Summary of Contents for HyproTherm FLFA - 2000
- Page 1 INSTALLATION AND OPERATING INSTRUCTIONS THE HYPROTHERM FRONT LOADING FORCED AIR FURNACE Manufactured by HyproTherm, LLC Salem, Arkansas 72576 870-895-2688...
- Page 2 The HyProTherm Furnace was the first and is the leader in the Outside Wood Burning Furnace field. We sell furnaces as far away as Canada, the UK, Ireland, the Ukraine and Spain!
-
Page 3: General Information
(available at ACE Hardware). Front: 10 feet, with the door facing away from the structure. Flooring: Non-Combustible FURNACE DIMENSIONS HyProTherm FLFA -1,000 Heats; up to 3,500 sq ft. 62"L x 46"W x 87"H 1,720 lb shipping weight HyProTherm FLFA -2,000 Heats;... -
Page 4: Safety Precautions Warning
SAFETY PRECAUTIONS WARNING Do not operate this equipment for other than its intended purpose nor other than in accordance with the instructions contained in this manual and all other instructions accompanying the furnace. For furnaces covered by this instruction book, it is important to observe safety precautions to protect yourself from possible injury. -
Page 5: Year Limited Warranty
HyProTherm Outdoor Wood Furnace 20 Year Limited Warranty 25 Year Warranty on roof and siding! We have a 5-YEAR warranty on the FIREBOX - NOT prorated. We have a 20-YEAR warranty on the whole furnace - Parts AND Labor. The water jacket has a 10-year warranty. - Page 6 • non-compatible fuels, destructive and/or damp fuels (treated wood, etc...); • consumption exceeding the use limits; • a lack of maintenance; • the use of electrical or electronic components that are not approved by Hyprotherm Manufacturing LLC. • any modification, transformation inside the appliance;...
- Page 7 OUTDOOR FURNACE BEST BURN PRACTICES 1. Read and follow all operating instructions supplied by the manufacturer. FUEL USED: You may burn any hardwood (or softwood), as well as pallets that have been split up and coal but NEVER burn driftwood, painted, stained or pressure or/and chemically treated wood. Never use the following: trash, plastics, gasoline, rubber, naphtha, household garbage, material treated with petroleum products (particle board, railroad ties and pressure treated wood), leaves, paper products, and cardboard.
- Page 8 THE HYPROTHERM OUTDOOR WOODBURNING FURNACE How does an outdoor furnace heat my home? The HyProTherm outdoor wood furnace is designed to save the most energy and provide the most comfortable heating available. It heats your home by heating a firebox surrounded by a steel air chamber.
- Page 9 HyProTherm FLFA -1000 - 46” x 62” Suggested pad size 48” x 110” HyProTherm FLFA - 2000 - 46” x 76” Suggested pad size 48” x 124” HyProTherm FLFA - 3000 - 46” x 89" Suggested pad size 48” x 137”...
- Page 10 Connection of Power to Furnace This furnace must be wired by a qualified electrician in accordance with the National Local and/or State Electrical Code. There are two insulated wires in a 12/2 wire; black, white and an uninsulated ground wire. Black is hot (from 110V source) White is common (from 110V source)
- Page 11 This furnace must be wired by a qualified electrician In accordance with the National or/and County/State Electrical Code. Wiring running to house 12/2 with Ground will run from inside house, and will connect to your HyProTherm Furnace under the back access door, as will the thermostat wires.
- Page 12 Starting a Fire Use small pieces of split kindling together with crumbled newspaper or cardboard, and add larger pieces. Kiln dried lumber (as shown) works great!! Remember: The smaller the better, the dryer the better.
- Page 13 If you have poor draft, heat up the chimney by twisting some newspaper into a torch and hold it up into the stove until the draft is reversed. If it is difficult to start the fire the reasons could be: Not enough air: Make sure that fan is on or open the ash door (approx.
-
Page 14: End Of Season
Do Not consider outdoor wood furnaces for built up urban areas. The HyProTherm furnace is not intended to be the only source of heat. Therefore a backup system should always be in place and be ready for use. - Page 15 Owner assumes all responsibility for this. This is just a general manual to aid in installation. We cannot know all applicable codes in your area! HyproTherm, LLC Salem, Arkansas 72576 870-895-2688...
Need help?
Do you have a question about the FLFA - 2000 and is the answer not in the manual?
Questions and answers