Trouble Shooting; Trouble Shooting Table - Zip HydroTap G4 IS Industrial Series Installation Instructions Manual

System fault
message
Power Board Fault
Interface Fault
Level Board Fault
Condenser Screen Blocked
Water leak, Isolate Mains
Compressor Over Run
Water Supply Failure
Hot Sensor Open
Hot Sensor Closed
Cold Sensor Open
Cold Sensor Closed
Flood Sensor Open
Condenser Sensor Closed
Condenser Sensor Open
Heater Driver Fault
Compressor. Driver Fault
Hot Sensor Degraded
A DC Pump is faulty
Condenser Overtemp
Steam too Cool
Steam Sensor Open
Steam Sensor Closed
Hot Overload
Hot Tank Overfilled
Comp Fuse/Driver Fault
Hot tank under filled
Boil dry protection
Flash Mem corrupted
Flow Sensor Fault
Call an electrician, a plumber, or Zip on 0345 6 005 005 for assistance, service, spare parts or enquiries.
Installation instructions
802742UK V4.00 Sept 2018 - Zip HydroTap Industrial

Trouble shooting

Possible cause
Electrical disruption
Internal fault
Internal fault
Blocked air filter
Water leak
Compressor too hot
No water
Internal fault
Internal fault
Internal fault
Internal fault
Internal fault
Internal fault
Internal fault
No hot water
No chilled water
Internal fault
Internal fault
Blocked air filter
Internal fault
Internal fault
Internal fault
Internal fault
Internal fault
Internal fault
Low water pressure
Safety activated
Internal fault
Internal fault
Solutions
Check power supply and all fuses
Call Zip service
Call Zip service
Remove blockage / clean filter / check user guide
Turn off mains water supply / call for service
Check ventilation
Check water supply is turned on
Call Zip service
Call Zip service
Call Zip service
Call Zip service
Call Zip service
Check ventilation / Call Zip service
Check ventilation / Call Zip service
Call Zip service
Call Zip service
Call Zip service
Call Zip Service
Remove blockage / Clean filter / check user guide
Call Zip service
Call Zip service
Call Zip service
Turn off to reset / Call Zip service
Call Zip Service
Call Zip service
Check water supply
Turn OFF / On power to reset
Call Zip Service
Call Zip Service
Tel: 0345 6 005 005 Email: service@zipindustries.co.uk www.zipwater.co.uk
Technical support 33