Sealey TH003.V2 Quick Start Manual

thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,
and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
Refer to Wear
instruction protective
manual gloves
1. SaFety
i
WarNiNg! Ensure Health & Safety, local authority, and general workshop practice regulations are adhered to when using this equipment.
‰
Always load centrally and evenly with the tyres registering with both load bearing uprights in the transport mode.
9
Do Not overload the trolley - see Specification.
8
Do Not leave unattended, especially when loaded, unless the wheels are chocked or the trolley is otherwise secured.
8
Do Not run over curbs or steps, use a ramp.
8
Do Not allow others to ride on the trolley.
8
Do Not use the trolley if any parts are damaged, paying particular attention to the jaws.
8
2. iNtroDuctioN
Pick up and transport stacks of car tyres with ease. Strong tubular steel construction with welded joints. Pneumatic tyres allow easy
transportation over rough ground.
3. SpeciFicatioN
Model No. ................................................................ tH003.V2
Capacity ..........................................................................150kg
Wheel diameter .............................................................250mm
Height ..........................................................................1520mm
max. jaw capacity ..........................................................900mm
min. jaw capacity ...........................................................420mm
4. aSSeMbly
Transport handlebars
and stack support
fig.1
8
3
1
4
7
13-15
2
11
operator side
© Jack Sealey limited
tyre trolley 150kg capacity
model no:
Wear
protective
footwear
Jaw sweep and lift
levers (with grips)
fig.3
fig.4
10 1
2
tH003.V2
7
fig.5
12
fig.6
Original Language Version
fig.2
9
5
TH003.V2 Issue: 2(3) 15/07/19
22
6