RIPLINE ZIPLINE Instructions And Safety Rules

Table of Contents

Quick Links

ZIPLINE KIT WITH SEAT INSTRUCTIONS AND SAFETY RULES

Thank you for your purchase of the RIPLINE™ ZIPLINE! This product was engineered to provide safe fun for ages 8 to 14 years

when the instructions and rules are followed. For best and safe results please read and follow all instructions carefully when

installing and riding your RIPLINE™ ZIPLINE. Obey all safety rules at all times.

IMPORTANT: FILL IN YOUR DATE OF PURCHASE

ON YOUR MAIN CABLE STICKER!

KIT CONTAINS:

A. (1) Trolley with sealed ball bearing pulleys. Non-slip hand grips.

B. (1) Main Cable length varies with model, 3/16in (.48cm) galvanized steel

cable, with looped eye on one end.

C. (1) Sling Cable 5ft. (1.53m), 3/16in (.48cm) steel cable w/looped

eye.

D. (1) Turnbuckle 6in (15.24cm) Steel w/ 2 eye bolts & nuts.

E. (3) U-clamps 3/16in(.48cm) with thread cover caps.

F. (1) Seat and Rope Only included with kits with seats. Seat color varies.

(1) Instructions

Items Required (Not Included):

1) Step ladder

2) (6) 2 inch nails

3) Duct tape

4) (2) Helpers with brooms

5) Pair of safety glasses

BE SAFE! ALWAYS FOLLOW THESE RULES

THIS PRODUCT IS INTENDED FOR USE BY CHILDREN 8-14 YEARS OLD

• To be setup and installed only by an Adult.

• Adult supervision is required at all times.

• Maximum weight 150lbs (68kg). This zipline is designed for children

to ride a few feet off ground.

• Wear suitable shoes and close fitting clothing. No jewelry, scarves

or other loose clothing.

• Make sure everything is installed correctly. Inspect and test the

line before each use.

• If worn or damaged parts are found, contact b4Adventure for

replacement parts – DO NOT substitute with other,

non-b4Adventure parts or failure resulting in injury may result.

To order parts: 1-844-834-4334.

• Remain seated for the entire ride, wait until you have stopped

COMPLETELY before letting go of the trolley or dismounting seat.

One zipline rider only at a time. Keep people and animals at

least 25ft (7.62 m) away from the zipline course.

• Never use the line when it is wet or if there is rain or lightning in the area.

• Do not place fingers or hair inside of trolley or serious injury may result.

• Do not reach up to grab cable while riding or as a spectator to slow

down rider or serious injury may result.

• For outdoor use ONLY!

QUESTIONS?

6) (2) Adjustable wrenches

7) Pair of work gloves

8) 100 ft. Tape measure

9) Torque Wrench

b4 Adventure 4040 Holly Street Unit 10 • Denver Colorado 80216 • 1-844-834-4334

info@RIP-LINE.com

www.RIP-LINE.com/help-center/

F..

WARNING:

REQUIRED - SERIOUS INJURY OR

cable attachment.

WARNING:

HAZARD

Do not attach or use a tree that is

diseased, damaged, or not healthy and stable.

Improper tree selection may cause product failure

and serious injury or even death.

WARNING:

REQUIRED

using 250 LBS (113 kg) at 5 feet (152 cm) from

each end at the Start and Finish Points.

WARNING:

REQUIREMENT

can wear or loosen during use. Inspect and

tighten all hardware. Replace your cable after one

year of use.

303-339-0482 -

RIP.904/905

READ CAREFULLY!

ADULT SUPERVISION

UN-HEALTHY TREE

ADULT STRESS TEST

This product should be tested

MAINTENANCE

This product has parts that

DC:061316

www.b4adventure.com

Table of Contents

Need help?

Do you have a question about the ZIPLINE and is the answer not in the manual?

Questions and answers

Summary of Contents for RIPLINE ZIPLINE

Page 1 READ CAREFULLY! Thank you for your purchase of the RIPLINE™ ZIPLINE! This product was engineered to provide safe fun for ages 8 to 14 years when the instructions and rules are followed. For best and safe results please read and follow all instructions carefully when installing and riding your RIPLINE™...
Page 2 Start Point Launching - CAUTION - The best and safest way to launch your riders, is to have them first get on the zipline seat at the lowest part of your course (where the most dipping/sagging occurs) and then tow them back up to the starting point.
Page 3 SET UP AN UNSAFE ZIPINE. have the rider accelerate at first, then at the last third of A steep zipline course or one that has too much line the course start decelerating and finish the course actually tension will create an unsafe, dangerous, high-speed going slightly uphill at the end, due to “dipping”...
Page 4 This will help you pull out the slack and attach your U-Clamps. When you wrap your zipline around the finishing point tree, you want to form a “tear drop” shaped wrap around the tree-See illustration below. Do not tighten up tight against the tree! •...
Page 5 TIGHTENING YOUR ZIPLINE Using the turnbuckle to tighten - Inspect your initial installation work carefully and thoroughly. The zipline cable can hold weight many times that of most riders. The loops, u-clamps and attachment trees are the most likely to fail, if not assembled correctly, and therefore should be inspected extra carefully and often.
Page 6 FINAL TUNING • After the Course Speed Test, your zipline cable may “stretch” a little (which is normal) and require some additional tightening by using your turnbuckle. • Check the tightness of all nuts and bolts of all clamps, the turnbuckle and the trolley.
Page 7 2. Do not move in front of, behind or in close proximity to a moving rider. 3. The best and safest way to launch your riders, is to have them first get on the zipline seat (or grip the trolley handle) at the lowest part of your course (where the most dipping/sagging occurs) and then tow them back up to the starting point and then carefully release them.
Page 8 Check all protective coverings: Trolley frame, grips and seat. Replace if they are loose, damaged, cracked or missing. Use ONLY genuine b4Adventure parts! • Check all moving parts including zipline swing seat, ropes, cables, and hardware for wear, rust, or other deterioration. Replace as needed. •...
Page 9 • Check the cable connection heights to make sure they have not slipped or changed height. At the end of each play season or when the temperature drops below 32F (0C): • Take down your entire zipline (including plastic swing seat) and store indoors, in a cool, dry location. •...
Page 10 4. Before each use, check to see that obstructions and hazards are removed from the zipline path and that all non-users are at a safe distance from that path. 5. Avoid taking risks. The buyer, installer and user of this product assume all risk and accept all responsibility for any damage or injury, including death, that may arise from the use of the RIPLINE™...