Page 1
DVDR3575H/05/31/58 DVDR3577H/05/31/51/58 DVDR3595H/05/31/51/58 DVDR3597H/05/31/58 Service Package Version 1.1 The table below gives the summary of all the files in the service package. Please refer to this document for the required information. Chapter No. Reference Document & Instructions Chapter 1 Technical Specifications and...
Page 2
Chapter 7 Electrical Circuits & Layout 1. Front Panel: Drawings, Test Point View, Waveforms 2. Analog Board 3. Digital Board 4. HDMI Board Chapter 8 Exploded View and Service Parts List Chapter 9 Revision List...
Page 3
Power consumption: 35 W Standby Power consumption: <3.5 W 1.3. RF Tuner (Analogue) Test equipment: Fluke 54200 TV Signal generator Test streams: PAL BG Philips Standard test pattern 1.3.1.1. System B/G, I, L/L’, D/K 1.3.2. RF – Loop Through: Frequency range: 43 MHz –...
Page 4
Audio Performance (Analogue Mono): Frequency response (100 Hz – 12 kHz) relative to 1 kHz: 0 ± 3dB ≥ 40 dB S/N Ratio unweighted (quasi peak, 22Hz – 22kHz): ≥ 45 dB S/N Ratio weighted (quasi peak, CCIR 468): ≤ 1.5 % Harmonic distortion at 1kHz: FM±...
Page 5
CVBS-out 1Vpp ± 0.1V into 75Ω CVBS-in Shield 1.4.2. SCART 2 (Connected to AUX) Pin Signals: Audio-out R 1.8V RMS Audio-in R Audio-out L 1.8V RMS Audio GND Blue GND Audio-in L Blue-in Function switch Green GND P50 control not used Green-in Red GND Fast switch GND...
Page 6
1.5. Digital Inputs/Outputs 1.5.1. DV IN CAM 2 (IEEE 1394 Digital Video Input) Implementation standard according: IEEE Std 1394-1995 IEC61883 - Part1 IEC61883 - Part 2 SD-DVCR (02-01-1997) Specification of consumer use digital VCR’s using 6.3mm magnetic tape – dec.1994 Mechanical connection according to Annex of IEC 61883-1 1.5.2.
Page 7
1.7. Audio Performance 1.7.1. Cinch Output Rear Output voltage 2 channel mode: 2Vrms ± 1dB Channel unbalance (1kHz): < 0.22 dB Crosstalk 1kHz: > 110 dB Crosstalk 16Hz-20kHz: > 110 dB ≤ |0.2| dB Frequency response: Signal to noise ratio (unweighted): >...
Page 8
Audio Playback Playback Media: Audio CD, CD-R/RW, DVD+R DL, DVD+R/+RW, DVD-R/-RW, MP3-CD, MP3- DVD, USB flash drive, WMA-CD Compression format: Dolby Digital, MP3, MPEG2 Multichannel, PCM, WMA MPEG1 bit rates: 64-384 kbps and VBR Still Picture Playback Playback Media: CD-R/RW, DVD+R DL, DVD+R/+RW, DVD-R/-RW, Picture CD, USB Digital Camera (PTP), USB flash drive Picture compression format: JPEG, JPEG digital...
Safety Information, General Notes & Lead Free Requirements Safety Instructions Warnings 2.1.1 General Safety 2.2.1 General Safety regulations require that during a repair: • All ICs and many other semiconductors are susceptible • Connect the unit to the mains via an isolation transformer. electrostatic discharges (ESD, ).
Page 10
• On our website www.atyourservice.ce.Philips.com you find more information to: BGA-de-/soldering (+ baking instructions) Heating-profiles of BGAs and other ICs used in Philips-sets You will find this and more technical information within the “magazine”, chapter “workshop news”. Bottom line of typeplate gives a 14-digit S/N. Digit 5&6 is the year, digit 7&8 is For additional questions please contact your local repair-helpdesk.
Page 11
EXT 1 TO TV EXT 2 TO VCR/SAT TV-OUT ANTENNA-IN Record Mode Press OK to start automatic analogue channel Your Philips Recorder allows you to control the TV AUDIO COAXIAL S-VIDEO OUT AUDIO OUT DIGITAL OUT VIDEO OUT TO VCR search.
Page 12
User Manual Note Only data fi les are able to copy to USB device. The making disc copy information appears. Press See the user manual that came with your Philips Recorder RF antenna cable Scart cable the Green button again to start copying.
Page 13
. the source and programme numbers are matching for all channels. CVBS OUT Press OK to start automatic analogue channel Your Philips Recorder allows you to control the TV HDMI EXT 1 TO TV EXT 2...
Page 14
The making disc copy information appears. Press User Manual the Green button again to start copying. STOP See the user manual that came with your Philips Recorder RF antenna cable Scart cable Note It is not possible to copy the TV recordings to (connect between USB device.
Page 15
Mechanical Instructions Note: The position numbers given here refers to the Exploded view on chapter 8. 1.1. Dismantling of the DVD Tray cover manually Insert a screwdriver into the slot provided at the bottom of the set and push in the direction as shown in Figure1 to unlock before sliding the Tray cover 110 out.
Page 16
Figure 3 – Unscrew the screws to detach front panel Insulation Sheet Figure 4 - Front Panel Service Position 1.3. Dismantling of the Basic Engine Remove 4 mounting screw mounting the Basic Engine1007 from the Frame Assembly 0920 as shown in figure 5.
Page 17
Flip the Basic Engine over to remove 4 screws from the PCB protection plate. Service Position of the Basic Engine is shown in Figure 6. Insulation Sheet Figure 6 - Basic Engine Service Position 1.4. Dismantling of the PSU Board Remove 3 screws to loosen the PSU Board 1004 as shown in Figure 7.
Page 18
1.5. Dismantling of the Digital Board Remove 4 screws to loosen the Digital Board 1003 as shown in Figure 9. Figure 9 - Remove mounting screws for Digital Board Service position for Digital Board is given in Figure 10. (Remove the Digital Board Bracket 187 and take out the cables beneath it to make it easier to flip over the digital board.
Page 19
1.6. Dismantling of the HDMI Board Remove 2 screws on the Rear Plate 230 as shown in figure 11 to dismantle the HDMI Board 1006. Figure 11 – HDMI Board mounting screws Remove the HDMI Shield 190 for HDMI Board service position as shown in figure 12. Figure 12 –...
Page 20
Figure 13 – Remove mounting screws for HDD Flip over the HDD Assembly to see the mounting screws 271. Remove the screws to dismantle the HDD 1005 from the HDD assembly. Notes: Only the special type of screws as described in Service Parts List must be used for position number 271. Using improper screws may damage the mounting holes on the HDD.
Page 57
No acknowledge received from BE 90305 Communicating with the Basic Engine failed 90306 The BE returned no info Example DS:> 903 090300: BE version = 31.30.24. PHILIPS ,VAD8031 ,31302400,REL_8031_313024 2073, Optical unit version = 00.06.82.19.00 Test OK @ DS_BE_TrayOut Nucleus Name Nucleus Number Description...
Page 145
Please visit our website www.philips.com/support for further software updates and additional information Developer name: Royal Philips Product name (xxxx = model number): DVDRxxxxH Official SW release number: Software Version (xx.xx = release): xx.xx (01.00 in the example above) Press <OPTIONS> button to exit.
Page 146
When the user version info screen is appeared, press the blue key on the remote control. The TV connected to the set will display the Development Version Info Screen as shown below: Version Info (c)PHILIPS 2007 Version Information: DI L+06_12/731839 SV 11621 BE 52.07.02.17 ASP 1,18,1,10 C1_8 20070510_1309 pro lecoplusleadV1 <void>...
Page 147
The slash versions used in DVDR3575H, DVDR3577H, DVDR3595H and DVDR3597H are as follows: • DVDR3575H & DVDR3577H/31 11621 • DVDR3577H/51 11622 • DVDR3575H & DVDR3577H/58 11623 • DVDR3575H & DVDR3577H/05 11624 • DVDR3595H & DVDR3597H/31 11625 • DVDR3595H/51 11626 • DVDR3595H & DVDR3597H/58 11627 •...
Page 148
Via the Dignostic Software the “Diversity String” can be stored with the command 1226, followed by the “Diversity String” as parameter. That stored “Diversity String” can be checked with the DS command 1229. The Diversity strings used in DVDR3575H, DVDR3577H, DVDR3595H and DVDR3597H are as follows: Non-EPG Sets:DVDR3575H/05/58, DVDR3577H/05/51/58, DVDR3595H/05/51/58 & DVDR3597H/05/58: 444248497A8240014C2B30365F3132007220070000020300000101004002000044564452323030312E303031 0202000000010300010002010000020000000000 EPG Sets: DVDR3575H/31, DVDR3577H/31, DVDR3595H/31 &...
Page 151
F404 C2 1400 F400 F401 F402 F403 F404 S7B-PH-K SETNAME DVDR3570H 2007-02-16 CLASS_NO 3PB120 PCB FR0NT DVDR3570H PANEL 2007-01-10 3139 243 3645 LECOPLUS INT BD 2006-10-10 NAME Tan Peng Hock SUPERS. CHECK DATE 2006-07-27 ROYAL PHILIPS ELECTRONICS N.V. 2006 DVDR3570H/boards/3139_243_36504_01...
Page 153
Layout: Front Board (Bottom View) Front Board Bot View 3139 243 36464_sh132_a4.eps 2007-07-11...
Page 154
Layout: Front Board Testpoint Overview Front Board Testpoint 3139 243 36464_sh132_a4.eps 2007-07-11...
Page 155
Layout: Front Board (Top View) Front Board Top View 3139 243 36464_sh132_a4.eps 2007-07-11...
Page 160
F120 F2 F121 F2 F122 G2 F126 H2 ******** SETNAME DVDR3570H 2007-02-16 CLASS_NO 3PB120 PCB FRONT DVDR3570H PANEL 2007-01-10 3139 243 3645 Display Part DISP 2006-10-10 NAME TAN PENG HOCK SUPERS. CHECK DATE 2006-07-19 ROYAL PHILIPS ELECTRONICS N.V. 2006 DVDR3570H/boards/3139_243_36464_01...
Page 161
CVBSFIN_FC CFIN_FC YFIN_FC 1203 AV_FP AV_GND ******** SETNAME DVDR3570H CLASS_NO 2007-02-16 3PB120 PCB FRONT DVDR3570H PANEL 2007-01-10 3139 243 3645 FRONT CONNECTOR 2006-10-10 NAME TAN PENG HOCK SUPERS. **** *** ***** CHECK DATE 2006-07-19 ROYAL PHILIPS ELECTRONICS N.V. 2006 DVDR3570H/boards/3139_243_36464_01...
Page 162
5301 F305 F303 WH02D-1 F304 not used not used ******** SETNAME DVDR3570H 2007-02-16 CLASS_NO 3PB120 PCB FRONT DVDR3570H PANEL 2007-01-10 3139 243 3645 Standby STBY 2006-10-10 NAME Tan Peng Hock SUPERS. CHECK DATE 2006-07-19 ROYAL PHILIPS ELECTRONICS N.V. 2006 DVDR3570H/boards/319_243_36474_01...
Page 163
Analogue Board Waveforms 7202 pin 15 AOUTB 7202 pin 18 AOUTA F100 SCART1 AOUTL F102 SCART1 AOUTR F104 SCART active BOUT F107 SCART active GOUT F108 SCART active ROUT F110 SCART CVBS F308 Aud R F309 Aud L F310 CVBS-Out F311 SY out F312 SC out F326 Digital Out Cinch...
Page 164
Layout: Analog (Bottom View) Analog Bottom 3139 243 37473_sh132_a3.eps 2007-07-11...
Page 165
Layout: Analog Board Testpoint Overview) Analog Testpoint Overview 3139 243 37473_sh132_a3.eps 2007-07-11...
Page 166
Layout: Analog (Top View) Analog Top 3139 243 37473_sh132_a3.eps 2007-07-11...
Page 167
3168 A9 3169 A9 HLW30S-2C7 VMUX_1A 4109 G4 4127 B6 SETNAME 2007-06-01 CLASS_NO 3PC332 PCB ANA DVDR3575H EU PANEL 2007-04-23 OPTION 3139 243 3747 Video In/Out 2007-02-23 NAME Samantha Chow SUPERS. CHECK DATE 2007-02-23 ROYAL PHILIPS ELECTRONICS N.V. 2007 DVDR5570H/boards/3139_243_37473_01...
Page 168
3260 D11 3261 G11 3262 F12 SETNAME 2007-06-01 CLASS_NO 3PC332 PCB ANA DVDR3575H EU PANEL *OPTION 2007-04-23 3139 243 3747 Audio In/Out + DAC IOA + DAC 2007-02-23 NAME Samantha Chow SUPERS. CHECK DATE 2007-02-23 ROYAL PHILIPS ELECTRONICS N.V. 2007 DVDR5570H/boards/3139_243_37473_01...
Page 169
3350 WSRO from COM (COM_0) 5NESD 5NESD SETNAME 2007-06-01 CLASS_NO *OPTION 3PC332 PCB ANA DVDR3575H EU PANEL 2007-04-23 3139 243 3747 Progressive+Digital In/Out PROG + DIGIO 2007-02-23 NAME Samantha Chow SUPERS. CHECK DATE 2007-02-23 ROYAL PHILIPS ELECTRONICS N.V. 2007 DVDR5570H/boards/3139_243_37473_01...
Page 170
F445 F2 F446 F2 F447 B13 SETNAME 2007-06-01 * OPTION CLASS_NO 3PC332 PCB ANA DVDR3575H EU PANEL 2007-04-23 3139 243 3747 Frontend Video+Com FV + COM 2007-02-23 NAME Samantha Chow SUPERS. CHECK DATE 2007-02-23 ROYAL PHILIPS ELECTRONICS N.V. 2007 DVDR5570H/boards/3139_243_37473_01...
Page 171
7515 F11 7516 F12 7517 F5 7518-1 D6 7518-2 D7 SETNAME 2007-06-01 * OPTION CLASS_NO 3PC332 PCB ANA DVDR3575H EU PANEL 2007-04-23 3139 243 3747 POWER SUPPLY 2007-02-23 NAME Samantha Chow SUPERS. CHECK DATE 2007-02-23 ROYAL PHILIPS ELECTRONICS N.V. 2007 DVDR5570H/boards/3139_243_37473_01...
Page 173
* Not used (Provision only) SETNAME DVDR3570H / DVDR5470H /DVDR5570H / DVDR7570H 2007-04-20 CLASS_NO 3PC332 PCB LECO+ 2006 PANEL 2007-02-09 3139 243 3683 LeCoplus LECO 2006-10-10 NAME KP Pang / KY Ng SUPERS. CHECK DATE 2006-10-10 ROYAL PHILIPS ELECTRONICS N.V. 2006 LECOPLUSSTEP/boards/3139_243_36835_01...
Page 174
DVDR3570H / DVDR5470H / DVDR5570H / DVDR7570H 2007-04-20 CLASS_NO * Not used (Provision only) 3PC332 PCB LECO+ 2006 PANEL 2007-02-09 3139 243 3683 FLASH+SDRAM 2006-10-10 NAME KP Pang / KY Ng SUPERS. CHECK DATE 2006-10-10 ROYAL PHILIPS ELECTRONICS N.V. 2006 LECOPLUSSTEP/boards/3139_243_36835_01...
Page 175
DVDR3570H / DVDR5470H / DVDR5570H / DVDR7570H * Not used (Provision only) 2007-04-20 CLASS_NO 3PC332 PCB LECO+ 2006 PANEL 2007-02-09 3139 243 3683 IEEE1394 + USB DV + USB 2006-10-10 NAME KP Pang / KY Ng SUPERS. CHECK DATE 2006-10-10 ROYAL PHILIPS ELECTRONICS N.V. 2006 LECOPLUSSTEP/boards/3139_243_36835_01...
Page 176
CLASS_NO * Not used (Provision only) 3PC332 PCB LECO+ 2006 PANEL 2007-02-09 3139 243 3683 VIDEO + IDE + BOOT PROM + EJTAG 2006-10-10 NAME KP Pang / KY Ng SUPERS. CHECK DATE 2006-10-10 ROYAL PHILIPS ELECTRONICS N.V. 2006 LECOPLUSSTEP/boards/3139_243_36835_01...
Page 177
DVDR3570H / DVDR5470H/DVDR5570H / DVDR7570H 2007-04-20 * Not used (provision only) CLASS_NO 3PC332 PCB LECO+ 2006 PANEL 2007-02-09 3139 243 3683 Audio/Video Decoder 2006-10-10 NAME KP Pang / KY Ng SUPERS. CHECK DATE 2006-10-10 ROYAL PHILIPS ELECTRONICS N.V. 2006 LECOPLUSSTEP/boards/3139_243_36835_01...
Page 178
DVDR3570H / DVDR5470H/DVDR5570H / DVDR7570H 2007-04-20 CLASS_NO * Not used (Provision only) 3PC332 PCB LECO+ 2006 PANEL 2007-02-09 3139 243 3683 Microcontroller+Reset ASP + RESET 2006-10-10 NAME KP Pang / KY Ng SUPERS. CHECK DATE 2006-10-10 ROYAL PHILIPS ELECTRONICS N.V. 2006 LECOPLUSSTEP/boards/3139_243_36835_01...
Page 179
* Not used (Provision only) 2007-04-20 CLASS_NO # APAC 3PC332 PCB LECO+ 2006 PANEL 2007-02-09 & HTS 3139 243 3683 Power Supply + URD 2006-10-10 NAME KP Pang / KY Ng SUPERS. CHECK DATE 2006-10-10 ROYAL PHILIPS ELECTRONICS N.V. 2006 LECOPLUSSTEP/boards/3139_243_36835_01...
Page 180
VIP_SD0_OUT 7805 AUDIO_MUX6_SEL PDTC124EU SETNAME DVDR3570H / DVDR5470H / DVDR5570H / DVDR7570H CLASS_NO 2007-04-20 PCB LECO+ 2006 PANEL 2007-02-09 3139 243 3683 External ADC 2006-10-10 KP Pang / KY Ng SUPERS. CHECK DATE 2006-11-10 ROYAL PHILIPS ELECTRONICS N.V. 2006 $PROJECT/LECOPLUESTEP/boards/3139_243_36835_01...
Page 184
HDMI Board Waveforms F100 ITU OUT 4 F101 SDA1 F103 SCL1 F104 VO CLK F105 ITU OUT 0 F106 ITU OUT 1 F107 ITU OUT 2 F108 ITU OUT 3 F111 ITU OUT 5 F112 ITU OUT 6 F113 ITU OUT 7 F114 FSCLK12 OUT F115 SCLK12 OUT F116 SD OUT...
Page 190
DVDR3575H/05/31/58 Service Parts List 0110 313924417191 COVER TRAY 0180 313924126261 SPRING EMC 0181 313924126291 SPRING AV 0185 313911426671 BUSH, AC CORD 0190 313924320941 SHIELD HDMI DVDR3575H 0193 313924160931 SPRING ESD DVDR3570H 0230 313924126871 PLATE REAR DVDR3575H 0240 313924126951 COVER TOP DVDR3575H 0271 252220098475 SCR PAN TORX ST BK #6-32X6 0341 242254901717...
Page 191
DVDR3577H/05/31/51/58 Service Parts List 0110 313924417181 COVER TRAY 0180 313924126261 SPRING EMC 0181 313924126291 SPRING AV 0185 313911426671 BUSH, AC CORD 0190 313924320941 SHIELD HDMI DVDR3575H 0193 313924160931 SPRING ESD DVDR3570H 0230 313924126871 PLATE REAR DVDR3575H 0240 313924124232 COVER TOP...
Page 192
DVDR3595H/05/31/51/58 Service Parts List 0110 313924417171 COVER TRAY DVDR3595H 0180 313924126261 SPRING EMC DVDR3570H 0181 313924126291 SPRING AV DVDR3570H 0185 313911426671 BUSH 450H259010 0190 313924320941 SHIELD HDMI DVDR3575H 0191 313924409101 HDD DAMPER 0193 313924160931 SPRING ESD DVDR3570H 0230 313924126871 PLATE REAR DVDR3575H 0240 313924124232 COVER TOP DVDR3455H 0271 252220000027...
Page 193
DVDR3597H/05/31/58 Service Parts List 0110 313924417161 COVER TRAY DVDR3597H 0180 313924126261 SPRING EMC 0181 313924126291 SPRING AV 0185 313911426671 BUSH, AC CORD 0190 313924320941 SHIELD HDMI DVDR3575H 0191 313924409101 HDD DAMPER 0193 313924160931 SPRING ESD DVDR3570H 0230 313924126871 PLATE REAR DVDR3575H 0240 313924126941 COVER TOP DVDR3597H 0271 252220000027...
Page 195
Revision_List Version 1.0 * Initial Release Version 1.1 * Mechanical Instructions v1.1 * Firmware Upgrading, Alignment and Test Procedures v1.1 * Service parts List v1.1 Pagina 1...