Page 3 RV lifestyle as a family friendly form of leisure, recreation and fun. It is the intent of the Grand Design RV Team and our Dealer Partners to do our absolute best to assure that you enjoy a positive ownership experience and capitalize on all the exciting opportunities this “Grand”...
Page 4 This page is intentionally blank.
Page 5 Travel Trailer Owner's Manual Introduction Reporting Safety Defects Service & Warranty Grand Design RV One Year Limited Base Warranty Grand Design RV Three Year Limited Structural Warranty Component Supplier Contact Information Component Manufacturer Warranty Information Occupant Safety . Pre-Travel Information Towing &...
Page 6 This page is intentionally blank.
Page 7: About This Manual
If you have any questions, concerns, or require assistance regarding any aspect of your RV, please contact your dealer or Grand Design RV. Contact Information: www.granddesignrv.com Website customerservice@granddesignrv.com...
Page 8 RV for the next owner. your Owner Information Package. Manufacturing Certification We build all Grand Design RV fifth wheels and travel trailers to meet or exceed the thorough safety and manufacturing codes, standards, and regulations of the Recreational Vehicle Industry Association (RVIA).
Page 9: Vehicle Identification Number
A-frame. It is also listed on the Federal Certification label. are also the RV's serial number. A breakdown of a typical Grand Design RV VIN is shown in the For the example shown, the serial number is M6600001. example below:...
Page 10: Safety Precautions
Introduction Safety Precautions Nothing is more important than the personal safety of you, your Various safety and family and others. Safety encompasses several areas related information labels to the RV experience. This includes driving/towing safety, are attached to surfaces both inside occupant safety, operational safety, environmental safety, and and outside your RV.
Page 11 Additional Terminology Used [Customer Supplied] This denotes aftermarket items not installed or included by Grand Design RV. Items noted as “customer supplied” are not covered by the Limited Base and Structural Warranties. The inclusion of items noted as “customer supplied”...
Page 12: Reporting Safety Defects
If they determine that a safety defect exists in other vehicles, a recall and remedy campaign may be ordered. The NHTSA does not become involved in individual cases between you, your dealer, or Grand Design RV. To contact the NHTSA, www.safercar.gov...
Page 13: Dealer's Responsibilities
Limited Base Warranty and Limited Structural Warranty. 4. SEND your completed Warranty Registration and The Limited Base New Vehicle PDI Check List to Grand Design RV. Warranty and the Your registration form is required within 30 days of Limited Structural Warranty the delivery date to activate your warranty coverage.
Page 14: Owner's Responsibilities
We recommend warranty and maintenance services in loss of reimbursement be performed by your Grand Design RV dealer. and/or loss of warranty. • it is important to protect yourself and others with insurance coverage for your RV. Your insurance agent can assist you in obtaining the appropriate insurance coverage for personal liability, theft, collision, property damage, etc.
Page 15: Obtaining Warranty Service
• If a problem re-occurs after leaving the dealership, within a specified time limit. contact the dealer’s service manager and Grand Design Please familiarize yourself with the RV dealer or repair RV Customer Support, to quickly resolve the issue.
Page 16: Obtaining Emergency Warranty Repair
Call the RV repair facility to discuss your situation and make an appointment. Ask how their billing will be handled. They may choose to bill Grand Design RV directly; otherwise, you are expected to pay them. b. Have the RV repair facility inspect your RV. Either they...
Page 17: Replacement Parts
Grand Design RV dealers or service centers. Grand Design RV does not sell parts retail direct or to non-authorized dealers. If an original part is no longer available, Grand Design RV or your dealer will try to provide an appropriate substitute.
Page 18 Service & Warranty Updating Your Contact Information Federal law requires that we keep a record of Grand Design RV owners. Please help us keep your contact information up to date, so that we can promptly contact you in the event of a recall or customer notification letter.
Page 19 SUMMARY What does this Warranty cover? Grand Design RV, LLC (“Warrantor”) provides this One (1) Year (“Warranty Period”) Limited Base Warranty [which begins to run from the earlier of (i) the date of purchase by the original retail consum- er purchaser or (ii) when the recreational vehicle is put into service] against certain defects in materials...
Page 20 Service & Warranty The defective material or workmanship for which the warranty work and/or part is sought must be to the RECREATIONAL VEHICLE itself only The other terms and conditions of this Limited Warranty must be satisfied. What types of things are excluded from the Warranty? This Warranty does not cover: a Defects in any component parts or labor of the recreational vehicle which are not considered the REC- REATIONAL VEHICLE or which were not manufactured by Warrantor;...
Page 21 Service & Warranty r Damage caused by unregulated water pressure, tank over-fill or plumbing system modifications resulting in flooding of the vehicle; s Damage caused by unprotected electrical hook-ups (home or campground), power surges, lightning, circuit overload or electrical system modifications; t Damage caused by overloading or improper weight distribution;...
Page 22 Service & Warranty What are purchaser’s obligations? The purchaser shall give notice to the Warrantor’s agent or dealer within Twenty (20) days after it is or should have been discovered, and any action to enforce it shall be commenced not more than three (3) months thereafter;...
Page 23 Service & Warranty What do I do to activate warranties of other manufacturers of component parts and goods? COMPONENT WARRANTIES As stated above, some components, accessories or equipment are not covered by this Base Limited War- ranty Examples include tires, batteries, optional generators, and some appliance & electronic entertain- ment equipment However, those items may have coverage provided by the component manufacturer These warranties are completely separate from this Limited Base Warranty, and in some cases may be longer and/or have specific coverage provisions and requirements.
Page 24 Service & Warranty DISCLAIMER OF EXPRESSED AND IMPLIED WARRANTIES THE WARRANTOR EXPRESSLY DISCLAIMS ALL IMPLIED WARRANTIES OF MERCHANT- ABILITY AND FITNESS FOR A PARTICULAR PURPOSE AND ANY OTHER IMPLIED WARRANTIES THERE IS NO EXPRESS OR IMPLIED WARRANTY MADE BY WARRANTOR BEYOND THAT CONTAINED IN THE LIMITED WARRANTY ABOVE THE ABOVE REFERENCED LIMITED WARRANTY IS IN LIEU OF ANY AND ALL OTHER WARRANTIES TO ACTIVATE THE LIM- ITED WARRANTY, THE RECREATIONAL VEHICLE MUST BE REGISTERED WITHIN THIRTY...
Page 25 SUMMARY What does this Warranty cover? Grand Design RV, LLC (“Warrantor”) provides this Three (3) Year (“Warranty Period”) Limited Struc- tural Warranty [which begins to run from the earlier of (i) the date of purchase by the original retail consumer purchaser or (ii) when the recreational vehicle is put into service] against certain defects...
Page 26 Service & Warranty The person seeking the replacement of the defective part or labor must be the original retail con- sumer purchaser An assignment of the recreational vehicle to another person voids this Limited Warranty The defective material or workmanship for which the warranty work and/or part is sought must be to the STRUCTURAL COMPONENTS only The other terms and conditions of this Limited Warranty must be satisfied.
Page 27 Service & Warranty Consequential/incidental expenses (damages) such as service calls, transportation, lodging, food, fuel, etc NOTE: Some states do not allow the exclusion of incidental or consequential damages, so this exclusion may not apply to you; Fading, yellowing or aging of exterior materials due to UV or sunlight or weather exposure; Damage that has occurred as a result of misuse, abuse, neglect, or lack of maintenance;...
Page 28 Service & Warranty Warrantor will remedy defects in materials and workmanship covered under this Limited Warranty under normal use and service caused by Warrantor in the STRUCTURAL COMPONENTS ONLY of the recre- ational vehicle Warranty performance can only be obtained at Warrantor’s authorized dealers and service representatives All costs incurred in transporting this recreational vehicle for warranty service shall be borne by purchaser unless otherwise approved in advance by Warrantor What are purchaser’s obligations?
Page 29 Service & Warranty DISCLAIMER OF CONSEQUENTIAL, PUNITIVE AND INCIDENTAL DAMAGES What other conditions or limitations apply to this Warranty? The original retail purchaser of the recreational vehicle and any person to whom the recreational vehicle is transferred or given or conveyed, and any person who is an intended or unintended user or beneficiary of this Limited Warranty, shall not be entitled to recover from Warrantor any consequential, punitive or incidental damages resulting from any defect in the recreational vehicle, or loss of use, time or revenues This warranty also excludes costs of transportation to any authorized dealer or service representative...
Page 30 Service & Warranty DESIGN CHANGES Warrantor reserves the right to change the design of its STRUCTURAL COMPONENTS from time to time without notice and without obligation to make corresponding changes in its products previously man- ufactured ATTORNEYS FEES Any warranty claim asserted or brought in violation of this Limited Warranty, or any claim brought against WARRANTOR, directly or indirectly, under which the Purchaser or any other person or entity seeks to broaden the terms of the Limited Warranty or under which the Purchaser or any other person fails to successfully prevail on any issue or matter of any type or nature, shall entitle Warrantor to recover its...
Page 31 This page is intentionally blank.
Page 32 Service & Warranty Component Supplier Contact Information All component suppliers listed are correct at the time of printing. Grand Design RV may change components at their discretion. Please contact GDRV Customer Support with any questions. Component Brand Supplier Website Phone Number...
Page 33: Component Manufacturer Warranty Information
Service & Warranty Component Manufacturer Warranty Information Each manufacturer provides their own warranty for the components on your Imagine TT. This warranty information is current at the time printing, but is subject to change at any time per the manufacturer. Details can be found on the company websites listed or by contacting them directly.
Page 34 This page is intentionally blank.
Page 35: Occupant Safety
Occupant Safety Occupant Safety Your Imagine Travel Trailer is designed with safety as the top WARNING priority. This RV meets or exceeds the safety standards and applicable codes in effect at the time it is built. All required During severe weather safety items are carefully installed to protect you and the conditions, move indoors occupants of your RV.
Page 36 Occupant Safety Pet Safety Emergency shelters could refuse to admit pets due to health or space reasons. The survival of a beloved pet often depends on the careful plans their owner has made in advance. • Prepare an emergency plan for pets that includes a 3-day supply (at least) of dry food and fresh water.
Page 37: Fire Safety
Leaving Children Unattended. • In a fire emergency, EVACUATE the RV first, NOTIFY then call 911 from a safe location. Grand Design RV Immediately • In a fire emergency, execute your Family Safety Plan. if you feel that product failure...
Page 38: Fire Extinguisher
Occupant Safety Fire Extinguisher A fire can spread very fast. BEFORE using the fire extinguisher, remember that safe escape is the most important part of any fire response plan. If there is a fire in or around your RV : •...
Page 39: Emergency Egress Window
Occupant Safety Disposal Please check the local laws BEFORE disposing of your used (non-refillable) dry chemical fire extinguisher. Contact your local fire, sanitation or environmental protection department for rules on disposal. Emergency Egress Window The Emergency Egress Window (or exit window) is your An emergency secondary exit, if the RV's entrance door becomes blocked egress window...
Page 40: Smoke Alarm
Occupant Safety Smoke Alarm The smoke alarm is located on the ceiling in the main living area of your RV. It is intended to help reduce injury or loss of life in a fire. Proper use can give you time to escape, but they are not foolproof.
Page 41: Carbon Monoxide (Co)
Occupant Safety Battery WARNING The smoke alarm will NOT function if the battery is: • Missing, Disconnected, or Dead. The Smoke Alarm • Installed incorrectly does NOT operate • The wrong type. without working batteries. REPLACE the 9-volt battery in your Smoke Alarm when it chirps Removing the batteries, or (the low battery warning).
Page 42: Carbon Monoxide (Co) Alarm
Occupant Safety Carbon Monoxide (CO) Alarm The CO alarm will sound if Carbon Monoxide (CO) in the air inside your RV reaches dangerous levels. If you hear this alarm, evacuate the RV immediately and stay outside in fresh air until the CO alarm ceases.
Page 43 Occupant Safety Test the CO alarm weekly TEST the CO alarm at least once EVERY WEEK to make sure that WARNING it is working properly. Stand at arm’s length from the alarm when testing. The alarm horn is loud and may be harmful TEST Carbon Monoxide to your hearing.
Page 44 Occupant Safety Propane Gas (LP) Alarm, Continued High temperatures can activate glue and adhesive vapors. If your RV is closed on a hot day, the chemicals used in its construction may be detected, even months after the vehicle was built. See page 39-42: Indoor Air Quality, Chemical Sensitivity &...
Page 45: Indoor Air Quality
Occupant Safety Battery or converter power source The propane gas alarm runs on a small amount of 12-volt DC from the converter or auxiliary battery. This slight current draw can still drain your auxiliary battery during an extended storage period. The Low Voltage Warning will sound if the charge drops below 8 volts.
Page 46 Occupant Safety Indoor Air Quality, Continued • CLEAN & VACUUM often to get rid of dust and pet fur which can irritate your nose and throat. • DO NOT use bug spray inside your trailer. • DO NOT smoke inside your RV. In addition to causing damage to your RV, tobacco smoke releases formaldehyde and other air pollutants.
Page 47 Occupant Safety There are many sizes and types of air cleaners on the market. Most of the less expensive, table-top models, are much less effective at particle removal. Generally, air cleaners DO NOT remove gaseous pollutants. Chemical Sensitivity & Outgassing When you first purchase your new RV, or after it has been closed for an extended time, you may notice a chemical odor due to outgassing.
Page 48: Effects Of Prolonged Occupancy
(MDF), and plywood which are commonly used throughout the Recreational Vehicle Industry. As mandated by the RV Industry, Grand Design RV recreation vehicles contain composite wood products (hard- wood plywood, particle board, and MDF) that comply with the California Air Resource Board (CARB) formaldehyde emission standards under California Code of Regulations §...
Page 49 Occupant Safety Tips for controlling condensation To reduce moisture in the air inside your RV, use these tips: If the tips presented here for controlling • Allow excess moisture to escape to the outside when condensation are bathing, washing dishes, hair drying, laundering and NOT effective, using appliances and non-vented gas burners.
Page 50 Occupant Safety Where There Is Moisture, There May Be Mold Molds are microscopic organisms that can live in virtually any indoor or outdoor environment. Mold growth requires a source of moisture (ie., high humidity, wet/damp materials, standing water) and a temperature between 40° and 100° Fahrenheit.
Page 51: Cold Weather Use
• To avoid damage to parts, CHECK the outside of the RV for ice BEFORE operating the: slide outs, compartment doors, locks, windows, vents etc. If you have further questions, please contact your dealer or Grand Design RV Customer Service.
Page 52 Grand Design RV has no control and for which Grand Design RV assumes no responsibil- ity: Grand Design RV shall have no liability for any loss or injury caused, in whole or in part, by its actions, omissions or negli- gence, or for any contingencies beyond its control in procuring, compiling or delivering any information.
Page 53: Additional Safety Precautions
External or third party links may be provided for the convenience of the users of that website. Grand Design RV is not responsible for the availability or content of these external or third party sites...
Page 54 Occupant Safety Additional Safety Precautions, Continued Loading & Weight Distribution • Distribute cargo weight evenly throughout your vehicle. • NEVER exceed your RV's Cargo Carrying Capacity or Gross Vehicle Weight Rating. • Place heavy items in the center of your vehicle, on the floor. •...
Page 55: Pre-Travel Information
RV with one that you already own. Discuss the owner of a Grand Design RV recreational vehicle as a GVWR, size and type of RV that you will be towing. If you plan...
Page 56: Vehicle Labels
• Ratings are maximum limits, NEVER to be exceeded. potential damage, may void a warranty, may complicate These limits are established by Grand Design RV and our an insurance claim, and in component manufacturers in the design of the vehicle.
Page 57: Weight Labels
Vehicle weight labels are affixed to your RV to help you make an informed decision before your purchase. DO NOT REMOVE THESE LABELS. If the labels are missing, contact your dealer or Grand Design RV Customer Service for replacements. Federal Certification Label This label specifies the maximum capacities for GVWR, GAWR and tires.
Page 58 Recreational vehicle overall length shall exclude some RV accessories as defined by Grand Design RV including but not limited to: • Safety-Related Equipment, (Signal, Clearance, or Identification Lamps;...
Page 59: Cargo Capacities
• Unloaded Vehicle Weight is calculated with empty LP bottles. • Cargo Carrying Capacity is calculated including the weight of full LP bottles. CCC = GVWR - (UVW - LP gas weight) If you have further questions, please contact your dealer or Grand Design RV Customer Service.
Page 60: Loading Your Rv
Pre-Travel Information Loading Your RV For traveling safety, distribute your cargo evenly side-to-side. WARNING Keep the weight on each tire from exceeding one-half of the GAWR (Gross Axle Weight Rating) for either axle. ONLY store items in the areas designated for storage. During a sudden stop, free-standing furniture or overlooked DO NOT store anything items on the counter top or range can become dangerous...
Page 61 Pre-Travel Information 2. Hitch the RV to your tow vehicle. Weigh the RV and the tow vehicle to obtain your Gross Combined Weight (GCW). WARNING ◦ Confirm that this overall weight is LESS THAN, or Total weight of your tow EQUAL TO the Gross Combined Weight Rating (GCWR) vehicle and RV must not specified by the manufacturer of your tow vehicle.
Page 62: Tire Safety Information
Pre-Travel Information Tire Safety Information This portion of the Owner’s Manual contains tire safety inform- ation as required by 49 CFR 575.6(4) and is based in part on the National Highway Traffic Safety Administration’s (NHTSA) brochure titled Tire Safety, Everything Rides On It. It is available as a free download on the NHTSA website: https://one.nhtsa.gov/Vehicle-Safety/Tires/ Tire-Safety:-Everything-Rides-On-It...
Page 63: Understanding Tire Pressure & Load Limits
Pre-Travel Information Recommended Tire Pressure & Load Limits The major causes of tire failure are under-inflated tires and overloaded vehicles. Tire information placards and vehicle certification labels give important information on tires and load limits, including: • Recommended Tire Size •...
Page 64: Checking Tire Pressure
Pre-Travel Information Checking Tire Pressure It is important to check your vehicle’s tire pressure at least once a month for the following reasons: • Most tires naturally lose air over time. • Tires can lose air suddenly by driving over a pothole, hitting road debris, or striking the curb when parking.
Page 65 Pre-Travel Information How Overloading Affects Your RV & Tires The results of overloading can have serious consequences DANGER for passenger safety. Too much weight on your vehicle’s sus- pension system can cause spring, shock absorber, or brake If the total weight of the failure, handling or steering problems, irregular tire wear, RV exceeds the GVWR, tire failure or other damage.
Page 66: Tire Safety Tips
Pre-Travel Information Tire Safety Tips Preventing tire damage • DO NOT run over curbs or foreign objects in the roadway or when parking. • SLOW WAY DOWN if you can not avoid a pothole or other object in the road. Tire safety checklist 1.
Page 67: Speed Rating
• DO NOT exceed the speed rating regardless of the post- ed maximum speed limit. • Tires are warranted by the tire manufacturer, not by Grand Design RV. If you need tire warranty assistance, please contact your dealer or refer to the tire warranty pamphlets provided with...
Page 68: Tire Tread
Pre-Travel Information Tire Tread The tire tread provides the gripping action and traction that prevent your vehicle from slipping or sliding, especially when the road is wet or icy. In general, tires are not safe and should be replaced when the tread is worn down to 1/16 of an inch. Tread wear bars are raised sections built into the bottom of a tire's tread grooves that show how much tread is remaining.
Page 69: Maximum Load Rating
Pre-Travel Information Tire Ply, Composition & Materials Tires are constructed from multiple layers of rubber-coated fabric. Each of these layers is called a ply. In general, the higher the number of plies in a tire, the more weight it can support. •...
Page 70: Wheel Nut Torque
Pre-Travel Information Wheel Nut Torque Torque is the amount of rotating force applied to a fastener, such WARNING as a lug nut. The axle and wheel assemblies of your RV are designed differently than those on your car. The overall size, weight and center of gravity subject the wheels Always torque the wheel nuts to the specifications to pressures unique to trailering.
Page 71: Roadside Emergency
Section Title Roadside Emergency A roadside emergency can happen at any time. ALWAYS carry an emergency kit with three red warning signs (or indicators) to display if necessary. If you must make an emergency roadside stop: • Pull off the road as far as possible. •...
Page 72 Section Title...
Page 73: Towing & Leveling
Towing & Leveling Towing & Leveling To improve safe driving and help protect against injury, WARNING please follow these recommendations: • Keep the RV and tow vehicle tires properly inflated, and DO NOT leave children or pets unsupervised in REPLACE the tires BEFORE they are excessively worn. or around the RV (even if children are secured by •...
Page 74 Towing & Leveling RV Driving Schools & Seminars If you have any concerns about driving while towing a RV, consult an expert for specific RV driver education. There are private RV schools and some RV owner's organizations that offer driving seminars. The schedules and locations of the various RV driver education seminars and schools can be researched through RV-related publications and websites.
Page 75: Battery Isolator
Towing & Leveling Battery Isolator (Customer Supplied) You may want to install a battery isolator on your tow vehicle. A battery isolator is a device that: • Receives current from the tow vehicle alternator to WARNING independently charge both the RV auxiliary battery and the tow vehicle battery.
Page 76: Safety Chains
Towing & Leveling Safety Chains Safety chain requirements vary from state to state. Your RV is WARNING equipped with chains to meet SAE standard requirements for maximum gross trailer weight. ALWAYS use safety chains when • ALWAYS have the safety chains attached when towing. towing your RV.
Page 77 TT / tow vehicle combination. to the RV frame. • Grand Design RV cannot • BEFORE selecting a hitch, you must know the GVWR be responsible for the tow and HITCH WEIGHT of your RV.
Page 78: Hitch Height & Hitch Ball
Towing & Leveling Hitch Height & Hitch Ball To determine your RV hitch height, make sure the RV is level. When the loaded trailer is hitched to the tow vehicle, check the hitch ball height by measuring the distance from the center of the hitch ball to the ground.
Page 79: Weight Distributing System
Towing & Leveling Weight Distributing System (Customer Supplied) Aftermarket weight distributing hitch systems provide a more stable tow vehicle/travel trailer towing combination. This system WARNING will spread the weight evenly to distribute it to the front and rear tow vehicle axles and the trailer axle. NEVER allow anyone to Be certain your tow vehicle can carry the hitch weight.
Page 80 Towing & Leveling Towing the RV Braking & Stopping Distance WARNING Towing an RV greatly increases your stopping distance. Practice braking in a large parking lot (where it is permissible) to become Towing items behind RV familiar with your RV’s stopping distance before driving in traffic. or overloading the rear will void the warranty and •...
Page 81 Towing & Leveling Passenger Safety • DO NOT allow anyone to ride inside as a passenger while your RV is in motion. • This practice is against the law in several states. Turning Corners WARNING While making a turn: • The RV does not follow the path of your Tow Vehicle. •...
Page 82: Leveling The Rv
Towing & Leveling Towing the RV, Continued If the parking spot Parking is on asphalt on a very hot day or on Once the RV is in your desired location: dirt and/or gravel, a block of wood under each 1. Set the tow vehicle parking brake. jack leg can be used to spread the load and reduce 2.
Page 83 Towing & Leveling Travel Trailer Set Up 1. Position the RV as desired, then • Block the wheels to keep the RV from rolling. 2. Unhook the 7-way wire harness/connector plug, safety chains and breakaway switch cable. 3. Release the weight distributing bars (customer supplied). 4.
Page 84 This page is intentionally blank.
Page 85: Electrical Systems
Electrical Systems Electrical Systems Your Imagine Travel Trailer is equipped with two independent WARNING electrical systems. One system is 120-volt 60hz AC power, the other system is 12-volt DC power. The electrical equipment and Use caution when using associated circuitry are engineered into a dedicated system metal tools.
Page 86: Volt Ac System
Electrical Systems 30-Amp or 50-Amp Power Cord, Continued Connecting the power cord WARNING 1. Turn OFF the load center main 120-volt circuit breaker. • DO NOT hook up the power 2. Carefully extend the entire length of the power cord from cord to any receptacle until the electric cable hatch to the external power source.
Page 87: Volt Circuit Breakers
Electrical Systems Power to your 120-volt 60hz AC electrical system (30 amp or WARNING 50 amp) can be supplied by the 120-volt 60hz utilities found at RV campgrounds or by a generator. A campground's electrical For 30 amp systems only: service may occasionally experience high or low voltage.
Page 88: Gfci Receptacle
Electrical Systems Converter The Power Converter changes 120-volt AC power to usable 12-volt DC power when the shore power cord is connected to an external power source. A thermal breaker is built-in to the converter to protect it from overheating. Overheating is usually caused by the converter operating above its maximum power output for an extended time period, or with too little air flow.
Page 89: Volt Dc System
Electrical Systems Test all GFCI receptacles monthly • Push in the TEST button. This should pop out the RESET button, indicating the GFCI receptacle has been tripped. This will interrupt the 120-volt power. • Push in the RESET button. This should restore the 120-volt power.
Page 90: Volt Fuse Panel
Electrical Systems 12-Volt Fuse Panel • The label inside the 12-volt fuse panel indicates the fuse WARNING sizes, positions and components powered. The fuse panel label should be kept permanently affixed to your RV. Replacement fuses must be of the same voltage, •...
Page 91 Electrical Systems For accuracy, test the auxiliary battery voltage using a volt-ohm meter. A fully charged auxiliary battery will read 12.7 volts DC and 1.265 specific gravity at 80°F (32°C). The auxiliary battery is considered discharged at 11.8 volts, and dead at 11.65 volts. When voltage drops below those levels, permanent damage may occur.
Page 92: Battery Disconnect Switch
Electrical Systems Battery Disconnect Switch The Battery Disconnect Switch (see photo) is located on the Universal Docking Station. At times when auxiliary power will NOT be needed: • TURN the Battery Disconnect Switch to the OFF position and REMOVE key. •...
Page 93 Electrical Systems Approximate Electrical Load Ratings Use the actual amperage of the appliance when possible. (Watts ÷ Volts) 120 Volt System Air Conditioner 14-18 amps Coffee Maker 6-12 amps Converter (Each) 8-11 amps Curling Iron or Hair Dryer 10-14 amps DVD / Blu-ray System 3 amps Microwave...
Page 94 This page is intentionally blank.
Page 95: Plumbing Systems
Plumbing Systems Plumbing Systems There are two separate water systems equipped on your RV, the Fresh Water System and the Waste Water System. • The Fresh Water System consists of the fresh water holding tank, fresh water connections, water heater, water pump, faucets, shower/tub and if so equipped, an outside shower assembly and/or water purification system.
Page 96: Monitor Panel
Plumbing Systems Monitor Panel The monitor panel is found on the interior Command Center. It displays the fill levels of your fresh water, grey water, and black water holding tanks. It also shows the voltage of your auxiliary battery. To make a selection, PRESS and HOLD one of the labeled buttons on the monitor panel faceplate.
Page 97: Water Pressure Regulator
Plumbing Systems 12-Volt Water Pump Once activated, the water pump (or on-demand pump) will self-prime, and provide water. The water pump continues to run until approximately 45 lbs. of pressure is achieved and shut off. The water pump will automatically restart when pressure drops.
Page 98: Fresh Water Connections
Plumbing Systems Fresh Water Connections There are two types of direct exterior fresh water connections NOTICE in your RV: The city water fill is typically used at a campground when there is access to an external, pressurized potable water The fresh water connection source.
Page 99 Plumbing Systems 4. Turn ON the water at the water source. 5. Enter the RV and open the cold water supply faucets to bleed air from the water lines. When the water lines are nearly full, you may experience some air pockets. Allow them to escape before closing the cold water supply faucets.
Page 100: Water Heater
Plumbing Systems Water Heater Read all safety and operating information provided here WARNING and in the manufacturer’s manual before attempting to activate the water heater. The water heater is designed to If you smell propane gas, heat water quickly and efficiently. It’s temperature is preset by STOP immediately! the manufacturer.
Page 101 Plumbing Systems If the water heater is not properly derated, poor efficiency in heat- WARNING ing the water may occur due to incomplete combustion. You may also notice pilot outage caused by burner lift-off or sooting from Water temperatures over a yellow burner, indicating the possibility of carbon monoxide.
Page 102 Plumbing Systems Water Heater, Continued Water Heater Water heater bypass 3-Valve System as equipped The water heater bypass is comprised of three (3) valves, located at the back of the water heater: a. Cold Water Line Bypass Valve, b. Mixer (middle) Valve, and c. Hot Water Line Bypass Valve. Also see page 102, Water Heater Bypass / 3-Valve System.
Page 103 Plumbing Systems 4. Turn ON the hot and cold knobs, and adjust the water temperature before showering. 5. To conserve water while showering, wet down and turn OFF the water while using soap, then rinse. 6. When shower is finished, shut OFF the hot and cold knobs. There is no shut-off valve for the showerhead;...
Page 104: Draining The Fresh Water System
Plumbing Systems Draining the Fresh Water System The low-point drain valves release water in the supply lines by opening the valves and all faucets. The water heater has its own drain plug. To drain the permanent fresh water holding tank and supply lines: 1.
Page 105: Sanitizing The Fresh Water System
Plumbing Systems Sanitizing the Fresh Water System Use the following procedures to sanitize your Fresh Water System (or Potable Water System) when it is new, becomes contaminated, or has not been used for a period of time. • PREPARE a Chlorine Solution using one (1) gallon of water and one-quarter (1/4) cup of household bleach (5% Sodium Hypochlorite solution).
Page 106: Winterizing The Plumbing System
Plumbing Systems Winterizing the Plumbing System Preparing your RV for storage is very important in climates that WARNING experience cold weather. Follow the steps listed below at the end of the camping season. Both automotive antifreeze (ethylene glycol) and See page 103, Winterization Valve. windshield washer anti- freeze (methanol) are •...
Page 107 Plumbing Systems iv. Continue to PULL the drawer towards you and remove it from the drawer guides. v. REPEAT steps (i - iv) to remove the remaining kitchen drawers. 6. REMOVE the re-usable cap from the Suction Line. (SAVE the cap for step 13.) 7.
Page 108 Plumbing Systems Water Heater Bypass / 3-Valve System Normal Use Positions: Bypass Positions: Antifreeze Hot Out Flow Flow Blocked Blocked Antifreeze Cold In Water Heater Normal Use Positions Water Heater Bypass Positions a. Cold Water Line Valve (OPEN) a. Cold Water Line Valve (CLOSED) b.
Page 109 Plumbing Systems Winterization Valve Normal / Sanitizing: 1. TURN the Winterization Valve to the CLOSED position. 2. POUR the Chlorine / Water mixture into the Fresh Water Gravity Fill Inlet. 3. TURN ON the Water Pump. 4. OPEN all faucet fixtures to circulate Winterization Valve Chlorine / Water mixture through all CLOSED Position...
Page 110 Plumbing Systems Black Water & Grey Water Systems Your RV toilet drains into the Black Water (sewage) holding tank. WARNING The sinks and shower drain into the Grey Water (waste water) holding tank. NEVER travel with full black or grey water holding tanks. •...
Page 111 Plumbing Systems To help prevent a toilet blockage: • Before use: FLUSH the toilet several times, releasing enough water to cover the bottom of the holding tank. • ALWAYS maintain four to six inches (10-15 cm) of water in the toilet for better performance. •...
Page 112 Plumbing Systems Emptying the Black & Grey Water Tanks The black tank and grey tank drain valves (or dump valves) NOTICE are located near the Sewer Outlet Connection, under the RV on the off-door side, and/or in the utility center. It is important to prevent •...
Page 113 Plumbing Systems Dump station locations Dump station locations throughout the United States and Canada can be found on many websites and publications including Woodall’s, Rand McNally Camp Guide, Good Sam Camp Guide, KOA Kampgrounds Camp Guide. Some gas stations also have dump stations. If you need assistance with the purchase or installation of a sewer hose or hose extension, Please contact your dealer.
Page 114 Plumbing Systems Black Tank Flusher The black tank flusher is designed to rinse the interior of the NOTICE black (waste) tank. A separate water hookup is located on the off-door side. When flushing the black tank, the gate valve must To flush the tank after dumping: be open or damage may occur to the system.
Page 115: Propane System
PROPANE GAS STOP! Maintenance Quickly and carefully Although both Grand Design RV and your selling dealer care- perform the 6-step procedure in the red box fully test the propane system for leaks, travel vibrations can at the bottom of this page.
Page 116 Propane Systems Propane Gas Cylinders While under pressure in the cylinder, propane gas is compressed WARNING into it's liquid form. Propane will not run through the appliances in its liquid state. As the fuel is released from the cylinder to operate Propane cylinders an appliance, it changes from liquid to gas.
Page 117: Propane Leak Test
Propane Systems Max output is 200,000 BTU/hr. It is used to connect propane WARNING cylinders to regulators, hoses and other fittings. It is not for use on gas grills and other low pressure devices. Before entering a propane or fuel service station make Servicing or filling sure all pilot lights are extinguished.
Page 118: Propane Alarm
Propane Systems Propane Alarm Your RV is equipped with a propane alarm. Please read and WARNING follow the component manufacturer instructions supplied in your Owner Information Package. Test Propane Gas Alarm operation after the RV has For detailed information on this alarm, See page 37-39, been in storage, before Propane Gas (LP) Alarm.
Page 119: Propane Regulator
Propane Systems • If you do experience a propane freeze up, close the main valve and wait at least fifteen (15) minutes before WARNING trying again. For more information, refer to the regulator manufacturer’s operator manual. All propane connections should be checked periodic- •...
Page 120: Cooking With Propane
Propane Systems Propane System Hoses, Tubes, Pipes & Fittings The hoses, pipes, tubes and fittings used in your propane system are designed to withstand pressures exceeding those of the pro- pane system. However, because environment and time can both contribute to the deterioration of these components, they must be inspected for wear at regular intervals.
Page 121 Propane Systems Using The Propane System After the RV is completely set up and you are prepared for WARNING camping enjoyment, use the following steps for propane operation: DO NOT operate the gas appliances while 1. CLOSE ALL burner valves, controls and pilot light valves. your RV is in motion.
Page 122 Propane Systems Calculating Propane Use Your Imagine TT's furnace, refrigerator, water heater and range (if applicable) all may use propane to operate. Use the BTU rating of each appliance to determine how long your propane supply will last. Propane consumption depends on their individual use and the length of time operated.
Page 123 Appliances Appliances DANGER The following is a brief overview of the factory-installed, RV IF YOU SMELL appliances. Please refer to the manufacturer’s owner manuals PROPANE GAS found in your Owner Information Package for detailed operating STOP! instructions for each specific component. Quickly and carefully perform the 6-step If there have been modifications or replacements made to your...
Page 124: Range Hood
Appliances Range Hood WARNING The range hood has a both a light and fan control switch on the front panel. The 8” x 8” aluminum mesh grease filter (located on DO NOT turn the gas range burner controls ON the underside range hood) can be gently hand-washed using and allow propane gas to mild soap and water.
Page 125 Electronics Electronics The following is a basic overview of the audio/visual (A/V) electronics operation. The information in this section is written for original factory-installed equipment usage. Refer to the manufacturer’s user guides included in your Owner Information Package for detailed operating instructions for each specific component, or visit that manufacturer’s website.
Page 126 Electronics TV Reception Basics TV broadcasting is a point-to-point communication. Any obstructions between the transmitter and the antenna will degrade the signal, affecting picture quality. • Television stations transmit their broadcast signal "over the air" to surrounding areas. • TV antennas are designed to receive the broadcast signals.
Page 127 Electronics TV Roof Antenna To watch local TV stations, turn ON power to both the TV and the TV Roof Antenna. For the best TV reception, your antenna must point toward the nearest signal transmitter. You can find the exact locations of transmitting towers at www.fcc.gov/ reports-research/maps/dtv-maps/ Winegard AIR 360 Operation (If So Equipped)
Page 128 This page is intentionally blank.
Page 129: Heating & Cooling
Heating & Cooling Heating & Cooling The following section contains an overview of the original factory-installed heating and cooling components. For more information on each specific component, please refer to the manufacturer’s operating instructions found in your Owner Information Package. If there have been modifications or replacements made to your RV, then these instructions may not apply.
Page 130 • NEVER attempt to repair the furnace yourself. To ensure your personal If you have any questions, Contact your dealer or safety, DO NOT obstruct Grand Design Customer Service. or alter the furnace in any manner. DO NOT install screens over the vent for any reason.
Page 131 Heating & Cooling Roof Vent(s) NOTICE The roof vents allow fresh air to circulate through your RV. They may be electric (12-volt DC) and/or manual. Make sure that roof vents are closed while traveling, and when you will be DO NOT leave a roof vent away from the RV, to prevent unexpected weather damage.
Page 132 Heating & Cooling Patio Awning WARNING System Information PINCH HAZARD. ® The Solera Power Awning features an internal motor to steadily Keep CLEAR of arm operate the awning. Additionally, the friction joint allows for rain assemblies while closing dump and adjustable pitch features, and there is no rafter arm awning.
Page 133 Heating & Cooling Idler Head Assembly Fabric Awning Rail Drive Head Assembly Pinch Points Pinch Points Pinch Points Roll Tube End Cap Pinch Points Support Arm Assembly Fig. 4 - Complete Extension Fig. 3 Fabric Valance Seam Roll Tube The Patio Awning Switch is located inside the RV, on the Command Center.
Page 134 Heating & Cooling Patio Awning, Continued Adjusting Pitch - All Solera Awnings CAUTION NOTE: The awning will pitch itself to purge the pooling of excess Tying down the roll water and may dump a significant amount of water without notice tube once the awning is extended will not allow the 1.
Page 135 Heating & Cooling • Liberally slosh the mixture on the top of the fabric WARNING and roll up the awning for 5 minutes. • This will apply the mixture to the bottom of the fabric DO NOT attempt any repairs as well.
Page 136: Slideout Systems
Slideout Systems Slideout Systems Slideout rooms are designed to provide you additional living WARNING space during stationary camping. The slideout room and mechanism are a potential BEFORE operating your slideout system: crush hazard. Disconnect the auxiliary battery to ◦ Check that you have sufficient power available. disable power to the ◦...
Page 137 • Clean and dry the outside surfaces of the room and slide rooms be closed (retracted). mechanism as much as possible. Contact your dealer or Grand Design RV Customer Service NOTICE for troubleshooting and/or repair if your slideout system: • Stalls out before reaching end of stroke, or Never ‘jump’...
Page 138 Slideout Systems Lippert Through Frame Electric Slideout System Extending and retracting the slideout room is powered by the CAUTION Lippert Through Frame Electric Slideout System. It is a rack and pinion guide system with a motor driven ball screw actuator. Always disconnect battery The actuator is equipped with an automatic clutching system.
Page 139 Slideout Systems Maintenance Although the system is designed to be almost maintenance free, actuate the room once or twice a month to keep the seals and internal moving parts lubricated. Check for any visible signs or external damage before and after movement of the RV.
Page 140 Slideout Systems Schwintek In-Wall Slideout System If the bedroom Schwintek In-Wall slideout does not extend or WARNING retract, follow these steps to override the system. • This process is much easier if you have Before working underneath one or more persons to assist you. the RV, both the front and rear axles should be supported with jack stands.
Page 141 Slideout Systems Manually push the slide room in override 1. LOCATE the circuit board. 2. UNPLUG both motors from circuit board. (this will release the motor brake) 3. PUSH or PULL slide room in as desired; ◦ Larger rooms may require several people to push. ◦...
Page 142 Slideout Systems Troubleshooting the Schwintek Slideout System Error codes During operation, when an error occurs the board will use the LED’s to indicate where the problem exists. • For motor specific faults, the GREEN LED will blink once for motor 1, and blink twice for motor 2. •...
Page 143 Slideout Systems Only one (1) side moving The Schwintek slide system has a separate motor to operate each side of the room. If only one side of the room moves a short distance (2 to 4 inches) and stops; • Will non-moving side move with help? If only one (1) side of the room is moving, with someone’s assistance, push the non-moving side in the appropriate direction while pressing the switch to extend or retract...
Page 144 Furniture Furniture Converting the Hide-A-Bed Sofa (If So Equipped) 1. Remove the seat back cushions. 2. Lift up and out on the front edge of the sofa, uncovering the legs. 3. Fully extend the legs on both sides. Lift Front of Sofa Extend Both Legs...
Page 145 Furniture 4. Pull the sofa forward and place the legs flat on the floor. 5. Pull the sofa back forward, and lay flat. Pull & Lay Flat (5.) Pull Forward (4.) Sofa Converted to Bed. Sofa Back Folded Down...
Page 146 Furniture Murphy Bed (Equipped on select XLS models) To Lower into a Bed: 1. PULL the back of sofa seat toward you, flip, and fold down. 2. LOCATE the latch on the Upper Right-Hand Side of the bed. 3. LIFT UP on the latch to release the bed board.
Page 147 Garage Garage (Equipped on select XLS models) (Equipped on select XLS models) DANGER Ramp Door (If So Equipped) Vehicles and equipment powered by internal The Rear Ramp Door is easily combustion engines and operated by one person to give placed in RVs may cause 1.
Page 148 This page is intentionally blank.
Page 149: Interior Care
Interior Care Interior Care Cleaning the Interior To keep the value of your RV, perform regular maintenance using the proper materials and procedures. • Check the component manufacturer’s information for the recommended cleaning agent. Using the wrong cleaner may result in damage to the surfaces in your RV.
Page 150 Interior Care Paneling • To clean, use a mild solution of soap and lukewarm water with a soft sponge or cloth. • DO NOT use abrasive cleaners as they could cause the vinyl to scratch and turn dull. • Grease spots and stubborn dirt can be cleaned off with an all-purpose spray Countertops To prevent permanent damage:...
Page 151 Interior Care Flooring • ALWAYS test cleaning agents for colorfastness in a hidden or inconspicuous area. Carpet Vacuum regularly with a vacuum cleaner with a revolving brush or beater bar. Be sure the vacuum does not have teeth, combs or rough edges as they may damage the carpet. It is important to remove loose soil and debris while it is on the surface.
Page 152: Furniture Upholstery
Interior Care Furniture Upholstery To retain the value of your RV, maintain the furniture upholstery carefully and keep the interior clean. Vacuum the furniture regularly using a soft brush attachment to remove any loose dirt or debris. • Fabric should be professionally cleaned if it becomes stained or more information, refer to the specific furniture manufacturer’s care instructions.
Page 153 Interior Care Decor Items Decor Glass Use a glass cleaner to remove smudges, smears and spots. If there is any decorative etching on the decor glass, use care when cleaning around that area. Window treatments, curtains, blinds and shades Dust occasionally with a vacuum and soft brush attachment. Professionally clean only.
Page 154: Exterior Care
Exterior Care Exterior Care The RV exterior is comprised of many different materials in- cluding; fiberglass gel-coat, automotive grade paint finishes, plastics, glass, sealant, and aluminum. There is an increased chance of damage to the exterior finish, the longer a foreign substance remains on the surface. Fre- quent washing and waxing is the best way to protect your RV from this damage.
Page 155 Exterior Care • Carefully clean the joints and flanges of the slideout, doors, etc. where dirt is likely to remain. NOTE: Some types of hot water washing equipment apply heat and high pressure to the RV. Excessive HEAT can cause distortion or damage to resin parts.
Page 156 Exterior Care Cleaning the Exterior, Continued Waxing your RV Wax your RV once or twice a year, or when painted surfaces do NOTICE not shed water well. Use a soft cloth to apply a small amount of wax to the painted surfaces. After the wax has dried, polish the DO NOT use a buffer and RV with a dry, soft cloth.
Page 157: Exterior Roof
Exterior Care Exterior Roof To maintain your warranty, inspect all roof sealant every three WARNING (3) months for voids, gaps and cracks then re-seal as needed (See below). Wash the Superflex roof with water and a mild As with the surface of any detergent twice a year and clean and inspect the roof vents.
Page 158 Exterior Care Sealants Sealants perform a very important function and should be inspected closely and regularly maintained. We incorporate many different types of sealants, including butyl/putty, black butyl-encapsulated foam, silicone (clear and colored), roof sealant and foam. In gen- eral, sealants do not have a "set" lifetime. Varying environmental factors affect the pliability and adhesiveness of sealants.
Page 159: Rear Bumper
Exterior Care Rear Bumper The rear bumper of your RV is not designed to carry cargo. NOTICE • Items that extend beyond the bumper will place undo strain on the bumper. DO NOT add items to the RV rear bumper. Add-on •...
Page 160 Exterior Care Winterizing / RV Storage Preparation To help prevent problems, prepare your RV for extended periods of non-use. This will also make it easier to get your RV ready for the next camping trip or season. • In colder climates, BEFORE storing for the winter, be sure your RV's plumbing system is properly Winterized to prevent costly freeze-ups.
Page 161: Maintenance
Exterior Care Maintenance Suggested Maintenance Checklist Here is a quick reference list of suggested areas for regular maintenance. Review all manufacturer’s operators manuals supplied with your RV to perform the maintenance items listed. Prior to first trip • INSPECT and reseal as needed. •...
Page 162: Required Maintenance Schedule
Required Maintenance Required Maintenance Schedule Procedure to be Performed: Maintenance schedules are minimum Maintenance requirements. Extended use, extreme Item temperatures, high humidity or other extreme conditions will require more frequent maintenance. Check settings & adjustments • • per manufacturers guide. Appliances •...
Page 163 Required Maintenance Required Maintenance Schedule Procedure to be Performed: Maintenance schedules are minimum Maintenance requirements. Extended use, extreme Item temperatures, high humidity or other extreme conditions will require more frequent maintenance. Check for damage & wear. • • Hitch / Coupler Clean and lubricate (with grease) •...
Page 164: Basic Troubleshooting
Basic Troubleshooting Basic Troubleshooting Air Conditioner (Roof) Will not operate • Make sure unit is turned on. • Check circuit breakers in coach. • Have your dealer check to see if there is proper voltage from shoreline or generator. Unit runs, but coil freezes and compressor cycles too soon •...
Page 165: Interior Lights
Basic Troubleshooting Furnace WARNING Furnace does not ignite and/or cycles frequently DO NOT attempt • Check that propane tank is full. to repair or adjust the furnace. • Remove any obstruction over furnace exhaust. Turn off the thermostat and • Inspect exhaust tube for any obstructions. furnace gas control valve, then contact your dealer or •...
Page 166: Outside Receptacle
Basic Troubleshooting Monitor Panel No lights on panel when switch is pressed • Check battery voltage and condition. • Check fuse at the battery; if fuse is good have a dealer or qualified RV technician check the condition of panel. Holding tank lights deliver false readings (i.e.
Page 167 Basic Troubleshooting Top burner or oven burner won’t light or won’t stay lit • Check position of top burners and flash tubing. • Clean clogged burner ports with a toothpick. • See the oven manufacturer’s instructions for proper care and maintenance. Gas smell •...
Page 168 Basic Troubleshooting Propane Gas Smell gas in or around unit DANGER • Propane tanks may be overfilled. IF YOU SMELL PROPANE GAS IF YOU SMELL PROPANE STOP! 1. EXTINGUISH any open flames, pilot lights and Quickly and carefully all smoking materials. perform the 6-step procedure in the red box.
Page 169: Running Lights
Basic Troubleshooting Heavy frost buildup on the evaporator fins • Defrost the freezer and refrigerator. • Have the refrigerator checked by your dealer or a qualified RV technician. Running Lights Running lights not working • Blown fuse. Replace fuse with one of the same ampere rating.
Page 170: Termination Valve
Basic Troubleshooting Termination Valve Termination valve leaks • Debris keeps valve from seating. Clear debris from and around valve O-ring set. • Bad gasket. Have your dealer or qualified RV technician replace gasket with new. TV Antenna Poor TV reception •...
Page 171 Basic Troubleshooting To remove the hydrogen sulfide (rotten egg) odor: 1. TURN OFF your main water supply; that is, your pump or your water hookup source. 2. DRAIN your water heater tank by removing the drain plug. Approximately two quarts of water will remain in the bottom of the tank.
Page 172: Water Pump
Basic Troubleshooting Water Pump Pump will not start • Check that house battery disconnect switch is ON. • Check pump switch at monitor panel. • Check fuse in power center. • Check to see if water is frozen. Pump will not prime, sputters (no discharge, but the motor runs) •...
Page 173 Glossary Glossary AC ELECTRICITY—Alternating current also known as shoreline power. For purposes of this manual, it refers to 120-volt AC (abbreviated 120 VAC). AMP—Short for ampere, the electric current unit of measure. RV sites with electric hookup will specify the maximum amps supported, which generally come in units of 20, 30, or 50 amps.
Page 174 12-volt DC (abbreviated 12 VDC). DEALER—For purposes of this manual, this refers to the independent dealer authorized to sell and/or service your camper by Grand Design RV. This term will be used in this context unless specified otherwise.
Page 175 Glossary DRY CAMPING—Camping when there is no city water hookup or shore power (i.e., using only the water and power available in the camper and not from any other source). DRY WEIGHT—The actual weight of a vehicle or trailer containing standard equipment without fuel, fluids, cargo, passengers, or optional equipment.
Page 176 Glossary GALLEY—The kitchen in an RV. GENERATOR—An engine powered device fueled by gasoline or diesel fuel, and sometimes propane, for generating 120-volt AC power. GENSET—Abbreviation for generator set. GOOSENECK—A trailer and hitch configuration connected to the tow truck directly above the rear axle by way of a standard ball hitch in the truck bed and a vertical, slender arm on front of the trailer.
Page 177 Glossary HIGH PROFILE—A fifth-wheel trailer with a higher-than-normal front to allow more than 6 feet of standing room inside the raised area. HITCH—The fastening unit that joins a movable vehicle to the vehicle that pulls it. HITCH WEIGHT—The amount of the camper’s weight that rests on the tow vehicle. It should be approximately 12% - 15% with conventional trailers;...
Page 178 Glossary JACKKNIFE—90° angle obtained from turning/backing fifth wheel or travel trailer with tow vehicle. Jackknifing a short bed truck towing a fifth wheel without the use of a slider hitch or extended fifth wheel pin box can result in damage to the truck cab or breaking out the back window of the truck cab from the truck and fifth wheel “colliding”.
Page 179 Glossary PATIO MAT—Carpet or woven mat for use on ground outside of RV. Used whether or not a concrete patio pad is available where camping. PAYLOAD CAPACITY—The maximum allowable weight that can be placed in or on a vehicle, including cargo, passengers, fluids and fifth-wheel or conventional hitch loads. PILOT—A pilot is a small standby flame that is used to light the main burner of a propane fired appliance when the thermostat calls for heat.
Page 180 Glossary SANITIZATION—Refers to the camper’s fresh water system that has been sanitized with chlo- rine bleach before use or after storage. SHORELINE POWER CORD—This is the electrical power cord that runs from the camper to the campsite shore power outlet. SLEEPING CAPACITY WEIGHT RATING (SCWR)—The manufacturer’s designated number of sleeping positions multiplied by 154 pounds (70 kilograms).
Page 181 Glossary TRAILER BRAKES—Brakes that are built into the trailer axle systems and are activated either by electric impulse or by a surge mechanism. The overwhelming majority of RVs utilize elec- tric trailer brakes that are actuated when the tow vehicle’s brakes are operated, or when a brake controller is manually activated.
Page 182 Glossary WEIGHT & LOAD—These terms are generally used interchangeably. For the purposes of understanding RV applications: • Vehicles have WEIGHT, which impart LOADS to tires, axles and hitches. • Scale measurements taken when weighing, are LOADS carried by the tires. The measured LOADS are used to calculate Gross Combination Weight (GCW) Gross Vehicle Weight (GVW), Gross Axle Weight (GAW), and Hitch Loads.
Page 183 Index Index 7-Way Wire Harness 12-Volt DC System 12-Volt Fuse Panel 12-Volt Water Pump 30-Amp or 50-Amp Power Cord 77-78 120-Volt AC System 120-Volt Circuit Breakers Air Quality 39-40 Appliances Auxiliary Battery Awning 124-127 Battery Disconnect Switch Black/Grey Water System Black Tank Flusher Breakaway Switch Carbon Monoxide (CO) Poisoning...
Page 184 Index Federal Certification Label Fire Extinguisher Fire safety Formaldehyde Fresh Water Connections Fresh Water System Furnace 121-122 • • Garage Hide-A-Bed Sofa 136-137 Interior Care Maintenance Checklist, Suggested Maintenance Schedule, Required Maximum Load Rating 52, 62 Monitor Panel Murphy Bed Occupant Safety Patio Awning 124-126...
Page 185 Index Safety Precautions 47-48 Sanitizing the Fresh Water System Slideout Systems • Lippert Electric • Schwintek In-Wall Smoke Alarm 34-35 Thermostat Tire And Loading Information Label Tire Safety Tips Tire Tread Toilet Towing and Leveling Troubleshooting TV Reception Basics Vehicle Identification Number Warranty, (1) One Year Limited Base Warranty, (3) Three Year Limited Structural Warranty Service...
Page 186 Customer Notes...
Page 187 Customer Notes...
Page 188: Maintenance Record
Maintenance Record Maintenance Record Date : Work Performed : Next Service :...
Page 190 Corporate Office 11333 County Road 2 Middlebury, IN 46540 (574) 825-8000 www.granddesignrv.com Copyright © 2020 Grand Design RV, All rights reserved. Part # 961019 Printed in the USA Rev. 07/2020...

This manual is also suitable for:

Imagine xls 2021 Transcend xplor