Model Number of Berth Date Purchased M.R.O M.T.P.L.M Pay Load Shipping Length Internal Length Body Width 2.3m Internal Width 2.133m Internal Height 1.98m Overall Height 2.57m Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 2
Awning Size C.R.I.S Number Note: Overall height does not include TV aerial or air conditioning. Vanmaster Limited reserves the right to make amendments to the specifications shown in the course of development. Note: All dimensions are approximate overall sizes. Illustration, photographs, descriptions, information and statements contained in the...
Page 3
OWNERS HANDBOOK Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
ADE HEATING SYSTEM ..............119 FRIDGE..................... 120 OVEN ....................121 TOILET ..................... 122 MICROWAVE ................... 123 AIRCONDITIONING ................124 SOLAR PANELS ................. 125 MOVER .................... 126 Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 5
SECURITY ..................127 TAKING CARE ................... 138 ANNUAL SERVICE INSPECTION RECORD .......... 150 Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
This Vanmaster warranty requires a full annual service to be carried out by Vanmaster. This service must be carried out within 90 days either side of the anniversary of the purchase date for interim years but before the anniversary date of the 3rd and 6th year.
Page 7
The warranty will be invalidated if the caravan has been neglected, misused or modified in any way without the prior agreement of Vanmaster Limited. The caravan will be deemed to have been neglected if it has not been serviced and maintained as stated in the service section of this handbook.
Page 8
Remaining Benefits of the Vanmaster Six Year Warranty The Warranty may be transferred to a new owner if the Caravan is sold providing the Caravan has been serviced by Vanmaster Ltd and details of the change of ownership have been supplied to Vanmaster Limited.
Page 9
For All Caravans Less than Six Years Old Caravan to be serviced annually by Vanmaster within 90 days either side of the anniversary of the purchase date. As part of the service schedule we will reseal every 6 years. The current cost of a reseal is £1500. Where the...
Vanmaster has designed and manufactured your caravan as a recreational vehicle and is intended for this use only. It is not intended for permanent habitation. Vanmaster accepts no liability if the caravan is used for any purpose other than recreational/holiday use,...
Page 11
Information It is a condition of your warranty that your Caravan must have an ‘Annual Service’ carried out by Vanmaster Ltd. And a record kept in the Annual Service/ Inspection section in the back of this handbook. Our Wigan factory Service Department is staffed by fully trained experts who will carry out the yearly inspection, adjustments and replacement of parts to maintain your Caravan in prestige condition.
Page 12
Finally, if for whatever reason you dispose of your Caravan would you please leave inside this handbook so that the next owner can also enjoy the pleasures that the Caravan has given you. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
After the threshold level has been passed, the draw shaft is pushed in, thus actuating the overrun lever; the wheel brakes are then applied via the expanding clutch. An automatic reversing system is also built in. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 14
The fully insulated floor is constructed from a timber frame with plywood and insulation laminated together for strength. The walls comprise an insulated foam sandwich having pre-coated aluminium exterior surface and vinyl coated/wood veneer plywood interior finish. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 15
A LED brake light is fitted to a higher level. Awning lights are fitted to both offside and nearside walls. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 16
A fully fitted washroom with fully lined shower cubical, half insert hand basin with domestic pipes and brushed steel taps, shower mixer and washroom accessories. There is a choice of either a Thetford or Dometic cassette toilet. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 17
All under floor waste pipes are also adequately insulated. Awning Channel Each Caravan is fitted, as standard, with an awning channel as an integral Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 18
Wheel locating pins. (Assist wheel change.) 25m hook-up lead. Sink plugs and Grill pan. Fiamma Waste master. Male coaxial plug and 12V plug. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
GENERAL SAFETY Please read this before using your new Caravan: In order for you to get the most out of your new Vanmaster Caravan it is necessary for you to be aware of the following: a) Do not obstruct ventilators. They should be cleaned on a regular basis.
Page 20
It is illegal to tow your Caravan whilst it is occupied. Ventilation All Vanmaster Caravans are ventilated at both high and low level in accordance with Safety Ventilation regulations. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE...
Page 21
Gas Dispersal Holes All gas appliances have a gas dispersal hole below them, and it is essential that these are not blocked or covered. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 22
Caravan through the front fixed ventilation points. Fire Safety Smoke Alarm Your Vanmaster Caravan will be fitted with a photoelectric battery operated smoke detector. It will be fitted normally on the internal roof adjacent to the entrance door.
Page 23
A good quality fire extinguisher should be purchased and should be carried inside your Caravan at all times. It should be fixed at an easy accessible point, possibly adjacent to the entrance door. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 24
Call the fire brigade. Turn off gas container valve if safe to do so. Fire Retardant Foams Under the requirements of the Consumer Protection Act 1987, Vanmaster Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 25
Resilient (C.M.H.R) foam cushions. These foams are much safer from a fire point of view than those previously used. All upholstery is made of fire retardant fabric. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
7m (23ft approx), excluding coupling and drawbar. This is legally the maximum size of trailer that can be towed by a normal motor car. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 27
Mass in Running Order. (Ex Works Weight inclusive of manufacturers tolerances) Vanmasters stated weight, as new, with standard fixtures and fittings. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 28
The part of the static mass of the caravan supported by a towing device on the rear of the vehicle. Note: All Vanmaster Caravans have the actual MTPLM weight printed on a plate affixed to the outside wall at the bottom of the entrance door.
Page 29
Train Weight: (Combination Weight) The maximum permitted combined weight of the towing vehicle and trailer combination as specified by the towing vehicle manufacturer. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 30
If in doubt this can be done on a public weighbridge. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 31
The vehicle insurer should be notified that a caravan or trailer would be towed. The Caravan should be separately insured against theft/damage. Additional insurance may be required if travelling on the continent. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 32
85% of the towing vehicles kerb weight providing both are properly maintained, fully serviceable and the other recommendations in this Handbook are followed. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 33
100% of the kerb weight of the towing vehicle and still give adequate performance, but it should be noted that the towing vehicle manufacturer's limit is, in some cases, less than the kerb weight. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 34
The remainder should be distributed to give a suitable nose weight at the towing coupling (see diagram). Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 35
All Vanmaster Caravans are of a well-balanced design and should be expected good towers.
Page 36
Loose articles should be stowed securely to avoid movement and possible damage. e) Ensure that all lockers and cupboard doors are closed and secured. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 37
Check tyre pressures (Refer to the Tyre pressure Table) and tyre condition for roadworthiness. Ensure the jockey wheel is down, in good contact with the ground, clamp tightly secured, and the Caravan handbrake is fully on. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 38
AKS 3004 using the coupling handle put the AKS on to the tow ball. Push the black handle down and check the green indicator button is showing. The stabiliser lever must be in the uppermost position. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 39
To operate the Stabiliser (once coupled to the tow ball), simple press the stabiliser level down as far as it will go. Lift the jockey to its highest position and clamp it firmly in place. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 40
Ensure the cable is long enough to allow for covering and will not become taut or snag during use as this could result in the handbrake operating whilst towing. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 41
Caravan a small distance backwards with the other. The user must supply this small but essential backward movement to ensure Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 42
No cable should be allowed to touch the ground as it will wear and become damaged and ineffective. Pulling Off: Operate the clutch smoothly. Allow more engine speed to produce the Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 43
It is also important to check that the brake had in fact operated correctly as soon as the Caravan has been uncoupled. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 44
AL-KO as the braking and reversing systems must be matched to ensure optimum braking performance. Combining parts manufactured by AL-KO with those produced by other suppliers will invalidate any Guarantee entered into by AL-KO. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
When passing other vehicles allow more than the normal clearance for driving solo. Allow longer to get up speed to pass. Allow for vehicle being twice its normal length. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 46
'weaves' from side to side often causing a similar swaying movement in the car itself. Causes: a) Unsuitable or unbalanced outfit. b) Incorrect loading or weight distribution. Excessive speed especially downhill. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 47
When going downhill, take extra care to ensure your outfit does not gain speed. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 48
Motorway driving requires extra alertness and an awareness of the effects of other traffic and crosswinds on your outfit. Settle for a speed at which your outfit and you feel comfortable. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 49
Caravan to be reversed immediately on stopping. a) When reversing round a corner, start with the outfit in a straight line. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 50
Finally straighten up. Proficiency in reversing can only be achieved with practice and should be first attempted in a large quiet area away from other traffic. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 51
Strength against unauthorised removal. Cost All Vanmaster Caravans are fitted as standard with the AL-KO wheel lock receiver. The wheel lock assembly is available as an optional extra. Note: It is recommended that all security devices should have been tested and approved by an appropriate body, e.g.
Page 52
1986, The Road Vehicle Lighting Regulations 1989 or the Motorway Traffic Regulations (England and Wales). It may also be helpful to consult a copy of the Highway Code. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Reverse onto your pitch a short distance (say 12") further back than you wish to end up. Then place the levelling ramp in front of the wheel that needs to be raised. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 54
Place the spirit level pointing front to back just inside the Caravan door or on the A frame. b) Then raise or lower the jockey wheel until the Caravan is horizontally level. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 55
Grab Handles: When pushing or pulling your Caravan always use the grab handles correctly, do not snatch them and do not push on exterior panels. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
The mains supply is suitable for your installation and appliances, i.e. whether it is AC or DC and whether it is at the correct voltage and frequency. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 57
Check that RCD main isolation switch in Caravan is set to OFF position. Unlock and open battery locker door and insert plug of mains cable. into Caravan mains inlet socket. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 58
If 12V power is required, switch on main 12V isolation switch adjacent to the entrance door. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 59
Unlock battery locker door and remove supply flexible cable plug from Caravan socket. Close and lock battery locker door. g) Coil up flexible supply cable. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 60
The two lockable opening doors to the front of the Caravan access the locker. The locker doors should be kept locked at all times and especially when travelling. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 61
Set control knob (a) to manually select which cylinder will be operating and which will be held in reserve. For example, turn control knob (a) to the left until it stops now Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 62
Note: We recommend using the reserve cylinder as operating cylinder every now and again, to make sure the reserve cylinder still has a sufficient gas supply. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 63
When in, securely tighten to form a gas seal, do not over tighten. Note: Do not over tighten the connector or the rubber sealing ring may be deformed. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 64
Note: It is recommended that the white gasket is replaced with every hose change. Screw alternative high-pressure hose to DuoControl and cylinder (or adaptor). Open gas cylinder valve. Check for leaks. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 65
Caravan which has individual isolation, taps for each appliance, as follows: RED - Space Heater WHITE - Oven BLUE - Fridge GREEN - Water Heater Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 66
Your Caravan can use three separate systems for its water supply. 1. External water carrier. 2. Onboard under slung water tank (for winter use essential). 3. Whale Waterline Mains Water Supply (Optional Extra) Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 67
Check closed both the water heater and the onboard tank drain valves. Fill a fresh water (not supplied) container and place it alongside the Whale wall socket located in the offside wall of your Caravan. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 68
Maximum pumping period is not more than 15minutes. All those connections are firm and watertight. The power is adequate, low performance could result from a weak battery or reduced voltage. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 69
When water has flowed freely from the hot kitchen tap, the water heater can be switched on to run via gas, mains electric or both. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 70
It is essential that you drain down your Caravan water system when it is not in use. This is most important during winter months to protect against frost damage. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 71
The waste water container is placed adjacent to the drain outlet. The screw cap is removed from the large removable cover and the flexi waste pipe is screwed on. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 72
Note: To clean, sanitise and freshen your waste water system and containers, Vanmaster recommends the regular use of Fenwicks Fendox Concentrate, available from most caravan dealer's accessory shop. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
The alarm monitors the air for the presence of CO. The alarm will sound and be accompanied by the flashing red LED light when there are relevant levels of CO present. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 74
Testing the Alarm: Test the unit’s electronics by pressing the test/reset button for five seconds. A series of beeps will sound. The unit needs to be tested weekly! Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 75
If it always sounds please call your supplier. What to do if the alarm sounds: If alarm sounds: a) Call your emergency services. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 76
Size: 26mm * 17mm * 49mm Recommended battery type: G6F22 (Golden Power) Electro Chemical system: Carbon Zinc Battery Jacket Metal Lifetimes of battery: more than one year. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 77
THE TEST RESET BUTTON! Never use detergents or other solvents to clean the unit. d) Avoid spraying air fresheners, hair spray , or other aerosols near the CO Alarm. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 78
In extreme cases there could be a build up of Carbon Dioxide to a dangerous level. Caravan owners are advised to allow some fresh air circulation in the awning space when such appliances are in use. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 79
LPG Gas System: Vanmaster does not recommend the use of any external cylinders. All cylinders in use should be within the gas locker provided. If you wish to utilise a larger cylinder and have this outside the gas locker (site rules permitted) then the connecting hose must not exceed 450mm.
Page 80
No appliance shall be used outside when connected to an internal outlet. Maintain adequate spacing of combustible materials from sources of heat. Do not use additional independent gas appliances inside the Caravan. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
The 40 amp RCD (Residual Current Device) gives protection against earth faults and also acts as a main isolation switch. For normal operation all switches on the unit need to be in the ON position (up). Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 82
RCD and 'trip' the main switch to the off position. The switch is only re-settable after elimination of the fault. To re-set, switch the RCD switch to the 'ON' (up) position. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 83
230V mains equipment typical consumption figures: Refrigerator..0.50 amps Charger......0.5 amps Water Heater..3.9 amps Blown air heaters..5 amps Colour TV....2.50 amps Microwave....4.00 amps Air conditioning..4.00 amps Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 84
Automatic Charging System: Your Caravan is fitted with fully automatic mains to 12-volt dc 20amp battery charger. Mains power is supplied directly from the mains unit via MCB3. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 85
Note: Any battery should be checked dimensionally before purchasing to ensure fitment within the battery compartment, as brands vary in size. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 86
Caravan socket. Unlock and open battery compartment door. Remove battery tray and place on floor. This tray should be fitted at all times. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 87
RCD to the ON position. 12V Electrical System: A 12V switch panel is fitted to the left hand side of the entrance door (model dependant). The panel has four switches, Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 88
Caravans 12V supply. Care should be taken not to reduce the level of the car battery so low that the car engine cannot be started. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 89
Radio/TV Aerial 10amp Roof Fans 5amp Fire (if fitted) 5amp Water Heater Colour Coding For Fuses Light Brown..5 amps Red....10 amps Blue..... 15 amps Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 90
Re-clip metal bulb carrier to light cluster. Replace light cluster back into light cavity on caravan. Replace 4 crosshead screws. Note: Do not over tighten screws. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 91
To replace shade/cover, hold up same to line up with threaded holes on lamp base (smooth outer rim to outside). Screw back the three retaining screws with plastic spacers in place. Tighten finger tight only. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 92
Halogen 12V DC 10w GW To replace bulb. With small flat blade screwdriver carefully prise off silver plastic cover via the two slots on either side of lamp base. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 93
The following table gives typical values for commonly used appliances. To avoid tripping allow a generous margin. Take care not to exceed Caravan circuit limits. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
USING FITTED EQUIPMENT The instructions covering fitted equipment to your Vanmaster Caravan were correct at the time of going to print. However Vanmaster Caravans cannot accept responsibility for any changes that may be made in specification or operating instructions to the equipment described in this section after the time of going to press.
Page 95
60mm. Extended Neck Tow Ball A50-X Tow Ball Type A50-1 Couplings of type A50-1 cannot be used. (Warranty will be invalid.) Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 96
The coupling is correctly engaged when the green edge of the safety button is visible. Check the black handle is fully down and check the green indicator button is showing. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 97
AL-KO ATC Trailer Control System All 2011 Caravans will be fitted with the AL-KO ATC Trailer Control System. AL-KO ATC is an electronic emergency control system for your Caravan. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 98
Upon connection to the towing vehicle via the 13 pin plug, ATC will carry out an initial self test and the LED light on the front fairing will light up RED. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 99
If live check OK, check PUSH ROD position if RED line is visible on the PUSH ROD do not tow Caravan. Red line not visible possible to drive but contact AL-KO. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 100
AL-KO at the earliest convenience. If the red line is visible on the push rod, as shown below, the Caravan should not be moved. Removal of the Push Rod. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 101
We (AL-KO) reserve the right to request credit card details to cover payment in advance. Information: Check state of ATC LED after any stop during your journey. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 102
AL-KO SPARE WHEEL CARRIER (Under slung) Operating Instructions: Your Vanmaster Caravan will be fitted with the AL-KO (under slung) spare wheel carrier. The carrier is able to carry steel or alloy wheels. Introduction: In the interests of safety, before using the carrier it is most important that you familiarise yourself with its operation.
Page 103
Important: If it becomes necessary to completely carrier from the chassis remember that the washers and split pins are on the inside of the chassis as well as on the outside. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 104
Caravan, which means that the 12V isolation switch is nearest switch to the entrance door. The main control panel is situated in the top offside central cupboard (model varies). Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 105
Fuses: The charger is protected by both mains (MCB 3) and DC output fuses. When replacing fuses use only one of the same type and rating. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 106
Your Caravan will be fitted with one or more Remis multifunctional roof lights. They are normally located in the front and rear section of the roof. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 107
The Midi Heki roof light will generally be fitted in washroom areas. To open, push in the large central button. Whilst depressed, slide the bar to the desired position and locate into the stops provided. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 108
It is not recommended that blinds and/or fly screens are left in the down position for long periods, or when travelling, as this can result in fatigue of the spring. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 109
Caution: When opening or releasing the door screen, care must be taken to avoid trapping fingers. Do not allow the door screen to slam closed. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 110
Lift one side bed front rail to overcome travel catch and pull out about six inches. Release Velcro strap from both legs (access under upholstered finisher), drop down legs and straighten. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 111
Lift and clip back the four support legs, refasten the Velcro strap (for travelling only) and arrange cushions as appropriate. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 112
Lift up again with the top end of the wooden frame as far as possible, the ratchet will release itself, and allow the frame to be lowered to its original position. Rearrange the cushions appropriately. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 113
Remove and store table. Pull out slide out bed bases, one from below each seat till they meet. Unclip and drop down legs, adjust length. Arrange bed cushions. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 114
Tune your television into the strongest signal. You may need to adjust the direction of the mast to achieve the best picture quality. h) Secure by tightening the mast locking collar and wall bracket. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 115
Digital Radio Antenna: Your Vanmaster Caravan is fitted with a digital radio antenna, which should enable good radio reception in all areas. The antenna is roof mounted normally to the front offside.
Page 116
When the temperature drops the breaker will automatically reset and start normal operations. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 117
Tyron Wheel Safety Bands: Your Vanmaster caravan comes fitted with Tyron wheel safety bands to all wheels excluding the steel spare wheel. The Tyron Bands: - Assist the driver in maintaining steering, cornering and braking control after a tyre deflation.
Page 118
It is recommended that if you have a tyre deflation you seek professional help to repair/replace the tyre, as special equipment is needed. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
ADE HEATING SYSTEM Please refer to separate instruction booklet Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
FRIDGE Please refer to separate instruction booklet Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
OVEN Please refer to separate instruction booklet Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
TOILET Please refer to separate instruction booklet Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
MICROWAVE Please refer to separate instruction booklet Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
AIRCONDITIONING Please refer to separate instruction booklet Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
SOLAR PANELS Please refer to separate instruction booklet Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
MOVER Please refer to separate instruction booklet Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 127
SECURITY Theft deterrent, prevention and security of your Caravan is taken very seriously at Vanmaster, that is why we have provided a number of standard features and optional extras designed to deter and prevent thieves from stealing your property. And in the unlikely event that they should succeed, aid the identification, speedy recovery of your property and assist in the prosecution of the thief.
Page 128
Registration Document, which is sent by CRIS to the Caravan registered keeper. Shortly after purchasing your Caravan you should receive your Caravan Registration Document. It will be sent direct to you by post. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 129
Keys: For your convenience your Vanmaster Caravan has a single security key which, opens the entrance door, front gas lockers, battery compartment, Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE...
Page 130
Two keys are supplied on delivery and a note should be kept of the number. You may if you wish have extra copies made at a reputable locksmith. Should you lose the keys Vanmaster can supply directly an extra key by post for a small fee.
Page 131
The LED can be reset by inserting the key and switching off (anticlockwise) then switching back on (clockwise), then removing the key. Disarming the system: Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 132
Coupling up and inserting the 13 pin connector. When coupled, unplugging the 13 pin connector. d) With the 13 pin connecter inserted, using the footbrake. e) Entering the Caravan (instant operation). Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 133
12V battery will trigger the alarm. Pressing the fob alarm button will switch off the siren at the end of each of the above actions. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 134
(gently 'waggling' from side to side) till it comes off its mounting plate. The control Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 135
This is a requirement of the Noise Pollution Act. AL-KO Safety Ball Part No 641255 (Available Separately) The safety ball can be inserted into tow ball socket, when used in conjunction with security device. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 136
AL-KO Wheel Lock As from 2007 all Vanmaster Caravan chassis will be fitted with the receivers for the AL-KO Wheel Lock as standard. The wheel lock is approved by Sold Secure and most insurance companies. The wheel lock can be purchased as an optional extra.
Page 137
Tracking Device A tracking device may have been fitted to your Caravan as an optional extra. Full operating instruction will have been provided by the relevant manufacture. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 138
It is a condition of these warranted that a service and safety check is carried out by Vanmaster at least yearly for the first five years in accordance with the National Caravan Council (NCC) recommendations. Exterior Cleaning: Under no circumstances should an abrasive or harsh cleaner be used.
Page 139
Any remaining dirt should be washed off using a soft cloth and warm water. Use talcum powder to care for the rubber seals. Only use water and mild soap suds to clean the blinds. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 140
The ventilation grids of the inner frame can be removed for cleaning purposes. All rubber seals should be dusted with talcum powder at least once a year. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 141
It must be remembered that because the frames of doors are made of ash, they can be affected by temperature and humidity and may not bow under certain conditions. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 142
Failure to follow these simple instructions may result in premature failure or cracking which will not be covered by any guarantees. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 143
Water at a suitably hot temperature containing an appropriate detergent is recommended for this purpose. Water should then be put into the container, swirled round, then emptied out. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 144
Remove Whale Aqua source water filter fitted, (below sink) and replace with a short length of hose or empty filter cartridge (this will ensure the filter is not affected by the disinfectant/sterilising solution). Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 145
ATC is a sealed unit and any evidence of removal of ATC or the components parts including outer casing and fixings will immediately invalidate any product warranty. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 146
The checks should be carried out before each journey and at regular intervals during storage. Tyre Wear and Damage: The legal requirements for thread depth on motor vehicle tyres apply also to caravans. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 147
The jack you use can be either a bottle or small trolley jack but it must be able to lift the MTPM of the Caravan. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 148
This should be kept in the Caravan at all times to make wheel removal possible. If possible after a puncture try to get your Caravan onto safe level ground where if possible you can leave thee towing vehicle coupled. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 149
Accolade 520 (Single) Accolade 520 (Twin) Applause 580 (Single) Applause 580 (Twin) Occasion 640 (Twin) The above pressures are recommended by Tyre-Line specifically for Vanmaster Caravans. Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 150
SERVICE DEALERS STAMP DATE................Technicians Signature I/we certify that an annual service has been carried out in accordance with the handbook Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 151
SERVICE DEALERS STAMP DATE................Technicians Signature I/we certify that an annual service has been carried out in accordance with the handbook Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 152
SERVICE DEALERS STAMP DATE................Technicians Signature I/we certify that an annual service has been carried out in accordance with the handbook Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 153
SERVICE DEALERS STAMP DATE................Technicians Signature I/we certify that an annual service has been carried out in accordance with the handbook Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 154
SERVICE DEALERS STAMP DATE................Technicians Signature I/we certify that an annual service has been carried out in accordance with the handbook Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 155
SERVICE DEALERS STAMP DATE................Technicians Signature I/we certify that an annual service has been carried out in accordance with the handbook Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Page 156
VANMASTER LTD Unit 5 Stone House Road Martland Park Wigan Lancashire United Kingdom WN5 0LE Tel: +44 (0)1942 212194 Fax: +44 (0)1942 212224 Email: Info@vanmaster.net Website: www.vanmaster.net Vanmaster, Unit 5 Stone House Road, Martland Park, Wigan WN5 0LE www.vanmaster.net | info@vanmaster.net...
Need help?
Do you have a question about the Accolade 480 and is the answer not in the manual?
Questions and answers
How do you remove the central front window. I've tried lifting it up but it hits the lip of the roof without detaching.