Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for Hydro EvoClean 1222GB
Summary of Contents for Hydro EvoClean 1222GB
- Page 1 user manual EvoClean ( 1221GB, 1222GB, 1223GB, 1224GB, 1225GB, 1226GB, 1227GB, 1228GB, 1230GB, 1231GB, 1232GB, 1233GB, 1234GB, 1235GB, 1236GB, 1237GB, 1238GB, 1239GB, 1214RAPAPAC, 1216RAPAPAC, 1234GBAPAC, 1235APAC2, 1235GBAPAC, 1218RAPAPAC, 1218RGBAPAC2) HYD90099594...
-
Page 2: Table Of Contents
8.2 Advised 9. specifications 10. troubleshooting 11. unit diagram & replacement parts 11.1 Replacement parts 11.2 Accessory parts 12. decommissioning and disposal 13. warranty 14. WEEE - waste electrical and electronic equipment 15. electrical approvals Page 2 Hydro Systems Europe 2018... -
Page 3: Introduction
The unit MUST be disconnected from its power source installation and operation of this Alarm are in accordance during cleaning, servicing or when replacing parts. with this Installation and User Manual and local and national regulations. Hydro Systems Europe 2018 Page 3... -
Page 4: Description
1235GBAPAC – EvoClean 2, 6 Product Unit – High Flow, RFS, EP • 1218RAPAPAC – EvoClean 2, 8 Product Unit – High Flow, RFS • 1218RGBAPAC2 – EvoClean 2, 8 Product Unit – High Flow, RFS, EP *other versions are available on request Page 4 Hydro Systems Europe 2018... -
Page 5: Contents Of Packaging
1. Connect incoming water supply using fittings provided. This will either be a 3/4” female Garden Hose fitting, or a 1/2” O.D. 2. A locally approved back-flow prevention device (not provided) may be required for sale and legal operation. Hydro Systems Europe 2018 Page 5... -
Page 6: Installation & Connection
If the unit is configured with the off-board controller, this can be mounted using the hook and loop tape supplied. Note: Please secure any cables so as not to create a hazard for the operator. Page 6 Hydro Systems Europe 2018... -
Page 7: Installation Step 2: Incoming Water Supply
5.4. Installation Step 4: Routing Pickup Tubes Check Valves Note: The check valves are supplied detached in a bag with the unit. To prevent damage, do not install hoses to the check valve while connected to the manifold. Hydro Systems Europe 2018 Page 7... -
Page 8: Installation Step 5: Trigger Connections
5.4.3. Cut the 12.7mm (½’’) or 13mm ID Flexible PVC Hose tube to length. Note: Alternative hose options are available. Contact Hydro Systems for further information. 5.4.4. Push the PVC hose on to the detached check valve and secure with cable tie, then push the elbow into the eductor and secure with the clip, as shown in the diagram on the next page. - Page 9 Use appropriate terminal connectors to connect the signal wires to the laundry machine. 5.5.5 If one or more trigger wires are not used, they do not need to be connected but should be suitably isolated and secured. Hydro Systems Europe 2018 Page 9...
-
Page 10: Installation Step 6: Power
There is a handy wall bracket that allows the remote select to be mounted and removed as necessary. The wall bracket can be installed using the double sided tape provided (front of machine) or using screws (wall), not supplied. Page 10 Hydro Systems Europe 2018... -
Page 11: Installation Step 8: Off Board Controller (Optional)
Once set the unit will then prompt the installer to set one of the six languages (English, French, German, Italian, Spanish or Japanese) that are preprogrammed into the EvoClean. Select Language? Back i h Yes ENGLISH Back i h Set Hydro Systems Europe 2018 Page 11... -
Page 12: Menu Structure
6.2.2. It is advisable to refer to the menu structure at the end of this section when navigating through screens, until you are familiar with the sequence. 6.3. Unit Controls 6.4. User Screens Page 12 Hydro Systems Europe 2018... -
Page 13: Setup & Programming Step 1: Program Controller
Machine Size – This is set to the size of the washer extractor being installed. This can be set from 1 – 200kg. All chemical delivery settings refer to this figure when calculating the amount of chemical to be injected during a formula. 6.5.3. Operational Mode – As detailed in section 6.1. Hydro Systems Europe 2018 Page 13... - Page 14 When the select button is pressed in order to move to the right, if an ‘s’ has been selected an additional screen is shown. This will allow the user to adjust the mls/kg amount. P Chemicals: 1s2x3x4x Page 14 Hydro Systems Europe 2018...
- Page 15 6.5.9. Set Date/Time This can be set here and is used to record when certain operations have taken place. The date and time is also used during the downloading of reports. YYY-MM-DD HH:MM 2016-10-19 11:45 Hydro Systems Europe 2018 Page 15...
-
Page 16: Setup & Programming Step 2: Priming
‘Enabled’ will reset all volume estimates to full drum values. 6.8.6. The ‘Alarm Reset’ menu shows the estimated volume remaining in the drum as well as offering the option to reset it to full again. Page 16 Hydro Systems Europe 2018... -
Page 17: Formula Editor
The EvoClean allows the addition of an external sensor. This should be a micro-switch type in a NO (normally open) state when sufficient chemical is present. 6.9. Formula Editor 6.9.1. To aid programming of the unit a PC application can be downloaded from the Hydro Systems Europe website (www.hydrosystemseurope.com) 6.9.2 This will allow the installer to produce and edit programs remotely that can then be installed on the EvoClean using a USB storage device. -
Page 18: Usb Insert Memory Stick
Enter date to: 2016-MM-DD 2016-MM-DD Back Events Report? Enter date from: Enter date to: 2016-MM-DD 2016-MM-DD Back Customer Passcode ( See 6.5.7.5) Enter Passcode: 0*** Usage Report? Enter date from: Enter date to: 2016-MM-DD 2016-MM-DD Back Page 18 Hydro Systems Europe 2018... -
Page 19: Settings Screen
7.3. Settings Screen Hydro Systems Europe 2018 Page 19... -
Page 20: Set Up Screen
7.4 Set up screen Page 20 Hydro Systems Europe 2018... - Page 21 Hydro Systems Europe 2018 Page 21...
-
Page 22: Maintenance
Min. (High Flow 4L/Min) 0.2 mPa (2.0 Bar / 29 PSI) Electrical Class Class II SYSTEM CABINET Cabinet Material Front Rear PP-TF 4 Product Size (mm) 6 Product Height Width Depth 8 Product IP RATING IP22 Page 22 Hydro Systems Europe 2018... -
Page 23: Troubleshooting
Issues listed here are to be investigated and resolved by a competent engineer. Any fault conditions not listed within this manual should not be attempted to be fixed/replaced without the advice of Hydro Systems Europe (Any unauthorised attempts to repair the unit will invalidate the warranty). - Page 24 2 detail Page 24 Hydro Systems Europe 2018...
-
Page 25: Replacement Parts
Components shown on the following page should only be replaced by a competent engineer. Any components not listed within this section should not be attempted to be replaced without the advice of Hydro Systems Europe (Any unauthorised attempts to repair the unit will invalidate warranty). -
Page 26: Accessory Parts
12. decommissioning & disposal Hydro products are manufactured from materials which can • Safe for disposal sign/note appended to each piece of be recycled. Dispose of Hydro products in accordance with listed items the current local regulations. • The items have been left in a condition such that it is safe for lay personnel or contractor to remove it without need •... -
Page 27: Warranty
The Low Level Alarm unit is a product placed onto market POST 13.08.05 , therefore called ‘future WEEE’. As a producer Hydro Systems Europe have the option to take responsibility for the EEE placed on the market. If Hydro Systems Europe chooses to receive WEEE they must make sure that it is disposed of in an environmentally sound way, including the treatment, reuse, recovery and recycling of the components where appropriate. -
Page 28: Electrical Approvals
Electromagnetic compatibility (EMC). Generic standards. Immunity for residential, commercial and light-industrial environments. BS EN 61000-6-3 : 2007+A1:2011 Electromagnetic compatibility (EMC). Generic standards. Emission standard for residential, commercial and light-industrial environments. Hydro Systems Europe Ltd. Phone +44 (O)1344 48888O HYD90099594 Evoclean 2 Fax +44 (O)1344 488879 Unit 3 The Sterling Centre, hydrosystemseurope.com...
Need help?
Do you have a question about the EvoClean 1222GB and is the answer not in the manual?
Questions and answers