Related Manuals for Schiller RYAN LAWNAIRE IV
Summary of Contents for Schiller RYAN LAWNAIRE IV
- Page 1 LAWNAIRE WITH EASY STEER TECHNOLOGY MODELS: 554918A LAWNAIRE IV with EST - HONDA (S/N 1124 and Lower)
- Page 2 CALIFORNIA WARNING Proposition 65 Warning Diesel engine exhaust and some The engine exhaust from this product of its constituents are known to the contains chemicals known to the State State of California to cause cancer, of California to cause cancer, birth birth defects and other reproductive defects or other reproductive harm.
-
Page 3: Table Of Contents
Your safe use of this Schiller Grounds Care, Inc. product is one of our prime design objectives. Many safety features are built in, but we also rely on your good sense and care to achieve accident-free operation. For best protection, study the manual thoroughly. -
Page 4: Safety
Schiller of hazard seriousness. These words appear in this Grounds Care, Inc.'s Engineering Department. Any manual and on the safety labels attached to Schiller Schiller Grounds Care, Inc. product that is altered, Grounds Care, Inc. machines. For your safety and... - Page 5 Lawnaire SAFETY with EST PREPARING FOR SAFE OPERATION Site preparation and circumstances Evaluate the terrain to determine what Operator preparation and training accessories and attachments are needed to Read the Operation & Safety properly and safely perform the job. Only use Manual accessories and attachments approved by the If an operator or mechanic...
- Page 6 Lawnaire SAFETY with EST OPERATING SAFELY Interrupting operation In general Before leaving the operator's position: Use extra care when loading or unloading the - Park on level ground. machine into a trailer or truck. - Disengage the traction clutch. Slow down and use caution when making turns - Shut off the engine.
- Page 7 Lawnaire SAFETY with EST MANEUVERING SAFELY MAINTENANCE AND STORAGE SAFETY In general In general Slow down before turning. Maintain machine according to manufacturer's Be aware when approaching blind corners, schedule and instructions for maximum safety shrubs, trees, tall grass or other objects that may and best results.
- Page 8 Lawnaire SAFETY with EST Tines Storage WARNING Tines are sharp and can Stop the engine and allow to cool before storing cut. Use extra caution when Drain the fuel tank outdoors only. handling. Wear appropriate Store fuel in an approved container in a cool, dry personal protective equip- place ment.
-
Page 9: Safety And Operation Decals
Lawnaire SAFETY AND OPERATION DECALS with EST Danger Hands And Feet Operating Instructions This decal is located on the main frame and informs the This decal can be found on top of the handlebar assembly. operator of areas which are capable of serious injury. It tells the operator the steps involved;... -
Page 10: Assembly/Set-Up Instructions
Lawnaire ASSEMBLY/SET-UP INSTRUCTIONS with EST GENERAL NOTE: FRONT, REAR, RIGHT HAND AND LEFT HAND REFERENCES BELOW ARE WITH RESPECT TO AN OPERATOR AT THE CONTROLS. UNPACKING 1. Cut the banding securing the aerator to the pallet. 2. Grab handle A and pull handle over to other side of unit. -
Page 11: Assembly/Set-Up Instructions
Lawnaire ASSEMBLY/SET-UP INSTRUCTIONS with EST CHECKING THE CLUTCH CABLE The clutch cable is adjusted prior to shipping; however, it should be checked before the unit is put into service. 1. Pull the clutch control handle D back and down and make sure the idler engages the belt. 2. -
Page 12: Controls
Lawnaire CONTROLS with EST HANDLE CONTROLS Transport Lift Handle C - Pushing down on the handle lowers the tines for aerating. Pulling the handle up raises the tines so the aerator can be moved or transported without incurring damage to the unit or the turf. -
Page 13: Controls
Lawnaire CONTROLS with EST PRE-OPERATION CHECK LIST (OPERATOR’S RESPONSIBILITY) ___ Review and follow all safety rules and safety ___ Inspect area and remove stones, branches or decal instructions. other hard objects that might be thrown, ___ Check that all safety decals are installed and in causing injury or damage. -
Page 14: Operation
Lawnaire OPERATION with EST AERATING 5. Push down on the transport lift handle, NOTE: For best performance and maximum tine lowering the aerating tines to the turf. penetration, the lawn should be thoroughly watered the day before aeration. 6. Pull back slowly on the clutch control handle to start aerating. -
Page 15: Maintenance/Adjustments
Lawnaire MAINTENANCE & ADJUSTMENTS with EST MAINTENANCE Lubrication: Grease the idler pivot and wheel bearings at the start of the season and every 25 hours. Tines: Replace damaged or broken tines. Keep roller chain clean and in proper running Do not weld or straighten tines. order. -
Page 16: Transporting
Lawnaire TRANSPORTING with EST TRANSPORTING If a tote trailer will be used to transport the unit, the two cast weights must be removed from the aerator frame and a locking shaft installed in their place. Removing the cast weights and draining the water drum will decrease the weight for easier loading on a vehicle or trailer. -
Page 17: Storage
Lawnaire STORAGE with EST STORAGE INSTRUCTIONS To prevent possible explosion or ignition of vaporized fuel, do not store equipment with fuel in tank or To put the equipment into service after an carburetor in an enclosure with open flame (for extended period of storage: example, a furnace or water heater pilot light). -
Page 18: Specifications
Lawnaire SPECIFICATIONS with EST LAWNAIRE IV Dimensions: Width.......... 28" (711 mm) Length......... 51" (1295 mm) Length (handle folded)....46" (1168 mm) Height (transport)....... 47.5" (1206 mm) Height (handle folded)....30" (762 mm) Net Weight: Dry, w/o acc. weight....240 lbs. (109 Kg) Dry, w/ acc. -
Page 19: Parts Section
Lawnaire PARTS SECTION with EST PARTS SECTION... -
Page 20: Frame Group
Lawnaire FRAME GROUP with EST FIGURE 1... - Page 21 Lawnaire FRAME GROUP with EST FIGURE 1 ITEM PART NO. DESCRIPTION ITEM PART NO. DESCRIPTION 64140-9 COTTER PIN, 12 x 1.12 YS 64262-018 BLT-FLG HD 3/8-16X1-3/4 4137227 SPRING-TORSION 64163-61 WASHER 841261 SPROCKET, 16T, 1/2P 2703341.7 BELLCRANK AY, IDLER 2703519 BUSHING, SH .33X.75X.88 2703756.7 LINK AY, LOWER LEFT 2703757.7...
-
Page 22: Main Group-Lawnaire Iv
Lawnaire MAIN GROUP-LAWNAIRE IV with EST FIGURE 2... - Page 23 Lawnaire MAIN GROUP LAWNAIRE IV with EST FIGURE 2 ITEM PART NO. DESCRIPTION ITEM PART NO. DESCRIPTION 64163-29 WASHER-21/64 X 1 X 11GA 5 64140-9 COTTER PIN, 12 x 1.12 4124192 WHEEL, 8X2.5 SEMI-PNEUM 2 2703148 WEIGHT, LAWNAIRE 4117195 CABLE, CLUTCH 2703444 COVER, DRIVE LA4 2703445...
-
Page 24: Handle Group
Lawnaire HANDLE GROUP with EST FIGURE 3... - Page 25 Lawnaire HANDLE GROUP with EST FIGURE 3 ITEM PART NO. DESCRIPTION ITEM PART NO. DESCRIPTION 64163-95 WSHR,.31.69.06 YS FLT 4138396 S-LA4 HANDLE W/DECALS 1 2703059.7 HANDLE, HEIGHT ADJ LA IV 1 2703067.7 TUBE, CONTROL 4164738.7 BAIL AY, LA V 2703185 CNTRL AY, THROTTLE 43 64123-69 BOLT-5/16-18X1-1/2 HEX...
-
Page 26: Tine Wheel Group
Lawnaire TINE WHEEL GROUP with EST FIGURE4... -
Page 27: Tine Wheel Group ..............................................Figure 4
Lawnaire TINE WHEEL GROUP with EST FIGURE 4 ITEM PART NO. DESCRIPTION ITEM PART NO. DESCRIPTION 4168461 WLDMT-TINE,CENTER (INCLUDES ITEMS 3,7,8 & 12) 4167881 SHAFT-TINE 22 85010N ZERK-1/4-28 STR SF TH (QTY 5 ON LA V) (QTY 3 ON LA IV) 2703160 SPROCKET-#40 42 TOOTH 1 2703508... -
Page 28: Drum Group
Lawnaire DRUM GROUP with EST FIGURE 5... - Page 29 Lawnaire DRUM GROUP with EST FIGURE 5 ITEM PART NO. DESCRIPTION ITEM PART NO. DESCRIPTION 2702741.7 PLATE, FLANGE 2703102.7 DRIVE AY, LA4 DRUM 2703157 SPROCKET, 30T .50P 2703508 FLANGE, BEARING 2.04 I.D. 4 2703783 DRUM, WATER LA4 522480 GASKET, 4.50 DIA. 522481 GASKET, 3.00 DIA.
-
Page 30: Decal Group
Lawnaire DECAL GROUP with EST FIGURE 6 MADE WITH PRIDE IN THE U.S.A. JOHNSON CREEK, WISCONSIN ENGINE TO BE LEVEL WHEN FILLING OR ADDING OIL... -
Page 31: Decal Group........................................................figure6
Lawnaire DECAL GROUP with EST FIGURE 6 ITEM PART NO. DESCRIPTION ITEM PART NO. DESCRIPTION 2703117 DECAL, OP INSTR LA IV & V 1 4116761 LABEL-MADE IN USA 4115768 DECAL, HAND THROTTLE 4161123 LABEL-RYAN 521787 DECAL,OIL ENGINE LEVEL 1 835892 DECAL,DANGER HNDS&FT 2 840697 DECAL,WARNING BELT... - Page 32 SCHILLER GROUNDS CARE, INC. ONE BOB-CAT LANE P.O. BOX 469 JOHNSON CREEK, WI 53038 920-699-2000 www.schillergc.com ©Schiller Grounds Care, Inc. 2010...
Need help?
Do you have a question about the RYAN LAWNAIRE IV and is the answer not in the manual?
Questions and answers