Table of Contents
Advertisement
Castleton
(Model 8030 AU)
Woodstove
OWNER'S MANUAL
Installation And
Operating Instructions
KEEP THESE INSTRUCTIONS FOR FUTURE REFERENCE
PLEASE READ THIS ENTIRE OWNER'S MANUAL BEFORE YOU INSTALL AND USE YOUR
NEW CASTLETON WOOD STOVE.
If this room heater is not properly installed, a house fire may result.
To reduce the risk of fire, follow the installation instructions.
Failure to follow these instructions can result in property damage, bodily injury, or even death.
Conforms to AS/NZS 2918: 2001
CONTACT LOCAL AUTHORITIES WITH JURISDICTION (BUILDING DEPARTMENT or FIRE
OFFICIALS), ABOUT PERMITS REQUIRED, RESTRICTIONS AND INSTALLATION
INSPECTION IN YOUR AREA.
Castleton Model 8030 AU
Manual: 6400-41407
R: 1/10/2018
Advertisement
Table of Contents
Related Manuals for HearthStone Castleton 8030 AU
Summary of Contents for HearthStone Castleton 8030 AU
- Page 1 Castleton (Model 8030 AU) Woodstove OWNER'S MANUAL Installation And Operating Instructions KEEP THESE INSTRUCTIONS FOR FUTURE REFERENCE PLEASE READ THIS ENTIRE OWNER’S MANUAL BEFORE YOU INSTALL AND USE YOUR NEW CASTLETON WOOD STOVE. If this room heater is not properly installed, a house fire may result. To reduce the risk of fire, follow the installation instructions.
- Page 2 COMPLIANCE WITH AS/NZS 4013:2014. THE APPLIANCE OR FLUE SYSTEM SHOULD NOT BE MODIFIED IN ANY WAY WITHOUT THE WRITTEN APPROVAL OF THE MANUFACTURER. Supplied by: Castworks Pty Ltd 57 Industrial Drive Braeside VIC 3195 Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU...
-
Page 3: Table Of Contents
................................22 ASKETS ................................. 22 LASS TROUBLESHOOTING ......................23 ........................... 24 ROUBLESHOOTING UIDE & O ....................25 EPLACEMENT ARTS PTIONAL CCESSORIES SAFETY LABEL ........................26 LIMITED WARRANTIES ....................... 27 Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU... -
Page 4: Introduction
• DO NOT BURN GARBAGE. Never burn garbage install your stove in a poorly insulated area. This is or trash, colored or glossy paper, solvents, inefficient and would likely result in higher fuel usage. Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU... -
Page 5: Periodic Checklist
6. A ventilation system is installed in the house. firing the stove again. You must correct any damage before using your stove again. If these or other indications suggest that Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU... -
Page 6: Specifications
4 to 12kg. per cubic foot depending on type of wood, moisture content, packing density and other factors. Figure 1 – Castleton Dimensions Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU... -
Page 7: Installation
Venting installations must meet the bottom of the stove and the bottom heat shield. requirements of the BCA (NCC) and the AS2918 Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU... -
Page 8: Hearth Requirements & Floor Protection
The floor protector should extend 300mm in front of the appliance fuel loading door and be placed centrally in the 830mm width. The minimum floor protection must be met under the stove and extend beyond the stove as follows: Figure 2 – Hearth Dimensions Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU... -
Page 9: Ombustible Urface Equired Learances
*An adaptor for 4” duct is available if needed. KIT The outside air kit for this stove allows for the direct #90-53308 connection of the stove's air intake to a minimum 3" Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU... -
Page 10: Outside Air Supply
• The construction of masonry chimneys, flue like to see any vertical rise in the duct’s termination. Hearthstone recommends the termination be at the block chimneys and connecting flue pipe same level, or lower than the air intake on the stove. - Page 11 (see diagram below). current construction regulations and is at least • Additional ventilation is required. This must be the minimum sizes shown. provided using a permanently open-air vent, of Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU...
- Page 12 If you are in any doubt about the installation requirements, or suitability of fire surrounds contact your Hearthstone dealer. Figure 6 – Flue System and is components Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU...
- Page 13 Figure 7 – Air ventilation through Figure 8 – Air ventilation through chimney chase top flashing Figure 9 – Minimum flue height as per AS/NZS 2918:2001 Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU...
-
Page 14: Installing The Rear Hearshield And Blower
Once both screws are through the holes slide the heat shield down to catch the screws in the slots then tighten to the brackets Top Exit Configuration #1 Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU... - Page 15 (Figure 11). Rear Exit Configuration #2 Figure 10 Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU...
- Page 16 Contact your dealer rheostat adjustment. To turn the blower off, turn the knob fully counterclockwise until it clicks into the off setting. Figure 12 Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU...
-
Page 17: Operation
Gently pull on the door Moisture content also plays a key role in the handle to make sure it is properly latched. performance of your stove. Wood freshly cut from a Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU... - Page 18 Mountain Ash Callitris columellaris Box- Good Excellent Poor Many Limited 8000 18.6 White Cypress Pine Ironbark Pinus Radiata Foothill Fair Excellent Poor Many Good 7000 17.9 Radiata Pine Plantations Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU...
-
Page 19: Buildinga Fire
• Do not throw wood into the stove. procedure is completed. Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU... -
Page 20: Normal Operation
Figure 16 – Air Control Positions Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU... - Page 21 In the unlikely event of a chimney fire, immediately close the front door, turn the air control to the minimum burn rate setting described above and contact the local fire department. Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU...
-
Page 22: Maintenance
12. After 5 or 6 fires, check the glass retainer screws, and retighten if necessary. Required Glass Kit: Part Number: 90-58300. Use only 5mm x 241mm x 390mm Ceramic IR, or Neoceram IR glass. Contact your Hearthstone dealer. Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU... -
Page 23: Creosote Formation & Removal
(your dealer may be a certified sweep!). Required Glass Kit: PN: 90-58300. We recommend that before each heating season you have the entire system professionally inspected, cleaned and repaired, if necessary. Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU... -
Page 24: Troubleshooting
This phenomenon of air starvation within the Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU... -
Page 25: Roubleshooting Uide
Do not over-fire the stove. Monitor stove temperatures. Use FINISH seasoned wood only. Excessive Draft Check the DRAFT. A damper may be required. Operate the stove at a LOW BURN range. Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU... -
Page 26: Replacement Parts & Optional Accessories
GLASS KIT 90-71100 DOOR HANDLE KIT 90-73212 DOOR LATCH KIT 90-76300 BAFFLE KIT Refer to the Illustrated Parts list for further detail about stove components, available online at www.hearthstonestoves.com. Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU... -
Page 27: Safety Label
Safety Label Hearthstone Quality Home Heating Products, Inc ® Castleton Model 8030 AU... -
Page 28: Limited Warranties
) year after the Purchase Date, Hearthstone will pay for warranty labor performed by an authorized Dealer at Hearthstone’s published labor rates in effect at the time the labor is performed only if the appliance is installed by an authorized dealer or their designated representative. Otherwise or thereafter, the Original Purchaser is responsible for the cost of labor. - Page 29 Hearthstone or an authorized Dealer, as the case may be. Notwithstanding any other provision of this document, in no event will Hearthstone pay for any Dealer fees or other fees for pick up or delivery of the appliance returned for repair; the Original Purchaser shall be responsible for any such fees.
- Page 30 Dealer on behalf of Hearthstone, as the case may be, will instruct the Original Purchaser to either return the defective part, or the entire appliance (if requested), to the Dealer or Hearthstone or allow a Dealer to make a service call at the place where the appliance is located. Hearthstone may require that a digital picture be provided to support the claim.
Need help?
Do you have a question about the Castleton 8030 AU and is the answer not in the manual?
Questions and answers