICING TO AVOID POSSIBLE EXPOSURE TO
(a) Do not operate or allow the oven to be operated with the door open.
(b) Make the following safety checks on all ovens to be serviced before activating the magnetron or other
microwave source, and make repairs as necessary :
(1) Interlock operation, (2) proper door closing, (3) seal and sealing surfaces (arcing, wear, and other damage),
(4) damage to or loosening of hinges and latches, (5) evidence of dropping or abuse.
(c) Before turning on microwave power for any service test or inspection within the microwave generating
compartments, check the magnetron, wave guide or transmission line, and cavity for proper alignment, integrity,
and connections.
(d) Any defective or misadjusted components in the interlock, monitor, door seal, and microwave generation and
transmission systems shall be repaired, replaced, or adjusted by procedures described in this manual before
the oven is released to the owner.
(e) A microwave leakage check to verify compliance with the Federal performance standard should be performed
on each oven prior to release to the owner.
Micr
Micr
owave Oven
owave Oven
Micr
Micr
Microwave Oven
owave Oven
owave Oven
CAUTION
CAUTION
CAUTION
CAUTION
CAUTION
ARNING TO SER
ARNING TO SER
ARNING TO SER
ARNING TO SERVICE TECHNICIANS
EXCESSIVE MICROWAVE ENERGY
Pr Pr Pr Pr Product Code No.
oduct Code No.
oduct Code No.
oduct Code No.
oduct Code No.
See the Service Manual of EM-S8000BS (SM-860278)
except the items described in this Service Manual.
VICE TECHNICIANS
VICE TECHNICIANS
VICE TECHNICIANS
VICE TECHNICIANS
File No :
File No :
File No :
File No :
File No :
EM-S9000S
EM-S9000S
EM-S9000S
EM-S9000S
EM-S9000S
(U.S.A.)
(U.S.A.)
(U.S.A.)
(U.S.A.)
(U.S.A.)
437 500 02
437 500 02
437 500 02
437 500 02
437 500 02
REFERENCE NO. SS-860289
Advertisement
Table of Contents
Related Manuals for Sanyo EM-S9000S
Summary of Contents for Sanyo EM-S9000S
- Page 1 File No : File No : File No : SUPPLEMENT OF SUPPLEMENT OF SUPPLEMENT OF SUPPLEMENT OF SUPPLEMENT OF Micr Micr owave Oven owave Oven EM-S9000S EM-S9000S Micr Micr Microwave Oven owave Oven owave Oven EM-S9000S EM-S9000S EM-S9000S (U.S.A.) (U.S.A.) (U.S.A.)
- Page 2 In the area emitting the highest reading, switch the meter CAUTION CAUTION CAUTION CAUTION CAUTION to SLOW RESPONSE, and take a reading for minimum of three (3) seconds. We recommended the pattern outline For micr For micr owave ener owave ener gy emission gy emission For micr...
- Page 3 - TABLE OF CONTENTS - Specifications ..............Exploded View and Parts List ........ 3 ~ 10 Power Output Measurement ........... Overall Circuit Diagram .......... 11 ~ 12 Circuit Diagram ............... 1. SPECIFICA 1. SPECIFICA 1. SPECIFICATIONS 1. SPECIFICA 1. SPECIFICA TIONS TIONS TIONS...
-
Page 4: Circuit Diagram
3. CIRCUIT DIAGRAM Figure 1 Figure 1 Figure 1 Figure 1 Figure 1 • • • • • - 2 -... - Page 5 4 . 4 . 4 . 4 . 4 . EXPLODED VIEW AND P EXPLODED VIEW AND P EXPLODED VIEW AND P TS LIST TS LIST EXPLODED VIEW AND P EXPLODED VIEW AND PAR ARTS LIST TS LIST TS LIST CAVITY PARTS * * * ALL SERVICE ON MICROWAVE OVENS SHOULD BE PERFORMED BY A QUALIFIED TECHNICIAN USING...
- Page 6 SWITCHES AND MICROWAVE PARTS ALL SERVICE ON MICROWAVE OVENS SHOULD BE PERFORMED BY A QUALIFIED TECHNICIAN USING APPROVED TESTING EQUIPMENT. CUSTOMERS SHOULD NOT ATTEMPT TO REPLACE PARTS IDENTIFIED BY A TRIPLE ASTERISK (***). Part No. Description Q’ty Part No. Description Q’ty 411 160 6106 SCR S-T TRS + SRT 4 x 10...
-
Page 7: Door Parts
DOOR PARTS * * * ALL SERVICE ON MICROWAVE OVENS SHOULD BE PERFORMED BY A QUALIFIED TECHNICIAN USING APPROVED TESTING EQUIPMENT. CUSTOMERS SHOULD NOT ATTEMPT TO REPLACE PARTS IDENTIFIED BY A TRIPLE ASTERISK (***). Part No. Description Q’ty Part No Description Q’ty 617 224 9988... -
Page 8: Control Panel Parts
CONTROL PANEL PARTS * * * ALL SERVICE ON MICROWAVE OVENS SHOULD BE PERFORMED BY A QUALIFIED TECHNICIAN USING APPROVED TESTING EQUIPMENT. CUSTOMERS SHOULD NOT ATTEMPT TO REPLACE PARTS IDENTIFIED BY A TRIPLE ASTERISK (***). Part No. Description Q’ty Part No. Description Q’ty 617 225 0342... -
Page 9: Control Circuit Board
CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD (Part No. 617 224 9650 617 224 9650 617 224 9650 617 224 9650 617 224 9650) 3 7 2 0 0 - 7 -... - Page 10 CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD (Part No. 617 224 9650 617 224 9650 617 224 9650 617 224 9650) 617 224 9650 Key No. Order Part No. Description Q’ty Key No. Order Part No.
- Page 11 CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD (Part No. 617 224 9667 617 224 9667 617 224 9667 617 224 9667) 617 224 9667 - 9 -...
- Page 12 CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD (Part No. 617 224 9667 617 224 9667 617 224 9667 617 224 9667) 617 224 9667 Key No. Order Part No. Description Q’ty Key No. Order Part No.
- Page 13 5 . 5 . 5 . 5 . 5 . OVERALL CIRCUIT DIAGRAM OVERALL CIRCUIT DIAGRAM OVERALL CIRCUIT DIAGRAM OVERALL CIRCUIT DIAGRAM OVERALL CIRCUIT DIAGRAM (Part No. 617 224 9650 617 224 9650 617 224 9650 617 224 9650) 617 224 9650 - 11 -...
- Page 14 5 . 5 . 5 . 5 . 5 . OVERALL CIRCUIT DIAGRAM OVERALL CIRCUIT DIAGRAM OVERALL CIRCUIT DIAGRAM OVERALL CIRCUIT DIAGRAM OVERALL CIRCUIT DIAGRAM (Part No. 617 224 9667 617 224 9667 617 224 9667 617 224 9667 617 224 9667) - 12 -...
- Page 15 File No : File No : File No : File No : File No : SERVICE MANUAL VICE MANUAL VICE MANUAL VICE MANUAL VICE MANUAL Micr Micr owave Oven owave Oven EM-S8000BS EM-S8000BS Micr Microwave Oven Micr owave Oven owave Oven EM-S8000BS EM-S8000BS EM-S8000BS...
- Page 16 In the area emitting the highest reading, switch the meter CAUTION CAUTION CAUTION CAUTION CAUTION to SLOW RESPONSE, and take a reading for minimum of three (3) seconds. We recommended the pattern outline For micr For micr For micr For micr For microwave ener owave ener owave ener...
- Page 17 PERSONNEL. PERSONNEL. SERVICE VICE VICE PERSONNEL. PERSONNEL. PERSONNEL. The SANYO service center should have the designated Door detector to measure the microwave energy leakage Latch after the repair or adjustment. Lever Stopper NOTE NOTE NOTE : Detector to be used at the service center is...
-
Page 18: Power Output Measurement
2. SPECIFICA 2. SPECIFICA TIONS TIONS 4 . 4 . 4 . 4 . 4 . PRECAUTIONS AND REP PRECAUTIONS AND REP PRECAUTIONS AND REP AIR SER AIR SER VICE TIPS VICE TIPS 2. SPECIFICA 2. SPECIFICA 2. SPECIFICATIONS TIONS TIONS PRECAUTIONS AND REP PRECAUTIONS AND REPAIR SER... - Page 19 5. CIRCUIT DIAGRAM • • • • • Figure 2 Figure 2 Figure 2 Figure 2 Figure 2 - 3 -...
-
Page 20: Test Procedures And Troubleshooting
6. TEST PROCEDURES AND TROUBLESHOOTING 6. TEST PROCEDURES AND TROUBLESHOOTING Filament Windings 6. TEST PROCEDURES AND TROUBLESHOOTING 6. TEST PROCEDURES AND TROUBLESHOOTING 6. TEST PROCEDURES AND TROUBLESHOOTING CAUTION CAUTION CAUTION CAUTION CAUTION - DISCONNECT THE POWER SUPPL - DISCONNECT THE POWER SUPPL Y CORD FROM Y CORD FROM - DISCONNECT THE POWER SUPPL... -
Page 21: High-Voltage Capacitor
COMPONENT COMPONENT COMPONENT COMPONENT COMPONENT CHECKOUT PROCEDURE CHECKOUT PROCEDURE CHECKOUT PROCEDURE CHECKOUT PROCEDURE CHECKOUT PROCEDURE RESUL RESUL RESUL RESUL RESULT T T T T Measure the resistance : Across two terminals Normal reading : with an ohm-meter on highest scale. Momentarily indicates several ohms, and gradually returns to 10 meg-ohms. -
Page 22: Checkout Procedures
COMPONENT COMPONENT COMPONENT COMPONENT COMPONENT CHECKOUT PROCEDURE CHECKOUT PROCEDURE CHECKOUT PROCEDURE CHECKOUT PROCEDURE CHECKOUT PROCEDURE RESUL RESUL RESUL RESUL RESULT T T T T When When not Measure the resistance between terminals of touched touched Resistance FPC connector after removing it from S101. value Less than More than... - Page 23 - 7 -...
- Page 24 - 8 -...
- Page 25 - 9 -...
- Page 26 - 10 -...
- Page 27 7 . 7 . 7 . 7 . 7 . DISASSEMBL DISASSEMBL DISASSEMBL DISASSEMBLY INSTRUCTIONS Y INSTRUCTIONS Y INSTRUCTIONS Y INSTRUCTIONS DISASSEMBL Y INSTRUCTIONS • • • • • OVEN MUST BE DISCONNECTED FROM ELECTRICAL OVEN MUST BE DISCONNECTED FROM ELECTRICAL OVEN MUST BE DISCONNECTED FROM ELECTRICAL B.
- Page 28 C. C. C. C. C. REMOVING BLOWER MOTOR REMOVING BLOWER MOTOR REMOVING BLOWER MOTOR REMOVING BLOWER MOTOR REMOVING BLOWER MOTOR (Figure 11 (Front View) (1) Disconnect wires from Blower Motor. (2) Unhook Control Frame after removing the screw. (3) Remove 3 front screws securing the Blower Base. D.
- Page 29 E. E. E. E. E. REMOVING FUSE REMOVING FUSE REMOVING FUSE REMOVING FUSE REMOVING FUSE Remove the 20A fuse with a screwdriver. NOTE NOTE NOTE NOTE NOTE Control Circuit Board - When replacing the 20A fuse, be sure to use an exact repair part.
-
Page 30: Removing Door
H. H. H. H. REMOVING DOOR REMOVING DOOR REMOVING DOOR REMOVING DOOR REMOVING DOOR J. J. J. J. J. REMOVING CA REMOVING CA REMOVING CA VITY COVER VITY COVER REMOVING CA REMOVING CAVITY COVER VITY COVER VITY COVER (Figure 16) (1) Remove 2 hex nuts securing the upper hinge. - Page 31 8 . 8 . 8 . 8 . 8 . EXPLODED VIEW AND P EXPLODED VIEW AND P EXPLODED VIEW AND P TS LIST TS LIST EXPLODED VIEW AND P EXPLODED VIEW AND PAR ARTS LIST TS LIST TS LIST CAVITY PARTS * * * ALL SERVICE ON MICROWAVE OVENS SHOULD BE PERFORMED BY A QUALIFIED TECHNICIAN USING...
- Page 32 SWITCHES AND MICROWAVE PARTS ALL SERVICE ON MICROWAVE OVENS SHOULD BE PERFORMED BY A QUALIFIED TECHNICIAN USING APPROVED TESTING EQUIPMENT. CUSTOMERS SHOULD NOT ATTEMPT TO REPLACE PARTS IDENTIFIED BY A TRIPLE ASTERISK (***). Part No. Description Q’ty Part No. Description Q’ty 411 160 6106 SCR S-T TRS + SRT 4 x 10...
- Page 33 DOOR PARTS * * * ALL SERVICE ON MICROWAVE OVENS SHOULD BE PERFORMED BY A QUALIFIED TECHNICIAN USING APPROVED TESTING EQUIPMENT. CUSTOMERS SHOULD NOT ATTEMPT TO REPLACE PARTS IDENTIFIED BY A TRIPLE ASTERISK (***). Part No. Description Q’ty Part No Description Q’ty 617 222 2097...
- Page 34 CONTROL PANEL PARTS * * * ALL SERVICE ON MICROWAVE OVENS SHOULD BE PERFORMED BY A QUALIFIED TECHNICIAN USING APPROVED TESTING EQUIPMENT. CUSTOMERS SHOULD NOT ATTEMPT TO REPLACE PARTS IDENTIFIED BY A TRIPLE ASTERISK (***). Part No. Description Q’ty Part No. Description Q’ty 617 222 2370...
-
Page 35: Control Circuit Board
CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD (Part No. 617 195 8263 617 195 8263 617 195 8263 617 195 8263 617 195 8263) 1 1 3 0 0 - 19 -... - Page 36 CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD CONTROL CIRCUIT BOARD (Part No. 617 195 8263 617 195 8263 617 195 8263 617 195 8263) 617 195 8263 Key No. Order Part No. Description Q’ty Key No. Order Part No.
- Page 37 9 . 9 . 9 . 9 . 9 . OVERALL CIRCUIT DIAGRAM OVERALL CIRCUIT DIAGRAM OVERALL CIRCUIT DIAGRAM OVERALL CIRCUIT DIAGRAM OVERALL CIRCUIT DIAGRAM - 21 -...
- Page 38 This file has been downloaded from: www.UsersManualGuide.com User Manual and User Guide for many equipments like mobile phones, photo cameras, monther board, monitors, software, tv, dvd, and othes.. Manual users, user manuals, user guide manual, owners manual, instruction manual, manual owner, manual owner's, manual guide, manual operation, operating manual, user's manual, operating instructions, manual operators, manual operator, manual product, documentation manual, user maintenance, brochure, user reference, pdf manual...