Download Print this page

Advertisement

Lüftungsgeräte
Air Handling Units
Montage-, Betriebs- und
Wartungsanleitung
Assembly, Operation and
Maintenance Instructions
Technische Änderungen vorbehalten!
Version: 09/2015

Advertisement

loading
Need help?

Need help?

Do you have a question about the Airset and is the answer not in the manual?

Questions and answers

Summary of Contents for Troges Airset

  • Page 1 Lüftungsgeräte Air Handling Units Montage-, Betriebs- und Wartungsanleitung Assembly, Operation and Maintenance Instructions Technische Änderungen vorbehalten! Version: 09/2015...
  • Page 2: Table Of Contents

    AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Inhaltsverzeichnis Table of contents Allgemeines ..................- 3 - General Hinweiszeichen ............... - 3 - Instruction Signs Sicherheitshinweise ............- 4 -...
  • Page 3: Allgemeines

    AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Allgemeines General Diese Montage-, Betriebs- und Wartungs- These Assembly, Operation anleitung gilt ausschließlich für TROGES Maintenance Instructions apply exclusively Lüftungsgeräte Typen...
  • Page 4: Sicherheitshinweise

    AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Sicherheitshinweise Safety instructions Für die Montage, Inbetriebnahme und Only adequately qualified personnel Wartung des Lüftungsgerätes darf nur may be employed for the assembly,...
  • Page 5: Anlieferung

    AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Beachten unbedingt Note the condensation limits of casing. Kondensationsgrenzen. Tabelle 1 zeigt den Table 1 shows the coherence between Zusammenhang zwischen Temperaturdifferenz temperature difference outside and inside Außen...
  • Page 6: Transport

    AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions In beiden Fällen muss jedoch vor dem Einbau In both cases get into contact with Lüftungsanlagen Troges TROGES Ges.m.b.H, before the AHU is Ges.m.b.H.
  • Page 7: Lagerung

    AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Bild 1a Bild 1b figure 1a figure 1b Lagerung Storage längerer Zwischenlagerung sind On prolonged intermediate storage the air Lüftungsgeräte in geschlossenen, sauberen, handling units must be kept in closed, trockenen, gut durchlüfteten und temperatur-...
  • Page 8: Aufstellung

    AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Aufstellung Installation Für die Aufstellung der Geräte ist ein ebener, A level, horizontal, dry and clean floor is waagrechter, stabiler, trockener...
  • Page 9: Assembling

    AIRSET AIRSET X-Large Use external brackets with hexagon-head Gerätegrößen 06.03 – 09.08 werden mit bolts M6 x 20 for AIRSE and AIRSET X-Large außenliegenden Verbindungswinkel with sizes from 06.03 to 09.08 (figure 3). Sechskantschrauben M6 x 20 miteinander verbunden (Bild 3).
  • Page 10 AIRSET AIRSTE X-Large Use internal clamps with hexagon-head Gerätegrößen 09.09 – 30.30 werden mit bolts M10 x 15 for AIRSET and AIRSET X- innenliegenden Verbindungsklammern Large with sizes from 09.09 to 30.30 (figure Sechskantschrauben M10 x 15 miteinander verbunden (Bild 4).
  • Page 11: Airset

    AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Grundrahmen sind mit eigenen Klammern zu Base frames must be joined with special verbinden. Die Klammern werden in die, im clamps. The clamps are engaged in the Grundrahmen eingefrästen...
  • Page 12: Inbetriebnahme Und Wartung

    AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Bild 9 figure 9 Nach Beendigung Montagearbeiten Following completion of the assembly müssen alle Bedienungstüren ihre work, check all operating doors to ensure Öffenbarkeit und Leichtgängigkeit überprüft,...
  • Page 13: Bild 10

    AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Ventilatorteil Fan section Inbetriebnahme Start-up: Transportsicherungen entfernen Remove transport locks Inbetriebnahmen Start up only with connected duct Attention angeschlossenen Kanalsystem system and closed maintenance doors geschlossenen Revisionstüren - Gefahr...
  • Page 14 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Messung Motorstromes allen Measure the motor current in all 3 phases. Phasen. Motorstrom darf The motor current must not exceed the Typenschild angegebenen Nennstrom nicht rated current specified on the rating plate.
  • Page 15 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Keilriemen korrekte Spannung Check V-belts for correct tension • • überprüfen (Tabelle 2). (table 2). Keilriemenscheiben auf Flucht prüfen und Check V-belt pulley alignment and •...
  • Page 16 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Die Taschen der untersten Filterreihe dürfen The filter bags of the lowest filter line may nicht am Geräteboden aufliegen. Die Filter not lie on the floor panel.
  • Page 17 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions In der Zuleitung soll bauseitig ein Filter bzw. Filters or dirt traps have to be situated at Schmutzfänger eingebaut werden. the inlet pipe.
  • Page 18 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Elektroerhitzer Electric heater Inbetriebnahme Start-up: elektrischen Anschluss Only a certified electrician is allowed to Lüftungsgerätes darf eine connect the electric power to the AHU.
  • Page 19: Bild 11

    AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Der Sifon muss immer mit Wasser gefüllt sein. The siphon must always be filled with water. Die Sifonhöhen müssen entsprechend dem The siphon levels must be designed in Geräteinnendruck ausgelegt werden (Bild 11...
  • Page 20: Direktverdampfer / Kondensator

    AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Siphon kontrollieren Bedarf Check siphon replenish • • nachfüllen. required. Tropfenabscheiderlamellen Check drop eleminator elements for • • Verschmutzung prüfen und bei Bedarf...
  • Page 21: Plattenwärmetauscher

    AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Plattenwärmetauscher Plate heat exchanger Inbetriebnahme Start-up: Die Funktion des Plattentauschers ist rein operation plate heat statisch und bedarf daher keiner besonderen...
  • Page 22 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Sitz umlaufenden Dichtelemente Check the seat of the sealing elements kontrollieren, gegebenenfalls nachstellen. and adjust them if required. vorhandener Bypassregelung If a bypass control exists check the bypass Bypassklappen auf Funktion prüfen.
  • Page 23 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Inbetriebnahme Start-up: gekoppelten Klappen With connected dampers check the Verbindungsgestänge zu kontrollieren. connection rods. Verbindungsgestänge muss so justiert werden, Adjust the connection rods, in order dass ein Öffnungswinkel von 90°...
  • Page 24 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Das Schwimmerventil ist so einzustellen, dass Set the float valve so that it closes at a es bei einem Wasserstand von 5-10mm water level of 5 –...
  • Page 25 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Abschlämmwassermenge muss The sludge water discharge quantity must eingestellt werden, dass sich be adjusted so that the water quality does Wasserqualität im Betrieb nicht übergebühr...
  • Page 26: Honey Comb

    AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Verdunstungsbefeuchter Honey comb Inbetriebnahme Start-up: Inbetriebnahme elektrische Start-up electrical connection Anschluss separat beiliegenden described in the separately enclosed Betriebsanleitung des Befeuchterherstellers zu operating instructions of the humidifier entnehmen.
  • Page 27 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions nach Elektrodentype sind Depending on the electrode type, the • • Elektroden entweder auszubauen und zu electrodes must either be removed...
  • Page 28 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Entsorgung Disposal Entsorgung einzelnen Only a certified company is allowed to Anlagenkomponenten muss durch eine dispose the individual parts of the air Fachbetrieb erfolgen.
  • Page 29 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Inbetriebnahmeprotokoll AuftragsNr.: ______________________________ PosNr.: ___________________________________ Auftrag: _________________________________ Anlage: __________________________________ Type ______________________________________________________________________________ Zuluft: Ventilator: Type: ____________________ Luftmenge soll [m³/h]: _______________ Luftmenge ist [m³/h]: ________________...
  • Page 30: Start-Up Journal

    AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Start up journal: OrderNo.: ___________________________________ PosNo. ______________________________________ Project: _____________________________________ Unit: ________________________________________ Type: ____________________________________________________________________________________ Supply: Fan: Type: ______________________ Set air quantity [m³/h]: ______ Actual air quantity [m³/h]: ____________________...
  • Page 31 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Leistungsumfang und Intervalle für die Wartung Quelle: VDMA 24186 Teil 0 und VDMA 24186 Teil 1. Anwendungsbereich und Zweck: Diese Blatt gilt für raumlufttechnische Geräte und Anlagen, die in der Raumlufttechnik Anwendung finden.
  • Page 32 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Ausfüh- Ausfüh- Tätigkeiten Tätigkeiten rung rung An Baugruppen und An Baugruppen und Elementen Elementen Luftfördereinrichtung Wasserablauf und Ventilatoren Geruchsverschluss auf Auf Verschmutzung, Funktion prüfen...
  • Page 33 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Ausfüh- Ausfüh- Tätigkeiten Tätigkeiten rung rung An Baugruppen und An Baugruppen und Elementen Elementen Ionisationsdrähte auf Dampfbefeuchter mit eigenem Dampferzeuger Beschädigung prüfen Auf Verschmutzung, Ionisationsdrähte...
  • Page 34 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Ausfüh- Ausfüh- Tätigkeiten Tätigkeiten rung rung An Baugruppen und An Baugruppen und Elementen Elementen Bauelemente des Luftverteilsystems Luftdurchlässe Wetterschutzgitter und sonstige Gitter Textile Luftdurchlässe auf...
  • Page 35 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Ausfüh- Ausfüh- Tätigkeiten Tätigkeiten rung rung An Baugruppen und An Baugruppen und Elementen Elementen Antriebskupplung Auf Befestigung und Auf Verschmutzung, Geräusch Prüfen Beschädigung, Korrosion und...
  • Page 36: Scope Of Services

    AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Scope of services Source: VDMA 24186 part 0 and VDMA 24186 part 1. Scope of application and intention: This hand out apply for air handling units. AHU’s are units to discharge and guarantee the room air conditions.
  • Page 37 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions activities interval activities interval components and components and elements elements Air discharge device Grease all regreasable Fans bearings Check pollution, damaging, Check function of sealing corrosion and fastenings.
  • Page 38 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions activities interval activities interval components and components and elements elements Filter for suspended matter Check function of regulation (Global activities can not be valve appointed.
  • Page 39 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions activities interval activities interval components and components and elements elements Damper actuator see VDMA 20186 part 4 Check tight seat of connection...
  • Page 40 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Anschlussbilder Connection Diagrams Schaltung der Wicklungsstränge Circuit of the winding phases Schaltung für 1 Drehzahl 1 speed winding zB.: 3000 1/min oder 1500 1/min e.g.
  • Page 41 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Schaltung der Wicklungsstränge Circuit of the winding phases Schaltung am Klemmbrett Circuit on the therminal bord niedriege Drehzahl mittlere Drehzahl hohe Drehzahl...
  • Page 42 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions - 42 -...
  • Page 43 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions - 43 -...
  • Page 44 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions - 44 -...
  • Page 45: Declaration Of Conformity

    AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions Konformitätserklärung Declaration of Conformity - 45 -...
  • Page 46 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions...
  • Page 47 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions...
  • Page 48 AIRSET – Montage-, Betriebs- und Wartungsanleitung T R O G E S AIRSET – Assembly, Operation and Maintenance Instructions TROGES P TROGES P RODUKTPALETTE RODUCT ANGE AIRSET Lüftungsgeräte (Standard, Hygiene, wetterfest) AIRSET und BONOBOX Air Handling Units (AHU) standard, hygienic, weatherproof BONOBOX Lüftungsgeräte (Standard, Hygiene, wetterfest)

This manual is also suitable for:

Airset x-large