Dispensing From The Top; Removing A 3D Biocontainer System From The Tote; Allegro Tote Stacking - Pall Allegro 200 L Instructions For Use Manual

5.6.2
5.7

Removing a 3D Biocontainer System from the Tote

1. Drain the 3D single-use biocontainer and tubing fully.
2. Close all clamps and disconnect the system completely from inlet and outlet tubing
and systems.
3. Remove the collapsed system after releasing the port bracket from its position by
disengaging the latches provided on the underside of the port bracket.
4. Remove the single-use system, by lifting out of the top (or via the access panel on the
500 L tote).
5. IMPORTANT: After removing the Allegro system, the Allegro tote port bracket should be
retained by detaching it from the hexagonal section of the Allegro system and reinstall it
in the tote for reuse. Spare port brackets are available to purchase if these are mislaid
(see section 7).
6.

Allegro Tote Stacking

Allegro plastic totes are suitable for stacking – examples are shown in Figures 39 and 40. Refer to Tables
4 and 5 for stacking limits.
Table 4
Stacking Specifications Allegro 200 L Plastic Tote
Fill Level
Empty
Full
Table 5
Stacking Specifications Allegro 500 L Plastic Tote
Fill Level
Empty
Full
5. Once drainage is complete, close the clamp on the dispensing line.
6. Disconnect the dispensing line in accordance with the requirements of the
connection device and your own site procedures.

Dispensing from the Top

Dispensing from the Allegro system is usually performed via the bottom port, but fluid
can be dispensed via the top ports if required. However, when emptying from the top,
sufficient tubing length on the top ports must be allowed to compensate for the col-
lapse of the system during emptying.
In order to dispense from the top, there should have been no air introduced during
filling so that the top port is in direct contact with the liquid in the biocontainer.
Otherwise, use of a vent and bag weight is required.
Configuration
200 L open
200 L collapsed
200 L open
Configuration
500 L open
500 L collapsed
500 L open
Without Trolley
Up to 3 high
Up to 5 high
3 high
Without Trolley
Up to 2 high
Up to 5 high
2 high
www.pall.com/biopharm
With Trolley
Not recommended
Up to 5 high
Not recommended
With Trolley
Not recommended
Up to 5 high
Not recommended
21