SPY 785 Operating Instructions Manual
Portable pulse holiday detector
Hide thumbs
Also See for 785:
- Operating instructions manual (12 pages) ,
- Operating instructions manual (36 pages)
Related Manuals for SPY 785
Summary of Contents for SPY 785
- Page 1 S py ® model 785 / 790 p o rtab l e p u ls e holiday detector o p e r at i n g i n st r u ct i o n s p i c lt d.com...
-
Page 2: Table Of Contents
Principles of Holiday Detector Operation ....7 all over the world since 1953. With the purchase of this high precision Model 785/ 790 Pulse Holiday Detector Overview ..8 ®... -
Page 3: Operator Safety
ELECTRONICS OR RADIO EQUIPMENT. When in standby the testing procedure. Personnel operating Portable Holiday Detectors should Model 785 / 790 Pulse Holiday Detector will generate radio frequency ® be aware of the safety limitations imposed by their environment at all times. -
Page 4: Unit Calibration
1-15 kV for the 785 and 5-35 kV for the 790. Since output voltage is regulated, this tolerance is maintained regardless of load. -
Page 5: Spy ® Model 785/ 790 Pulse Holiday Detector Overview
785 / 790 pulse holiday detector overview The Model 785 Pulse Holiday Detector is a high voltage (1-15 kV) detector designed to cover a wide range of coatings from thin films to tapes to extruded or coal tar types of coatings (4 -150 Mils). Since... -
Page 6: Connecting Accessories
DETECTOR IS OPERATING. USE A GROUND ROD WITH A GROUNDING CABLE CLAMPED TO THE PIPE OPTIONAL: BRUSH ADAPTER KIT. The Model 785 / 790 Kit comes with CUTBACK WHILE HOLIDAY DETECTOR GROUND CABLE IS ALSO CONNECTED TO a brush adapter kit for use in connecting flat brush /neoprene electrodes, half A SEPARATE GROUNDING ROD circle electrodes and full circle electrodes. -
Page 7: Controls And Voltage Adjustments
The front clip can slide to the left or right on the handle to allow hand placement Using the SPY provided flathead screwdriver place the flat screwdriver ®... -
Page 8: Field Calibration
Prior to each use of the Model 785 / 790 Pulse Holiday Detector it is STEP 7. TURNING ON UNIT FOR HOLIDAY DETECTION. Turn important to perform a Field Calibration to verify that the required voltage the unit clockwise to the ON position. -
Page 9: Battery Charging And Storage Instructions
Charger CHARGING THE BATTERY. Slide the charger onto the battery as far as possible. A discharged battery The SPY battery is a completely sealed, rechargeable 12 volt unit. It ® requires 4-6 hours to fully charge. can be used in any position and under most conditions. Batteries are shipped fully charged. -
Page 10: Troubleshooting Guide
VOLTAGE Check Electrode/Wand With the detector OFF remove the wand and 1,000 Volts. The SPY JM is rated for 7 kV DC NEEDS TO BE Connection fully reinsert until it locks into place. Ensure and 40 kV Peak (crescent) on pulse. -
Page 11: Maintenance And Repair
If maintained the Model 785 / 790 Pulse Holiday Detector will offer you PROBLEM POSSIBLE SOLUTION CORRECTION METHOD a lifetime of dependable operation. Regular care and maintenance of the THE BATTERY Check/Replace Battery Use a multimeter to measure the battery unit is a requirement of good quality management practices. -
Page 12: Technical Specifications
Pipeline Inspection Company, hereafter referred to as (SPY ® ) warrants that Model 785 / 790 Series Holiday Detectors shall, under normal use ® and service, be free from defects in material and workmanship. SPY ‘s ®... -
Page 13: Electrode Types
Electrode types accessories The Model 785 / 790 can be fitted with a wide variety of electrodes that The Model 785 / 790 has a wide variety of accessories to assist you with vary in form, size and material to fit a wide range of coating inspection your coating inspection project. -
Page 14: Related Equipment
Test voltage Guide for 785 / 790 related equipment portable holiday detector 525* SQRT (MILS) MINIMUM TEST VOLTAGE FOR THIN FILM COATINGS COATING THICKNESS MINIMUM TESTING VOLTAGE KiloVolts 0.25 1.67 0.30 1.82 MODEL 780 PORTABLE DC MODEL JM 0.36 1.97 ®... -
Page 15: P I C Lt D.com
PIPELINE INSPECTION COMPANY p i c lt d.com...
Need help?
Do you have a question about the 785 and is the answer not in the manual?
Questions and answers