Sealey SA894.V3 Instructions

thank you for purchasing a sealey product. Manufactured to a high standard, this product will, if used according to these instructions,
and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
refer to Wear eye
instruction protection
manual
1. saFetY
Warning! Do not dismantle the hose reel casing. to do so may result in damage to the appliance and/or personal injury and will
‰
invalidate the warranty. internal maintenance, which will require the opening of the casing, must only be undertaken by an authorised
service agent.
familiarise yourself with the application and limitations of the air hose reel, as well as the specific hazards.
9
Warning! disconnect the air hose reel from the air supply before changing accessories, servicing or performing any maintenance.
‰
maintain the air hose reel in good condition (use an authorised service agent).
9
replace or repair damaged parts. Use recommended parts only. Unauthorised parts may be dangerous and will invalidate the warranty.
9
locate and fix the air hose reel in a suitable working area. Do not position the hose in direct sun light, or in areas of extreme heat
9
or cold. ensure there is adequate lighting.
Warning! ensure maximum air pressure is not exceeded.
‰
Keep extended air hose away from heat, oil and sharp edges. check hose for wear before each use, and ensure all connections are
9
secure.
Keep the unwound air hose at a safe distance from the working area and free from wet, damp, oily surfaces.
9
Warning! Always wear approved eye or face protection when operating the air hose reel.
‰
maintain correct balance and footing. ensure the floor is not slippery and wear non-slip shoes.
9
remove ill fitting clothing. remove ties, watches, rings, and other loose jewellery and contain and/or tie back long hair.
9
Keep children and unauthorised persons away from the working area.
9
Do not operate the air hose reel if any parts are damaged or missing as this may cause failure and/or personal injury.
8
Do not exceed the rated capacity of the air hose reel.
8
Do not use the air hose reel for any purpose other than that for which it is designed.
8
Do not pull the hose from the air supply.
8
Do not operate the air hose reel when you are tired or under the influence of alcohol, drugs or intoxicating medication.
8
Do not direct air from the air hose at yourself or others.
8
When not in use ensure the air supply is turned off and tools disconnected. disconnect from the air supply and retract the hose into case.
9
2. introDuction
n
Hard wearing, composite cased retracting air hose reels supplied with heavy duty polyurethane hose. reels feature ratchet or free running
operation and are supplied with wall/ceiling mounting brackets.
3. speciFication
fi
model no: .................................................................. sA894.V3
Hose length: .................................................................... 15mtr
Hose size id/od: ..........................................................8/12mm
maximum pressure: ........................................................ 150psi
inlet/outlet: ................................................................... 1/4"BsP
model no: .................................................................. sA895.V3
Hose length: .................................................................... 10mtr
Hose size id/od: ........................................................10/15mm
maximum pressure: ........................................................ 150psi
inlet/outlet: ................................................................... 3/8"BsP
© Jack sealey limited
instructions for
retracting air hose reels
sa894.V3 & sa895.V3
model no:
Original Language Version sA894.V3, sA895.V3 | issue 2(l) 22/12/16