Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for Arctic Cat ZR 200
Summary of Contents for Arctic Cat ZR 200
- Page 2 Snowmobile. Arctic Cat does not assume any liability for incidental or consequential damages. Arctic Cat will repair or replace, at its option, free of charge (including any related labor charges), any parts that are found to be warrantable in material or workmanship. This repair work MUST be done by an authorized Arctic Cat Snowmobile dealer.
-
Page 3: Table Of Contents
Table Of Contents Limited Warranty..........Inside Front Cover Foreword..................3 Specifications ................4 Getting Ready to Safely Operate the ZR 200 ........ 5 Operating the ZR 200 ..............6 General Information ..............7-8 Control Locations................. 7 Snowmobile Identification ............7 Gasoline - Oil ................ - Page 4 Phone: _________________________________________________ Parts and Accessories When in need of replacement parts, oil, or accessories for your Arctic Cat snowmo- bile, be sure to use only GENUINE ARCTIC CAT PARTS, OIL, AND ACCESSO- RIES. Only genuine Arctic Cat parts, oil, and accessories are engineered to meet the standards and requirements of your Arctic Cat snowmobile.
-
Page 5: Foreword
The ZR 200 Snowmobile is intended to be a learning/recreational snowmobile. The rider of the ZR 200 must be a responsible operator, at least 13 years of age, and under adult supervision. This snowmobile is intended to be ridden by the operator only;... -
Page 6: Specifications
Specifications ENGINE AND DRIVE Type Forced Air Cooled/4-Cycle Bore x Stroke 70 x 50 mm (2.76 x 1.97 in.) Valve Arrangement Overhead Displacement 192 cc (11.7 cu in.) Lighting Coil Output 96W @ 3000 RPM Lubrication Forced Splash Cooling System Forced Air Drive Clutch Arctic 5.25 in. -
Page 7: Getting Ready To Safely Operate The Zr 200
B. Make sure the throttle lever works NOTE: This section and Operating properly (moves freely) and that it the ZR 200 section must be read and snaps back to the idle position explained to the operator by the quickly when it is released. The idle owner/parent/guardian. -
Page 8: Operating The Zr 200
Operating the ZR 200 You must be a responsible, careful, and C. Never drive the snowmobile faster considerate snowmobile operator at all than a safe speed. Do not drive too times. Your safety is our concern and close to roads, buildings, trees, other must always be yours. -
Page 9: General Information
0744-926 These numbers are required by the dealer to complete warranty claims properly. No warranty will be allowed by Arctic Cat if either the ESN or VIN is removed or mutilated in any way. -
Page 10: Engine Break-In
After the 10 hour break- Recommended Oil in period, the snowmobile may be taken to an authorized Arctic Cat Snowmobile NOTE: This snowmobile comes dealer for a checkup and oil change. This... -
Page 11: Operating Instructions
Allow a cold engine to “warm up” should malfunction, take the snow- for approximately 2-3 minutes. The mobile to an authorized Arctic Cat choke should be pushed in com- Snowmobile dealer for service. pletely after the “warm up.” Release the parking brake. -
Page 12: Periodic Maintenance/Tune-Up Chart
Periodic Maintenance/Tune-Up Chart 1st 10 Every 20 Every 50 Every 100 Every 300 Daily Hours Hours Hours Hours Hours (2 Weeks) (1 Month) (3 Months) (6 Months) (12 Months) Valve Clearance Engine Compression Spark Plug Fuel Supply Hose Replace every 3 years Carburetor Float Chamber... -
Page 13: Maintenance
Maintenance Engine Oil NOTE: If the oil level is below the oil level mark, add recommended oil NOTE: After the engine break-in until it reaches the oil level mark. period, the engine oil should be changed every 100 operating hours (6 4. -
Page 14: Carburetor
Since carburetor adjustments criti- cally affect engine performance and emissions, Arctic Cat recommends that any changes in internal carburetor cali- bration be made by an authorized Arctic Cat Snowmobile dealer; however, three... -
Page 15: Spark Plug
Cat Snowmobile dealer if the plug insula- ! WARNING tor is not a light brown color. To help pre- Use only Arctic Cat approved DOT 4 vent cold weather fouling, make sure to brake fluid. Never substitute or mix thoroughly warm up the engine before different types or grades of brake operating. -
Page 16: Track Tension
“lock up” the track. ately take the snowmobile to an autho- 3. Repeat procedure 10-15 times allow- rized Arctic Cat Snowmobile dealer for ing some cooling between stops. service. If not under warranty, this ser- vice is at the discretion and expense of ! WARNING the snowmobile owner. -
Page 17: Track Alignment
Excessive wear to the idler wheels, drive lugs, and track will occur if the track is improperly aligned. Arctic Cat recom- mends that the track alignment be checked once a week or whenever the track tension is adjusted. -
Page 18: Adjusting Rear Spring Tension
Checking Track Alignment ! WARNING Make sure the ignition key is in the OFF position and the track is not rotating before checking or adjust- ing track alignment. Personal injury could result if contact is made with a rotating track. 1. -
Page 19: Ski Alignment
Loctite #243 to the jam object is hit while the snowmobile is being nut threaded areas and tighten each operated. Arctic Cat recommends that the jam nut securely against its adjust- ski alignment be checked once a week. -
Page 20: Ski Wear Bar
0744-923 To maintain positive steering characteris- CAUTION tics, Arctic Cat recommends that the ski Serious overheating of the engine wear bars be checked once a week and and engine damage will result if the replaced if worn to 1/2 of original diame- air vents are not kept clean. - Page 21 2. Remove the bulb from the housing 5. Engage the brake lever lock and start by rotating it counterclockwise until the engine. Move the headlight dim- loose. mer switch to the HIGH beam posi- tion. DO NOT USE LOW BEAM. CAUTION 6.
-
Page 22: Preparation For Storage
6. Change the oil. nent deterioration. Arctic Cat recom- mends the following procedure to 7. Tighten all screws, nuts, and cap prepare the snowmobile for storage. -
Page 23: Preparation After Storage
Arctic Cat rec- alignment, brake pads, and ski wear ommends the following procedure to bars; adjust or replace as necessary. -
Page 24: Snowmobile Safety Rules
Snowmobile Safety Rules... -
Page 25: Epa Emission Control Statement/Warranty Coverage - Snowmobile (U.s. Only)
Coverage - Snowmobile (U.S. Only) STATEMENT/WARRANTY Arctic Cat warrants to the original retail purchaser, and each subsequent purchaser, that all U.S. EPA- certified Arctic Cat snowmobiles are designed, built, and equipped to conform to all U.S. EPA Emission Control Regulations. Please read the following information completely. -
Page 26: Declaration Of Conformity
Standards to which conformity is declared: EMC: EN 55012, EN 61000-6-2 MACHINERY: 2006/42/EEC Manufacturer (if not issuing agent): Arctic Cat Inc. 601 Brooks Ave. S. Thief River Falls, MN 56701 USA I, the undersigned, hereby declare that the equipment specified above conforms to the directive(s) and standard(s) as specified. -
Page 27: Change Of Address, Ownership, Or Warranty Transfer
Please make sure a copy of this form is completed and returned to Arctic Cat Inc. if you move or if the vehicle is sold to another party. This form may also be used to transfer the unused portion of the original warranty to a second party. - Page 28 Fold Back Place Stamp CHANGE OF ADDRESS/OWNERSHIP Here ARCTIC CAT INC. PRODUCT SERVICE AND WARRANTY DEPT. P.O. BOX 810 THIEF RIVER FALLS, MN 56701...
- Page 29 NOTES...
-
Page 30: Warranty Procedure/Owner Responsibility
You, the consumer, will then be asked to sign a warranty form to ensure Arctic Cat that the warranty work was actually performed.
Need help?
Do you have a question about the ZR 200 and is the answer not in the manual?
Questions and answers