Table of Contents
Advertisement
INSTRUCTIONAL BOOK
CARE & USE/INSTALLATION
Model GS-32 Propane/NG, Model GSL-32 Propane /
NG and Model GSL-SB2 Propane/NG
DANGER – IF YOU SMELL GAS:
1 – Shut off the gas supply to the appliance at
its source
2 – Extinguish any open flames
3 – Open grill hood to release any
accumulation of gas vapor
4 – If a gas odor persists, keep away from your
appliance and contact your gas supplier or fier
department immediately.
PLEASE LEAVE THESE INSTRUCTIONS WITH THE CONSUMER.
PLEASE RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE
ATTENTION INSTALLER:
ATTENTION CONSUMER:
- CONTACT INFORMATION -
2222 Diversified Way
Orlando, FL 32824
800-604-2023
www.myparadisegrill.com
Paradise Grilling Systems Instructional Book
WARNING
1 – Do not store or use gasoline or other
flammable liquids or vapor in the vicinity of
this or any other appliance
2 – An LP cylinder not connected for use shall
not be stored in the vicinity of this or any
other appliances.
Advertisement
Table of Contents
Related Manuals for STEELE PRODUCTS PARADISE GS-32
Summary of Contents for STEELE PRODUCTS PARADISE GS-32
- Page 1 INSTRUCTIONAL BOOK CARE & USE/INSTALLATION Model GS-32 Propane/NG, Model GSL-32 Propane / NG and Model GSL-SB2 Propane/NG DANGER – IF YOU SMELL GAS: WARNING 1 – Shut off the gas supply to the appliance at 1 – Do not store or use gasoline or other its source flammable liquids or vapor in the vicinity of this or any other appliance...
- Page 2 THIS MANUAL APPLIES TO THE FOLLOWING: Model:GS-32N/P PREMIUM GRILL Model: GSL-32N/P PROFESSIONAL GRILL BBQ Dimensions 30 3/8 x 8 x 21" 30 3/8 x 8 x 21" BBQ Dimensions BTU Output 12,000 BTU per Burner x4 BTU Output 12,000 BTU per Burner x4 Infrared Back Burner 10,000 BTU x1 Infrared Back Burner...
- Page 3 THIS MANUAL APPLIES TO THE FOLLOWING: Model: GSL-SB2 N/P DOUBLE SIDE BURNER BBQ Dimensions 12 Y2 20 5/8 8" Total BTU Output 24,000 BTU Number of Burners 12,000 BTU Orifice Size mm LP 1.05mm Orifice Size mm NG 1.6mm Drip tray Stainless Steel &...
-
Page 4: Safety And Installation Instructions
Safety and Installation Instructions When using your grill, please read and follow these basic precautions: GRILL INSTALLATION This gas grill must be installed in accordance with all local codes. If installation is planned in an area with no local codes, the gas grill must be installed in accord with the National Fuel Gas Code ANSI Z223.1 and storage and handling of liquefied petroleum gases, ANSI/NFPA 58 or CSA B149.1 natural gas and propane installation code. - Page 5 Safety and Installation Instructions Location of your Barbecue Most importantly, this is an outdoor appliance. Ensure your barbecue is positioned safely away from anything that can catch fire. Under no circumstance is this barbecue to be used indoors. This includes garages or any other enclosed area.
-
Page 6: Safety And Installation Warnings
Maintenance Access: When your barbecue is installed, you should be able to access the gas supply line including the gas piping or hose, gas regulator, gas cylinder and any shut off valves. Partial Enclosures: Many backyards have areas that are partially closed off, such as balconies and pergolas. - Page 7 Keep any electrical supply cord and fuel supply hose away from any heated surfaces and dripping grease. Do not twist the gas supply hose. Before each use, visually inspect the gas supply hose for cracks, cuts or excessive wear. Replace the hose if necessary. Never test the grill for gas leaks using a lighted match or any other open flame;...
-
Page 8: Natural Gas Requirements
with the unit and set to 11" water column pressure. The gas valves used in the grills are preset at the factory for Natural Gas or Liquid Propane operation. Please contact your dealer and use a licensed contractor or installer to convert your grill to a different gas type. The self-contained LP system barbeque grill is design certified to be used with a standard 20 lb, 12 1/4"... -
Page 9: Checking For Gas Leaks
Connection Slide the grill forward to gain access to the regulator and gas connection point in the rear. Connect a suitable natural gas flex connector to the grill regulator. Check the grill controls to ensure all control valves are in the full OFF position. Turn on the main gas supply and check all connections for leaks using soapy water as Described in the leak testing procedure section. - Page 10 Apply the leak-testing solution by spraying it on joints of the gas delivery system. Blowing bubbles in the soap solution indicates that a leak is present. Stop a leak by tightening the loose joint or by replacing the faulty part with a replacement part recommended by the manufacturer.
- Page 11 LP TANK REQUIREMENTS: - a collar to protect the cylinder threads on the customer supplied tank. - an arrangement for gas vapor withdrawal. - a safety relief device having direct communication with the vapor space of the cylinder. - a method of mounting. - when not in use, the tank shut off valve should be turned off.
- Page 12 Transporting and Storing LP Gas Transport only one cylinder at a time. Ensure the cylinder is secured in an upright position with the control valve turned off and the dust cap in place. Store cylinders outdoors and out of reach of children.
-
Page 13: Installing The Grill In A Bbq Island
Installing the Grill in a BBQ Island You will need a second person to help you avoid damaging the grill or your barbecue island. Before installing a grill in any island or cut out, make sure that the opening is not bigger than the outside frame of the grill unit. -
Page 14: Building Bbq Specifications
BUILDING BBQ SPECIFICATIONS ALL BBQ ISLANDS MUST BE MANUFACTURED FROM “NON-COMBUSTIBLE” MATERIAL. Minimum clearance to adjacent combustible construction at 14” from sides & 16” from back MODEL DESCRIPTION WIDTH DEPTH HEIGHT GS-32 4 Burner 30 5/8” 21 1/4” 8 1/2” GSL-32 4 Burner Lighted 30 5/8”... - Page 16 Installation Method for Propane Installation Method for Natural Gas Connection Method for Dual Side Burner When connecting your Side Burner to LP or NG No Regulator is required on the Side Burner. Paradise Grilling Systems Instructional Book...
-
Page 17: Bbq Specifications
BBQ SPECIFICATIONS NOTE: “ALWAYS” have equipment measured by Contractor before building. NOTE: Check with City and Fire department for Local Building Codes. A Permit may be required for outdoor Kitchen Construction. Paradise Grilling Systems Instructional Book... -
Page 18: Electrical Precautions
ELECTRICAL PRECAUTIONS: Extension cords are available and may be used if care is exercised in their use. If an extension cord is used: • the marked electrical rating of the cord set or extension cord should be at least as great as the electrical rating of the appliance, and, •... - Page 19 GENE RA L USE AN D C A RE NOTE: The manufacturer cannot be held responsible for damage or injury caused by improper use of this appliance. ➢ Be certain your appliance is properly installed and grounded by a qualified technician in accordance with applicable codes.
- Page 20 Safety and Installation Instructions UNIT INSTALLATION: Your Paradise Grilling Systems Grill comes pre-assembled and requires very little setup. We do however; recommend the use of professional help during the installation of your unit as improper installation may affect your warranty. Remove the unit from the box along with all accessories and check that no damage has occurred to the unit or any parts.
-
Page 21: Lighting Instructions
Lighting Instructions Caution: Never operate the grill unattended. Do not operate the rotisserie burner with the hood closed. Prior to using your grill, verify that all of the following is correct: ❒ The burner tube is free of insects and insect nests, webs, etc. ❒... -
Page 22: Lighting The Grill
Lighting the Grill 1. Open the hood. 2. Keep your face as far away from the burners as possible. 3. Slowly rotate the burner knob counter-clockwise to the high position. 4. You will hear a loud click as the electronic lighter produces a spark. Listen for the sound of the gas igniting. -
Page 23: First Time Operation
First Time Operation MAIN BURNERS: Before cooking with your grill for the first time, burn off any foreign matter and rid the unit of any odors by operating the unit for about five minutes. When lit, the flame should have a bluish color to it. It may have a tint of yellow and adjustment to the air shutters can be made to obtain a blue flame and proper gas flow. - Page 25 Fuel (Gas) Conversion Instructions for Paradise Grilling Systems Gas grills. CAUTION: This should only by performed by a licensed gas professional. NATURAL GAS TO PROPANE CONVERSION - Main Burners: Currently all grills are supplied with a regulator set at a pressure of 4” water column. Fuel Conversion of Main Burners: 1.
- Page 27 10. Replace burner flame tamers and cooking grills 11. If necessary, adjust the LOW flame setting screw located under the knob on the front of the valve Rear Burner For the Summer Sizzler 4 Burner, replace the back burner orifice by removing the plate on the rear of the BBQ and carefully removing the fitting.
-
Page 28: Warranty Registration
Warranty Registration If you have purchased a Paradise Grilling Systems Grill you must maintain your original receipt to get service on the grill. The warranty is for original owners only and cannot be transferred to new owners. You should retain your sales slip or invoice. All Natural and LP Gas grills must have a qualified installer complete the installation for the warranty to be in effect. - Page 29 Paradise Grilling Systems Instructional Book GS-32...
- Page 30 Paradise Grilling Systems Instructional Book GSL-32...
- Page 31 Paradise Grilling Systems Instructional Book GSL Double Side Burner – GSL-SB2...
- Page 33 Paradise Grilling Systems Instructional Book...
- Page 34 Locating the Product Serial Number: The serial number of your Paradise Grilling Systems Gas or LP Grill is located on the left- hand side of the Firebox. You will need this number to properly register your grill or cart and activate coverage.
-
Page 35: Warranty Registration Form
WARRANTY REGISTRATION FORM Please complete this form to register your Paradise Grilling Systems Product. Please make sure all fields are correct and complete. Items marked with an asterisk (*) are required to be eligible for warranty. *NAME: *DATE OF DELIVERY: ADDRESS: CITY: STATE:...
Need help?
Do you have a question about the PARADISE GS-32 and is the answer not in the manual?
Questions and answers